Tk-5410 Service Manual

Key top Key top (4key) (DTMF) (K29-9320-03) (K29-9321-13)

Main cabinet Main cabinet (4key) (DTMF) (A02-3877-11) (A02-3879-11)

Does not come with antenna. Antenna is available as an option. CONTENTS GENERAL ...... 2 PC BOARD SYSTEM SET-UP ...... 3 CONTROL UNIT (X53-4390-XX) ...... 70 REALIGNMENT ...... 3 TX-RX UNIT (X57-7560-10) ...... 74 INSTALLATION ...... 6 INTERCONNECTION DIAGRAM ...... 78 DISASSEMBLY FOR REPAIR ...... 7 SCHEMATIC DIAGRAM ...... 80 CIRCUIT DESCRIPTION ...... 13 BLOCK DIAGRAM ...... 92 COMPONENTS DESCRIPTION ...... 21 LEVEL DIAGRAM ...... 96 PARTS LIST ...... 23 OPTIONAL ACCESSORIES EXPLODED VIEW ...... 34 KNB-32N (Ni-MH Battery Pack) ...... 97 PACKING ...... 35 KNB-33L (Li-ion Battery Pack)...... 97 TROUBLE SHOOTING ...... 36 KNB-54N (Ni-MH Battery Pack) ...... 97 ADJUSTMENT ...... 38 KSC-32 (Rapid Charger) ...... 97 TERMINAL FUNCTION ...... 64 KBP-6 (Battery Case) ...... 97 SPECIFICATIONS ...... BACK COVER

This product complies with the RoHS directive for the European market. This product uses Lead Free solder. TK-5410

Document Copyrights Firmware Copyrights Copyright 2009 by Kenwood Corporation. All rights re- The title to and ownership of copyrights for firmware served. embedded in Kenwood product memories are reserved for No part of this manual may be reproduced, translated, Kenwood Corporation. Any modifying, reverse engineer- distributed, or transmitted in any form or by any means, ing, copy, reproducing or disclosing on an Internet website electronic, mechanical, photocopying, recording, or other- of the firmware is strictly prohibited without prior written wise, for any purpose without the prior written permission consent of Kenwood Corporation. Furthermore, any resell- of Kenwood. ing, assigning or transferring of the ﬁ rmware is also strictly prohibited without embedding the firmware in Kenwood Disclaimer product memories.

While every precaution has been taken in the preparation Transceivers containing AMBE+2™ Vocoder: of this manual, Kenwood assumes no responsibility for er- The AMBE+2™ voice coding technology is embedded rors or omissions. Neither is any liability assumed for dam- in the ﬁ rmware under the license of Digital Voice Systems, ages resulting from the use of the information contained Inc. herein. Kenwood reserves the right to make changes to any products herein at any time for improvement purposes.

GENERAL

INTRODUCTION PERSONAL SAFETY SCOPE OF THIS MANUAL The following precautions are recommended for personal This manual is intended for use by experienced techni- safety: cians familiar with similar types of commercial grade com- • DO NOT transmit until all RF connectors are veriﬁ ed se- munications equipment. It contains all required service cure and any open connectors are properly terminated. information for the equipment and is current as of the pub- • SHUT OFF and DO NOT operate this equipment near lication date. Changes which may occur after publication electrical blasting caps or in an explosive atmosphere. are covered by either Service Bulletins or Manual Revisions. • This equipment should be serviced by a qualiﬁ ed techni- These are issued as required. cian only.

ORDERING REPLACEMENT PARTS SERVICE When ordering replacement parts or equipment informa- This transceiver is designed for easy servicing. Refer to tion, the full part identifi cation number should be included. the schematic diagrams, printed circuit board views, and This applies to all parts : components, kits, or chassis. If the alignment procedures contained within. part number is not known, include the chassis or kit number of which it is a part, and a suffi cient description of the re- NOTE quired component for proper identifi cation. You must use KPG-95D version 6.00 or later for this transceiver. KPG-95D versions earlier than version 6.00 will not work properly.

2 TK-5410 SYSTEM SET-UP

Merchandise received Frequency range (MHz) RF power Type 4-key DTMF keypad TX 763~775.99375 793~805.99375 License and frequency allocated by FCC 3W TK-5410 K2 Yes No 806~825 851~870 Choose the type of transceiver RX 763~775.99375 3W TK-5410 K3 Yes Yes 851~870 Transceiver programming A personal computer, programming interface (KPG-36/36A), USB adapter (KCT-53U), and programming software (KPG-95D: ver. 6.00 or later) are required for programming. (The frequency, and signaling data are programmed for the transceiver.) YES Are you using the optional antenna? KRA-32 NO Optional antenna (Option)

YES Are you using the speaker microphone? KMC-25/KMC-41 NO Speaker microphone (Option)

YES Are you using the voice guide & storage unit? VGS-1 See page 6 NO (Option)

Delivery

REALIGNMENT

1. Modes Mode Function User mode For normal use. User mode Used by the dealer to check the fundamen- Panel test mode tal characteristics.

Panel test mode Panel tuning mode Panel tuning mode Used by the dealer to tune the transceiver. Used for communication between the trans- PC mode PC mode Data programming mode ceiver and PC. Data programming Used to read and write frequency data and mode other features to and from the transceiver. Firmware PC test mode PC tuning mode programming mode Used to check the transceiver using the PC. PC test mode This feature is included in the FPU. Firmware version information Firmware Used when changing the main program of programming the fl ash memory. mode Clock adjustment mode Firmware version Used to confi rm the internal fi rmware ver- information sion. Transceiver information mode Clock adjustment Used by the dealer to adjust date and time. mode Transceiver Used to confi rm the transceiver fi rmware information mode version.

3 TK-5410 REALIGNMENT

2. How to Enter Each Mode 5. PC Mode Mode Operation 5-1. Preface User mode Power ON The transceiver is programmed by using a personal computer, programming interface (KPG-36/36A), USB adapter Press and hold the [Side3] and [PTT] keys Panel test mode while turning the transceiver power ON and (KCT-53U) and programming software (KPG-95D: ver. 6.00 then release the [PTT] key ﬁ rst. or later). The programming software can be used with a PC. Fig- PC mode Received commands from PC ure 1 shows the setup of a PC for programming. Panel tuning mode Press the [Side3] key, in Panel test mode

Firmware Press and hold the [Side3] and [PTT] keys PC programming while turning the transceiver power ON and KPG-36 or KPG-36A or mode then release the [Side3] key fi rst. KPG-36A + KCT-53U Illustration is KPG-36. Firmware version Press and hold the [Side3] key while turning information the transceiver power ON. Press and hold the [Orange] and [PTT] keys Clock adjustment while turning the transceiver power ON and mode then release the [Orange] key fi rst. Press and hold the [Side1] and [PTT] keys Transceiver while turning the transceiver power ON and information mode then release the [PTT] key fi rst.

KPG-95D 3. Panel Test Mode (ver. 6.00 or later) Setting method refer to ADJUSTMENT. PC PC PC D-SUB D-SUB USB 4. Panel Tuning Mode (25-pin) (9-pin) KCT-53U Setting method refer to ADJUSTMENT. KPG-36 KPG-36A KPG-36A Transceiver Transceiver Transceiver

Fig. 1

5-2. Connection procedure 1. Connect the transceiver to the computer using the interface cable and USB adapter (When the interface cable is KPG-36A, the KCT-53U can be used.).

Note: • You must install the KCT-53U driver in the computer to use the USB adapter (KCT-53U). • When using the USB adapter (KCT-53U) for the ﬁ rst time, plug the KCT-53U into a USB port on the computer with the computer power ON.

2. When the POWER switch on, user mode can be entered immediately. When PC sends command the transceiver enter PC mode, and “PROGRAM” is displayed on the LCD. When data is transmitting from the transceiver, the red LED lights. When data is receiving by the transceiver, the green LED lights.

Note: The data stored in the computer must match the “Model Name and Market Code” when it is written into the EE- PROM and ﬂ ash memory. 4 TK-5410 REALIGNMENT

5-3. KPG-36/KPG-36A description 8. If you want to continue programming other transceivers, (PC programming interface cable: Option) repeat steps 4 to 7. The KPG-36/36A is required to interface the transceiver to the computer. It has a circuit in its D-sub connector (KPG- Note: 36: 25-pin, KPG-36A: 9-pin) case that converts the RS-232C This mode cannot be entered if the Firmware Program- logic level to the TTL level. ming mode is set to Disable in the Programming soft- The KPG-36/36A connects the universal connector of the ware. transceiver to the RS-232C serial port of the computer. 7. Firmware Version Information 5-4. KCT-53U description (USB adapter: Option) Press and hold the [Side3] key while turning the trans- The KCT-53U is a cable which connects the KPG-36A to ceiver power ON and then keep pressing and holding the a USB port on a computer. [Side3] key, the ﬁ rmware version information appears on the When using the KCT-53U, install the supplied CD-ROM LCD. (with driver software) in the computer. The KCT-53U driver runs under Windows 2000, XP or Vista (32-bit).

5-5. Programming software KPG-95D description 8. Clock Adjustment Mode The KPG-95D is the programming software for the trans- 8-1. Flow chart of operation ceiver supplied on a CD-ROM. This software runs under Windows 98, ME, Windows NT4.0, Windows 2000, XP or [Orange] + [PTT] + Power ON Release [Orange] Vista (32-bit) on a PC. The data can be input to or read from the transceiver and YEAR [Side2] and [Side3] keys or [C] and [D] keys edited on the screen. The programmed or edited data can [A] be printed out. It is also possible to tune the transceiver. MONTH [Side2] and [Side3] keys or [C] and [D] keys [A] 6. Firmware Programming Mode DAY [Side2] and [Side3] keys or [C] and [D] keys 6-1. Preface [A] Flash memory is mounted on the transceiver. This al- HOUR [Side2] and [Side3] keys or [C] and [D] keys lows the transceiver to be upgraded when new features are [A] released in the future. (For details on how to obtain the ﬁ rm- MINUTE [Side2] and [Side3] keys or [C] and [D] keys ware, contact Customer Service.) [A]

6-2. Connection procedure Completion Connect the transceiver to the personal computer using the interface cable (KPG-36/36A) and USB adapter (KCT-53U: when the interface cable is KPG-36A, the KCT-53U can be 9. Transceiver Information Mode used.). (Connection is the same as in the PC Mode.) Use this function to confirm the transceiver firmware 6-3. Programming version. 1. Start up the fi rmware programming software (Fpro.exe (ver. 5.00 or later)). The Fpro.exe exists in the KPG-95D 1. Press and hold the [Side1] and [PTT] keys while turning installed folder. the transceiver power ON and then release the [PTT] key 2. Set the communications speed (normally, 115200 bps) fi rst. and communications port in the confi guration item. 2. The transceiver fi rmware version appears on the LCD. 3. Set the fi rmware to be updated by File name item. 3. To exit the transceiver information mode, turn the trans- 4. Press and hold the [Side3] and [PTT] keys while turning ceiver power OFF. the transceiver power ON and then release the [Side3] key fi rst. Then, the orange LED on the transceiver lights and the “PROGRAM FIRMWARE” is displayed. 5. Check the connection between the transceiver and the personal computer, and make sure that the transceiver is in the Program mode. 6. Press “write” button in the window. The orange LED turns off while the fi rmware is being erased. [PG] appears on the LCD and the green LED turns on when the fi rmware data is being received. 7. If writing ends successfully, the checksum is calculated and a result is displayed. 5 TK-5410 INSTALLATION

Voice Guide & Storage Unit (VGS-1: Option) 5. Insert the VGS-1 connector (CN1) into the connector (CN501) of the TX-RX PCB. ■ Installing the VGS-1 unit in the transceiver 1. Remove the 4 screws from the cover. 2. Remove the cover by inserting the tip of a pair of twee- Cushion zers into the screw hole of the cover and prying it open. (G13-1995-04) 20X30X1.0mm

VGS-1

VGS-1 Cushion (G13-1992-04) 21X21X2.5mm CN1

CN501

Fig. 3 Fig. 1 6. Reinstall the cover using the 4 screws removed in step 1.

3. Remove the OPTION PCB from the connector (CN501) Note: of the TX-RX PCB. You must setup using the KPG-95D.

OPTION PCB

CN501

Fig. 2

4. Attach two cushions to the VGS-1 as shown in the ﬁ gure 3.

Note: Be sure not to cover the VGS-1 connector (CN1) with the cushion.

6 TK-5410 DISASSEMBLY FOR REPAIR

Disassembly Procedure ■ Removing the CONTROL PCB (X53-439) from the chassis ■ Removing the front case from the chassis 1. Remove the six screws u. 1. Remove the rear panel with a ﬂ at-head screwdriver. Insert the screwdriver between the rear panel (right side) CONTROL PCB > and the chassis (the place next to the “ ” mark shown on the chassis), push it in the direction of the arrow q, > and remove the right side of the rear panel. Repeat the > above action for the left side of the rear panel w.

“ ” mark Rear panel

“ ” mark Chassis @

2. On the reverse side of the CONTROL PCB i, remove the cord ASSY and each FPC from the connectors (CN40, : CN35, CN38) of the CONTROL PCB.

CN35 CN38

2. Remove the four screws e and universal connector cap CN40 r. 3. Lift the battery pack release latch on the bottom of the chassis t and remove the chassis from the front case. 2

Note: • Lift the chassis from the front case slowly and carefully. Cord ASSY If the chassis is lifted suddenly, the SP/MIC FPC may be pulled and the connector may become damaged. • Handle the main packing with care. It is likely to collect Note: dust and dirt. Fold indications are printed on the Cord ASSY and Uni- versal Connector FPC. 4. Remove the SP/MIC FPC from the CONTROL PCB con- “- - - -” line shows creased line on the bottom. nector (CN34) y.

CONT TX-RX

. Chassis Cord ASSY

Battery pack CN34 release latch = ; SP/MIC FPC

Front case

7 TK-5410 DISASSEMBLY FOR REPAIR

■ Removing the TX-RX PCB (X57-756 A/3) from ■ Removing the TOP PCB (X57-756 B/3) from the the chassis chassis 1. Remove the 14 screws o. 1. Remove the two screws !.9 2. Remove the universal connector FPC from the TX-RX 2. Lift the TOP PCB and remove the VOL/CH FPC @ 0 and PCB connector (CN505) !.0 CONTROL-TOP FPC @ 1 from the two connectors (CN902, 3. Insert the two tips of a pair of tweezers into the two CN903) of the TOP PCB. holes in the bottom of the shield plate of the TX-RX PCB, firmly squeeze the tweezers to hold the shield plate, then remove the TX-RX PCB !.1 TOP PCB 4. Remove the coaxial cables from the connector (MAIN (CN201) of the TX-RX PCB !.2 CN902 8 TX-RX PCB 8 8 CN903 8 8 8 8 MAIN (CN201)

Precautions for Reassembly ■ Installing the VOL/CH FPC and CONTROL-TOP CN505 FPC on the TOP PCB 1. Remove the volume q and channel switch w from the chassis. Universal 2. Position the coaxial cable connecting the ANT PCB and connector FPC TX-RX PCB as shown in the ﬁ gure below. Chassis

■ Removing the top panel from the chassis !3 !4 1. Remove the volume knob and channel knob . The projection 2. Remove the concentric switch knob !.5 of the volume 3. Remove the volume torque-up packing ! 6 using a pair of pedestal tweezers. : The projection of 4. Remove the nuts from the volume knob, channel knob CONTROL-TOP @ the channel FPC VOL/CH FPC and antenna receptacle. switch pedestal 5. Remove the top panel !.7 e Note: 3. Pass the coaxial cable of the antenna receptacle r • Before removing the top panel, set the lever switch to through the round hole of the hardware ﬁ xture , then the “●” position (circle painted in white) !.8 insert it into the coaxial connector (MAIN (CN201)) of the • Each of the volume knob, channel knob and antenna re- TX-RX PCB. ceptacle on the top panel has an O-ring. Take care not to lose them after removing the panel.

;

CN201 . Sheet O-ring

8 TK-5410 DISASSEMBLY FOR REPAIR

4. Pass the volume, channel switch, VOL/CH FPC and ■ LCD ASSY Installation Procedure CONTROL-TOP FPC through hardware fixture holes, 1. Fold the LCD ASSY FPC to the back of the holder q so then bring the hardware fixture into contact with the that the FPC is between the two tabs on the right side of chassis and ﬁ x it with a screw t. the holder w.

Note: The projections of the volume and channel switch ped- estals must protrude from the square holes of the hard- LCD ASSY FPC ware ﬁ xture. tab

y tab @ Sheet 5. Fix the antenna receptacle with the two screws . : 6. Fix the hardware ﬁ xture with a screw u. Sheet

2. Fit the two tabs on the right side of the holder e and the two tabs on the left side of the holder r into the CON- = TROL PCB. > Note: B Take care that the FPC is not caught when ﬁ tting the two tabs on the right side of the holder.

7. Insert the VOL/CH FPC i and the CONTROL-TOP FPC o. into the connectors (CN902, CN903) of the TOP PCB. 8. Fix the TOP PCB with a screw !.0 9. Fix the TOP PCB with a screw !.1 tab

. CN902 . ; 2 ; 8 CONTROL PCB CN903

3. Insert the FPC into the CONTROL PCB connector (CN1) t.

■ TX-RX PCB Installation Procedure 1. Insert the coaxial cable of the antenna receptacle into the coaxial connector (CN201) of the TX-RX PCB q. 2. Grasp both sides of the lower part of the TX-RX PCB, tilt CN1 the TX-RX PCB and install the chassis so that the PTT FPC w, CONTROL-TOP FPC e and universal connector = FPC r are not caught t. 3. Fix the TX-RX PCB with the 14 screws.

@ :

CN201

; . =

9 TK-5410 DISASSEMBLY FOR REPAIR

■ Main Packing (G53-1637-04) Installation Procedure 3. Verify that the packing ﬁ ts snuggly into the groove of the 1. Hook the packing (coated with silicon oil) in the upper chassis. groove of the chassis q, then fit the packing into the lower groove of the chassis w. ■ Volume Torque-up Packing (G53-1628-04) Installation Procedure Note: Insert the packing using a pair of tweezers so that the Ensure that the chassis grooves and packing are free hollow of the packing ﬁ ts the convex of the panel q. from dirt and dust.

2. Fit the packing into the grooves on both sides of the chassis e. (Fit the packing into the groove in the chassis by tracing it lightly with your ﬁ ngers.) Volume torque-up packing : Main packing

. ■ Screw sequence for mounting the battery @ terminal block to the chassis Attach the battery terminal block to the chassis as described in the following procedure. 1. Loosely ﬁ x the hexagon screws of the GND terminal to Note: the chassis (enough so that the hexagon screws do not To remove the packing from the chassis groove, use a move). resin adjustment bar or other such device. If the packing is pried with a sharp metallic tool, such as tweezers, the packing may become damaged.

3. Verify that the packing ﬁ ts snuggly into the groove of the GND terminal chassis.

■ Top Packing (G53-1638-04) Installation Procedure 1. Ensure that the hardware fi xture is fi rst secured to the chassis. 2. Tighten the two screws from the TX-RX PCB side. 2. Hook the packing (coated with silicon oil) in the upper left groove of the chassis q, then fi t the packing into the Two screws right groove of the chassis w.

Hardware fixture

3. Firmly tighten the hexagon screws of the GND terminal. @ Top packing

Note: • Verify that the chassis grooves and packing are free from dirt and dust. • To remove the packing from the chassis groove, use a resin adjustment bar or other such device. If the packing is pried with a sharp metallic tool, such as tweezers, the packing may become damaged. 10 TK-5410 DISASSEMBLY FOR REPAIR

Installation Procedure During Parts ■ Installing a new LCD ASSY to the holder 1. Remove the separation paper (brown) from the new Replacement sheet q w, and attach the sheet to the surface of the ■ Attaching the Sheet (G10-1338-04, J99-0383-14) holder e. to the Front Case Speaker and Installation of the 2. Remove the protection sheets attached to both sides of Packing (G53-1633-04) the new LCD ASSY. 3. Remove the separation paper (white) from the sheet in 1. Attach a new fiber sheet q (G10-1338-04) so that its step 1 r, then attach the LCD ASSY t to the sheet. convex fi ts the hollow of the front case w. 4. Attach two pieces of double-sided adhesive tape y to 2. Attach a new pressure sensitive adhesive sheet e (J99- the back of the holder and remove the separation paper. 0383-14) so that its convex fi ts the hollow of the front 5. Remove the protection sheet (transparent) attached to case r. one side of the new fi lter u i and remove the protec- 3. Remove the separation sheet from the pressure sensi- tion sheet (yellow) from the other side o. tive adhesive sheet with a pair of tweezers t. 6. Attach the fi lter from step 5 to the back of the holder. 4. Fit the packing y (G53-1633-04) into the front case 7. Attach the new cushion ! 0 so that it fi ts to the corner of speaker. the holder convex. Note: Fit the packing into the hollow of the case so that the two low-height places in the convex of the packing are : = positioned on the lower side u. @

B . ;

: > . . ;= : B @ B >

B B 2

5. Verify that the packing does not ride on the rib of the case.

11 TK-5410 DISASSEMBLY FOR REPAIR

■ Procedures when Replacing the Top Panel ■ Volume Knob and Channel Knob Parts 1. Insert the O-ring q into the lever switch part of the new Replacement top panel. Since the volume knob consists of two components, a 2. Apply grease to the base of the shaft of the lever knob knob q and a spacer w, replace and reinstall these two w and install the lever knob so that it is in the “●” posi- parts at the same time. tion (circle painted in white) on the top panel e. Since the channel knob consists of three components, a 3. Pass the hardware fi xture r through the shaft and install knob e, a 16CH display seal r and a spacer t, replace it onto the top panel. and reinstall these three parts at the same time. 4. Apply grease to between the two holes in the hardware fi xture r. 5. Install the hardware fi xture t so that it is inserted into Volume Knob Channel Knob the hole on the left side of the hardware fi xture r. 6. Fix the two hardware fi xtures with the hexagon nut y. 7. Apply bond (Three Bond 1401C) to the tip of the lever = . knob shaft and the surface of the hexagon nut u. : ; @

Inserted into the hole on the left side of the . hardware fixture. @ ■ Procedure when replacing the universal connector FPC (J82-0097-25) : When assembling a new universal connector FPC, insert the FPC into the chassis hole by gently bending the FPC ; as shown in the ﬁ gure. >

= B Universal connector FPC Top panel (J82-0097-25) Apply bond (Three Bond 1401C) to the tip of the lever knob shaft Apply grease to the and the surface of the hexagon base of the shaft of nut. the lever knob. Apply grease to between the two holes in the hardware fixture. Right Wrong Universal connector FPC Universal connector FPC

Universal Universal Connector Connector Bend the FPC gently. Do not bend the FPC at a sharp angle.

12 TK-5410 CIRCUIT DESCRIPTION

1. Overview 2. Frequency Confi guration The KENWOOD model TK-5410 is a 700M/800MHz The receiver is a double-conversion super heterodyne FM & P25 Portable transceiver designed to operate in using a fi rst intermediate frequency (IF) of 58.05MHz and a the frequency range of 763 to 775.99375MHz, 793 to second IF of 450kHz. Incoming signals from the antenna are 805.99375MHz (700M) and 806 to 825MHz, 851 to 870MHz mixed with the local signal from the PLL circuit to produce (800M). the fi rst IF of 58.05MHz. The unit consists of a receiver, a transmitter, a phase- This is then mixed with the 57.6MHz second local signal locked loop (PLL) frequency synthesizer, a digital control to produce the 450kHz second IF. This signal is detected to unit, and a power supply circuit. give the demodulated signal in the DSP. The transmit signal frequency is generated by the PLL VCO, and modulated by the signal from the DSP. It is then amplifi ed and fed to the antenna.

700M: 763~775.99375MHz (RX/TX) ANT 793~805.99375MHz (TX) CF 800M: 806~825MHz (TX) 450kHz 851~870MHz (RX/TX)

1st MIX MCF SP ANT RF MIX AF SW AMP IF AMP AMP 58.05MHz

x3 19.2MHz 57.6MHz ASIC

TCXO A/D D/A 700M: 821.05~834.04375MHz DSP MIC 800M: 792.95~811.95MHz PA TX PLL MIC AMP AMP 700M: 763~775.99375MHz VCO AMP 793~805.99375MHz 800M: 806~825MHz 851~870MHz

Fig. 1 Frequency conﬁ guration

3. Receiver System 3-3. IF Amplifi er The 1st IF signal is amplifi ed by the IF amplifi er (Q309) 3-1. Front-end RF Amplifi er and fed into the FM IC (IC304). The IF signal is then mixed The receive signal from antenna SW (D202, D203, D303, with the 2nd local oscillator frequency of 57.6MHz to gener- D304) is amplifi ed by a RF amplifi er (700MHz band: Q305, ate the 2nd IF of 450kHz. The 450kHz signal is then passed 800MHz band: Q302) and passes through the band-pass fi l- through a ceramic fi lter (CF300) and fed back into IC304 for ter (700MHz band: L301, L303, 800MHz band: L300, L302) additional amplifi cation. to remove unwanted signals. These are controlled with the RF fi lter switch (IC309 and IC310). The signal is then fed to 3-4. Wide/Narrow/P25 Switching Circuit the 1st mixer. Wide, Narrow, NPSPAC and P25 settings can be made for each channel by switching the ceramic filters CF303 3-2. 1st Mixer (Wide, NPSPAC), and CF302 (Narrow, P25). These are con- The 1st mixer uses a silicon monolithic mixer (IC300). trolled with multiplexers (IC306, IC307). The 1st mixer mixes the signal with the 1st local oscilla- When a W_/N signal line is H, the 450kHz signal is tor frequency from the VCO, and converts it to the 1st IF passed through a ceramic fi lter (CF303). (58.05MHz) (700M/Upper heterodyne, 800M/Lower hetero- When a W_/N signal line is L, the 450kHz signal is dyne). passed through a ceramic fi lter (CF302). The signal then passes through the monolithic crystal The signal is then fed into ASIC (IC10) through ceramic filter (XF300) to remove unnecessary nearby frequency fi lter (CF400). The signal is then demodulated in ASIC, and components. The signal from the MCF is used as the 1st IF the AF signal is dealing with DSP (IC3). signal. 13 TK-5410 CIRCUIT DESCRIPTION

X100 Q303 Q302 CF300 L300 LNA L302 TCXO x3 BPF BPF BPF IC300 XF300 Q309 CF400 IC400 IC304 Q305 BPF LPF L301 LNA L303 FM IC IC309 IC310 BPF BPF 1st Lo CF302 Narrow/P25

BPF

IC306 IC307 BPF

CF303 Wide/NPSPAC

Fig. 2 RF and IF circuit

3-5. Audio Amplifi er Circuit The audio output can be provided to an external speaker The AF signal from ASIC (IC10) is fi ltered for anti-aliasing (CN505 12-pin, 13-pin) or internal speaker (CN34 1-pin, 2-pin, and to eliminate unwanted spectrums. Next, the AF signal 3-pin, 4-pin). When the INAMT signal is H, AF signal loads goes through an electronic volume control (IC10) to adjust CN34. When the EXAMT signal is H, AF signal loads CN505. its level and a buffering AF amplifi er IC506. Finally the AF signal into the audio power amplifi er (IC11, IC12).

IC11

IC10 IC506 IC510 IC502 IC13 IC9 INT SP

ASIC DAC IC12

EXT SP

Fig. 3 Audio ampliﬁ er circuit

3-6. Squelch Circuit IC304 IC503 D500 IC10 It amplifies the demodulated noise signal from FM IC Noise FM IC ASIC (IC304) after ﬁ ltering through the BPF circuit. Then ampliﬁ ed AMP DET signal is the converted to a DC signal by the detection circuit. The converted signal is fed to the ASIC (IC10). Fig. 4 Squelch circuit

14 TK-5410 CIRCUIT DESCRIPTION

4. Transmitter System 4-2. Base Band Circuit The audio signal output from the base band circuit is con- 4-1. Audio Band Circuit verted to digital data with a sampling frequency of 48kHz. The signal from the microphone passes through the This digital data is sent to the DSP (IC3), and voice signals mute switch (Q506), summing amplifi er (IC516), and AGC of 300Hz or lower and frequencies of 3kHz or higher are cut circuit (IC516, D511, D512, Q504, Q505), and goes to the off so that the audio range of 300Hz to 3kHz is extracted. microphone amplifi er (IC513). It is then fed into ASIC (IC10) The audio signal is then pre-emphasized in FM mode and and converted from analog to digital. The digitalized signal synthesized with signals, such as QT and DQT, as required, undergoes AGC processing, pre-emphasizing, fi ltering, voc- and is then output from the ASIC (IC10). In Digital mode, the oding (in P25 mode), and returns to the ASIC (IC10). The audio signal is converted to the C4FM base band signal and signal is converted from digital to analog and is amplifi ed by output from IC10. The DTMF and MSK base band signals ASIC (IC10). Then the signal is adjusted to the appropriate are also generated by the DSP and output via IC10. level and is passed through the amplifi er (IC512), and then LPF (IC512) works as a smoothing fi lter. The DAC (IC502) to the VCO and TCXO in the PLL section. assigns the base band signal to the VCO and TCXO (X100). At this time, the level output according to the transmit carrier is fi ne-adjusted according to each modulation method.

INT. MIC EXT. MIC IC3 DSP IC13 Q508 Q506 IC516 IC515 IC513 NC MIC DIFF IC10 AMP SW SW AMP SW AMP ASIC

Q6 SW Q507 SW AGC

D511,D512 Q504,Q505 ECSW MSW MM /SCSW

IC512 IC502 IC500 X100

LPF DAC AMP TCXO

VCO

Fig. 5 Audio band and Base band circuit

15 TK-5410 CIRCUIT DESCRIPTION

4-3. Drive and Final amplifi er and controls the output power by controlling the current. It The transmit signal passing through the T/R switch (D200) detects the current using R222 and R223 and applies a drop is amplifi ed to approx. 50mW by the two transistor ampli- voltage between both resistors during transmission to APC fication circuits (Q200, Q201). The transmit signal output IC (IC201). It controls the transmission current of the drive from Q201 passes through an attenuator to improve high- amplifi er and fi nal amplifi er so that it is constant by compar- frequency signal matching, and is amplified by the drive ing this current with the reference voltage output from pin amplifi er (Q202). The signal is then applied to the fi nal am- 7 of IC200. The reference voltage input to pin 6 of IC200 is plifi er (Q204) so that the antenna output is 3W (1W for Low output from the DAC (IC502). High/Low power output is set Power). according to the DAC output voltage. The output of the fi nal amplifi er (Q204) is then passed through the antenna switch (D202, D203), spurious remov- 4-5. Temperature Protection Circuit ing LPF (L212) and surge protection HPF. It is then applied The temperature protection circuit reduces the APC to the antenna terminal (CN201). voltage when the temperature of Q204 rises, to prevent thermal destruction of the fi nal amplifi er (Q204). The ASIC 4-4. APC circuit (IC10) detects the temperature with a thermistor (TH200) to The APC circuit detects the current of the drive ampli- control the reference voltage to the APC circuit. fier (Q202) and final amplifier (Q204) during transmission

Q200 Q201 Q202 Q204 ANT Pre Drive Pre Drive Drive Final D200 AMP AMP AMP AMP D202 D308 D203 L212 T/R ANT SW ATT SW LPF

IC201 APC R222 R223 APC SW

Fig. 6 Drive and ﬁ nal ampliﬁ er and APC circuit

5. PLL Frequency Synthesizer 417.025MHz) and transmits a carrier for the 800MHz band (403.0 to 435.0MHz). 5-1. TCXO (X100) The VCO oscillation frequency is determined by one sys- TCXO (X100) generates a reference frequency of tem of operation switching terminal “VCOSW1” and two 19.2MHz for the PLL frequency synthesizer. This reference systems of voltage control terminals “CV” and “ASSIST”. frequency is applied to pin 8 of the PLL IC (IC101). The operation switching terminal, “VCOSW1”, is controlled The TCXO oscillation frequency is ﬁ ne-adjusted by con- by the ASIC (IC10). When the VCOSW1 logic is high, the trolling the voltage applied to pin 1 of the TCXO with DAC VCO1 outputs the signal, and if the logic is low, VCO2 out- (IC502). It is also controlled with pin 1 of the TCXO if the puts the signal. output from the TCXO is modulated. The voltage control terminals, “CV” and “assist”, are controlled by the PLL IC (IC101) and ASIC (IC10) and the 5-2. VCO output frequency changes continuously according to the There are two VCOs (VCO1, VCO2). VCO1 (Q106) gener- applied voltage. For the modulation input terminal, “VCO_ ate the 1st local receive signal for the 800MHz band (396.475 MOD”, the output frequency changes according to the to 405.975MHz) and transmits a carrier for the 700MHz applied voltage. This is used to modulate the VCO output. band (381.5 to 403.0MHz). VCO2 (Q107) generates the “VCO_MOD” works only when transmitting (user pressed 1st local receive signal for the 700MHz band (410.525 to PTT). 16 TK-5410 CIRCUIT DESCRIPTION

5-3. Doubler (Q111) to the desired frequency. As a result, the VCO CV voltage The doubler (Q111) extracts the double harmonic com- does not change and is always stable at approx. 2.5V. ponent from the signal output from the VCO. This double The desired frequency is set for the PLL IC by the ASIC harmonic component is then fed into pin 5 of the PLL IC. through the 3-line “PCS_RF”, “SDO0”, “SCK0” serial bus. Whether the PLL IC is locked or not is monitored by the 5-4. PLL IC (IC101) ASIC through the “PLD” signal line. If the VCO is not the The PLL IC compares the differences in phases of the desired frequency (unlock), the “PLD” logic is low. VCO oscillation frequency and the TCXO reference frequency, returns the difference to the VCO CV terminal and real- 5-5. Local Switch (D200, D308) izes the “Phase Locked Loop” for the return control. This The connection destination of the signal output from the allows the VCO oscillation frequency to accurately match VCO is changed with the diode switch (D200) that is con- (lock) the desired frequency. trolled by the transmission power supply, 5T, and the diode When the frequency is controlled by the PLL, the fre- switch (D308) that is controlled by the receiver power sup- quency convergence time increases as the frequency differ- ply, 5R. ence increases when the set frequency is changed. To sup- If the 5T logic is high, it is connected to a transmit-side plement this, the ASIC (IC10) is used before it is controlled pre-drive (Q200). If the 5T logic is low, it is connected to a by the PLL IC to bring the VCO oscillation frequency close receiver-side mixer (IC300).

Q105,Q108 Q104 5C Ripple filter VCOSW1 IC100 Q100 15V Ripple filter

Q103 Q109 Q111 Q112 Q106,Q107 D200 to pre-drive BUFF VCO1,VCO2 BUFF x2 BUFF SW (Q200) IC10 ASIC PLD CV D308 to 1st mixer SW (IC300) IC101 PLL IC LE VCO AFC DATA CLC TCXO IC500 MOD X100 MOD IC502 TCXO SUM DAC

Fig. 7 PLL block diagram

6. Control Circuit 6-1. ASIC The ASIC (IC10) is 32bit RISC processor, equipped with The control circuit consists of the ASIC (IC10) and its pe- peripheral function and ADC/DAC. ripheral circuits. IC10 mainly performs the following; This ASIC operates at a 18.432MHz clock and 3.3V/1.5V 1) Switching between transmission and reception by PTT DC. It controls the flash memory, SRAM, DSP, receiver signal input. circuit, transmitter circuit, control circuit, and display circuit 2) Reading system, zone, frequency, and program data and transfers data to or from an external device. from the memory circuit. 3) Sending frequency program data to the PLL. 4) Controlling squelch on/off by the DC voltage from the squelch circuit. 5) Controlling the audio mute circuit by decode data input. 17 TK-5410 CIRCUIT DESCRIPTION

6-2. Memory Circuit 6-7. Battery Type Detection The memory circuit consists of the ASIC (IC10), the The transceiver automatically detects the battery type, SRAM (IC4), and the fl ash memory (IC1). The fl ash memory measuring the resistance between the S-terminal and GND has capacity of 32M-bit that contains the transceiver control terminal on the battery pack and changes the supplied volt- program for the ASIC and stores the data. It also stores the age to the S-terminal as below. The microprocessor then data for transceiver channels and operating parameters that detects the battery type. are written by the FPU. This program can be easily written from external devices. The SRAM has a capacity of 1M-bit Battery type Input voltage of S-termial Resistor value that contains work area and data area. Battery case 0~0.2V Short ■ Flash memory Li-ion battery 1.00~1.11 47kΩ Note: The fl ash memory stores the data that is written by Ni-Cd battery 3.23~3.37 Open the FPU (KPG-95D), tuning data (Deviation, Squelch, etc.), Ni-MH battery 1.90~2.06 150kΩ and firmware program (User mode, Test mode, Tuning mode, etc.). This data must be rewritten when replacing the fl ash memory. 6-8. VOX The VOX function can be used only with an external mi- ■ SRAM (static memory) crophone. Note: The SRAM has a temporary data area and work area. The VOX (Voice Operated Transmission) function detects When the power supply is off, it is backed up via an internal voice input to the microphone and automatically switches secondary lithium battery. Therefore, the saved data is not between transmission and reception. lost. If the microphone input exceeds a certain level, transmission automatically begins. If the input falls below a certain ■ Real-time clock level, the transceiver automatically returns to receive mode. The clock function is based on a real-time clock IC (IC7). The transceiver realizes this function using DSP (IC8). When the power supply is off, it is backed up by an internal secondary lithium battery 6-9. DSP The DSP circuit consists of a DSP (IC3) and processes 6-3. LCD the base band signal. The DSP operates on an external clock The LCD is controlled using the bus lines on the connec- of 18.432MHz (the same as the IC10). The I/O section oper- tor (CN1) of the control unit. The LCD contrast voltage is ates at 3.3V and the core section operates at 1.5V. The DSP corrected using IC712. carries out the following processes: • C4FM, CQPSK processing 6-4. Temperature Detection Circuit • Analog FM pre-emphasis/de-emphasis The temperature detection circuit detects the tempera- • Vocoder processing between audio codec and modula- ture using a temperature IC (IC714) and corrects the thermal tion/demodulation characteristic change of the squelch or LCD. • CAI processing, such as error correction encoding • QT/DQT encoding/decoding • DTMF encoding 6-5. Key Detection Circuit • Compressor/expander processing Keys are detected using a Key scan circuit in IC10. • Voice scrambler processing The/KEYI* signals that are normally pulled down go high • Transmit/receive audio fi ltering processing when any key is pressed. • Microphone amplifi er AGC processing • Audio mute processing 6-6. Low Battery Warning • Modulation level processing The battery voltage is divided using R713 and R714 and is detected by the ASIC (IC10). When the battery voltage falls below the voltage set by the Low battery warning adjustment, the red LED blinks to notify the operator that it is time to replace the battery. If the battery voltage falls even more (approx. 5.8V), a beep sounds and transmission stops.

Low battery warning Battery condition The red LED blinks during The battery voltage is low but transmission. the transceiver is still usable. The red LED blinks and the The battery voltage is low and warning tone while the PTT the transceiver is not usable to switch is pressed. make calls.

18 TK-5410 CIRCUIT DESCRIPTION

7. Power Supply Circuit ASIC (IC10) start to operate. After the ASIC starts up, it begins controlling two regulators (IC701, IC702) with the The power supply voltage (+B) is supplied from the bat- SBC and/SAVE signals. After that, the two regulators (IC700, tery terminal, and is then passed through the fuse (F700). IC704) are controlled by the SB and 5M signals. If +B voltage is detected above 5.6V by the voltage de- The output voltage from IC701 is switched by the 5RC tection IC (IC16), IC17 CE pin (pin 6) becomes high and IC17 signal (which is turned on while receiving) or the 5TC signal outputs 3.1V (pin 3). Additionally, when VOL SW is ON, the (which is turned on while transmitting). These signals are 3.6V and 15V DC/DC converter (IC707, IC708) CE pin (pin 4) controlled by the ASIC (IC10). becomes high and the 3.6V power source turns ON. The output voltage from IC700 is controlled by Q703 The output from the 3.6V DC/DC converter (IC707) pro- and Q704, and is used as a power source for 5MCS, for an vides the power source for three regulators (IC705, IC706, optional accessory which is connected to the universal con- IC710) and 1.5V DC/DC converter (IC709). After these parts nector (CN505). became ON, the Flash (IC1), DSP (IC3), SRAM (IC4), and

F700 +B Q707,Q708 SB Battery SBC terminal IC713 IC712 Switched Capacitor Voltage LCDCNT Doubling Inverter IC704 DAC6 AVR IC 5M Q703,Q704 IC700 AVR IC 5MCS 5UC

Q700 IC701 AVR IC 5T 5TC SBC Q701 IC702 AVR IC 5C 5R 5RC /SAVE IC707 IC706 DCDC AVR IC 33C

36MC

IC705 AVR IC 33M

IC710 AVR IC 33A

IC709 DCDC 15M

IC708 DCDC 15V

36MC

Fig. 8 Power supply circuit

19 TK-5410 CIRCUIT DESCRIPTION

8. Signaling Circuit 8-1. Encode (QT/DQT/DTMF) Each data signal of QT, DQT and DTMF is generated by the DSP circuit, superimposed on a modulation signal and output from IC10. The modulation balance of the QT/ DQT signal is adjusted by the D/A converter (IC502) and the resulting signal is routed to the modulation input of the VCO and TCXO (X100). Each deviation of the TX QT, DQT and DTMF tone is adjusted by changing the output level of IC108 and the resulting signal is routed to the VCO and TCXO.

8-2. Decode (QT/DQT) The audio signal is removed from the FM detection signal sent to the DSP circuit and the resulting signal is de- coded.

9. Compander Circuit The term “compander” means compressor and expander. The compander reduces noise by utilizing a compressor and an expander. The transceiver contains a DSP (IC3) to perform this operation. The transceiver compander can be turned on or off using the FPU.

20 TK-5410 COMPONENTS DESCRIPTION

Control unit (X53-4390-XX) TX-RX unit (X57-7560-10) Ref. No. Part Name Description Ref. No. Part Name Description IC1 IC Flash memory IC100 IC DC AMP IC3 IC DSP IC101 IC PLL IC IC4 IC Static memory IC200 IC Buffer AMP (APC) IC5 IC Voltage detector (RST) IC201 IC APC AMP IC6 IC Buffer AMP (Logic) IC300 IC Mixer IC7 IC Real-time clock IC304 IC IF IC IC8 IC Clock buffer AMP IC306,307 IC RX ﬁ lter control IC9 IC Bus buffer (LCD) IC309,310 IC RX band control switch IC10 IC ASIC IC400 IC IF AMP IC11,12 IC Audio AMP (BTL) IC500 IC Buffer AMP (AFC/TCXO_MOD) Audio AMP (1/2 Audio pre-AMP, IC501 IC 5V to 3.3V Level convertor IC13 IC 2/2 NC MIC AMP) IC502 IC DAC IC15 IC I/O Expander IC503 IC A_SQL IC16 IC Voltage Detector (/BINT) IC505 IC I/O Expander IC17 IC Voltage regulator (3.1V) IC506 IC Buffer AMP (AF) IC18 IC Bus buffer (LCD) IC507~509 IC AF pass control IC19 IC 5V to 3.3V Level convertor IC510 IC DC AMP/Summing AMP Q1,2 Transistor AVR for backlight LED IC511 IC Logic switch Q3,5 Transistor 5A AVR IC512 IC Modulation Q4 FET DC switch (5AC) IC513 IC Buffer AMP (MIC) Q6 Transistor Echo cancel MIC switch IC514 IC Buffer AMP (VOX) IC515 IC MIC switch (/SCSW) Q7,8 FET DC switch (/BINT,PSW) IC516 IC Buffer AMP (MIC) Q10,11 FET DC switch (BLED,TXLED) IC517 IC Buffer AMP (Logic) Q12 Transistor DC switch (36MC) IC700 IC AVR (5MCS) Q13,16 Transistor DC switch IC701 IC AVR (5T/5R) Q14 FET DC switch (31BU) IC702 IC AVR (5C) Q15 FET DC switch (STCAMI) IC704 IC AVR (5M) D1 Zener diode AVR for backlight LED IC705 IC AVR (33M) D2~5 LED Key backlight IC706 IC AVR (33C) D6~8 LED LCD backlight IC707 IC DC/DC converter (3.6V) D9~12 LED Key backlight IC708 IC DC/DC converter (15V) D13~16 Diode Reverse current prevention IC709 IC DC/DC converter (1.5V) D19,20,22 Varistor Surge absorption IC710 IC AVR (33A) D23~26 Diode Reverse current prevention IC712 IC DC AMP (LCDCNT) D27 Varistor Surge absorption IC713 IC DC/DC converter IC714 IC Temperature detection

21 TK-5410 COMPONENTS DESCRIPTION

Ref. No. Part Name Description Ref. No. Part Name Description Q100 Transistor 15V ripple ﬁ lter Variable D100~107 capacitance VCO (Frequency control) Q102 FET PLL IC reset diode Q103 FET CV detection D119 Diode Assist DC Q104 Transistor Ripple ﬁ lter D200 Diode TX/RX switch Q105 FET VCO control switch D201 Zener diode Surge absorption Q106,107 FET VCO D202,203 Diode TX/RX switch Q108 FET VCO control switch D303,304 Diode TX/RX switch Q109 Transistor RF AMP D305 Diode Protect of RF power Q111 Transistor Double AMP D308 Diode TX/RX switch Q112 Transistor RF AMP D500 Diode SQL Q200 Transistor RF AMP D501 Diode PLD Q201 FET RF AMP D502,504 Zener diode Surge absorption Q202 FET RF AMP (Drive AMP) D505 Diode /PTT Q203 FET APC switch D510 Diode VOX Q204 FET RF AMP (Final AMP) D511,512 Diode MIC AGC Q205 Transistor DC switch (5M) D515,516 Zener diode Surge absorption Q206 FET APC D517 Diode VOX DC Q207 Transistor APC switch D518,519 Diode RXD1 Q208 FET APC switch D521 Diode OPT6 Q300 FET RX band switch D700 Diode +B Q302 FET RF AMP (LNA) D702 Diode 33M Q303 Transistor Tripler AMP D704 Diode AVR CE (IC705, IC706, IC710) Q304 Transistor Wide/Narrow control switch D706 Diode DC/DC converter (3.6V) Q305 FET RF AMP (LNA) D901 LED TX/RX LED Q308 FET RX band switch Q309 Transistor IF AMP Q311 Transistor RX Isolator Q312 Transistor Local AMP Q502 Transistor SQL AMP Q503 FET TONE switch Q504,505 Transistor MIC AGC Q506 FET MIC mute switch Q507,508 FET Int/Ext MIC switch Q509 FET DC switch Q700 FET 5TC Q701 FET 5RC Q703 FET 5MC Q704 FET 5MCS switch Q705 FET DC/DC (15V) Q706 FET DC/DC (3.6V) Q707 FET DC switch Q708 FET DC switch Q709 FET 15V switch

22 TK-5410 PARTS LIST

✽ New Parts. indicates safety critical components. L : Scandinavia K : USA P : Canada Parts without Parts No. are not supplied. Y : PX (Far East, Hawaii) T : England E : Europe Les articles non mentionnes dans le Parts No. ne sont pas fournis. C : China X : Australia M : Other Areas Teile ohne Parts No. werden nicht geliefert.

TK-5410 New Desti- New Desti- Ref. No. Address parts Parts No. Description nation Ref. No. Address parts Parts No. Description nation TK-5410 68 3D ✽ H52-2320-02 ITEM CARTON CASE 1 1B A02-3877-11 MAIN CABINET (4KEY) K2 70 1A J19-5475-12 HOLDER (LCD) 2 1B A02-3879-11 MAIN CABINET (DTMF) K3 71 2B J19-5477-04 HOLDER (EMG) 3 3A ✽ A10-4084-51 CHASSIS 72 2B J21-8482-13 MOUNTING HARDWARE (TOP) 4 2B A62-1104-02 PANEL (TOP) 73 2B ✽ J21-8483-13 MOUNTING HARDWARE (SP) 5 3A A82-0057-02 REAR PANEL 74 3A J21-8484-04 MOUNTING HARDWARE (NC MIC)

7 2B B03-3612-04 DRESSING PLATE (16CH) 76 2B J21-8495-04 MOUNTING HARDWARE (LEVER SW PANEL) 8 1B,2C B09-0682-13 CAP (SP/MIC) ACCESSORY 77 2B J21-8581-04 MOUNTING HARDWARE (LEVER SW) 9 2B B11-1821-03 ILLUMINATION GUIDE (TX-BUSY) 78 2C J29-0730-05 BELT CLIP ACCESSORY 10 1A B11-1832-04 FILTER (LCD) 79 2B J39-0646-03 SPACER (VOL) 11 1A ✽ B38-0929-05 LCD 80 2B J39-0647-03 SPACER (16CH)

13 3A B41-1841-04 CAUTION STICKER (HUMAN BODY PROTECTION) 82 3B J82-0097-25 FPC (UNIV) 14 1B B43-1171-04 BADGE (FRONT) 83 2B J82-0098-05 FPC (SP/MIC) 15 2B B43-1172-04 BADGE (REAR) 84 2A ✽ J87-0011-05 FPC (LEAD FREE/CONT-TOP) 16 2D ✽ B59-2596-00 SUB-INSTRUCTION MANUAL (QRC) 85 2A ✽ J87-0025-05 FPC (LEAD FREE/VOL,CH) 17 2C ✽ B62-2155-00 INSTRUCTION MANUAL (ENG/FRE) 86 3A J99-0377-14 ADHESIVE SHEET (PTT)

22 2B E37-1126-25 LEAD WIRE WITH CONNECTOR (ANT) 88 1B J99-0383-14 ADHESIVE SHEET (SP) 23 3B E58-0510-15 RECTANGULAR RECEPTACLE (UNIV) 89 1A J99-0390-04 ADHESIVE SHEET (LCD FILTER) 24 3A E72-0420-33 TERMINAL BLOCK 91 2B K29-9319-03 KEY TOP (EMG) 26 3A ✽ F07-1887-22 COVER ASSY 92 1B K29-9320-03 KEY TOP (4KEY) 27 2A ✽ F10-3104-03 SHIELDING CASE (CONT-B) 93 1A K29-9321-13 KEY TOP (DTMF) 28 2A ✽ F10-3114-03 SHIELDING CASE (TXRX-A UPPER) 94 2B K29-9322-03 KNOB (VOL) 29 2A ✽ F10-3115-04 SHIELDING CASE (TXRX-A BOTTOM) 95 2B K29-9323-03 KNOB (16CH)

31 3A G10-1327-04 FIBROUS SHEET (AIR) 97 2B K29-9324-13 KNOB (CONCENTRIC SW) 32 1B G10-1338-04 FIBROUS SHEET (SP) 98 1B K29-9325-04 KNOB (LEVER SW) 33 1A G10-1346-04 FIBROUS SHEET (LCD FPC) 99 1A K29-9327-03 KEY TOP (PTT) 34 3A G10-1366-04 FIBROUS SHEET (REAR PANEL) 100 1A K29-9328-02 KNOB (PTT) 35 1A G11-4302-04 SHEET (LCD) A 1B,2C N08-0531-14 DRESSED SCREW (CAP) ACCESSORY 37 3A G11-4303-14 SHEET (PTT) B 2B N09-2439-25 SPECIAL SCREW (SP) 38 1B,2C G11-4340-04 RUBBER SHEET (CAP) ACCESSORY C 3A N09-2441-25 SPECIAL SCREW (COVER ASSY) 39 - G11-4346-08 SHEET (UNIV) D 2B N09-2442-15 SPECIAL SCREW (ANT) 40 2B G11-4490-04 SHEET (ANT) E 3A N09-2443-14 HEXAGON HEAD SCREW (-TERMINAL) 41 1B ✽ G11-4526-04 SHEET (MIC) F 3A N09-6574-05 SPECIAL SCREW (CASE) 43 3A G13-1941-04 CUSHION (CHASSIS/PCB) G 2B N14-0813-14 CIRCULAR NUT (VOL) 44 1A G13-2036-04 CUSHION (MIC) H 2B N14-0814-14 CIRCULAR NUT (CH) 45 2A G13-2046-04 CUSHION (UNIV) J 2B N14-0815-04 CIRCULAR NUT (ANT) 46 3A G13-2070-04 CUSHION (OPB) K 2B N14-0817-14 HEXAGON NUT (LEVER SW) 47 2A,2B G13-2071-04 CONDUCTIVE CUSHION (CHASSIS/PCB) L 2C N30-3008-60 PAN HEAD MACHINE SCREW (BELT CLIP) 49 2A,2B G13-2079-04 CUSHION (VOL) M 2B N32-2004-48 FLAT HEAD MACHINE SCREW (TOP) 50 1A ✽ G13-2087-14 CUSHION (LCD) N 1A,2A N83-2005-48 PAN HEAD TAPTITE SCREW (CONT/TXRX) 51 2A ✽ G13-2284-04 CUSHION (CORD ASSY) O 2B N83-2006-43 PAN HEAD TAPTITE SCREW (TOP) 52 2A ✽ G13-2307-04 CONDUCTIVE CUSHION (SHIELDING) 53 2B G53-1628-04 PACKING (VOL-TQ-UP) 102 3B R31-0654-05 VARIABLE RESISTOR (VOL)

55 2B G53-1629-05 PACKING (VOL,CH O-RING) 104 2B S60-0431-15 ROTARY SWITCH (CH) 56 2B G53-1630-05 PACKING (ANT O-RING) 105 1A S79-0454-05 KEYBOARD ASSY (4KEY & DTMF) 57 2A G53-1631-05 PACKING (LEVER SW O-RING) 58 1B G53-1633-04 PACKING (SP) 107 1A T07-0755-15 SPEAKER 59 1B,2A G53-1634-14 PACKING (MAIN MIC,NC MIC) 108 2A,2B T91-0575-05 MIC ELEMENT (MAIN MIC,NC MIC)

61 2A G53-1637-04 PACKING (MAIN) 110 1A W09-0971-05 LITHIUM CELL 62 2B G53-1638-04 PACKING (TOP) 63 3A G53-1640-03 PACKING (BATT) 112 3A X41-3690-10 SWITCH UNIT (FPC (PTT)) 64 3A G53-1649-05 PACKING (-TERMINAL O-RING) 113 2A ✽ X42-3370-10 CORD ASSY (FPC (100PIN)) 66 3A G53-1663-23 PACKING (TERMINAL BLOCK) - ✽ X53-4390-14 SERVICE CONTROL UNIT K2 - ✽ X53-4390-15 SERVICE CONTROL UNIT K3 67 1D ✽ H12-3169-05 PACKING FIXTURE

23 TK-5410 PARTS LIST

CONTROL UNIT (X53-4390-XX) New Desti- New Desti- Ref. No. Address parts Parts No. Description nation Ref. No. Address parts Parts No. Description nation CONTROL UNIT (X53-4390-XX) -11: K2 -12: K3 C96 CK73HB0J474K CHIP C 0.47UF K C97-100 CK73HB1H471K CHIP C 470PF K D2-5 B30-2171-05 LED K3 C101 CK73HB1A104K CHIP C 0.10UF K D5 B30-2171-05 LED K2 C102 CK73HB1H471K CHIP C 470PF K D6-8 B30-2261-05 LED C103-111 CK73HB1H472K CHIP C 4700PF K D9-12 B30-2171-05 LED K3 D12 B30-2171-05 LED K2 C112 CK73HB1A104K CHIP C 0.10UF K C113,114 CK73GB0J106K CHIP C 10UF K C12-15 CK73HB1A104K CHIP C 0.10UF K C115 CK73HB1H471K CHIP C 470PF K C16 CK73HB0J105K CHIP C 1.0UF K C116 CK73HB0J105K CHIP C 1.0UF K C17 CK73HB1E103K CHIP C 0.010UF K C117 CK73GB1E105K CHIP C 1.0UF K C18,19 CK73HB1A104K CHIP C 0.10UF K C21,22 CK73HB1H102K CHIP C 1000PF K C118,119 CK73HB1E103K CHIP C 0.010UF K C120 CK73HB1H472K CHIP C 4700PF K C23 CK73HB1A104K CHIP C 0.10UF K C121,122 CK73HB1E103K CHIP C 0.010UF K C24 CC73HCH1H101J CHIP C 100PF J C136,137 CK73HB1A104K CHIP C 0.10UF K C25 CK73HB1A104K CHIP C 0.10UF K C141 CK73HB1A104K CHIP C 0.10UF K C27 CK73HB1A104K CHIP C 0.10UF K C29 CK73HB1A104K CHIP C 0.10UF K C143 CK73HB1A104K CHIP C 0.10UF K C144 CC73HCH1H221J CHIP C 220PF J C30 CK73HB1E103K CHIP C 0.010UF K C146,147 CK73HB1A104K CHIP C 0.10UF K C31 CK73HB1A104K CHIP C 0.10UF K C148-152 CK73HB0J105K CHIP C 1.0UF K C32 CK73HB1E103K CHIP C 0.010UF K C153,154 CK73HB1A104K CHIP C 0.10UF K C33 CK73HB0J105K CHIP C 1.0UF K C34 CK73HB1A104K CHIP C 0.10UF K C155 CK73HB1H102K CHIP C 1000PF K C156 CC73HCH1H470J CHIP C 47PF J C35 CK73HB0J105K CHIP C 1.0UF K C157 CC73HCH1H101J CHIP C 100PF J C36 CK73HB1A104K CHIP C 0.10UF K C161 CK73HB1E103K CHIP C 0.010UF K C37 CK73HB1E103K CHIP C 0.010UF K C38,39 CK73HB1A104K CHIP C 0.10UF K CN1 ✽ E40-6884-05 FLAT CABLE CONNECTOR C40 CK73HB1E103K CHIP C 0.010UF K CN34 ✽ E41-3183-05 FLAT CABLE CONNECTOR CN35 E40-6755-05 FLAT CABLE CONNECTOR C44 CK73HB1E682K CHIP C 6800PF K CN38 ✽ E40-6777-05 FLAT CABLE CONNECTOR C47 CK73HB1E103K CHIP C 0.010UF K CN40 ✽ E40-6846-05 PIN ASSY C48 CK73HB1A104K CHIP C 0.10UF K C49 CK73GB0J106K CHIP C 10UF K CN37 J19-5386-05 HOLDER (LITHIUM CELL) C50-55 CK73HB1A104K CHIP C 0.10UF K L4-6 L92-0444-05 CHIP FERRITE C56 CK73HB1E103K CHIP C 0.010UF K L7 ,8 L92-0162-05 BEADS CORE C57,58 CK73GB1E105K CHIP C 1.0UF K L9 L92-0444-05 CHIP FERRITE C59,60 CC73HCH1H101J CHIP C 100PF J L10 L92-0149-05 CHIP FERRITE C61 CK73HB1H102K CHIP C 1000PF K L11,12 L92-0467-05 CHIP FERRITE C62 CK73HB1E103K CHIP C 0.010UF K L13 L92-0163-05 BEADS CORE C63 CK73HB0J105K CHIP C 1.0UF K L14,15 L92-0467-05 CHIP FERRITE C64,65 CK73HB1A104K CHIP C 0.10UF K L16,17 L92-0444-05 CHIP FERRITE C66 CK73HB1E682K CHIP C 6800PF K L19 L92-0444-05 CHIP FERRITE C67 CK73HB1A104K CHIP C 0.10UF K L20,21 L92-0163-05 BEADS CORE C68 CK73GB0J106K CHIP C 10UF K L22,23 L92-0446-05 BEADS CORE C69 CC73HCH1H101J CHIP C 100PF J L24,25 L92-0162-05 BEADS CORE C70,71 CK73HB1A104K CHIP C 0.10UF K L27 L92-0446-05 BEADS CORE C72 CC73HCH1H030C CHIP C 3.0PF C X1 L77-1802-05 CRYSTAL RESONATOR(32768HZ) C73 CK73HB1E103K CHIP C 0.010UF K X2 L77-3015-05 TCXO (18.432MHZ) C74 CK73HB0J105K CHIP C 1.0UF K R5 RK73HB1J474J CHIP R 470K J 1/16W C75-78 CK73HB1A104K CHIP C 0.10UF K R6-9 RK73HB1J101J CHIP R 100 J 1/16W K3 C79 CK73HB1E103K CHIP C 0.010UF K R9 RK73HB1J101J CHIP R 100 J 1/16W K2 C80 CK73HB0J105K CHIP C 1.0UF K R11-13 RK73HB1J181J CHIP R 180 J 1/16W C81-85 CK73HB1A104K CHIP C 0.10UF K R16 RK73HB1J474J CHIP R 470K J 1/16W C86 CC73HCH1H101J CHIP C 100PF J R17 RK73HB1J222J CHIP R 2.2K J 1/16W C87 CK73HB1A104K CHIP C 0.10UF K R18 RK73HB1J102J CHIP R 1.0K J 1/16W C88 CK73HB1H102K CHIP C 1000PF K R19,20 RK73HB1J104J CHIP R 100K J 1/16W C90 CK73HB1A104K CHIP C 0.10UF K R21 RK73HB1J474J CHIP R 470K J 1/16W C91 CK73HB1H102K CHIP C 1000PF K R25,26 RK73HB1J473J CHIP R 47K J 1/16W C92 CK73HB1A104K CHIP C 0.10UF K C93 CK73HB0J105K CHIP C 1.0UF K R27 RK73HB1J104J CHIP R 100K J 1/16W R29 RK73HB1J104J CHIP R 100K J 1/16W C94 CK73HB0J474K CHIP C 0.47UF K R30 RK73HB1J474J CHIP R 470K J 1/16W C95 CK73HB1H102K CHIP C 1000PF K R31 RK73HB1J471J CHIP R 470 J 1/16W

24 TK-5410 PARTS LIST

CONTROL UNIT (X53-4390-XX) New Desti- New Desti- Ref. No. Address parts Parts No. Description nation Ref. No. Address parts Parts No. Description nation R32-34 RK73HB1J104J CHIP R 100K J 1/16W R135,136 RK73HB1J182J CHIP R 1.8K J 1/16W R35,36 RK73HB1J471J CHIP R 470 J 1/16W R137-142 RK73HB1J473J CHIP R 47K J 1/16W R37-39 RK73HB1J000J CHIP R 0.0 J 1/16W R143,144 RK73HB1J104J CHIP R 100K J 1/16W R40-42 RK73HB1J101J CHIP R 100 J 1/16W R145 RK73HB1J473J CHIP R 47K J 1/16W R43 RK73HB1J104J CHIP R 100K J 1/16W R146,147 RK73HB1J104J CHIP R 100K J 1/16W

R44 RK73HB1J101J CHIP R 100 J 1/16W R148 RK73HB1J000J CHIP R 0.0 J 1/16W R45 RK73HB1J471J CHIP R 470 J 1/16W R151 RK73HB1J104J CHIP R 100K J 1/16W R46-49 RK73HB1J104J CHIP R 100K J 1/16W R152 RK73HB1J102J CHIP R 1.0K J 1/16W R50 RK73HB1J473J CHIP R 47K J 1/16W R154-156 RK73HB1J474J CHIP R 470K J 1/16W R51 RK73HB1J104J CHIP R 100K J 1/16W R157 RK73HB1J102J CHIP R 1.0K J 1/16W

R52 RK73HB1J000J CHIP R 0.0 J 1/16W R158 RK73HB1J474J CHIP R 470K J 1/16W R53 RK73HB1J104J CHIP R 100K J 1/16W R159 RK73HB1J104J CHIP R 100K J 1/16W R54-57 RK73HB1J471J CHIP R 470 J 1/16W R160 RK73HB1J471J CHIP R 470 J 1/16W R58 RK73HB1J104J CHIP R 100K J 1/16W R161 RK73HB1J103J CHIP R 10K J 1/16W R59 RK73HB1J471J CHIP R 470 J 1/16W R162 RK73HB1J474J CHIP R 470K J 1/16W

R60-65 RK73HB1J104J CHIP R 100K J 1/16W R163 RK73HB1J471J CHIP R 470 J 1/16W R66 RK73HB1J102J CHIP R 1.0K J 1/16W R164,165 RK73HB1J474J CHIP R 470K J 1/16W R67 RK73HB1J151J CHIP R 150 J 1/16W R166-168 RK73HB1J103J CHIP R 10K J 1/16W R69 RK73HB1J153J CHIP R 15K J 1/16W R169,170 RK73HB1J474J CHIP R 470K J 1/16W R70 RK73HB1J474J CHIP R 470K J 1/16W R171 RK73HB1J332J CHIP R 3.3K J 1/16W

R71 RK73HB1J104J CHIP R 100K J 1/16W R172 RK73HB1J102J CHIP R 1.0K J 1/16W R72 RK73HB1J102J CHIP R 1.0K J 1/16W R173 RK73HB1J474J CHIP R 470K J 1/16W R74 RK73HB1J470J CHIP R 47 J 1/16W R174,175 RK73HB1J102J CHIP R 1.0K J 1/16W R75 RK73HB1J103J CHIP R 10K J 1/16W R176 RK73HB1J103J CHIP R 10K J 1/16W R76 RK73HB1J473J CHIP R 47K J 1/16W R177 RK73HB1J474J CHIP R 470K J 1/16W

R77,78 RK73HB1J222J CHIP R 2.2K J 1/16W R178 RK73HB1J000J CHIP R 0.0 J 1/16W R80,81 RK73HB1J220J CHIP R 22 J 1/16W R179 RK73HB1J473J CHIP R 47K J 1/16W R82 RK73HB1J470J CHIP R 47 J 1/16W R181 RK73HB1J102J CHIP R 1.0K J 1/16W R83,84 RK73HB1J000J CHIP R 0.0 J 1/16W R182 RK73HB1J473J CHIP R 47K J 1/16W R86 RK73HB1J474J CHIP R 470K J 1/16W R184 RK73HB1J473J CHIP R 47K J 1/16W

R88 RK73HB1J000J CHIP R 0.0 J 1/16W R185 RK73HB1J100J CHIP R 10 J 1/16W R90 RK73HH1J104D CHIP R 100K D 1/16W R187 RK73HB1J471J CHIP R 470 J 1/16W R92-95 RK73HH1J153D CHIP R 15K D 1/16W R188,189 RK73HB1J104J CHIP R 100K J 1/16W R96,97 RK73HH1J683D CHIP R 68K D 1/16W R190 RK73HB1J000J CHIP R 0.0 J 1/16W R98,99 RK73HH1J473D CHIP R 47K D 1/16W R191-199 RK73HB1J104J CHIP R 100K J 1/16W

R100 RK73HB1J102J CHIP R 1.0K J 1/16W R201,202 RK73HB1J103J CHIP R 10K J 1/16W R101 RK73HB1J104J CHIP R 100K J 1/16W R203 RK73HB1J000J CHIP R 0.0 J 1/16W R102 RK73HB1J102J CHIP R 1.0K J 1/16W R204 RK73HB1J104J CHIP R 100K J 1/16W R103 RK73HB1J000J CHIP R 0.0 J 1/16W R205-212 RK73HB1J103J CHIP R 10K J 1/16W R105 RK73HB1J104J CHIP R 100K J 1/16W R215 RK73HB1J000J CHIP R 0.0 J 1/16W

R106 RK73HB1J000J CHIP R 0.0 J 1/16W R219-221 RK73HB1J101J CHIP R 100 J 1/16W R107 RK73HB1J103J CHIP R 10K J 1/16W R225-227 RK73HB1J101J CHIP R 100 J 1/16W R108 RK73HB1J104J CHIP R 100K J 1/16W R230-284 RK73HB1J101J CHIP R 100 J 1/16W R109,110 RK73HH1J223D CHIP R 22K D 1/16W R285 RK73HB1J000J CHIP R 0.0 J 1/16W R111-113 RK73HB1J104J CHIP R 100K J 1/16W R287 RK73HB1J333J CHIP R 33K J 1/16W

R115 RK73HB1J473J CHIP R 47K J 1/16W R288 RK73HB1J393J CHIP R 39K J 1/16W R116 RK73HB1J104J CHIP R 100K J 1/16W R291 RK73HB1J822J CHIP R 8.2K J 1/16W R117 RK73HB1J105J CHIP R 1.0M J 1/16W R292 RK73HB1J000J CHIP R 0.0 J 1/16W R118 RK73HB1J274J CHIP R 270K J 1/16W R293 RK73HB1J473J CHIP R 47K J 1/16W R119 RK73HB1J000J CHIP R 0.0 J 1/16W R295 RK73HB1J223J CHIP R 22K J 1/16W

R120 RK73HB1J274J CHIP R 270K J 1/16W R998 RK73HB1J000J CHIP R 0.0 J 1/16W K2 R121,122 RK73HB1J102J CHIP R 1.0K J 1/16W R999 RK73HB1J000J CHIP R 0.0 J 1/16W K3 R123,124 RK73HB1J474J CHIP R 470K J 1/16W R125 RK73HB1J470J CHIP R 47 J 1/16W D1 UDZW3.9(B) ZENER DIODE R126,127 RK73HB1J154J CHIP R 150K J 1/16W D13-16 1SS388F DIODE D19,20 AVRM1005C270M VARISTOR R128 RK73HB1J273J CHIP R 27K J 1/16W D22 AVRM1005C270M VARISTOR R129 RK73HB1J473J CHIP R 47K J 1/16W D23 1SS301F DIODE R130,131 RK73HB1J223J CHIP R 22K J 1/16W R132,133 RK73HB1J473J CHIP R 47K J 1/16W D24 1SS416 DIODE R134 RK73HB1J223J CHIP R 22K J 1/16W D25 1SS301F DIODE

25 TK-5410 PARTS LIST

CONTROL UNIT (X53-4390-XX) TX-RX UNIT (X57-7560-10) New Desti- New Desti- Ref. No. Address parts Parts No. Description nation Ref. No. Address parts Parts No. Description nation D26 1SS388F DIODE C134,135 CC73GCH1H0R5B CHIP C 0.5PF B D27 AVRM1005C270M VARISTOR C136,137 CC73HCH1H0R5B CHIP C 0.5PF B IC1 Note 1 ROM IC C139,140 CC73GCH1H040B CHIP C 4.0PF B IC3 Note 1 MICROPROCESSOR IC IC4 Note 1 SRAM IC C141 CC73GCH1H050B CHIP C 5.0PF B C142 CC73GCH1H070B CHIP C 7.0PF B IC5 XC6109C29ANN ANALOGUE IC C143 CC73GCH1H050B CHIP C 5.0PF B IC6 TC7SH08FU-F MOS-IC C144 CS77CP0J100M CHIP TNTL 10UF 6.3WV IC7 RV5C386A MOS-IC C145 CC73GCH1H060B CHIP C 6.0PF B IC8 SM5023CNDH-G MOS-IC IC9 TC7W66FK-F MOS-IC C147 CK73GB0J475K CHIP C 4.7UF K C148-150 CK73HB1H471K CHIP C 470PF K IC10 Note 1 MOS-IC C151 CC73HCH1H101J CHIP C 100PF J IC11,12 TPA6201A1DRBR ANALOGUE IC C153 CC73HCH1H101J CHIP C 100PF J IC13 ✽ AK2925T MOS-IC C154 CC73HCH1H0R5B CHIP C 0.5PF B IC15 PCA9535BS MOS-IC IC16 XC61CC5602NR MOS-IC C155 CC73HCH1H101J CHIP C 100PF J C156 CC73HCH1H0R5B CHIP C 0.5PF B IC17 S-812C31BPI-G ANALOGUE IC C157 CK73HB1H821K CHIP C 820PF K IC18 TC7WZ245FK-F MOS-IC C159 CC73HCH1H100B CHIP C 10PF B IC19 TC74LCX245FK MOS-IC C162 CC73HCH1H050B CHIP C 5.0PF B Q1 2SB798AZ(DLDK TRANSISTOR Q2 2SC4617(S) TRANSISTOR C168 CK73HB1H471K CHIP C 470PF K C173 CC73HCH1H010C CHIP C 1.0PF C Q3 2SB1132(Q,R) TRANSISTOR C174 CC73HCH1H101J CHIP C 100PF J Q4 SSM3K15TE(F) FET C176 CC73HCH1H040B CHIP C 4.0PF B Q5 UMG3N TRANSISTOR C177,178 CC73HCH1H101J CHIP C 100PF J Q6 EMD12 TRANSISTOR Q7 ,8 SSM6N16FE-F FET C179 CC73HCH1H020B CHIP C 2.0PF B C180 CC73HCH1H150J CHIP C 15PF J Q10,11 SSM6L05FU-F FET C181 CC73HCH1H010B CHIP C 1.0PF B Q12 EMD12 TRANSISTOR C182 CC73HCH1H150J CHIP C 15PF J Q13 2SA1955A-F TRANSISTOR C183 CC73HCH1H1R5B CHIP C 1.5PF B Q14,15 SSM3K15TE(F) FET Q16 2SA1955A-F TRANSISTOR C184 CC73HCH1H101J CHIP C 100PF J C185 CC73HCH1H100B CHIP C 10PF B C186 CC73HCH1H101J CHIP C 100PF J C188 CC73HCH1H101J CHIP C 100PF J C189 CC73HCH1H080B CHIP C 8.0PF B

TX-RX UNIT (X57-7560-10) C190 CC73HCH1H040B CHIP C 4.0PF B C191 CC73HCH1H101J CHIP C 100PF J D901 B30-2019-05 LED (RE/GR) C192 CC73HCH1H040B CHIP C 4.0PF B C193 CC73HCH1H120G CHIP C 12PF G C100 CK73HB1E103K CHIP C 0.010UF K C194 CC73HCH1H040B CHIP C 4.0PF B C101 CK73HB1A104K CHIP C 0.10UF K C104 CK73HB1E103K CHIP C 0.010UF K C195-198 CK73HB1E103K CHIP C 0.010UF K C106,107 CC73HCH1H101J CHIP C 100PF J C200 CK73HB1E103K CHIP C 0.010UF K C108 CK73HB1A104K CHIP C 0.10UF K C201,202 CC73HCH1H101J CHIP C 100PF J C203 CC73HCH1H040B CHIP C 4.0PF B C109 CK73GB1E105K CHIP C 1.0UF K C204,205 CC73HCH1H101J CHIP C 100PF J C110 CC73HCH1H101J CHIP C 100PF J C111 CK73GB1E105K CHIP C 1.0UF K C206 CK73HB1A104K CHIP C 0.10UF K C112 CC73HCH1H101J CHIP C 100PF J C207 CC73HCH1H030B CHIP C 3.0PF B C113 CK73HB1H471K CHIP C 470PF K C208,209 CC73HCH1H101J CHIP C 100PF J C211 CC73HCH1H040B CHIP C 4.0PF B C114,115 CK73HB1A104K CHIP C 0.10UF K C213 CC73HCH1H101J CHIP C 100PF J C116,117 CK73HB1E103K CHIP C 0.010UF K C119 CK73HB1E103K CHIP C 0.010UF K C214 CK73HB1E103K CHIP C 0.010UF K C120,121 CK73HB1H471K CHIP C 470PF K C215 CK73HB1A104K CHIP C 0.10UF K C122 CC73HCH1H101J CHIP C 100PF J C216,217 CC73HCH1H101J CHIP C 100PF J C218 CK73HB1A104K CHIP C 0.10UF K C124 CS77CA1VR33M CHIP TNTL 0.33UF 35WV C219 CC73HCH1H030B CHIP C 3.0PF B C125 CK73GB1H104K CHIP C 0.10UF K C126 C93-0787-05 CERAMIC 0.1UF 50WV C220 CC73GCH1H101J CHIP C 100PF J C128 CC73HCH1H470J CHIP C 47PF J C221 CC73HCH1H050B CHIP C 5.0PF B C130 CC73HCH1H470J CHIP C 47PF J C222 CC73HCH1H150G CHIP C 15PF G C131 CC73HCH1H100B CHIP C 10PF B C223,224 CC73HCH1H101J CHIP C 100PF J C225 CC73HCH1H100B CHIP C 10PF B C132 CC73HCH1H101J CHIP C 100PF J C133 CC73HCH1H120G CHIP C 12PF G C226 CC73HCH1H101J CHIP C 100PF J

26 Note 1: This part cannot be replaced. Therefore, this part is not supplied as a service part. TK-5410 PARTS LIST

TX-RX UNIT (X57-7560-10) New Desti- New Desti- Ref. No. Address parts Parts No. Description nation Ref. No. Address parts Parts No. Description nation C228 CC73GCH1H060B CHIP C 6.0PF B C355 CC73HCH1H020B CHIP C 2.0PF B C230 CC73HCH1H101J CHIP C 100PF J C356 CC73HCH1H330J CHIP C 33PF J C231 CK73HB1E103K CHIP C 0.010UF K C357 CC73HCH1H030B CHIP C 3.0PF B C233-236 CC73HCH1H101J CHIP C 100PF J C358 CC73HCH1H100B CHIP C 10PF B C238 CK73GB1E105K CHIP C 1.0UF K C359 CC73HCH1H101J CHIP C 100PF J

C240-242 CC73HCH1H101J CHIP C 100PF J C360 CC73HCH1H010B CHIP C 1.0PF B C243 CK73HB1E103K CHIP C 0.010UF K C361 CC73HCH1H060B CHIP C 6.0PF B C244-246 CC73HCH1H101J CHIP C 100PF J C362 CC73HCH1H010B CHIP C 1.0PF B C248 CC73HCH1H101J CHIP C 100PF J C363 CC73HCH1H101J CHIP C 100PF J C249 CK73GB1H104K CHIP C 0.10UF K C364 CK73HB1E103K CHIP C 0.010UF K

C251 CK73HB1E103K CHIP C 0.010UF K C365 CC73HCH1H101J CHIP C 100PF J C254 CC73HCH1H101J CHIP C 100PF J C366 CC73HCH1H180G CHIP C 18PF G C256 CK73GB0J475K CHIP C 4.7UF K C367 CK73HB0J105K CHIP C 1.0UF K C259 CC73GCH1H101J CHIP C 100PF J C368 CK73HB1E103K CHIP C 0.010UF K C260 CC73HCH1H101J CHIP C 100PF J C371 CK73HB1E103K CHIP C 0.010UF K

C261 CC73GCH1H010B CHIP C 1.0PF B C372 CC73HCH1H101J CHIP C 100PF J C262,263 CC73GCH1H101J CHIP C 100PF J C373 CK73HB1E103K CHIP C 0.010UF K C264 CC73HCH1H030B CHIP C 3.0PF B C381 CC73GCH1H101J CHIP C 100PF J C265 CC73GCH1H010B CHIP C 1.0PF B C383,384 CC73HCH1H101J CHIP C 100PF J C266 CC73HCH1H010B CHIP C 1.0PF B C385 CK73HB1E103K CHIP C 0.010UF K

C267 CC73GCH1H060B CHIP C 6.0PF B C387 CK73HB1H471K CHIP C 470PF K C268 CC73GCH1H150G CHIP C 15PF G C388 CK73HB1E103K CHIP C 0.010UF K C269 CC73HCH1H060B CHIP C 6.0PF B C389 CC73HCH1H220G CHIP C 22PF G C270 CC73HCH1H220G CHIP C 22PF G C390 CC73HCH1H120G CHIP C 12PF G C272 C93-0941-05 CHIP C 18PF G C391,392 CC73HCH1H820J CHIP C 82PF J

C273 C93-0937-05 CHIP C 12PF G C393-396 CK73HB1A104K CHIP C 0.10UF K C274 ✽ C93-0976-05 CHIP C 3.9PF B C397 CC73HCH1H680J CHIP C 68PF J C275 C93-0878-05 CHIP C 2.0PF B C399 CK73HB1E103K CHIP C 0.010UF K C276 CC73HCH1H101J CHIP C 100PF J C400-404 CK73HB1A104K CHIP C 0.10UF K C277 ✽ C93-0974-05 CHIP C 3.3PF G C405,406 CK73HB1E103K CHIP C 0.010UF K

C279 CC73HCH1HR75B CHIP C 0.75PF B C407 CK73FB0J106K CHIP C 10UF K C300 CC73HCH1H330J CHIP C 33PF J C409 CK73HB1A104K CHIP C 0.10UF K C301,302 CC73HCH1H101J CHIP C 100PF J C410 CC73HCH1H390J CHIP C 39PF J C304,305 CC73HCH1H101J CHIP C 100PF J C411,412 CC73HCH1H151J CHIP C 150PF J C306 CC73HCH1H080B CHIP C 8.0PF B C413 CK73HB1C223K CHIP C 0.022UF K

C307 CC73HCH1H101J CHIP C 100PF J C414 CC73HCH1H101J CHIP C 100PF J C308 CK73HB1A104K CHIP C 0.10UF K C415 CK73HB1H102K CHIP C 1000PF K C309,310 CC73HCH1H020B CHIP C 2.0PF B C416 CK73HB1A104K CHIP C 0.10UF K C311 CC73HCH1H101J CHIP C 100PF J C418,419 CK73HB1A104K CHIP C 0.10UF K C315 CK73HB1E103K CHIP C 0.010UF K C420 CK73GB0J225K CHIP C 2.2UF K

C316 CC73HCH1H150J CHIP C 15PF J C421 CK73HB1A104K CHIP C 0.10UF K C317 CC73HCH1H101J CHIP C 100PF J C423 CC73HCH1H470J CHIP C 47PF J C319 CC73HCH1H101J CHIP C 100PF J C425-428 CK73HB1A104K CHIP C 0.10UF K C321,322 CC73HCH1H101J CHIP C 100PF J C429 CK73HB1H102K CHIP C 1000PF K C323 CC73HCH1H020B CHIP C 2.0PF B C430,431 CC73HCH1H101J CHIP C 100PF J

C324,325 CC73HCH1H101J CHIP C 100PF J C432 CK73HB1E103K CHIP C 0.010UF K C327 CC73HCH1H101J CHIP C 100PF J C433 CC73HCH1H270G CHIP C 27PF G C332 CK73HB1A104K CHIP C 0.10UF K C500 CK73HB1E103K CHIP C 0.010UF K C333 CC73HCH1H101J CHIP C 100PF J C503 CC73HCH1H101J CHIP C 100PF J C334 CC73HCH1H030B CHIP C 3.0PF B C504 CK73HB1A104K CHIP C 0.10UF K

C335 CK73HB1E103K CHIP C 0.010UF K C505,506 CC73HCH1H151J CHIP C 150PF J C337 CK73HB1E103K CHIP C 0.010UF K C507 CK73HB1A104K CHIP C 0.10UF K C339 CC73HCH1H060B CHIP C 6.0PF B C508 CK73HB1H102K CHIP C 1000PF K C340-343 CC73HCH1H101J CHIP C 100PF J C509 CK73HB0J105K CHIP C 1.0UF K C345 CC73HCH1H101J CHIP C 100PF J C510,511 CK73HB1A104K CHIP C 0.10UF K

C347 CC73HCH1H101J CHIP C 100PF J C512 CK73HB1H102K CHIP C 1000PF K C349-351 CC73HCH1H040B CHIP C 4.0PF B C513 CC73HCH1H101J CHIP C 100PF J C352 CK73HB1E103K CHIP C 0.010UF K C515 CK73HB1A224K CHIP C 0.22UF K C353 CC73HCH1H101J CHIP C 100PF J C516 CK73HB1E103K CHIP C 0.010UF K C354 CC73HCH1H010B CHIP C 1.0PF B C518 CK73HB1A224K CHIP C 0.22UF K

27 TK-5410 PARTS LIST

TX-RX UNIT (X57-7560-10) New Desti- New Desti- Ref. No. Address parts Parts No. Description nation Ref. No. Address parts Parts No. Description nation C519 CK73HB0J105K CHIP C 1.0UF K C618 CK73HB0J105K CHIP C 1.0UF K C520,521 CK73HB1A104K CHIP C 0.10UF K C619 CK73GB0J106K CHIP C 10UF K C522 CK73HB0J105K CHIP C 1.0UF K C620 CK73HB1H471K CHIP C 470PF K C524,525 CK73HB1A104K CHIP C 0.10UF K C621 CK73HB1A393K CHIP C 0.039UF K C527 CK73HB1A104K CHIP C 0.10UF K C622 CK73HB0J105K CHIP C 1.0UF K

C528 CK73HB1H152K CHIP C 1500PF K C674 CC73HCH1H101J CHIP C 100PF J C529 CK73HB1E103K CHIP C 0.010UF K C700 CC73HCH1H101J CHIP C 100PF J C532 CK73HB1A104K CHIP C 0.10UF K C701 CK73HB1H471K CHIP C 470PF K C533 CK73HB1E103K CHIP C 0.010UF K C702 CC73HCH1H101J CHIP C 100PF J C536 CC73HCH1H151J CHIP C 150PF J C703 CK73HB1H471K CHIP C 470PF K

C537,538 CK73HB1A104K CHIP C 0.10UF K C704,705 CK73HB1H102K CHIP C 1000PF K C539,540 CK73HB1E103K CHIP C 0.010UF K C706 CK73GB1H104K CHIP C 0.10UF K C542,543 CK73HB1E103K CHIP C 0.010UF K C707 CK73GB1E105K CHIP C 1.0UF K C544 CK73HB1A104K CHIP C 0.10UF K C709 CK73GB0J106K CHIP C 10UF K C545 CK73HB0J105K CHIP C 1.0UF K C711 CK73GB1E105K CHIP C 1.0UF K

C546 CK73HB1E103K CHIP C 0.010UF K C712 CK73GB1H104K CHIP C 0.10UF K C547 CC73HCH1H100B CHIP C 10PF B C713 CK73GB1E105K CHIP C 1.0UF K C551 CK73HB1H102K CHIP C 1000PF K C714 CK73HB1H471K CHIP C 470PF K C552 CK73HB1E103K CHIP C 0.010UF K C716,717 CK73HB1H471K CHIP C 470PF K C554 CC73HCH1H101J CHIP C 100PF J C719,720 CK73GB1E105K CHIP C 1.0UF K

C555 CK73HB0J105K CHIP C 1.0UF K C721 CC73HCH1H101J CHIP C 100PF J C556 CK73HB1E103K CHIP C 0.010UF K C724 CK73GB1E105K CHIP C 1.0UF K C557-560 CK73HB1A104K CHIP C 0.10UF K C725 CK73HB1E682K CHIP C 6800PF K C561 CC73HCH1H101J CHIP C 100PF J C727 CK73HB1H471K CHIP C 470PF K C562 CK73HB1A104K CHIP C 0.10UF K C728 CK73GB1E105K CHIP C 1.0UF K

C563 CK73HB1H152K CHIP C 1500PF K C730 C92-0822-05 CHIP TNTL 33UF 10WV C564 CK73HB1E103K CHIP C 0.010UF K C731,732 CK73HB0J105K CHIP C 1.0UF K C565 CC73HCH1H101J CHIP C 100PF J C733 CK73HB1A104K CHIP C 0.10UF K C566 CK73HB1H331K CHIP C 330PF K C735 CK73HB1E103K CHIP C 0.010UF K C567 CC73HCH1H101J CHIP C 100PF J C736 CK73GB1E105K CHIP C 1.0UF K

C568 CK73HB1H821K CHIP C 820PF K C737 CC73HCH1H820J CHIP C 82PF J C570 CK73HB1H471K CHIP C 470PF K C739 CK73GB1E105K CHIP C 1.0UF K C571 CK73HB1E562K CHIP C 5600PF K C740 CK73HB0J105K CHIP C 1.0UF K C573 CK73HB1A104K CHIP C 0.10UF K C741 CK73FB1E475K CHIP C 4.7UF K C574,575 CK73HB1H471K CHIP C 470PF K C742 CK73GB1E105K CHIP C 1.0UF K

C576 CK73HB1C223K CHIP C 0.022UF K C744 CK73HB1H102K CHIP C 1000PF K C577 CC73HCH1H101J CHIP C 100PF J C745 CK73HB0J105K CHIP C 1.0UF K C578 CK73HB1A104K CHIP C 0.10UF K C746 CK73FB1E475K CHIP C 4.7UF K C579 CK73HB1E103K CHIP C 0.010UF K C748 CC73HCH1H181J CHIP C 180PF J C581 CK73HB1H471K CHIP C 470PF K C749 CK73GB0J475K CHIP C 4.7UF K

C582 CK73HB1E103K CHIP C 0.010UF K C750 CC73HCH1H220G CHIP C 22PF G C583 CK73HB1E682K CHIP C 6800PF K C751 CK73HB1H471K CHIP C 470PF K C585-587 CC73HCH1H101J CHIP C 100PF J C752 CK73FB1E475K CHIP C 4.7UF K C589 CK73HB1A224K CHIP C 0.22UF K C753 CK73GB1E105K CHIP C 1.0UF K C590,591 CK73HB1A104K CHIP C 0.10UF K C754 CK73FB1E475K CHIP C 4.7UF K

C594 CC73HCH1H101J CHIP C 100PF J C755 CK73GB1E105K CHIP C 1.0UF K C595 CK73HB1H471K CHIP C 470PF K C756 CK73FB1E475K CHIP C 4.7UF K C598 CK73HB1H332K CHIP C 3300PF K C758 CK73GB1E105K CHIP C 1.0UF K C599-601 CC73HCH1H101J CHIP C 100PF J C759 CK73HB1H102K CHIP C 1000PF K C602 CK73HB1E103K CHIP C 0.010UF K C761,762 CK73FB1E475K CHIP C 4.7UF K

C603 CC73HCH1H101J CHIP C 100PF J C763 CC73HCH1H101J CHIP C 100PF J C604-606 CK73HB0J105K CHIP C 1.0UF K C765 CS77CP1C2R2M CHIP TNTL 2.2UF 16WV C607,608 CC73HCH1H101J CHIP C 100PF J C766 CK73HB1A104K CHIP C 0.10UF K C609 CC73HCH1H150G CHIP C 15PF G C767-769 CS77CP1C2R2M CHIP TNTL 2.2UF 16WV C610 CC73HCH1H680J CHIP C 68PF J C770,771 CK73HB1H102K CHIP C 1000PF K

C611-613 CK73HB1A104K CHIP C 0.10UF K C772 CK73HB1E103K CHIP C 0.010UF K C614 CK73HB0J105K CHIP C 1.0UF K C773-785 CC73HCH1H470J CHIP C 47PF J C615 CK73HB1A393K CHIP C 0.039UF K C786 CK73HB1H102K CHIP C 1000PF K C616 CK73HB1E103K CHIP C 0.010UF K C787 CC73HCH1H470J CHIP C 47PF J C617 CK73HB1A104K CHIP C 0.10UF K C788-791 CK73HB1H102K CHIP C 1000PF K

28 TK-5410 PARTS LIST

TX-RX UNIT (X57-7560-10) New Desti- New Desti- Ref. No. Address parts Parts No. Description nation Ref. No. Address parts Parts No. Description nation C792-796 CC73HCH1H470J CHIP C 47PF J L216 L40-2263-92 SMALL FIXED INDUCTOR (2.2NH) C797 CK73HB1H102K CHIP C 1000PF K L219 L40-3975-71 SMALL FIXED INDUCTOR (39NH) C798-819 CC73HCH1H470J CHIP C 47PF J L300 ✽ L79-1928-05 FILTER C821-846 CC73HCH1H470J CHIP C 47PF J L301 ✽ L79-1927-05 FILTER C911 CK73HB1E103K CHIP C 0.010UF K L302 ✽ L79-1928-05 FILTER

CN201 E04-0403-05 PIN SOCKET L303 ✽ L79-1927-05 FILTER CN300 E23-0762-05 TERMINAL L304 L92-0446-05 BEADS CORE CN501 E40-6357-05 PIN ASSY L305 ✽ L41-3965-45 SMALL FIXED INDUCTOR (3.9NH) CN502 E40-6586-05 SOCKET FOR PIN ASSY L306 ✽ L41-5165-45 SMALL FIXED INDUCTOR (5.1NH) CN505 E41-3167-05 FLAT CABLE CONNECTOR L307 L92-0446-05 BEADS CORE

CN707 ✽ E40-6846-05 PIN ASSY L308 L40-8265-92 SMALL FIXED INDUCTOR (8.2NH) CN902 ✽ E40-6722-05 FLAT CABLE CONNECTOR L309 ✽ L41-5165-45 SMALL FIXED INDUCTOR (5.1NH) CN903 E40-6464-05 FLAT CABLE CONNECTOR L310 ✽ L41-6868-45 SMALL FIXED INDUCTOR (6.8NH) CN923 E40-6358-05 SOCKET FOR PIN ASSY L311,312 L92-0446-05 BEADS CORE L313 L40-1891-86 SMALL FIXED INDUCTOR (1.8UH) F500 F53-0360-05 FUSE(0.25A) F700 F53-0372-05 FUSE(3.15A) L316 L34-4604-15 AIR-CORE COIL F701 F53-0360-05 FUSE(0.25A) L317 L40-6865-92 SMALL FIXED INDUCTOR (6.8NH) L318 L41-4778-45 SMALL FIXED INDUCTOR (47NH) CD300 L79-1850-05 TUNING COIL L319 L40-1575-92 SMALL FIXED INDUCTOR (15NH) CF300 L72-1017-05 CERAMIC FILTER L320 L40-1885-92 SMALL FIXED INDUCTOR (180NH) CF302 L72-1021-05 CERAMIC FILTER CF303 L72-1017-05 CERAMIC FILTER L321 L40-1085-92 SMALL FIXED INDUCTOR (100NH) CF400 ✽ L72-1030-05 CERAMIC FILTER L325 L40-8265-92 SMALL FIXED INDUCTOR (8.2NH) L326 L40-2285-92 SMALL FIXED INDUCTOR (220NH) L100 L92-0446-05 BEADS CORE L327 L41-4778-45 SMALL FIXED INDUCTOR (47NH) L104 L40-2785-92 SMALL FIXED INDUCTOR (270NH) L328 L40-2285-92 SMALL FIXED INDUCTOR (220NH) L107 L92-0446-05 BEADS CORE L109,110 L40-2785-92 SMALL FIXED INDUCTOR (270NH) L330 L40-1068-71 SMALL FIXED INDUCTOR (1.0NH) L115 L40-2785-92 SMALL FIXED INDUCTOR (270NH) L331 ✽ L41-5165-45 SMALL FIXED INDUCTOR (5.1NH) L332 ✽ L41-1578-45 SMALL FIXED INDUCTOR (15NH) L119,120 L40-2785-92 SMALL FIXED INDUCTOR (270NH) L333 ✽ L41-8768-45 SMALL FIXED INDUCTOR (8.7NH) L127,128 L40-2785-92 SMALL FIXED INDUCTOR (270NH) L335 L41-1278-45 SMALL FIXED INDUCTOR (12NH) L134,135 L40-2785-92 SMALL FIXED INDUCTOR (270NH) L139 L40-2763-92 SMALL FIXED INDUCTOR (2.7NH) L336 L41-7568-45 SMALL FIXED INDUCTOR (7.5NH) L140 L41-1078-45 SMALL FIXED INDUCTOR (10NH) L337 ✽ L41-8768-45 SMALL FIXED INDUCTOR (8.7NH) L338 L41-1078-45 SMALL FIXED INDUCTOR (10NH) L142 L40-2775-71 SMALL FIXED INDUCTOR (27NH) L500 L92-0140-05 CHIP FERRITE L143 L40-1868-71 SMALL FIXED INDUCTOR (1.8NH) L501 L92-0444-05 CHIP FERRITE L145,146 L40-1075-71 SMALL FIXED INDUCTOR (10NH) L147 L40-3963-92 SMALL FIXED INDUCTOR (3.9NH) L502 L92-0140-05 CHIP FERRITE L148 L40-1075-71 SMALL FIXED INDUCTOR (10NH) L503,504 L92-0467-05 CHIP FERRITE L505,506 L92-0163-05 BEADS CORE L149 L40-1275-71 SMALL FIXED INDUCTOR (12NH) L700 L92-0136-05 CHIP FERRITE L150 L33-0745-05 SMALL FIXED INDUCTOR (33NH) L701,702 L92-0162-05 BEADS CORE L151 L33-1267-05 SMALL FIXED INDUCTOR (27NH) L153 L40-1868-71 SMALL FIXED INDUCTOR (1.8NH) L703 L92-0467-05 CHIP FERRITE L154 L40-4775-71 SMALL FIXED INDUCTOR (47NH) L704 L92-0162-05 BEADS CORE L705 L33-1462-05 SMALL FIXED INDUCTOR (68UH) L155 L40-1275-71 SMALL FIXED INDUCTOR (12NH) L706 L33-1469-05 SMALL FIXED INDUCTOR (68UH) L200 L40-1075-92 SMALL FIXED INDUCTOR (10NH) L707 L33-1494-05 SMALL FIXED INDUCTOR (4.7UH) L201 L40-6865-92 SMALL FIXED INDUCTOR (6.8NH) L202 L40-1075-92 SMALL FIXED INDUCTOR (10NH) L708 L33-1462-05 SMALL FIXED INDUCTOR (68UH) L203 L40-5663-92 SMALL FIXED INDUCTOR (5.6NH) L710 L92-0446-05 BEADS CORE X100 L77-3016-05 TCXO (19.2MHZ) L204 L92-0140-05 CHIP FERRITE XF300 L71-0640-05 MCF (58.05MHZ) L205 L40-5667-92 SMALL FIXED INDUCTOR (5.6NH) L206 L40-2263-92 SMALL FIXED INDUCTOR (2.2NH) CP10,11 R90-0740-05 MULTIPLE RESISTOR L207 L41-3978-45 SMALL FIXED INDUCTOR (39NH) L208 L92-0149-05 CHIP FERRITE R100 RK73HB1J000J CHIP R 0.0 J 1/16W R102 RK73HB1J473J CHIP R 47K J 1/16W L209 L34-4550-05 AIR-CORE COIL R103,104 RK73HB1J000J CHIP R 0.0 J 1/16W L210 L92-0149-05 CHIP FERRITE R105 RK73HB1J560J CHIP R 56 J 1/16W L211 ✽ L41-6878-43 SMALL FIXED INDUCTOR (68NH) R106 RK73HB1J101J CHIP R 100 J 1/16W L212 L79-1468-05 FILTER MODULE L213 L34-4604-15 AIR-CORE COIL R107 RK73HB1J000J CHIP R 0.0 J 1/16W R108 RK73HB1J104J CHIP R 100K J 1/16W L214 L34-4606-15 AIR-CORE COIL R109 RK73HB1J102J CHIP R 1.0K J 1/16W L215 L40-3367-92 SMALL FIXED INDUCTOR (3.3NH) R110 RK73HB1J104J CHIP R 100K J 1/16W

29 TK-5410 PARTS LIST

TX-RX UNIT (X57-7560-10) New Desti- New Desti- Ref. No. Address parts Parts No. Description nation Ref. No. Address parts Parts No. Description nation R111 RK73HB1J101J CHIP R 100 J 1/16W R218 RK73HB1J102J CHIP R 1.0K J 1/16W R112 RK73HB1J100J CHIP R 10 J 1/16W R219 RK73HB1J103J CHIP R 10K J 1/16W R113 RK73HB1J474J CHIP R 470K J 1/16W R220 RK73HB1J000J CHIP R 0.0 J 1/16W R114 RK73HH1J184D CHIP R 180K D 1/16W R221 RK73GB2A331J CHIP R 330 J 1/10W R115 RK73HB1J100J CHIP R 10 J 1/16W R222,223 RK73EB2HR22F CHIP R 0.22 F 1/2W

R116 RK73HH1J333D CHIP R 33K D 1/16W R224 RK73HB1J473J CHIP R 47K J 1/16W R117 RK73HB1J682J CHIP R 6.8K J 1/16W R225,226 RK73HH1J154D CHIP R 150K D 1/16W R118 RK73HB1J472J CHIP R 4.7K J 1/16W R228-231 RK73HH1J154D CHIP R 150K D 1/16W R119 RK73HB1J102J CHIP R 1.0K J 1/16W R232 RK73HB1J472J CHIP R 4.7K J 1/16W R120 RK73HB1J106J CHIP R 10M J 1/16W R233 RK73HB1J103J CHIP R 10K J 1/16W

R121 RK73HB1J104J CHIP R 100K J 1/16W R234 RK73GB2A000J CHIP R 0.0 J 1/10W R122 RK73HB1J473J CHIP R 47K J 1/16W R235 RK73HB1J472J CHIP R 4.7K J 1/16W R123 ✽ RN73HH1J221D CHIP R 220 D 1/16W R236 RK73HB1J333J CHIP R 33K J 1/16W R124 ✽ RN73HH1J181D CHIP R 180 D 1/16W R237 RK73HB1J474J CHIP R 470K J 1/16W R125 ✽ RN73HH1J220D CHIP R 22 D 1/16W R238 RK73HB1J473J CHIP R 47K J 1/16W

R126 RK73HB1J104J CHIP R 100K J 1/16W R239 RK73HB1J184J CHIP R 180K J 1/16W R127 RK73HB1J683J CHIP R 68K J 1/16W R240 RK73HB1J474J CHIP R 470K J 1/16W R128 RK73HB1J560J CHIP R 56 J 1/16W R241 RK73HB1J104J CHIP R 100K J 1/16W R131 RK73HB1J101J CHIP R 100 J 1/16W R242 RK73HB1J222J CHIP R 2.2K J 1/16W R134 RK73HB1J104J CHIP R 100K J 1/16W R243 RK73HB1J183J CHIP R 18K J 1/16W

R135 RK73HB1J101J CHIP R 100 J 1/16W R244 RK73FB2B000J CHIP R 0.0 J 1/8W R136 RK73HB1J473J CHIP R 47K J 1/16W R245 RK73HB1J153J CHIP R 15K J 1/16W R137 RK73HB1J152J CHIP R 1.5K J 1/16W R246,247 RK73HB1J271J CHIP R 270 J 1/16W R138 RK73HB1J104J CHIP R 100K J 1/16W R248 RK73EB2E823J CHIP R 82K J 1/4W R139 RK73HB1J474J CHIP R 470K J 1/16W R300,301 RK73HB1J474J CHIP R 470K J 1/16W

R140,141 RK73HB1J101J CHIP R 100 J 1/16W R302 RK73HB1J104J CHIP R 100K J 1/16W R142 RK73HB1J682J CHIP R 6.8K J 1/16W R303 RK73HB1J000J CHIP R 0.0 J 1/16W R143 RK73HB1J103J CHIP R 10K J 1/16W R304 RK73HB1J474J CHIP R 470K J 1/16W R144 RK73HB1J102J CHIP R 1.0K J 1/16W R306,307 RK73HB1J223J CHIP R 22K J 1/16W R145 RN73HH1J104D CHIP R 100K D 1/16W R308,309 RK73HB1J474J CHIP R 470K J 1/16W

R146 RK73HB1J271J CHIP R 270 J 1/16W R310 RK73HB1J000J CHIP R 0.0 J 1/16W R148 RK73HB1J101J CHIP R 100 J 1/16W R311,312 RK73HB1J474J CHIP R 470K J 1/16W R150 RK73HB1J222J CHIP R 2.2K J 1/16W R319 RK73HB1J271J CHIP R 270 J 1/16W R151 RK73HB1J474J CHIP R 470K J 1/16W R320 RK73HB1J333J CHIP R 33K J 1/16W R152 RK73FB2B000J CHIP R 0.0 J 1/8W R321 RK73HB1J683J CHIP R 68K J 1/16W

R154 RK73HB1J562J CHIP R 5.6K J 1/16W R322 RK73HB1J333J CHIP R 33K J 1/16W R155 RK73HB1J122J CHIP R 1.2K J 1/16W R323 RK73HB1J683J CHIP R 68K J 1/16W R156 RK73HB1J102J CHIP R 1.0K J 1/16W R327 RK73HB1J332J CHIP R 3.3K J 1/16W R173 RK73HB1J106J CHIP R 10M J 1/16W R332 RK73HB1J560J CHIP R 56 J 1/16W R178-180 RK73HB1J122J CHIP R 1.2K J 1/16W R335 RK73HB1J470J CHIP R 47 J 1/16W

R182 RK73HB1J102J CHIP R 1.0K J 1/16W R337,338 RK73HB1J000J CHIP R 0.0 J 1/16W R183 ✽ RN73HH1J220D CHIP R 22 D 1/16W R339 RK73GB2A000J CHIP R 0.0 J 1/10W R185 RK73HB1J101J CHIP R 100 J 1/16W R340 RK73HB1J822J CHIP R 8.2K J 1/16W R186 RK73GB2A000J CHIP R 0.0 J 1/10W R341 RK73HB1J470J CHIP R 47 J 1/16W R200 RK73HB1J332J CHIP R 3.3K J 1/16W R342 RK73HB1J684J CHIP R 680K J 1/16W

R201 RK73HB1J182J CHIP R 1.8K J 1/16W R343,344 RK73HB1J392J CHIP R 3.9K J 1/16W R202 RK73HB1J392J CHIP R 3.9K J 1/16W R347 RK73HB1J102J CHIP R 1.0K J 1/16W R203 RK73HB1J330J CHIP R 33 J 1/16W R348,349 RK73HB1J220J CHIP R 22 J 1/16W R204 RK73HB1J331J CHIP R 330 J 1/16W R352 RK73HB1J474J CHIP R 470K J 1/16W R205 RK73HB1J220J CHIP R 22 J 1/16W R353 RK73HB1J154J CHIP R 150K J 1/16W

R206,207 RK73HB1J104J CHIP R 100K J 1/16W R354,355 RK73HB1J474J CHIP R 470K J 1/16W R208 RK73HB1J390J CHIP R 39 J 1/16W R356 RK73HB1J153J CHIP R 15K J 1/16W R209 RK73HB1J152J CHIP R 1.5K J 1/16W R357 RK73HB1J563J CHIP R 56K J 1/16W R210 RK73HB1J332J CHIP R 3.3K J 1/16W R358 RK73HB1J472J CHIP R 4.7K J 1/16W R211 RK73HB1J331J CHIP R 330 J 1/16W R359 RK73HB1J182J CHIP R 1.8K J 1/16W

R212 RK73HB1J000J CHIP R 0.0 J 1/16W R360 RK73HB1J392J CHIP R 3.9K J 1/16W R213 RK73HB1J471J CHIP R 470 J 1/16W R361 RK73HB1J332J CHIP R 3.3K J 1/16W R215 RK73HB1J120J CHIP R 12 J 1/16W R362 RK73HB1J272J CHIP R 2.7K J 1/16W R216 RK73HB1J471J CHIP R 470 J 1/16W R363 RK73HB1J474J CHIP R 470K J 1/16W R217 RK73HB1J333J CHIP R 33K J 1/16W R364 RK73HB1J392J CHIP R 3.9K J 1/16W

30 TK-5410 PARTS LIST

TX-RX UNIT (X57-7560-10) New Desti- New Desti- Ref. No. Address parts Parts No. Description nation Ref. No. Address parts Parts No. Description nation R365 RK73HB1J473J CHIP R 47K J 1/16W R553 RK73HB1J563J CHIP R 56K J 1/16W R366 RK73HB1J220J CHIP R 22 J 1/16W R554 RK73HB1J472J CHIP R 4.7K J 1/16W R367 RK73HB1J474J CHIP R 470K J 1/16W R556 RK73HB1J683J CHIP R 68K J 1/16W R368 RK73HB1J000J CHIP R 0.0 J 1/16W R557 RK73HB1J564J CHIP R 560K J 1/16W R369 RK73HB1J473J CHIP R 47K J 1/16W R558,559 RK73HB1J104J CHIP R 100K J 1/16W

R371 RK73HB1J683J CHIP R 68K J 1/16W R560 RK73HB1J103J CHIP R 10K J 1/16W R373,374 RK73HB1J223J CHIP R 22K J 1/16W R561 RK73HB1J334J CHIP R 330K J 1/16W R378 RK73HB1J684J CHIP R 680K J 1/16W R562-565 RK73HB1J104J CHIP R 100K J 1/16W R380 RK73HB1J271J CHIP R 270 J 1/16W R566 RK73HB1J000J CHIP R 0.0 J 1/16W R381 RK73HB1J180J CHIP R 18 J 1/16W R567 RK73HB1J104J CHIP R 100K J 1/16W

R382 RK73HB1J151J CHIP R 150 J 1/16W R568 RK73HB1J102J CHIP R 1.0K J 1/16W R384 RK73HB1J101J CHIP R 100 J 1/16W R569 RK73HB1J103J CHIP R 10K J 1/16W R386 RK73HB1J564J CHIP R 560K J 1/16W R570 RK73HB1J224J CHIP R 220K J 1/16W R387 RK73HB1J000J CHIP R 0.0 J 1/16W R571,572 RK73HB1J334J CHIP R 330K J 1/16W R388 RK73HB1J122J CHIP R 1.2K J 1/16W R573 RK73HB1J105J CHIP R 1.0M J 1/16W

R389 RK73HB1J221J CHIP R 220 J 1/16W R574 RK73HB1J104J CHIP R 100K J 1/16W R390 RK73HB1J000J CHIP R 0.0 J 1/16W R575 RK73HB1J473J CHIP R 47K J 1/16W R394 RK73HB1J104J CHIP R 100K J 1/16W R576 RK73HB1J103J CHIP R 10K J 1/16W R395 RK73HB1J473J CHIP R 47K J 1/16W R577 RK73HB1J472J CHIP R 4.7K J 1/16W R398 RK73GB2A000J CHIP R 0.0 J 1/10W R578 RK73HB1J473J CHIP R 47K J 1/16W

R401 RK73HB1J102J CHIP R 1.0K J 1/16W R579 RK73HB1J103J CHIP R 10K J 1/16W R402 RK73HB1J100J CHIP R 10 J 1/16W R580 RK73HB1J104J CHIP R 100K J 1/16W R403 RK73HB1J102J CHIP R 1.0K J 1/16W R581,582 RK73HB1J103J CHIP R 10K J 1/16W R404 RK73HB1J333J CHIP R 33K J 1/16W R583,584 RK73HB1J102J CHIP R 1.0K J 1/16W R405 RK73HB1J104J CHIP R 100K J 1/16W R585 RK73HB1J274J CHIP R 270K J 1/16W

R406 RK73HB1J103J CHIP R 10K J 1/16W R586,587 RK73HB1J474J CHIP R 470K J 1/16W R407 RK73HB1J000J CHIP R 0.0 J 1/16W R588 RK73HB1J000J CHIP R 0.0 J 1/16W R408 RK73HB1J223J CHIP R 22K J 1/16W R589,590 RK73HB1J473J CHIP R 47K J 1/16W R409 RK73HB1J104J CHIP R 100K J 1/16W R591,592 RK73HB1J000J CHIP R 0.0 J 1/16W R501 RK73HB1J104J CHIP R 100K J 1/16W R593 RK73HB1J102J CHIP R 1.0K J 1/16W

R503 RK73HB1J121J CHIP R 120 J 1/16W R594,595 RK73HB1J000J CHIP R 0.0 J 1/16W R505 RK73HB1J000J CHIP R 0.0 J 1/16W R596 RK73HB1J154J CHIP R 150K J 1/16W R506 RK73HB1J104J CHIP R 100K J 1/16W R597-601 RK73HB1J000J CHIP R 0.0 J 1/16W R507 RK73HB1J103J CHIP R 10K J 1/16W R602 RK73HB1J274J CHIP R 270K J 1/16W R509 RK73HB1J104J CHIP R 100K J 1/16W R603-608 RK73HB1J000J CHIP R 0.0 J 1/16W

R511 RK73HB1J101J CHIP R 100 J 1/16W R610-612 RK73HB1J104J CHIP R 100K J 1/16W R513 RK73HB1J101J CHIP R 100 J 1/16W R614 RK73HB1J154J CHIP R 150K J 1/16W R514 RK73HB1J123J CHIP R 12K J 1/16W R615 RK73HB1J104J CHIP R 100K J 1/16W R515 RK73HB1J392J CHIP R 3.9K J 1/16W R616 RK73HB1J000J CHIP R 0.0 J 1/16W R517 RK73HB1J101J CHIP R 100 J 1/16W R617 RK73HB1J473J CHIP R 47K J 1/16W

R518 RK73HB1J474J CHIP R 470K J 1/16W R618 RK73HB1J103J CHIP R 10K J 1/16W R519 RK73HB1J000J CHIP R 0.0 J 1/16W R619,620 RK73HB1J104J CHIP R 100K J 1/16W R520 RK73HB1J472J CHIP R 4.7K J 1/16W R621 RK73HB1J124J CHIP R 120K J 1/16W R521 RK73HB1J224J CHIP R 220K J 1/16W R622 RK73HB1J223J CHIP R 22K J 1/16W R522 RK73HB1J100J CHIP R 10 J 1/16W R623,624 RK73HB1J000J CHIP R 0.0 J 1/16W

R525 RK73HB1J473J CHIP R 47K J 1/16W R625 RK73HB1J104J CHIP R 100K J 1/16W R526 RK73HB1J474J CHIP R 470K J 1/16W R626 RK73HB1J183J CHIP R 18K J 1/16W R527 RK73HB1J473J CHIP R 47K J 1/16W R627 RK73HB1J103J CHIP R 10K J 1/16W R528 RK73HB1J332J CHIP R 3.3K J 1/16W R628 RK73HB1J183J CHIP R 18K J 1/16W R529 RK73HB1J473J CHIP R 47K J 1/16W R629,630 RK73HB1J223J CHIP R 22K J 1/16W

R530 RK73HB1J474J CHIP R 470K J 1/16W R631 RK73HB1J000J CHIP R 0.0 J 1/16W R531 RK73HB1J104J CHIP R 100K J 1/16W R635,636 RK73HB1J471J CHIP R 470 J 1/16W R532,533 RK73HB1J472J CHIP R 4.7K J 1/16W R637 RK73HB1J102J CHIP R 1.0K J 1/16W R534 RK73HB1J220J CHIP R 22 J 1/16W R638 RK73HB1J273J CHIP R 27K J 1/16W R535 RK73HB1J563J CHIP R 56K J 1/16W R640 RK73HB1J102J CHIP R 1.0K J 1/16W

R536 RK73HB1J000J CHIP R 0.0 J 1/16W R641 RK73HB1J562J CHIP R 5.6K J 1/16W R538 RK73HB1J103J CHIP R 10K J 1/16W R642 RK73HB1J473J CHIP R 47K J 1/16W R541 RK73HB1J000J CHIP R 0.0 J 1/16W R643,644 RK73HB1J000J CHIP R 0.0 J 1/16W R544-547 RK73HB1J104J CHIP R 100K J 1/16W R645 RK73HB1J102J CHIP R 1.0K J 1/16W R550 RK73HB1J563J CHIP R 56K J 1/16W R646 RK73HB1J103J CHIP R 10K J 1/16W

31 TK-5410 PARTS LIST

TX-RX UNIT (X57-7560-10) New Desti- New Desti- Ref. No. Address parts Parts No. Description nation Ref. No. Address parts Parts No. Description nation R647 RK73HB1J471J CHIP R 470 J 1/16W R761,762 RK73HB1J474J CHIP R 470K J 1/16W R648 RK73HB1J104J CHIP R 100K J 1/16W R907 RK73HB1J333J CHIP R 33K J 1/16W R649 RK73HB1J102J CHIP R 1.0K J 1/16W R908 RK73HB1J184J CHIP R 180K J 1/16W R650 RK73HB1J000J CHIP R 0.0 J 1/16W R909 RK73HB1J102J CHIP R 1.0K J 1/16W R651 RK73HB1J102J CHIP R 1.0K J 1/16W R910 RK73HB1J474J CHIP R 470K J 1/16W

R652 RK73HB1J000J CHIP R 0.0 J 1/16W R912 RK73HB1J103J CHIP R 10K J 1/16W R653,654 RK73HB1J103J CHIP R 10K J 1/16W R913 RK73HB1J682J CHIP R 6.8K J 1/16W R655 RK73HB1J105J CHIP R 1.0M J 1/16W R914 RK73HB1J105J CHIP R 1.0M J 1/16W R656,657 RK73HB1J683J CHIP R 68K J 1/16W R915 RK73HB1J564J CHIP R 560K J 1/16W R658 RK73HB1J474J CHIP R 470K J 1/16W R916 RK73HB1J473J CHIP R 47K J 1/16W

R659 RK73HB1J473J CHIP R 47K J 1/16W S901 S64-0406-05 LEVER SWITCH R660 RK73HB1J000J CHIP R 0.0 J 1/16W S902 S70-0496-05 TACT SWITCH R661 RK73HB1J684J CHIP R 680K J 1/16W R662 RK73HB1J000J CHIP R 0.0 J 1/16W D100,101 1SV325F VARIABLE CAPACITANCE DIODE R663 RK73HB1J564J CHIP R 560K J 1/16W D102,103 1SV282-F VARIABLE CAPACITANCE DIODE D104-107 1SV278F VARIABLE CAPACITANCE DIODE R664 RK73HB1J473J CHIP R 47K J 1/16W D119 DA221 DIODE R665 RK73HB1J683J CHIP R 68K J 1/16W D200 RN142S DIODE R666 RK73HB1J153J CHIP R 15K J 1/16W R667 RK73HB1J333J CHIP R 33K J 1/16W D201 HZU4CLL ZENER DIODE R668 RK73HB1J564J CHIP R 560K J 1/16W D202,203 HVC131 DIODE D303,304 HVC131 DIODE R669 RK73HB1J123J CHIP R 12K J 1/16W D305 HSM88AS-E DIODE R670 RK73HB1J104J CHIP R 100K J 1/16W D308 RN142S DIODE R671 RK73HB1J102J CHIP R 1.0K J 1/16W R672 RK73HB1J472J CHIP R 4.7K J 1/16W D500 RB706F-40 DIODE R673 RK73HB1J104J CHIP R 100K J 1/16W D501 MA2S111-F DIODE D502 NNCD6.8G-A ZENER DIODE R674 RK73HB1J471J CHIP R 470 J 1/16W D504 NNCD6.8G-A ZENER DIODE R675 RK73HB1J182J CHIP R 1.8K J 1/16W D505 1SS416 DIODE R676 RK73HB1J104J CHIP R 100K J 1/16W R690 RK73HB1J103J CHIP R 10K J 1/16W D510-512 RB706F-40 DIODE R693 RK73HB1J473J CHIP R 47K J 1/16W D515,516 AVRM1005C270M VARISTOR D517 DA221 DIODE R694,695 RK73HB1J104J CHIP R 100K J 1/16W D518,519 1SS416 DIODE R697-699 RK73HB1J104J CHIP R 100K J 1/16W D521 1SS416 DIODE R700-703 RK73HB1J474J CHIP R 470K J 1/16W R704 RK73HB1J104J CHIP R 100K J 1/16W D700 1SR154-400 DIODE R705 RK73HB1J474J CHIP R 470K J 1/16W D702 MA2S111-F DIODE D704 1SS388F DIODE R706 RK73HB1J000J CHIP R 0.0 J 1/16W D706 HRB0502A DIODE R707-709 RK73HB1J474J CHIP R 470K J 1/16W IC100 TLV2381IDBV MOS-IC R710 RK73HB1J000J CHIP R 0.0 J 1/16W R711 RK73HB1J474J CHIP R 470K J 1/16W IC101 ADF4111BCP7 MOS-IC R713 RK73HB1J564J CHIP R 560K J 1/16W IC200 TC75W51FK(F) MOS-IC IC201 TA75W01FUF MOS-IC R714 RK73HB1J154J CHIP R 150K J 1/16W IC300 CMY210 MOS-IC R716 RK73HB1J471J CHIP R 470 J 1/16W IC304 TA31137FNG MOS-IC R720 RK73HB1J224J CHIP R 220K J 1/16W R722 RK73HH1J334D CHIP R 330K D 1/16W IC306,307 TC7W53FK(F) MOS-IC R723 RK73HH1J124D CHIP R 120K D 1/16W IC309,310 ✽ NJG1615HA8 ANALOGUE IC IC400 MCP6021-E/OT MOS-IC R724 RK73GB2A100J CHIP R 10 J 1/10W IC500 TC75W51FK(F) MOS-IC R726 RK73HB1J474J CHIP R 470K J 1/16W IC501 TC7MBD3245AFK MOS-IC R727 RK73HB1J000J CHIP R 0.0 J 1/16W R729 RK73HB1J123J CHIP R 12K J 1/16W IC502 AK2330 MOS-IC R730 RK73HH1J334D CHIP R 330K D 1/16W IC503 TC75W51FK(F) MOS-IC IC505 PCA9535BS MOS-IC R731 RK73HH1J223D CHIP R 22K D 1/16W IC506 TC75S51FE(F) MOS-IC R749 RK73HB1J104J CHIP R 100K J 1/16W IC507-509 TC7W53FK(F) MOS-IC R750 RK73HB1J123J CHIP R 12K J 1/16W R751 RK73HB1J105J CHIP R 1.0M J 1/16W IC510 TC75W51FK(F) MOS-IC R752 RK73HB1J470J CHIP R 47 J 1/16W IC511 TC7SH126FU-F MOS-IC IC512,513 TC75W51FK(F) MOS-IC R753 RK73HB1J473J CHIP R 47K J 1/16W IC514 TC75S51FE(F) MOS-IC R754 RK73HB1J100J CHIP R 10 J 1/16W IC515 TC7S66FUF MOS-IC R756,757 RK73HB1J000J CHIP R 0.0 J 1/16W R759 RK73HB1J000J CHIP R 0.0 J 1/16W IC516 TC75W51FK(F) MOS-IC R760 RK73HB1J563J CHIP R 56K J 1/16W IC517 TC7SET08FU-F MOS-IC

32 TK-5410 PARTS LIST

TX-RX UNIT (X57-7560-10) New Desti- New Desti- Ref. No. Address parts Parts No. Description nation Ref. No. Address parts Parts No. Description nation IC700 TK11250CUCB MOS-IC IC701 XC6209B502PR MOS-IC IC702 XC6204B502MR MOS-IC IC704 TK11250CUCB MOS-IC IC705,706 XC6204B332M MOS-IC

IC707 XC6365D103M MOS-IC IC708 XC9101D09AKR ANALOGUE IC IC709 XC9235A15CM1 MOS-IC IC710 XC6204B332M MOS-IC IC712 NJM2130F3-ZB BI-POLAR IC

IC713 LM2682MMX MOS-IC IC714 LM73CIMKX-0 MOS-IC Q100 2SC4617(S) TRANSISTOR Q102 SSM6L05FU-F FET Q103 2SK879-F(Y) FET

Q104 2SC4617(S) TRANSISTOR Q105 SSM6L05FU-F FET Q106,107 2SK508NV(K52) FET Q108 2SJ347F FET Q109 2SC5636 TRANSISTOR

Q111,112 2SC5636 TRANSISTOR Q200 2SC5636 TRANSISTOR Q201 2SK3077F FET Q202 RD01MUS1-T113 FET Q203 SSM3K15TE(F) FET

Q204 ✽ RD07MVS1BT132 FET Q205 EMD9 TRANSISTOR Q206 SSM3K15TE(F) FET Q207 DTA144EEB DIGITAL TRANSISTOR Q208 SSM3K15TE(F) FET

Q300 SSM6L05FU-F FET Q302 BB505CES-TL-E FET Q303 2SC5636 TRANSISTOR Q304 EMD9 TRANSISTOR Q305 BB505CES-TL-E FET

Q308 2SJ347F FET Q309 2SC4215-F(Y) TRANSISTOR Q311 2SC4617(S) TRANSISTOR Q312 2SC5636 TRANSISTOR Q502 2SC4617(S) TRANSISTOR

Q503 SSM3K15TE(F) FET Q504 2SC4738(GR)F TRANSISTOR Q505 2SA1832(GR)F TRANSISTOR Q506 2SJ243-A FET Q507 SSM3K15TE(F) FET

Q508 2SJ347F FET Q509 SSM6N16FE-F FET Q700,701 SSM6L05FU-F FET Q703 SSM3K15TE(F) FET Q704 TPC6108-F FET

Q705 SSM5H01TU-F FET Q706 TPC6108-F FET Q707 2SJ648-A FET Q708 SSM3K15TE(F) FET Q709 SSM6L05FU-F FET

TH102 B57331V2104J THERMISTOR TH200 ERTJ0EV104H THERMISTOR

33 TK-5410 EXPLODED VIEW

A B

50 14 11 100 33 2 35 99 38 8 70

89x2 A 1 1 10 44 32 105 Nx2 88

Control PCB Nx2 41 Nx2 92 (X53) 93 58 59 107 110 98 83 57 94 108 95 113 27 79 73 53

G 51 47 55x2 7 49 B 80 B 76 52 9 H 97 J N N 77 40 2 61 45 N 84 K 56 N 4 28 15 O Top PCB Nx2 71 91 O Nx2 N (X57 B/3) 29 49 M O Nx3 108 Nx2 85 59 Dx2

702 22 Nx2 104 47 72 37 43 62 TX-RX PCB 74 (X57 A/3) 102 Option PCB 112 (X57 C/3) 86 46 3 82 31 23 A :N08-0531-14 B :N09-2439-25 Fx2 Fx2 3 64 C :N09-2441-25 43 D :N09-2442-15 66 E :N09-2443-14 700 26 24 F :N09-6574-05 701 G :N14-0813-14 E 34 H :N14-0814-14 J :N14-0815-04 63 703 K :N14-0817-14 5 M M2 x 4 :N32-2004-48 Cx2 Cx2 N M2 x 5 :N83-2005-48 13 O M2 x 6 :N83-2006-43

34 Parts with the exploded numbers larger than 700 are not supplied. TK-5410 PACKING

C D

1 67 Packing fixture (H12-3169-05)

17 Instruction manual 706 Pamphlet (ENG/FRE) 16 Sub-Instruction manual (QRC) (B62-2155-00) (B59-2596-00)

2 L Pan head machine screw (Belt clip) (N30-3008-60) x2 78 Belt clip (J29-0730-05) A Dressed screw (Cap) (N08-0531-14) 8 Cap (SP/MIC) (B09-4340-04)

38 Rubber sheet (Cap) (G11-4340-04)

3 68 Item carton case (H52-2320-02)

704

705

Parts with the exploded numbers larger than 700 are not supplied. 35 TK-5410 TROUBLE SHOOTING

Fault diagnosis of the BGA (Ball Grid Array) IC ■ Overview A ﬂ owchart for determining whether or not the transceiver can be powered on (the LCD does not function even if the power switch is turned on) due to broken BGA parts.

■ BGA parts ASIC (IC10), DSP (IC3), FLASH (IC1), SRAM (IC4)

When the BGA IC is problematic, please bring the printed circuit board (X53-4390-14 for 4-key, X53-4390-15 for DTMF keypad) in for service.

● Checking power supply voltage Checking voltage Checking for an abnormal point When an abnormal Points to be checked Normal voltage value is confirmed. 33M has an abnormal voltage. 33M IC705 (5 pin) 3.3V [ASIC] 15M IC709 (4 pin) 1.5V Remove L16 to check the voltage of the 33M. 33A IC710 (5 pin) 3.3V If the voltage becomes normal, the ASIC is broken. 31BU IC17 (3 pin) 3.1V [DSP] Remove L9 to check the voltage of the 33M. Power supply of each device is connected through the coil. If the voltage becomes normal, the DSP is broken. [ASIC] 33M: L16, 15M: L17, 33A: L19 15M has an abnormal voltage. [DSP] [ASIC] 33M: L9, 15M: L5 Remove L17 to check the voltage of the 15M. [FLASH] If the voltage becomes normal, the ASIC is broken. 33A: L4 [DSP] [SRAM] Remove L5 to check the voltage of the 15M. 31BU: L6 If the voltage becomes normal, the DSP is broken.

When a normal 33A has an abnormal voltage. ● Checking the clock value is confirmed. [ASIC] Checking the clock Remove L19 to check the voltage of the 33A. When an abnormal If the voltage becomes normal, the ASIC is broken. Points to be checked Normal voltage (3.3V) value is confirmed. [FLASH] 18.432MHz ASIC side R80 18.432MHz Remove L4 to check the voltage of the 33A. DSP side R81 18.432MHz If the voltage becomes normal, the FLASH is broken. 32.768kHz IC7 (1 pin) 32.768kHz 31BU has an abnormal voltage. When a normal [SRAM] ● Checking the Reset/Control signal value is confirmed. Remove L6 to check the voltage of the 31BU. Checking the control signal input to the ASIC If the voltage becomes normal, the SRAM is broken. When an abnormal Points to be checked Normal voltage value is confirmed. If the voltage is not corrected, there is a problem RESET IC5 (4 pin) 3.3V other than the BGA parts. /BINT Q7 (6 pin) 3.3V PSW Q8 (3 pin) 3.3V The BGA parts are not broken. When a normal value is confirmed. Checking the control signal output from the ASIC When an abnormal If the /FRST is always 0V, the ASIC is broken. value is confirmed. Points to be checked Normal voltage If the /FRST repeats 3.3V and 0V at intervals, /FRST C22 3.3V the ASIC, FLASH and SRAM may be broken. The BGA parts are not broken. When a normal value is confirmed.

36 TK-5410 TROUBLE SHOOTING

● Checking the output signal When a normal from the ASIC value is confirmed. When an abnormal Points to be checked Normal voltage value is confirmed. Remove R166, R161 and R270. If the ASIC side is 0V, SBC TP7 3.3V the ASIC/FLASH/SRAM may be broken. When a normal value is confirmed. When an abnormal Points to be checked Normal voltage value is confirmed. If the /DRST is 0V, the ASIC/FLASH/SRAM are broken. /DRST C21 3.3V When a normal ● The LCD displays control value is confirmed. When an abnormal Points to be checked Normal voltage value is confirmed. Remove R203. If the ASIC side is 0V, /LCDRST R203 3.3V the ASIC/FLASH/SRAM may be broken. When a normal value is confirmed. When an abnormal Points to be checked Normal voltage value is confirmed. If the /CS4 is 0V or 3.3V, the ASIC/FLASH/SRAM /CS4 IC18 (7 pin) 3.3V→0V→3.3V may be broken. When a normal value is confirmed. When an abnormal Points to be checked Normal voltage value is confirmed. If 5M is 0V, parts other than the BGA are broken. 5M IC704 (6 pin) 5.0V When a normal value is confirmed. It is unlikely that the BGA parts are broken.

● When an error display appears on the LCD. An error occurs when the ASIC internal RAM reads The LCD displays “INIT ERROR1”. or writes. The ASIC may be broken.

An error occurs when the DSP internal RAM reads The LCD displays “INIT ERROR2”. or writes. The DSP may be broken.

An error occurs when the SRAM internal RAM The LCD displays “INIT ERROR3”. reads or writes. The SRAM may be broken.

■ Descriptions of signal names 1) RST (RESET) : ASIC reset signal LOW → Reset 2) /BINT : Battery ﬁ nal voltage monitoring LOW → Final voltage 3) PSW : Power switch signal HIGH → ON 4) /FRST : FLASH reset signal LOW → Reset 5) SBC : Switch B control HIGH → ON 6) /DRST : DSP reset signal LOW → Reset 7) /LCDRST : LCD reset signal LOW → Reset 8) /CS4 : LCD controller chip select signal LOW → Active

Replacing Control Unit ■ Control unit Information Original Control For Service Control Model Name unit Number unit Number TK-5410 (K2: 4-key) X53-4390-11 X53-4390-14 TK-5410 X53-4390-12 X53-4390-15 (K3: DTMF keypad)

37 TK-5410 ADJUSTMENT

Controls Key Function Display [Side1] Squelch off Selector Hold Volume Wide: “W” Bandwidth change Concentric Switch NPSPAC: “S” [Side2] (Wide→NPSPAC→Narrow→ Narrow: “N” P25→Wide→...) P25: “A” [Side2] Unused - Side 1 key Hold Universal Shifts to the Panel tuning PTT switch connector Lever switch [Side3] - mode Orange key Side 2 key [Side3] LCD all lights LCD all point appears Side 3 key Hold [Orange] Beat shift on/off On: icon appears 6 [A] AFC on/off *1 On: icon appears [A] Compander on/off On: icon appears Hold Transmit power switching High: “HI” [B] (High→Low→Intnerant→ Low: “LO” Panel Test Mode High→...) Itinerant: “ ” ■ Test mode operation features [C] Test signaling down Signaling No. This transceiver has a test mode. To enter test mode, [D] Test signaling up Signaling No. press and hold the [Side3] and [PTT] keys while turning the Use as the DTMF keypad. transceiver power ON and then the [PTT] key first. Test [0] to [9] If a key is pressed during mode can be inhibited by programming. To exit test mode, and transmission, the DTMF turn the transceiver power OFF. [#], [ ] corresponding to the key that was presses is sent. • When the panel test mode is activated, the channel se- *1 AFC is normally ON when used. lected with the [Selector] knob and the last used signaling number are displayed. When it is activated for the • LED indicator ﬁ rst time, the signaling number is 1. Red LED Lights during transmission. Blinks at the low battery voltage warning. • If test signaling 26 (Tone Pattern) is selected, the result Green LED Lights when there is carrier. of Bit Error Rate (BER) calculation is displayed on the LCD. The BER value is also output from the serial port. • LCD display in the panel test mode

• The P25 and analog modes are switched automatically W: Wide by selecting test signaling. When P25 mode is effective, S: NPSPAC “A” is displayed on the LCD. N: Narrow A: P25 • Key operation LO W Key Function Display Signaling No. SQ.LV1 Test frequency channel [Selector] Channel No. Channel No. 1 - 1 [None ] up/down AFC PWR [Concentric Unused - switch] Talk around switching [Lever • Bandwidth (K: Talk around on, ●: Talk On: icon appears switch] around off) Display Condition [PTT] Transmit - W WIDE (5.0kHz/25.0kHz) Squelch level 0: S NPSPAC (4.0kHz/20.0kHz) “SQ.LV0” N NARROW (2.5kHz/12.5kHz) Squelch level change Squelch level 1: [Side1] A P25 (2.5kHz/12.5kHz) (0→1→2→...→9→0→1→2→...) “SQ.LV1” Squelch level 9: “SQ.LV9”

38 TK-5410 ADJUSTMENT

■ Frequency and Signaling Signaling P25/ RX Signaling TX Signaling The transceiver has been adjusted for the frequencies No. Analog shown in the following table. When required, readjust them 23 NAC 293 0 Continuous Pattern P25 following the adjustment procedure to obtain the frequencies you want in actual operation. 24 NAC 293 Fidelity Pattern P25 25 None FSW + PN9 P25 • Test Frequency NAC 293+1011Hz 26 NAC 293 P25 CH RX (MHz) TX (MHz) Tone Pattern NAC 293+1011Hz 1 763.05000 793.05000 27 Tone Pattern P25 Tone Pattern 2 769.05000 799.05000 Silence Pattern NAC 293 + Silence 28 P25 3 775.95000 805.95000 (1011Hz Full Rate) Pattern 4 763.55000 793.55000 Audio Test Pattern NAC 293+Audio Test 29 P25 5 769.55000 799.55000 (Full Rate) Pattern (Full Rate) Vocoder Loop 6 775.45000 805.45000 30 None P25 (Full Rate) 7 851.05000 806.05000 8 860.05000 815.05000 9 869.95000 824.95000 Panel Tuning Mode 10 851.55000 806.55000 The transceiver is adjusted in this mode. 11 860.55000 815.55000 12 869.45000 824.45000 ■ Preparations for tuning the transceiver Before attempting to tune the transceiver, connect the 13~16 - - unit to a suitable power supply. Whenever the transmitter is turned, the unit must be • Test Signaling connected to a suitable dummy load (i.e. power meter). Signaling P25/ The speaker output connector must be terminated with RX Signaling TX Signaling No. Analog a 8Ω dummy load and connected to an AC voltmeter and an 1 None None Analog audio distortion meter or a SINAD measurement meter at all times during tuning. 2 None 100Hz Square wave Analog 3 QT 67.0Hz QT 67.0Hz Analog ■ To enter the Panel Tuning Mode 4 QT 151.4Hz QT 151.4Hz Analog Press the [Side3] key in the panel test mode. Use the [B] key to write tuning data through tuning 5 QT 210.7Hz QT 210.7Hz Analog modes, and the [C] and [D] keys to adjust tuning require- 6 QT 254.1Hz QT 254.1Hz Analog ments (1 to 256 appears on the LCD). 7 DQT 023N DQT 023N Analog Use the [A] key to select the adjustment item through 8 DQT 754I DQT 754I Analog tuning modes. Use the [Side1] key to adjust 4, 6 or 8 reference level adjustments, and use the [Side2] key to switch DTMF Encode 9 None Analog between Wide/NPSPAC/Narrow/P25. (CODE: 159D) DTMF Encode 10 None Analog • LCD display in the panel tuning mode (CODE: 9) 11 None None Analog W: Wide 12 None None Analog S: NPSPAC Tuning point N: Narrow 13 None None Analog A: P25 14 None None Analog LO 15 None None Analog 7RL W 16 Codec Loop None Analog FM Max Dev 256 17 NAC 293 NAC 293 P25 Adjustment NXT SET item 18 NAC 023 NAC 023 P25 Adjustment 19 NAC 5EA NAC 5EA P25 value (1~256) 20 None PN9 P25 21 NAC 293 Symbol Rate Pattern P25 22 NAC 293 1/3 Deviation Pattern P25

39 TK-5410 ADJUSTMENT

• Key operation QT Fine Deviation (Wide/NPSPAC/Narrow) DQT Fine Deviation (Wide/NPSPAC/Narrow) Key Function DTMF Deviation (Wide/NPSPAC/Narrow) [Selector] Unused Tuning point Display RX (MHz) TX (MHz) [Concentric Unused switch] 700MHz RX/TA High 7RH 775.90000 776.00000 [Lever 700MHz TX High 7TH 775.90000 805.99375 Unused switch] 800MHz TX High 8TH 869.90000 825.00000 Transmission. When the battery low voltageis 800MHz RX/TA High 8RH 869.90000 870.00000 [PTT] adjusted, the adjustment value is displayed on the LCD. Squelch Open (Wide/NPSPAC/Narrow/P25) [Side1] To enter 4,6 or 8 reference level adjustments Squelch Tight (Wide/NPSPAC/Narrow) Bandwidth change [Side2] RSSI (Reference) (Wide/Narrow/P25) (Wide→NPSPAC→Narrow→P25→Wide→...) RSSI (–120dBm) (Wide/Narrow/P25) Exit the panel tuning mode and shift to the panel test RSSI (–70dBm) (Wide/Narrow/P25) [Side3] mode. Tuning point Display RX (MHz) TX (MHz) [Orange] Unused 700MHz RX/TA Low 7RL 763.10000 763.00000 Go to the next adjustment item [A] 700MHz RX/TA Center 7RC 769.10000 769.00000 (The current adjustment data is cleared.) 700MHz RX/TA High 7RH 775.90000 776.00000 Back to the last adjustment item [A] Hold (The current adjustment data is cleared.) 800MHz RX/TA Low 8RL 851.10000 851.00000 [B] Write the new adjustment value to the transceiver. 800MHz RX/TA Center 8RC 859.90000 860.00000 [C] Adjustment value down 800MHz RX/TA High 8RH 869.90000 870.00000 [D] Adjustment value up

■ 4,6 or 8 reference level adjustments frequency

Transmit Assist Voltage High Transmit Power Low Transmit Power Itinerant Frequency Transmit Power Balance Max Deviation (Wide,NPSPAC,Narrow) P25 High Deviation Tuning point Display RX (MHz) TX (MHz) 700MHz RX/TA Low 7RL 763.10000 763.00000 700MHz RX/TA High 7RH 775.90000 776.00000 700MHz TX Low 7TL 763.10000 793.00000 700MHz TX High 7TH 775.90000 805.99375 800MHz TX Low 8TL 851.10000 806.00000 800MHz TX High 8TH 869.90000 825.00000 800MHz RX/TA Low 8RL 851.10000 851.00000 800MHz RX/TA High 8RH 869.90000 870.00000

Receive Assist Voltage Tuning point Display RX (MHz) TX (MHz) 700MHz RX/TA Low 7RL 763.10000 763.00000 700MHz RX/TA High 7RH 775.90000 776.00000 800MHz RX/TA Low 8RL 851.10000 851.00000 800MHz RX/TA High 8RH 869.90000 870.00000

40 TK-5410 ADJUSTMENT

■ Adjustment item and Display (***: 1~256) Wide/NPSPAC/ No. Adjustment item Display Tuning Point Note Narrow/P25 1 Counterclockwise Volume Volume CCW *** -1 2 Clockwise Volume Volume CW *** -1 3 Transmit Assist Voltage TX Assist *** -8 4 Receive Assist Voltage RX Assist *** -4 5 Frequency Adjustment Frequency *** -1 6 High Transmit Power High Power *** -8 7 Low Transmit Power Low Power *** -8 8 Itinerant Frequentry Transmit Power ItinerantPow *** -8 9 Mic Sensitivity Mic Sense *** -1 100Hz 10 Balance Balance *** -8Square Wave 11 Max Deviation FM Max Dev *** Wide/NPSPAC/Narrow W: 8/S: 8/N: 8 Symbol 12 P25 High Deviation P25 High Dev *** P25 8 Rate Pattern QT: 13 QT Fine Deviation QT Dev Wide/NPSPAC/Narrow W: 4/S: 4/N: 4 *** 67Hz DQT: 14 DQT Fine Deviation DQT Dev Wide/NPSPAC/Narrow W: 4/S: 4/N: 4 *** 0.23N DTMF 15 DTMF Deviation DTMF Dev Wide/NPSPAC/Narrow W: 4/S: 4/N: 4 *** Code: 9 16 VOX 1 VOX1 *** -1 17 VOX 10 VOX10 *** -1 AF 18 Squelch Open Squelch (1) Wide/NPSPAC/Narrow/P25 W: 6/S: 6/N: 6/A: 6 *** unmute AF 19 Squelch Tight Squelch (9) Wide/NPSPAC/Narrow W: 6/S: 6/N: 6 *** unmute 20 RSSI (Reference) RSSI (Ref) *** Wide/Narrow/P25 W: 6/N: 6/A: 6 21 RSSI (–120 dBm) RSSI (–120) *** Wide/Narrow/P25 W: 6/N: 6/A: 6 22 RSSI (–70 dBm) RSSI (–70) *** Wide/Narrow/P25 W: 6/N: 6/A: 6 23 Battery Warning Level Battery *** -1 24 LCD Contrast LCD Contrast *** -1 25 RTC Correction RTC *** -1

41 TK-5410 ADJUSTMENT

■ Flow Chart

Panel Test Mode

[Side 3]

Counterclockwise Volume [Volume CCW] [A] Clockwise Volume [Volume CW] [A] Transmit Assist Voltage [Side 1] 8 reference level [TX Assist] adjustments [A] Recive Assist Voltage [Side 1] 4 reference level [RX Assist] adjustments [A] Frequency Adjustment [Frequency] [A] High Transmit Power [Side 1] 8 reference level [High Power] adjustments [A] Low Transmit Power [Side 1] 8 reference level [Low Power] adjustments [A] Itinerant Frequentry Transmit Power [Side 1] 8 reference level [ItinerantPow] adjustments [A] Mic Sensitivity [Mic Sense] [A] Balance [Side 1] 8 reference level [Balance] adjustments [A] Max Deviation (Wide) [Side 2] Max Deviation (NPSPAC) [Side 2] Max Deviation (Narrow) [A] Wide NPSPAC Narrow [FM Max Dev] [FM Max Dev] [FM Max Dev] [Side 1] [Side 1] [Side 1] 8 reference level adjustments

P25 High Deviation [Side 1] P25 8 reference level [P25 Hi Dev] adjustments [A] QT Fine Deviationn (Wide) [Side 2] QT Deviation (NPSPAC) [Side 2] QT Deviation (Narrow) [A] Wide NPSPAC Narrow [QT Dev] [QT Dev] [QT Dev] [Side 1] [Side 1] [Side 1] 4 reference level adjustments

DQT Fine Deviation (Wide) [Side 2] DQT Deviation (NPSPAC) [Side 2] DQT Deviation (Narrow) [A] Wide NPSPAC Narrow [DQT Dev] [DQT Dev] [DQT Dev] [Side 1] [Side 1] [Side 1] 4 reference level adjustments

DTMF Deviation (Wide) [Side 2] DTMF Deviation (NPSPAC) [Side 2] DTMF Deviation (Narrow) [A] Wide NPSPAC Narrow [DTMF Dev] [DTMF Dev] [DTMF Dev] [Side 1] [Side 1] [Side 1] 4 reference level adjustments

VOX 1 [VOX 1] [A] VOX 10 [VOX 10] [A] Squelch Open (Wide) [Side 2] Squelch Open (NPSPAC) [Side 2] Squelch Open (Narrow) [Side 2] Squelch Open (P25) [A] Wide NPSPAC Narrow P25 [Squelch (1)] [Squelch (1)] [Squelch (1)] [Squelch (1)] [Side 1] [Side 1] [Side 1] [Side 1] 6 reference level adjustments

Squelch Tight (Wide) [Side 2] Squelch Tight (NPAPAC) [Side 2] Squelch Tight (Narrow) [A] Wide NPSPAC Narrow [Squelch (9)] [Squelch (9)] [Squelch (9)] [Side 1] [Side 1] [Side 1] 6 reference level adjustments

RSSI (Reference) (Wide) [Side 2] RSSI (Reference) (Narrow) [Side 2] RSSI (Reference) (P25) [A] Wide NPSPAC P25 [RSSI (Ref)] [RSSI (Ref)] [RSSI (Ref)] [Side 1] [Side 1] [Side 1] 6 reference level adjustments

RSSI (–120 dBm) (Wide) [Side 2] RSSI (–120 dBm) (Narrow) [Side 2] RSSI (–120 dBm) (P25) [A] Wide NPSPAC P25 [RSSI (–120)] [RSSI (–120)] [RSSI (–120)] [Side 1] [Side 1] [Side 1] 6 reference level adjustments Battery Warning Level [Battery] [A] RSSI (–70 dBm) (Wide) [Side 2] RSSI (–70 dBm) (Narrow) [Side 2] RSSI (–70 dBm) (P25) [A] Wide NPSPAC P25 [RSSI (–70)] [RSSI (–70)] [RSSI (–70)] LCD Contrast [LCD Contrast] [Side 1] [Side 1] [Side 1] 6 reference level [A] adjustments RTC Correction [RTC] 42 [A] TK-5410 ADJUSTMENT

press and hold [A] press and hold [A] 4 reference 700M RX/TA Low [Side 1] 8 reference 700M RX/TA Low [Side 1] level 7RL level 7RL adjustments adjustments press and hold [A] [A] press and hold [A] [A] 700M RX/TA High [Side 1] 700M RX/TA High [Side 1] 7RH 7RH press and hold [A] [A] press and hold [A] [A] 800M RX/TA Low [Side 1] 700M TX Low [Side 1] 8RL 7TL press and hold [A] [A] press and hold [A] [A] 800M RX/TA High [Side 1] 700M TX High [Side 1] 8RH 7TH [A] press and hold [A] [A] adjustments 800M TX Low [Side 1] exit 8TL [Receive Assist Voltage] press and hold [A] [A] 800M TX High [Side 1] 8TH press and hold [A] [A] 800M RX/TA Low [Side 1] press and hold [A] 8RL 4 reference 700M RX/TA High [Side 1] press and hold [A] [A] level 7RH adjustments 800M RX/TA High [Side 1] press and hold [A] [A] 8RH 700M TX High [Side 1] [A] 7TH adjustments press and hold [A] [A] exit 800M TX High [Side 1] [Transmit Assist Voltage] 8TH [High Transmit Power] [Low Transmit Power] press and hold [A] [A] [Itinerant Frequency Transmit Power] 800M RX/TA High [Side 1] [Balance] 8RH [Max Deviation (Wide/NPSPAC/Narrow)] [A] [P25 High Deviation] adjustments exit [QT Fine Deviation (Wide/NPSPAC/Narrow)] [DQT Fine Deviation (Wide/NPSPAC/Narrow)] [DTMF Deviation (Wide/NPSPAC/Narrow)]

press and hold [A] 6 reference 700M RX/TA Low [Side 1] level 7RL adjustments press and hold [A] [A] 700M RX/TA Center [Side 1] 7RC press and hold [A] [A] 700M RX/TA High [Side 1] 7RH press and hold [A] [A] 800M RX/TA Low [Side 1] 8RL press and hold [A] [A] 800M RX/TA Center [Side 1] 8RC press and hold [A] [A] 800M RX/TA High [Side 1] 8RH [A] adjustments exit [Squelch Open (Wide/NPSPAC/Narrow/P25)] [Squelch Tight (Wide/NPSPAC/Narrow)] [RSSI (Reference)(Wide/Narrow/P25)] [RSSI (–120dBm)(Wide/Narrow/P25)] [RSSI (–70dBm)(Wide/Narrow/P25)]

43 TK-5410 ADJUSTMENT

BER (Bit Error Rate) Measurement C4FM (P25) Deviation Adjustment 1. The Panel Test Mode is used to measure the BER (Refer 1. The transceiver adjusts the deviation between High De- “Test mode operation features” described on page 38.). viation ±1800Hz for the C4FM (P25). 2. Select “26” for test signaling (Refer to “Test Signaling” 2. The Symbol Rate Pattern is used when adjusting the described on page 39.). High Deviation for the C4FM (P25) (Refer to “Test Signal- When “26” is selected for the test signaling, the Band- ing” described on page 39.). This test signal has a peak width is automatically selected to “P25”. deviation equal to π/2 1800Hz = 2827Hz. (If there is no RF input signal, the display shows “500000”.) Service Jig 3. Select a ﬁ lter (Refer to “Bandwidth” described on page 38.). ■ Nut wrench 4. Select a test frequency (Refer to “Test Frequency” de- In order to turn the volume nut and the channel selector scribed on page 39.). nut, use a recommendation tool. KENWOOD part No.: W05-1123-00

5. Measure the BER (Bit Error Rate) using the digital radio tester. Enter a standard input signal into the transceiver as a standard tone test pattern. 6. Adjust the input signal level to achieve the standard bit error rate (BER). (For example, if the BER is 5%, the display shows “050000”.)

Adjustment Points

TX-RX UNIT (X57-7560-10) (A/3) Component side

44 TK-5410 ADJUSTMENT

Test Equipment Required for Alignment Test Equipment Major Speciﬁ cations Frequency Range 700 to 900MHz Standard Signal Generator 1. Modulation Frequency modulation and external modulation (SSG) Output –127dBm/0.1µV to greater than –47dBm/1mV Input Impedance 50Ω 2. Power Meter Operation Frequency 700 to 900MHz or more Measurement Range Vicinity of 10W 3. Deviation Meter Frequency Range 700 to 900MHz Digital Volt Meter Measuring Range 10mV to 10V DC 4. (DVM) Input Impedance High input impedance for minimum circuit loading 5. Oscilloscope DC through 30MHz High Sensitivity Frequency Range 10Hz to 1000MHz 6. Frequency Counter Frequency Stability 0.2ppm or less 7. Ammeter 5A AF Volt Meter Frequency Range 50Hz to 10kHz 8. (AF VTVM) Voltage Range 1mV to 10V Frequency Range 50Hz to 5kHz or more 9. Audio Generator (AG) Output 0 to 1V Capability 3% or less at 1kHz 10. Distortion Meter Input Level 50mV to 10Vrms 11. Spectrum Analyzer Measuring Range DC to 1GHz or more Center frequency 50kHz to 900MHz 12. Tracking Generator Output Voltage 100mV or more 13. 8Ω Dummy Load Approx. 8Ω, 3W 5V to 10V, approx. 3A 14. Regulated Power Supply Useful if ammeter equipped

■ The following parts are required for adjustment

1. Antenna connector adapter The antenna connector of this transceiver uses an SMA 5.80V terminal. Use an antenna connector adapter [SMA (f) – BNC (f) or DC Power Supply SMA (f) – N (f)] for adjustment. (The adapter is not provided as an option, so buy a commercially-available one.)

Note: When the antenna connector adapter touches the knob, + Battery terminal draw out the knob to mount the connector.

2. Battery Jig Sensing line The optional KBP-6 battery case can be used as a battery KBP-6 JIG using the following modiﬁ cation (please refer to the following diagram).

We recommend that you increase the DC power supply - Battery terminal voltage to about 0.2V higher than the “TX inhibit voltage” before pressing the PTT switch. Then press the PTT switch and decrease the DC power supply voltage to the target Notice: level (such as 5.8V) for the adjustment check in TX mode. The battery voltage for TX inhibit should be measured at the “Battery terminal”, such as the sensing line, not the DC power supply terminal. Generally, there is approxi- mately a 0.1 to 0.3 V loss through the cable, causing a difference between the DC power supply and the Bat- tery terminal. 45 TK-5410 ADJUSTMENT

3. Universal connector BLU (7) To transceiver PTT SW Use the interface cable (KPG-36/36A) for PC tuning or the lead wire with plug (E30-3287-28) and screw (N08-0535- BRN (10) 08) for panel tuning. Connect the plug to the universal connector of the transceiver and tighten the screw. 100μ 10V RED (2) The lead wire with plug (E30-3287-28) and screw (N08- + 0535-08) terminals are as follows. Numbers are universal 8Ω AF Voltmeter connector terminal numbers. BLK (3) + 100μ 10V Caution WHT 1. When connecting the plug to the universal connector of (5) + 10μ 10V Audio generator the transceiver, a short circuit may occur. To prevent this, BRN (6) be sure to turn the transceiver POWER switch off. 2. Since the RX AF output is a BTL output, there is a DC component. Isolate this with a capacitor or transformer Note: Pin 1 (SSW) and Pin 4 (MSW) are connected to Pin 10 as shown in the ﬁ gure. (GND) to active External SP and External MIC. 3. Do not connect an instrument between red or black and GND. • PC tuning • Universal connector Connect the wires to the PCB in the connector case of interface cable. For output the wires out of the connector case, need to process the connector case.

KPG-36/36A 1 : SSW 2 : SP+ 3 : SP– 4 : MSW 5 : EMC 6 : ME 7 : PTT 8 : PF 9 : OPT 10 : E 11 : 5V 12 : TXD 13 : RXD 14 : NC

Remove the • Panel tuning screw Connector case

100μ 10V PCB layout 8Ω + 2 : RED (RX AF OUTPUT) AF voltmeter 100μ 10V 3 : BLACK (RX AF OUTPUT) +

5 : WHITE (MIC INPUT) 10μ 10V SCREW + 6 : BROWN (MIC GND) Audio generator TUBE 7 : BLUE (PTT SW) GND → ON Shield

8 : YELLOW (PF SW)

10 : BROWN (GND)

11 : GREEN (5M)

46 TK-5410 ADJUSTMENT

How to Remove the Flat Cable 1. Gently draw out both sides of the connector lever uni- formly in the direction of the arrow with tweezers. (CN1, CN35, CN38, CN505)

Tweezers

Flat cable

Lever

2. Gently rise up the connector lever in the direction of the arrow with a ﬂ at-head screwdriver or tweezers. (CN34)

Note: Gently push both sides of the connector lever, when put in the ﬂ at cable.

Flat-head screwdriver

Flat cable

Lever

3. Gently depress the connector lever in the direction of the arrow with a ﬂ at-head screwdriver or tweezers. (CN902, CN903)

Flat-head screwdriver

Lever

Flat cable

47 TK-5410 ADJUSTMENT

Common Section Condition Measurement Adjustment Speciﬁ cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment 1. Setting 1) BATT terminal voltage: 7.5V 2) SSG standard modulation [Wide] MOD: 1kHz, DEV: 3kHz [Narrow] MOD: 1kHz, DEV: 1.5kHz

2. Counter- 1) Adj item: [Volume 1) Adj item: [Counter- Panel [Panel tuning mode] This item is needed clockwise CCW] clockwise Volume] Turn the volume knob when the variable Volume Adjust: [***] counterclockwise resistor (R31-0654- fully. Press [B] key to 05) is replaced. store the adjustment value.

[PC test mode] Turn the volume knob counterclockwise fully. Press [Apply] button to store the adjustment value.

3. Clockwise 1) Adj item: [Volume 1) Adj item: [Clock- [Panel tuning mode] Volume CW] wise Volume] Turn the volume knob Adjust: [***] clockwise fully. Press [B] key to store the adjustment value.

[PC test mode] Turn the volume knob clockwise fully. Press [Apply] button to store the adjustment value.

4. Transmit 1) Adj item: [TX As- [Manual Adjustment] Power Panel ANT Panel [Panel [PC test mode] 2.3V±0.06V (CV) Assist sist] 1) Adj item: [Transmit meter TX/RX CV tuning [Automatic Adjustment] Voltage Adjust: [***] Assist Voltage] DVM (A/3) mode] 1) Press [*Tune Assist [PC test mode] 2) Adj item: [7RL]→ 2) Adj item: [Frequen- [C][D] Voltage (Auto)] button. [Manual Adjustment] [7RH]→[7TL]→ cy: 700MHz Band] 2) [Assist Voltage When adjusting [7TH]→[8TL]→ [RX/TA Low]→ [PC Result] window the assist voltage [8TH]→[8RL]→ [RX/TA High]→ test shows result of as- in PC tuning mode, [8RH] [TA Low]→ mode] sist voltage after the slide the bar to Adjust: [***] [TA High] [ ][ ] automatic adjustment indicate “VCO Lock PTT: ON [Frequency: was fi nished. Voltage” within Press [B] key to 800MHz Band] *This mode adjust 2.5V±0.1V on Me- store the adjust- [RX/TA Low]→ [TX], [RX] Assist volt- ter window. ment value. [RX/TA High]→ age at once. [TA Low]→ [Manual Adjustment] Remark: [TA High] 1) Press [Meter] but- Because the assist PTT: Press [Trans- ton. voltage in the PC mit] button. 2) The display on the tuning mode divides Press [OK] button [VCO Lock Voltage] the voltage through to store the adjust- indicator on the PC the buffer amplifi er, ment value. window shows VCO it is different from lock voltage. the voltage of the Change the adjust- CV terminal. ment value to get VCO lock voltage within the limit of the specifi ed voltage.

48 TK-5410 ADJUSTMENT

Condition Measurement Adjustment Specifi cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment Receive 1) Adj item: [RX As- [Manual Adjustment] Power Panel ANT Panel [Panel [PC test mode] 2.3V±0.06V (CV) Assist sist] 1) Adj item:[Receive meter TX/RX CV tuning [Automatic Adjustment] Voltage Adjust: [***] Assist Voltage] DVM (A/3) mode] 1) Press [*Tune Assist [PC test mode] 2) Adj item: [7RL]→ 2) Adj item: [Frequen- [C][D] Voltage (Auto)] button. [Manual Adjustment] [7RH]→[8RL]→ cy: 700MHz Band] 2) [Assist Voltage When adjusting [8RH] [RX/TA Low]→ [PC Result] window the assist voltage Adjust: [***] [RX/TA High] test shows result of as- in PC tuning mode, Press [B] key to [Frequency: mode] sist voltage after the slide the bar to store the adjust- 800MHz Band] [ ][ ] automatic adjustment indicate “VCO Lock ment value. [RX/TA Low]→ was fi nished. Voltage” within [RX/TA High] *This mode adjust 2.5V±0.1V on Me- [TX], [RX] Assist volt- ter window. age at once. [Manual Adjustment] Remark: 1) Press [Meter] but- Because the assist ton. voltage in the PC 2) The display on the tuning mode divides [VCO Lock Voltage] the voltage through indicator on the PC the buffer amplifi er, window shows VCO it is different from lock voltage. the voltage of the Change the adjust- CV terminal. ment value to get VCO lock voltage within the limit of the specifi ed voltage.

5. Frequency [Panel test mode] 1) Adj item: [Frequen- f. counter Panel ANT Panel [Panel 870.000210~ Note: Adjust- 1) CH-Sig: 1-1 cy Adjustment] tuning 870.000310MHz After replacing the ment *1 [Panel tuning mode] Press [OK] button mode] TCXO (X100) align 1) Adj item: [Frequen- to store the adjust- [C][D] frequency. cy] ment value. Adjust: [***] [PC PTT: ON test Press [B] key to mode] store the adjust- [ ][ ] ment value after adjustment.

6. LCD 1) Adj item: [LCD 1) Adj item: [LCD Panel [Panel Adjust the LCD This item is needed Contrast Contrast] Contrast] tuning contrast by looking. when the LCD Adjust: [***] Press [OK] button mode] (B38-0929-05) is Press [B] key to to store the adjust- [C][D] replaced. store the adjustment value. ment value. [PC test mode] [ ][ ]

*1 The reference oscillator frequency may drift due to shock (jarring the radio) or operating conditions. We recommend that the Frequency adjustment be checked each time the radio is serviced, or at least once per year. Maintenance should only be performed normal temperatures. 49 TK-5410 ADJUSTMENT

Condition Measurement Adjustment Speciﬁ cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment 7. RTC 1) Adj item: [RTC] 1) Adj item: [RTC Cor- Panel [Orange] [Panel tuning mode] Correction Adjust: [***] rection] Press [Orange] key. After automatic adjustment adjusted value is displayed on LCD. Press [B] key to store the adjustment value.

[PC test mode] Press [Start] button of “Auto Tuning”. Press [Apply] button to store the adjustment value after the automatic adjustment was ﬁ nished.

Transmitter Section Condition Measurement Adjustment Speciﬁ cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment 1. High 1) Adj item: [Hi Power] 1) Adj item: [High Power Panel ANT Panel [Panel 700MHz Band: <700MHz Band> Transmit Adjust: [***] Transmit Power] meter tuning 2.95W ±0.05W Power 2) Adj item: [7RL]→ 2) Adj item: [Frequen- Ammeter mode] 800MHz Band: 2.0A or less adjust [7RH]→[7TL]→ cy: 700MHz Band] [C][D] 3.0W [7TH]→[8TL]→ [RX/TA Low]→ <800MHz Band> [8TH]→[8RL]→ [RX/TA High]→ [PC ±0.1W [8RH] [TA Low]→ test 2.0A or less Adjust: [***] [TA High] mode] PTT: ON [Frequency: [ ][ ] Press [B] key to 800MHz Band] store the adjust- [RX/TA Low]→ ment value. [RX/TA High]→ [TA Low]→ [TA High] PTT: Press [Trans- mit] button. Press [OK] button to store the adjustment value.

2. Low 1) Adj item: [Low 1) Adj item: [Low 0.95W ±0.05W Transmit Power] Transmit Power] 1.0A or less Power Adjust: [***] 2) Adj item: [Frequen- adjust 2) Adj item: [7RL]→ cy: 700MHz Band] [7RH]→[7TL]→ [RX/TA Low]→ [7TH]→[8TL]→ [RX/TA High]→ [8TH]→[8RL]→ [TA Low]→ [8RH] [TA High] Adjust: [***] [Frequency: PTT: ON 800MHz Band] Press [B] key to [RX/TA Low]→ store the adjust- [RX/TA High]→ ment value. [TA Low]→ [TA High] PTT: Press [Trans- mit] button. Press [OK] button to store the adjustment value.

50 TK-5410 ADJUSTMENT

Condition Measurement Adjustment Speciﬁ cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment 3. Itinerant 1) Adj item: [Itinerant 1) Adj item: [Itinerant Power Panel ANT Panel [Panel 0.95W ±0.05W Frequency Pow] Frequency Transmit meter tuning 1.0A or less Transmit Adjust: [***] Power] Ammeter mode] Power 2) Adj item: [7RL]→ 2) Adj item: [Frequen- [C][D] [PC test mode] adjust [7RH]→[7TL]→ cy: 700MHz Band] As a simple adjust- [7TH]→[8TL]→ [RX/TA Low]→ [PC ment method, set [8TH]→[8RL]→ [RX/TA High]→ test it the adjustment [8RH] [TA Low]→ mode] value obtained from Adjust: [***] [TA High] [ ][ ] the [Low Transmit PTT: ON [Frequency: Power adjust] ad- Press [B] key to 800MHz Band] justment of step 2). store the adjust- [RX/TA Low]→ ment value. [RX/TA High]→ [TA Low]→ [TA High] PTT: Press [Trans- mit] button. Press [OK] button to store the adjustment value.

4. Mic 1) Adj item: [Mic 1) Adj item: [Mic Sen- Deviation Panel ANT Panel [Panel Write the value as Mic sensitivity Sensitivity Sens] sitivity] meter tuning followings. check: adjust Adjust: [***] PTT: Press [Trans- Oscilloscope mode] 48 (Reference 15mV±3.5mV PTT: ON mit] button. [C][D] value) Press [B] key to Press [OK] button store the adjust- to store the adjust- [PC ment value. ment value. test mode] [ ][ ]

5. Balance 1) Adj item: [Balance] 1) Adj item: [Balance] Deviation Panel ANT Panel [Panel Make the demodu- adjust *2 Adjust: [***] Deviation meter meter tuning lation waves into Deviation meter LPF: 3kHz Oscilloscope mode] square waves. LPF: 3kHz HPF: OFF [C][D] HPF: OFF 2) Adj item: [Frequen- 2) Adj item: [7RL]→ cy: 700MHz Band] [PC [7RH]→[7TL]→ [RX/TA Low]→ test [7TH]→[8TL]→ [RX/TA High]→ mode] [8TH]→[8RL]→ [TA Low]→ [ ][ ] [8RH] [TA High] Adjust: [***] [Frequency: PTT: ON 800MHz Band] Press [B] key to [RX/TA Low]→ store the adjust- [RX/TA High]→ ment value. [TA Low]→ [TA High] PTT: Press [Trans- mit] button. Press [OK] button to store the adjustment value.

51 TK-5410 ADJUSTMENT

Condition Measurement Adjustment Speciﬁ cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment 6. Max 1) Adj item: [W FM 1) Adj item: [Max Deviation Panel ANT Panel [Panel 4.0kHz 4.2kHz or less Deviation Max Dev] Deviation (Wide)] meter tuning (According to the adjust *2 Adjust: [***] 2) Adj item: [Frequen- Oscilloscope mode] larger +, –) Remark: [Wide] 2) Adj item: [7RL]→ cy: 700MHz Band] [C][D] As a simple adjust- [7RH]→[7TL]→ [RX/TA Low]→ ment method, set [7TH]→[8TL]→ [RX/TA High]→ [PC it the adjustment [8TH]→[8RL]→ [TA Low]→ test value obtained from [8RH] [TA High] mode] the [Max Deviation Adjust: [***] [Frequency: [ ][ ] adjust [Narrow]] PTT: ON 800MHz Band] adjustment of step Press [B] key to [RX/TA Low]→ 2). store the adjust- [RX/TA High]→ ment value. [TA Low]→ [TA High] PTT: Press [Trans- mit] button. Press [OK] button to store the adjustment value.

[NPSPAC] 1) Adj item: [S FM 1) Adj item: [Max De- 3.2kHz ±50Hz Max Dev] viation (NPSPAC)] (According to the Adjust: [***] 2) Adj item: [Frequen- larger +, –) Remark: 2) Adj item: [7RL]→ cy: 700MHz Band] As a simple adjust- [7RH]→[7TL]→ [RX/TA Low]→ ment method, set [7TH]→[8TL]→ [RX/TA High]→ it the adjustment [8TH]→[8RL]→ [TA Low]→ value obtained from [8RH] [TA High] the [Max Deviation Adjust: [***] [Frequency: adjust [Narrow]] PTT: ON 800MHz Band] adjustment of step Press [B] key to [RX/TA Low]→ 2). store the adjust- [RX/TA High]→ ment value. [TA Low]→ [TA High] PTT: Press [Trans- mit] button. Press [OK] button to store the adjustment value.

[Narrow] 1) Adj item: [N FM 1) Adj item: [Max 2.0kHz ±50Hz Max Dev] Deviation (Narrow)] (According to the Adjust: [***] Deviation meter larger +, –) Deviation meter LPF: 15kHz LPF: 15kHz HPF: OFF HPF: OFF 2) Adj item: [Frequen- 2) Adj item: [7RL]→ cy: 700MHz Band] [7RH]→[7TL]→ [RX/TA Low]→ [7TH]→[8TL]→ [RX/TA High]→ [8TH]→[8RL]→ [TA Low]→ [8RH] [TA High] Adjust: [***] [Frequency: PTT: ON 800MHz Band] Press [B] key to [RX/TA Low]→ store the adjust- [RX/TA High]→ ment value. [TA Low]→ [TA High] PTT: Press [Trans- mit] button. Press [OK] button to store the adjustment value.

52 TK-5410 ADJUSTMENT

Condition Measurement Adjustment Speciﬁ cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment 7. P25 High 1) Adj item: [A P25 1) Adj item: [P25 High Power Panel ANT Panel [Panel 2827Hz 2771~2883Hz Deviation High Dev] Deviation] meter tuning adjust *2 Adjust: [***] 2) Adj item: [Frequen- Deviation mode] Remark: Deviation meter cy: 700MHz Band] meter [C][D] As a simple adjust- LPF: 3kHz [RX/TA Low]→ Oscilloscope ment method, set HPF: OFF [RX/TA High]→ [PC it the adjustment 2) Adj item: [7RL]→ [TA Low]→ test value obtained from [7RH]→[7TL]→ [TA High] mode] the [Max Deviation [7TH]→[8TL]→ [Frequency: [ ][ ] adjust [Narrow] ] [8TH]→[8RL]→ 800MHz Band] adjustment of step [8RH] [RX/TA Low]→ 2). Adjust: [***] [RX/TA High]→ PTT: ON [TA Low]→ Press [B] key to [TA High] store the adjust- PTT: Press [Trans- ment value. mit] button. Press [OK] button to store the adjustment value.

8. QT Fine 1) Adj item: [W QT 1) Adj item: [QT Fine Deviation Panel ANT Panel [Panel Write the value as 0.75kHz±50Hz Deviation Dev] Deviation (Wide)] meter tuning followings. adjust *2 Adjust: [***] Deviation meter Oscilloscope mode] 136 (Reference [Wide] PTT: ON LPF: 3kHz [C][D] value) Press [B] key to HPF: OFF store the adjust- 2) Adj item: [Frequen- [PC ment value. cy: 700MHz Band] test [RX/TA High]→ mode] [TX High] [ ][ ] [Frequency: 800MHz Band] [RX/TA High]→ [TX High] PTT: Press [Trans- mit] button. Press [OK] button to store the adjustment value.

[NPSPAC] 1) Adj item: [S QT 1) Adj item: [QT 0.60kHz±50Hz Dev] Fine Deviation Adjust: [***] (NPSPAC)] PTT: ON 2) Adj item: [Frequen- Press [B] key to cy: 700MHz Band] store the adjust- [RX/TA High]→ ment value. [TX High] [Frequency: 800MHz Band] [RX/TA High]→ [TX High] PTT: Press [Trans- mit] button. Press [OK] button to store the adjustment value.

53 TK-5410 ADJUSTMENT

Condition Measurement Adjustment Speciﬁ cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment QT Fine 1) Adj item: [N QT 1) Adj item: [QT Fine Deviation Panel ANT Panel [Panel Write the value as 0.375kHz±50Hz Deviation Dev] Deviation (Narrow)] meter tuning followings. adjust *2 Adjust: [***] 2) Adj item: [Frequen- Oscilloscope mode] 136 (Reference [Narrow] PTT: ON cy: 700MHz Band] [C][D] value) Press [B] key to [RX/TA High]→ store the adjust- [TX High] [PC ment value. [Frequency: test 800MHz Band] mode] [RX/TA High]→ [ ][ ] [TX High] PTT: Press [Trans- mit] button. Press [OK] button to store the adjustment value.

9. DQT Fine 1) Adj item: [W DQT 1) Adj item: [DQT Fine Write the value as 0.75kHz±50Hz Deviation Dev] Deviation (Wide)] followings. adjust *2 Adjust: [***] Deviation meter 114 (Reference [Wide] PTT: ON LPF: 3kHz value) Press [B] key to HPF: OFF store the adjust- 2) Adj item: [Frequen- ment value. cy: 700MHz Band] [RX/TA High]→ [TX High] [Frequency: 800MHz Band] [RX/TA High]→ [TX High] PTT: Press [Trans- mit] button. Press [OK] button to store the adjustment value.

[NPSPAC] 1) Adj item: [S DQT 1) Adj item: [DQT Write the value as 0.60kHz±50Hz Dev] Fine Deviation followings. Adjust: [***] (NPSPAC)] 126 (Reference PTT: ON 2) Adj item: [Frequen- value) Press [B] key to cy: 700MHz Band] store the adjust- [RX/TA High]→ ment value. [TX High] [Frequency: 800MHz Band] [RX/TA High]→ [TX High] PTT: Press [Trans- mit] button. Press [OK] button to store the adjustment value.

54 TK-5410 ADJUSTMENT

Condition Measurement Adjustment Speciﬁ cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment DQT Fine 1) Adj item: [N DQT 1) Adj item: [DQT Fine Deviation Panel ANT Panel [Panel Write the value as 0.375kHz±50Hz Deviation Dev] Deviation (Narrow)] meter tuning followings. adjust *2 Adjust: [***] 2) Adj item: [Frequen- Oscilloscope mode] 116 (Reference [Narrow] PTT: ON cy: 700MHz Band] [C][D] value) Press [B] key to [RX/TA High]→ store the adjust- [TX High] [PC ment value. [Frequency: test 800MHz Band] mode] [RX/TA High]→ [ ][ ] [TX High] PTT: Press [Trans- mit] button. Press [OK] button to store the adjustment value.

10. DTMF 1) Adj item: [W DTMF 1) Adj item: [DTMF Write the value as 3.0kHz±100Hz Deviation Dev] Fine Deviation followings. adjust *2 Adjust: [***] (Wide)] 173 (Reference [Wide] PTT: ON Deviation meter value) Press [B] key to LPF: 3kHz store the adjust- HPF: OFF ment value. 2) Adj item: [Frequen- cy: 700MHz Band] [RX/TA High]→ [TX High] [Frequency: 800MHz Band] [RX/TA High]→ [TX High] PTT: Press [Trans- mit] button. Press [OK] button to store the adjustment value.

[NPSPAC] 1) Adj item: [S DTMF 1) Adj item: [DTMF 2.4kHz±100Hz Dev] Fine Deviation Adjust: [***] (NPSPAC)] PTT: ON 2) Adj item: [Frequen- Press [B] key to cy: 700MHz Band] store the adjust- [RX/TA High]→ ment value. [TX High] [Frequency: 800MHz Band] [RX/TA High]→ [TX High] PTT: Press [Trans- mit] button. Press [OK] button to store the adjustment value.

55 TK-5410 ADJUSTMENT

Condition Measurement Adjustment Speciﬁ cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment DTMF 1) Adj item: [N DTMF 1) Adj item: [DTMF Deviation Panel ANT Panel [Panel Write the value as 1.5kHz±100Hz Deviation Dev] Fine Deviation (Nar- meter tuning followings. adjust *2 Adjust: [***] row)] Oscilloscope mode] 173 (Reference [Narrow] PTT: ON 2) Adj item: [Frequen- [C][D] value) Press [B] key to cy: 700MHz Band] store the adjust- [RX/TA High]→ [PC ment value. [TX High] test [Frequency: mode] 800MHz Band] [ ][ ] [RX/TA High]→ [TX High] PTT: Press [Trans- mit] button. Press [OK] button to store the adjustment value.

11. VOX 1 1) Adj item: [VOX1] 1) Adj item: [VOX1] AG Panel Universal Panel [Panel tuning mode] adjust Adjust: [***] AG: 1kHz/45mV at connector After apply signal AG: 1kHz/45mV at MIC terminal from AG, press [B] MIC terminal key to store the adjustment value.

[PC test mode] After apply signal from AG, press [Ap- ply] button to store the adjustment value.

12. VOX 10 1) Adj item: [VOX10] 1) Adj item: [VOX10] AG Panel Universal Panel [Panel tuning mode] adjust Adjust: [***] AG: 1kHz/3mV at connector After apply signal AG: 1kHz/3mV at MIC terminal from AG, press [B] MIC terminal key to store the adjustment value.

[PC test mode] After apply signal from AG, press [Ap- ply] button to store the adjustment value.

56 TK-5410 ADJUSTMENT

Condition Measurement Adjustment Speciﬁ cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment 13. Battery 1) Adj item: [Battery] 1) Adj item: [Battery Power Panel ANT Panel [Panel tuning mode] BATT terminal volt- Warning Adjust: [***] Warning Level] meter BATT After pressing the age: 5.8V Level PTT: ON PTT: Press [Trans- DVM terminal PTT switch, conﬁ rm writing mit] button. that one predeter- mined numeric in the range 1 to 256 appears and then press [B] key That numeric will be stored in memory.

[PC test mode] After pressing the PTT switch, conﬁ rm that one predeter- mined numeric in the range 1 to 256 appears and then press [Apply] key That numeric will be stored in memory.

14. Battery [Panel test mode] 1) Test Channel: Chan- The transceiver can Warning 1) CH-Sig: 1-1 nel 1 transmit without Level BATT terminal volt- Test Signaling causing the LED to check age: 6.0V Mode: Analog blink. PTT: ON Signaling: 1 BATT terminal voltage: 6.0V PTT: Press [Trans- mit] button.

57 TK-5410 ADJUSTMENT

*2 Necessary adjustment and order for each signaling is shown as below. Necessary adjustment and order Mode Signaling Wide Narrow 1. Balance adjust 1. Balance adjust Audio 2. Max Deviation adjust [Wide] 2. Max Deviation adjust [Narrow] 1. Balance adjust 1. Balance adjust QT 2. Max Deviation adjust [Wide] 2. Max Deviation adjust [Narrow] 3. QT Fine Deviation adjust [Wide] 3. QT Fine Deviation adjust [Narrow] Analog 1. Balance adjust 1. Balance adjust DQT 2. Max Deviation adjust [Wide] 2. Max Deviation adjust [Narrow] 3. DQT Fine Deviation adjust [Wide] 3. DQT Fine Deviation adjust [Narrow] 1. Balance adjust 1. Balance adjust DTMF 2. Max Deviation adjust [Wide] 2. Max Deviation adjust [Narrow] 3. DTMF Deviation adjust [Wide] 3. DTMF Deviation adjust [Narrow] 1. Balance adjust P25 – 2. P25 High Deviation adjust

Receiver Section Condition Measurement Adjustment Speciﬁ cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment 1. AF level [Panel test mode] 1) Test Ch: SSG Panel ANT Panel Volume Turn the Volume 0.63V±0.1V setting 1) CH-Sig: 1-1 Channel 1 DVM Universal knob knob to obtain SSG output: Test Signaling AF VTVM connector 0.63V AF output. –47dBm (1mV) Mode: Analog Dummy (MOD: 1kHz/±1.5kHz) Signaling: 1 load SSG output: –47dBm (1mV) (MOD: 1kHz/±1.5kHz)

2. Sensitivity 1) CH-Sig: 2-1 1) Test Channel: SSG Panel ANT Check 12dB SINAD or check SSG output Channel 2 AF VTVM Universal more Wide: –118dBm Test Signaling Oscilloscope connector (0.28µV) Mode: Analog (MOD: 1kHz/±3kHz) Signaling: 1 Narrow: –118dBm SSG output (0.28µV) Wide: –118dBm (MOD: 1kHz/±1.5kHz) (0.28µV) 2) CH-Sig: 8-1 (MOD: 1kHz/±3kHz) Other conditions Narrow: –118dBm are same as 1. (0.28µV) (MOD: 1kHz/±1.5kHz) 2) Test Channel: Channel 8 Other conditions are same as 1.

58 TK-5410 ADJUSTMENT

Condition Measurement Adjustment Speciﬁ cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment 3. RSSI 1) Adj item: [W RSSI 1) Adj item: [RSSI SSG Panel ANT Panel [Panel tuning mode] reference (Ref)] Reference (Wide)] AF VTVM Universal After input signal adjust Adjust: [***] 2) Adj item: [Frequen- Oscilloscope connector from SSG, press [Wide] 2) Adj item: [7RL]→ cy: 700 MHz Band] [B] key to store the [7RC]→[7RH]→ [RX/TA Low]→ adjustment value. [8RL]→[8RC]→ [RX/TA Center]→ [8RH] [RX/TA High] [PC test mode] SSG output: 12dB [Frequency: 800 After input signal SINAD level –3dB MHz Band] from SSG, press (MOD: 1kHz/±3kHz) [RX/TA Low]→ [Apply] button to [RX/TA Center]→ store the adjust- [RX/TA High] ment value. SSG output: 12dB SINAD level –3dB (MOD: 1kHz/±3kHz)

[Narrow] 1) Adj item: [N RSSI 1) Adj item: [RSSI Ref- (Ref)] erence (Narrow)] Adjust: [***] 2) Adj item: [Frequen- 2) Adj item: [7RL]→ cy: 700 MHz Band] [7RC]→[7RH]→ [RX/TA Low] [8RL]→[8RC]→ [RX/TA Center]→ [8RH] [RX/TA High]→ SSG output: 12dB [Frequency: 800 SINAD level –3dB MHz Band] (MOD: 1kHz/±1.5kHz) [RX/TA Low]→ [RX/TA Center]→ [RX/TA High] SSG output: 12dB SINAD level –3dB (MOD: 1kHz/±1.5kHz)

[P25] 1) Adj item: [A RSSI 1) Adj item: [RSSI (Ref)] Reference (P25)] Adjust: [***] 2) Adj item: [Frequen- 2) Adj item: [7RL]→ cy: 700 MHz Band] [7RC]→[7RH]→ [RX/TA Low]→ [8RL]→[8RC]→ [RX/TA Center]→ [8RH] [RX/TA High] SSG output: 12dB [Frequency: 800 SINAD level –3dB MHz Band] (MOD: 1kHz/±3kHz) [RX/TA Low]→ [RX/TA Center]→ [RX/TA High]

59 TK-5410 ADJUSTMENT

Condition Measurement Adjustment Speciﬁ cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment 4. Open 1) Adj item: [W 1) Adj item: [Squelch SSG Panel ANT Panel [Panel tuning mode] Squelch Squelch (1)] Open (Wide)] AF VTVM Universal After input signal adjust Adjust: [***] 2) Adj item: [Frequen- Oscilloscope connector from SSG, press (Squelch 2) Adj item: [7RL]→ cy: 700 MHz Band] [B] key to store the level 1 [7RC]→[7RH]→ [RX/TA Low]→ adjustment value. adjust) [8RL]→[8RC]→ [RX/TA Center]→ [Wide] [8RH] [RX/TA High] [PC test mode] SSG output: 12dB [Frequency: 800 After input signal SINAD level –3dB MHz Band] from SSG, press (MOD: 1kHz/±3kHz) [RX/TA Low]→ [Apply] button to [RX/TA Center]→ store the adjust- [RX/TA High] ment value. SSG output: 12dB SINAD level –3dB (MOD: 1kHz/±3kHz)

[NPSPAC] 1) Adj item: [S Squelch 1) Adj item: [Squelch (1)] Open (NPSPAC)] Adjust: [***] 2) Adj item: [Frequen- 2) Adj item: [7RL]→ cy: 700 MHz Band] [7RC]→[7RH]→ [RX/TA Low]→ [8RL]→[8RC]→ [RX/TA Center]→ [8RH] [RX/TA High] SSG output: 12dB [Frequency: 800 SINAD level –3dB MHz Band] (MOD: 1kHz/±2.4kHz) [RX/TA Low]→ [RX/TA Center]→ [RX/TA High] SSG output: 12dB SINAD level –3dB (MOD: 1kHz/±2.4kHz)

[Narrow] 1) Adj item: [N 1) Adj item: [Squelch Squelch (1)] Open (Narrow)] Adjust: [***] 2) Adj item: [Frequen- 2) Adj item: [7RL]→ cy: 700 MHz Band] [7RC]→[7RH]→ [RX/TA Low]→ [8RL]→[8RC]→ [RX/TA Center]→ [8RH] [RX/TA High] SSG output: 12dB [Frequency: 800 SINAD level –4dB MHz Band] (MOD: 1kHz/±1.5kHz) [RX/TA Low]→ [RX/TA Center]→ [RX/TA High] SSG output: 12dB SINAD level –4dB (MOD: 1kHz/±1.5kHz)

[P25] 1) Adj item: [A 1) Adj item: [Squelch Squelch (1)] Open (P25)] Adjust: [***] 2) Adj item: [Frequen- 2) Adj item: [7RL]→ cy: 700 MHz Band] [7RC]→[7RH]→ [RX/TA Low]→ [8RL]→[8RC]→ [RX/TA Center]→ [8RH] [RX/TA High] SSG output: 12dB [Frequency: 800 SINAD level of [Wide] MHz Band] (MOD: 1kHz/±3kHz) [RX/TA Low]→ [RX/TA Center]→ [RX/TA High] SSG output: 12dB SINAD level of [Wide] (MOD: 1kHz/±3kHz)

60 TK-5410 ADJUSTMENT

Condition Measurement Adjustment Speciﬁ cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment 5. Tight 1) Adj item: [W 1) Adj item: [Squelch SSG Panel ANT Panel [Panel tuning mode] Squelch Squelch (9)] Tight (Wide)] AF VTVM Universal After input signal adjust Adjust: [***] 2) Adj item: [Frequen- Oscilloscope connector from SSG, press (Squelch 2) Adj item: [7RL]→ cy: 700 MHz Band] [B] key to store the level 9 [7RC]→[7RH]→ [RX/TA Low]→ adjustment value. adjust) [8RL]→[8RC]→ [RX/TA Center]→ [Wide] [8RH] [RX/TA High] [PC test mode] SSG output: 12dB [Frequency: 800 After input signal SINAD level +6dB MHz Band] from SSG, press (MOD: 1kHz/±3kHz) [RX/TA Low]→ [Apply] button to [RX/TA Center]→ store the adjust- [RX/TA High] ment value. SSG output: 12dB SINAD level +6dB (MOD: 1kHz/±3kHz)

[NPSPAC] 1) Adj item: [S Squelch 1) Adj item: [Squelch (9)] Tight (NPSPAC)] Adjust: [***] 2) Adj item: [Frequen- 2) Adj item: [7RL]→ cy: 700 MHz Band] [7RC]→[7RH]→ [RX/TA Low]→ [8RL]→[8RC]→ [RX/TA Center]→ [8RH] [RX/TA High] SSG output: 12dB [Frequency: 800 SINAD level +6dB MHz Band] (MOD: 1kHz/±2.4kHz) [RX/TA Low]→ [RX/TA Center]→ [RX/TA High] SSG output: 12dB SINAD level +6dB (MOD: 1kHz/±2.4kHz)

[Narrow] 1) Adj item: [N 1) Adj item: [Squelch Squelch (9)] Tight (Narrow)] Adjust: [***] 2) Adj item: [Frequen- 2) Adj item: [7RL]→ cy: 700 MHz Band] [7RC]→[7RH]→ [RX/TA Low]→ [8RL]→[8RC]→ [RX/TA Center]→ [8RH] [RX/TA High] SSG output: 12dB [Frequency: 800 SINAD level +6dB MHz Band] (MOD: 1kHz/±1.5kHz) [RX/TA Low]→ [RX/TA Center]→ [RX/TA High] SSG output: 12dB SINAD level +6dB (MOD: 1kHz/±1.5kHz)

61 TK-5410 ADJUSTMENT

Condition Measurement Adjustment Speciﬁ cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment 6. RSSI at 1) Adj item: [W RSSI 1) Adj item: [RSSI SSG Panel ANT Panel [Panel tuning mode] –120dBm (–120)] (–120dBm) (Wide)] AF VTVM Universal After input signal adjust Adjust: [***] 2) Adj item: [Frequen- Oscilloscope connector from SSG, press [Wide] 2) Adj item: [7RL]→ cy: 700 MHz Band] [B] key to store the [7RC]→[7RH]→ [RX/TA Low]→ adjustment value. [8RL]→[8RC]→ [RX/TA Center]→ [8RH] [RX/TA High] [PC test mode] SSG output: [Frequency: 800 After input signal –120dBm (0.22µV) MHz Band] from SSG, press (MOD: 1kHz/±3kHz) [RX/TA Low]→ [Apply] button to [RX/TA Center]→ store the adjust- [RX/TA High] ment value. SSG output: –120dBm (MOD: 1kHz/±3kHz)

[Narrow] 1) Adj item: [N RSSI 1) Adj item: [RSSI (–120)] (–120dBm) Adjust: [***] (Narrow)] 2) Adj item: [7RL]→ 2) Adj item: [Frequen- [7RC]→[7RH]→ cy: 700 MHz Band] [8RL]→[8RC]→ [RX/TA Low]→ [8RH] [RX/TA Center]→ SSG output: [RX/TA High] –120dBm (0.22µV) [Frequency: 800 (MOD: 1kHz/±1.5kHz) MHz Band] [RX/TA Low]→ [RX/TA Center]→ [RX/TA High] SSG output: –120dBm (MOD: 1kHz/±1.5kHz)

[P25] 1) Adj item: [A RSSI 1) Adj item: [RSSI (–120)] (–120dBm) (P25)] Adjust: [***] 2) Adj item: [Frequen- 2) Adj item: [7RL]→ cy: 700 MHz Band] [7RC]→[7RH]→ [RX/TA Low]→ [8RL]→[8RC]→ [RX/TA Center]→ [8RH] [RX/TA High] SSG output: [Frequency: 800 –120dBm (0.22µV) MHz Band] (MOD: 1kHz/±3kHz) [RX/TA Low]→ [RX/TA Center]→ [RX/TA High]

62 TK-5410 ADJUSTMENT

Condition Measurement Adjustment Speciﬁ cations / Item Test- Panel tuning mode PC test mode Unit Terminal Unit Parts Method Remarks equipment 7. RSSI at 1) Adj item: [W RSSI 1) Adj item: [RSSI SSG Panel ANT Panel [Panel tuning mode] –70dBm (–70)] (–70dBm) (Wide)] AF VTVM Universal After input signal adjust Adjust: [***] 2) Adj item: [Frequen- Oscilloscope connector from SSG, press [Wide] 2) Adj item: [7RL]→ cy: 700 MHz Band] [B] key to store the [7RC]→[7RH]→ [RX/TA Low]→ adjustment value. [8RL]→[8RC]→ [RX/TA Center]→ [8RH] [RX/TA High] [PC test mode] SSG output: [Frequency: 800 After input signal –70dBm (70.7µV) MHz Band] from SSG, press (MOD: 1kHz/±3kHz) [RX/TA Low]→ [Apply] button to [RX/TA Center]→ store the adjust- [RX/TA High] ment value. SSG output: –70dBm (MOD: 1kHz/±3kHz)

[Narrow] 1) Adj item: [N RSSI 1) Adj item: [RSSI (–70)] (–70dBm) Adjust: [***] (Narrow)] 2) Adj item: [7RL]→ 2) Adj item: [Frequen- [7RC]→[7RH]→ cy: 700 MHz Band] [8RL]→[8RC]→ [RX/TA Low]→ [8RH] [RX/TA Center]→ SSG output: [RX/TA High] –70dBm (70.7µV) [Frequency: 800 (MOD: 1kHz/±1.5kHz) MHz Band] [RX/TA Low]→ [RX/TA Center]→ [RX/TA High] SSG output: –70dBm (MOD: 1kHz/±1.5kHz)

[P25] 1) Adj item: [A RSSI 1) Adj item: [RSSI (–70)] (–70dBm) (P25)] Adjust: [***] 2) Adj item: [Frequen- 2) Adj item: [7RL]→ cy: 700 MHz Band] [7RC]→[7RH]→ [RX/TA Low]→ [8RL]→[8RC]→ [RX/TA Center]→ [8RH] [RX/TA High] SSG output: [Frequency: 800 –70dBm (70.7µV) MHz Band] (MOD: 1kHz/±3kHz) [RX/TA Low]→ [RX/TA Center]→ [RX/TA High]

63 TK-5410 TERMINAL FUNCTION

Control unit (X53-4390-XX) Pin Name I/O Function No Pin Name I/O Function No CN35 CN1 1 NC - No connection 1 NC - No connection 2 L_MIC I Noise canceler MIC 2 LCDCNT O LCD reset output 3 MICE - MIC GND 3V4 -Step up capacitor connecting terminal 4 GND - GND 4V3 -Step up capacitor connecting terminal 5 CH_A I Rotary switch input 1 5V2 -Step up capacitor connecting terminal 6 CH_B I Rotary switch input 2 6V1 -Step up capacitor connecting terminal 7 CH_C I Rotary switch input 3 7 NC - No connection 8 CH_D I Rotary switch input 4 8 NC - No connection 9 31BU - 3.1V 9 NC - No connection 10 S31BUS - 3.1V 10 NC - No connection 11 33M - 3.3V 11 NC - No connection 12 TGL0 I Lever switch input 0 12 NC - No connection 13 TGL1 I Concentric switch input 1 13 GND - GND 14 TGL2 I Concentric switch input 2 14 GND - GND 15 BLED - Busy LED control 15 NC - No connection 16 TXLED - TX LED control 16 33M O 3.3V LCD power supply output 17 ORG O Key scan signal output 17 33M O 3.3V LCD power supply output 18 VoL I Volume level input 18 D7 I/O Data bus 7 19 GND - GND 19 D6 I/O Data bus 6 20 GND - GND 20 D5 I/O Data bus 5 CN38 21 D4 I/O Data bus 4 1 PF2 O Key output (Side2 key) 22 D3 I/O Data bus 3 2 PF3 O Key output (Side3 key) 23 D2 I/O Data bus 2 3 KoPF I Key input 24 D1 I/O Data bus 1 4 L_PTTG I PTT GND 25 D0 I/O Data bus 0 5 L_PTT I PTT input 26 33M O 3.3V LCD power supply output 6 PF1 O Key output (Side1 key) 27 /WR I/O WR bus CN40 28 A0 O Address bus 0 output 1 GND - GND 29 /LCDRST O LCD reset output 2 GND - GND 30 /WR I/O WR bus 3 I2CSDA I/O I3C bus data CN34 4 I2CCK O I2C bus clock 1 INT SP+ O BTL output + for internal spaker 5 GND - GND 2 INT SP+ O BTL output + for internal spaker 6 GND - GND 3 INT SP- O BTL output - for internal spaker 7 RXAF O AF from ASIC 4 INT SP- O BTL output - for internal spaker AF after passing through the DAC 8AF I (IC502) 5 INT MIC+ I Internal MIC input 9 MICE - MIC GND 6 INT MIC- - Internal MIC GND 10 MIC I MIC signal input 11 33C - 3.3V 12 MICmain O INT MIC signal output 13 AFC O AFC signal 14 GND - GND 15 MOD O Modulation signal from ASIC

64 TK-5410 TERMINAL FUNCTION

Pin Pin Name I/O Function Name I/O Function No No 16 AUD_VREFC O VREF for AF signal 61 GND - GND 17 GND - GND 62 GND - GND 18 GND - GND 63 5TC O 50T output switch 19 CGND - GND 64 5RC O 50R output switch 20 ASSIST O VCO tuning voltage control output 65 5UC I 5U Reg. control input 21 RSSI I RSSI voltage input 66 /SAVE O 50C Reg. control output 22 GND - GND 67 S_DET I Battery select input 23 /SCSW O RSSI voltage input 68 SBC O SB SW control output 24 THP I Temperature data input 69 BATT I Battery level 25 MM O MIC mute switch 70 DSR I/O DSR signal 26 ASQDET I Analog Squelch signal input 71 5M - 5.0V 27 VOX I MIC input level 72 33A - 3.3V 28 TONESW I TONE switch Power input after passing through 73 +B - the fuse 29 BEEP O BEEP output 74 33A - 3.3V 30 W_/N O Wide/Narrow switch Power input after passing through 31 VADAC O Voice announce 75 +B - the fuse 32 TONE O Tone signal output 76 33M - 3.3V 33 STSW O Sidetone output switch Power input after passing through 77 +B - 34 AMT I SP mute control the fuse 35 LCDCNT I LCD Contrast Control Voltage 78 33M - 3.3V 36 VCOSW O VCO switch Power input after passing through 79 +B - the fuse 37 APCSW I APC switch control input 80 15M - 1.5V 38 VCOSW2 - No connection 81 SCTAMI for production 39 /EVCS O DAC CE 82 15M - 1.5V 40 CV I CV voltage input 83 SPuniv- I BTL output - for external speaker 41 PCS_RF O PLL enable output 84 SPuniv+ I BTL output + for external speaker 42 PLD I 1st PLL lock detect input 85 SPuniv+ I BTL output + for external speaker 43 PCS_Pot - No connection 86 SPuniv- I BTL output - for external speaker 44 DACRST O DAC reset 87 /UDET O Universal connector detect input 45 SCK0 O DAC serial clock 88 RTS0 O RTS signal input 46 SDO0 O DAC data 89 PFKEY I PF key interrupt signal for KMC-25 47 HD7 - for production 90 RXD0 I Serial data input 48 BFSR2 - for production 91 RXD1 I Request to send 49 BER_EN - for production 92 TXD0 O Serial data output 50 INT3 - for production 93 /PTT I PTT signal output 51 HD5 - for production 94 CTS0 I CTS signal input and MIC switch 52 PSRPLL - for production 95 RXD2 I Serial data input (VGS-1) 53 BDR2 - for production 96 36MC O 36M Reg. control output 54 BCLKR2 - for production 97 /OINT O Option board interrupt signal 55 BDX2 - for production 98 TXD2 O Serial data output (VGS-1) 56 BCLKX2 - for production 99 GND - GND 57 GND - GND 100 GND - GND 58 BFSX2 - for production 59 IFDET I IF input 60 GND - GND

65 TK-5410 TERMINAL FUNCTION

TX-RX unit (X57-7560-10 A/3) Pin Name I/O Function No Pin Name I/O Function No CN502 (for production) CN501 1~20 - - - 1 OPT1 I Busy (VGS-1) CN505 2 OPT3 I Play (VGS-1) 1 DSR I Data set ready 3 26P_RD I Serial data input (VGS-1) 2 E - GND 4 26P_TD O Serial data output (VGS-1) 3 RXD I Serial data input 5 NC - No connection 4 TXD O Serial data output 6 OPT4 O Enable (VGS-1) 55M -5V 7 OPT10 - GND (VGS-1) 6 RTS1 O Request to send 8 OPT5 O Reset output (VGS-1) 7 REM I Programmable function key input 9 DGND - DGND 8 PTT I External PTT input 10 AGND - GND 9 MICE - External MIC GND 11 AI I VGS Audio input (VGS-1) 10 EMC I External MIC input 12 AO O VGS Audio output (VGS-1) 11 MSW/CTS I EXT/INT MIC switch input 13 AGND - GND 12 SP- O BTL output - for external speaker 14 5V - 5V 13 SP+ O BTL output + for external speaker 15 OPT9 - No connection 14 SSW I EXT/INT speaker switch input 16 DTI - No connection 17 OPT8 - No connection 18 OPT11 - No connection 19 OPT7 - No connection 20 OPT2 - No connection 21 TXO - No connection 22 RXEO - No connection 23 RXEI - No connection 24 TXI - No connection 25 OPT6 - No connection 26 POW O Switched B output

66 TK-5410 TERMINAL FUNCTION

Pin Pin Name I/O Function Name I/O Function No No CN707 44 NC - No connection 1 GND - GND 45 SDO0 I DAC data 2 GND - GND 46 SCK0 I DAC serial clock 3 I2CCK I I2C bus clock 47 BFSR2 O for production 4 I2CSDA I/O I3C bus data 48 HD7 O for production 5 GND - GND 49 INT3 I for production 6 GND - GND 50 BER_EN O for production AF after passing through the DAC 51 PSRPLL O for production 7AF O (IC502) 52 HD5 O for production 8 RXAF I AF from ASIC 53 BCLKR2 O for production 9 MIC O MIC signal output 54 BDR2 O for production 10 MICE - MIC GND 55 BCLKX2 for production 11 MICmain I INT MIC signal input 56 BDX2 for production 12 33C - 3.3V 57 BFSX2 for production 13 GND - GND 58 GND - GND 14 AFC I AFC signal 59 GND - GND 15 AUD_VREFC I VREF for AF signal 60 IFDET O IF output 16 MOD I Modulation signal from ASIC 61 GND - GND 17 GND - GND 62 GND - GND 18 GND - GND 63 5RC I 50R output switch 19 ASSIST I VCO tuning voltage control input 64 5TC I 50T output switch 20 CGND - GND 65 /SAVE I 50C Reg. control input 21 GND - GND 66 5UC O 5U Reg. control input 22 RSSI O RSSI voltage output 67 SBC I SB SW control input 23 THP O Temperature data output 68 S_DET O Battery select output 24 /SCSW I Scrambler switch 69 DSR I/O DSR signal 25 ASQDET O Analog Squelch signal output 70 BATT O Battery level 26 MM I MIC mute switch 71 33A - 3.3V 27 TONESW O TONE switch 72 5M - 5.0V 28 VOX O MIC input level 73 33A - 3.3V 29 W_/N I Wide/Narrow switch Power input after passing through 74 +B - 30 BEEP I BEEP input the fuse 31 TONE I Tone signal input 75 33M - 3.3V 32 VADAC I Voice announce Power input after passing through 76 +B - the fuse 33 AMT O SP mute control 77 33M - 3.3V 34 STSW I Sidetone input switch Power input after passing through 35 VCOSW I VCO switch 78 +B - the fuse 36 LCDCNT - LCD Contrast Control Voltage 79 15M - 1.5V 37 NC - No connection Power input after passing through 80 +B - 38 APCSW O APC switch control output the fuse 39 CV O CV voltage output 81 15M - 1.5V 40 /EVCS I DAC CE 82 SCTAMI for production 41 PLD O 1st PLL lock detect output 83 SPuniv+ O BTL output + for external speaker 42 PCS_RF I PLL enable input 84 SPuniv- O BTL output - for external speaker 43 DACRST I DAC reset 85 SPuniv- O BTL output - for external speaker

67 TK-5410 TERMINAL FUNCTION

Pin Top panel unit (X57-7560-10 B/3) Name I/O Function No Pin Name I/O Function 86 SPuniv+ O BTL output + for external speaker No 87 RTS0 I RTS signal input CN902 88 /UDET I universal connector detect input 1 36M - 3.1V 89 RXD0 O Serial Data Output 2 S36M - 3.1V 90 PFKEY O PF key interrupt signal for KMC-25 3 GND - GND 91 TXD0 I Serial Data input 4 VoL I Volume level input 92 RXD1 O Request to send 5 33M - 3.3V 93 CTS0 O CTS signal input and MIC switch 6 CH_A I Rotary switch input 1 94 /PTT O PTT signal output 7 TGL2 I Concentric switch input 2 95 36MC I 36M Reg. control input 8 TGL1 I Concentric switch input 1 96 RXD2 O Serial data input (VGS-1) 9 C - GND 97 TXD2 I Serial data output (VGS-1) 10 CH_B I Rotary switch input 2 98 /OINT I Option board interrupt signal 11 CH_D I Rotary switch input 4 99 GND - GND 12 CH_C I Rotary switch input 3 100 GND - GND CN903 1 GND - GND 2 CH_A O Rotary switch output 1 3 CH_B O Rotary switch output 2 4 CH_C O Rotary switch output 3 5 CH_D O Rotary switch output 4 6 36M - 3.1V 7 S36M - 3.1V 8 33M - 3.3V 9 TGL0 O Lever switch output 0 10 TGL1 O Concentric switch output 1 11 TGL2 O Concentric switch output 2 12 BLED - Busy LED control 13 TXLED - TX LED control 14 ORG I Key scan signal input 15 VoL O Volume level output 16 KIN I Key scan signal input 22 GND - GND

68 TK-5410 TERMINAL FUNCTION

Option board unit (X57-7560-10 C/3) Universal Connector Pin Pin Name I/O Function Name I/O Function No No CN923 1 SSW I EXT/INT speaker switch input 1 OPT1 O Busy (VGS-1) 2 SP+ O BTL output + for external speaker 2 OPT3 O Play (VGS-1) 3 SP- O BTL output - for external speaker 3 RXD1 O Serial data output (VGS-1) 4 MSW I EXT/INT MIC switch input 4 TXD1 I Serial data input (VGS-1) 5 EMC I External MIC input 5 NC - No connection 6 ME - External MIC GND 6 OPT4 I Enable (VGS-1) 7 PTT I External PTT input 7 NC - No connection 8 PF I Programmable function key input 8 OPT5 I Reset input (VGS-1) 9 OPT I/O Aux I/O port (for EXT option) 9 DGND - DGND 10 E - GND 10 AGND1 - GND 11 5M O 5V 11 NC - No connection 12 TXD O Serial data output 12 NC - No connection 13 RXD I Serial data input 13 AGND2 - GND 14 NC - Not used 14 5A - 5V 15 STON - No connection 16 DI - No connection 17 TCONT - No connection 18 MANDOWN - No connection 19 INH - No connection 20 OPT2 - No connection 21 TXO - No connection 22 RXEO - No connection 23 RXEI - No connection 24 TXI - No connection 25 C3 - No connection 26 SB I Switched B input

69 A B C D E F G H I J

1 TK-5410 PC BOARD

2 CONTROL UNIT (X53-4390-XX) -11 : K2 -12 : K3 Component side view (J79-0230-09)

14 IC16 TP7 C113 R46 C114 C115 23 L7

TP104 R168 4 3 C117 3 1 R169 R165 R171 R178 R25 R26

Q12 C37

6 1 IC6 Q16 16 4 5 R154 R161 TP10 R156 IC17 G IC4 R29 R27 C25 R34 R33 C29 4 R144 4 3 R166 34 D R19 Q7 S Q14 TP6 R67 R146 R143 6 1 C116 R176 R177

D23 R62 4 3 R157 D26 R65

G Q13 Q8 R155 L10 R61 R52 TP13 R147 6 1 D S L25 R60 R43 CN40 D25 Q15 L4 L6 C33 R30 99 R283 D24 C39 R42 R64 100 R173 R284 GND GND C36 R51 R282 TP103 /OINT TXD2 E 5 R273 RXD2 36MC R280 R21 R63 C34 R281 /PTT CTS0 RXD1 TXD0 R278 R17 C24 Q2 R279 PFKEY RXD0 Q3 C R41 IC3 R291 R277 /UDET RTS0 R276 D1 R275 SPuniv+ SPuniv– C16 R49 R40 SPuniv– SPuniv+ R274 IC1 SCTAMI 15M B R48 +B 15M +B 33M R66 R58 R271 +B 33M C17 R53 +B 33A R268 R265 5M 33A R272 6 4 C35 BATT DSR R270 Q5 E C B R269 S_DET SBC R266 1 3 R39 6 5UC /SAVE R234 R194 5TC 5RC C22 GND GND R264 R262 CN4 R267 IFDET GND Q1 R69 R263 GND BFSX2 R260 R38 BDX2 BCLKX2 R233 R70 R261 R259 BDR2 BCLKR2 HD5 PSRPLL R255 R257 C18 R72 L13 R185 R47 R44 C27 R20 R258 BER_EN INT3 R71 R32 R256 HD7 BFSR2 R253 D20 SCK0 SDO0 R251 R254 C58 S C31

PCS_Pot DACRST TP8

R252 R249 D19 C137

L11 D PCS_RF PLD R247 L12 R250 /EVCS CV C155 C60 G R248 APCSW VCOSW2 R245 C122 R181 R179 X2 C47 R8 R246 LCDCNT VCOSW Q4 7 STSW AMT R244 5 R231 R243 VADAC TONE R242 4 3 R184 R182 16 BEEP W_/N R241 R99

C161 Q11 VOX TONESW C119 C118 C121 C120

R230 R240 R239 R164 MM ASQDET 6 1 IC8 IC12 /SCSW THP R170 C56 R227 R225 RSSI GND R226 34 18 4 CGND ASSIST R238 R295 R101 C112 R237 GND GND 4 3 R287 R235 MOD AUD_VREFC

R236 R162 R100 R158 Q10 C136 AFC GND R232 R94 R288 R167 R221 33C MICmain 6 1 MICE MIC C55 R163 C52 R95 R98 RXAF AF L27 CN46 20 GND GND GND R160 I2CSDA I2CCK C156 GND 8 C53 R137 R195

VOL 5 1

GND GND R293 R220 4 1 12 7 C111

ORG TP2 1 2 13 6 R138 R219 C110 TXLED IC7 C40 IC9 R139 BLED TGL2 5 8 C109 TP3 6 IC15

R140 10 R74 TGL1 TP9 TGL0 18 1 R141 C108 19 24 33M R148 L23 S31BUS

R142 CN35 R82 L22 31BU TP4 C93 CH_D R159 R151 R145 R50 C95 C97 C71 C92 CH_C C141 R152 9 C70 C90 C101 C107 CH_B

C106 CH_A TP5 GND

TP1 1 8 R136 C105 MICE C86 Q6 R118 R109 16 34 L_MIC X1 C96 C104 IC13 R134 1 NC R110 R130 45 C103

TP1001 R135 R131

R285 C98 R125

R129 TP11 C87 C157 R127 R120 R126

R187 R133 C94 10 R128 R132 D27

11 Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address IC1 5H IC12 7E Q4 7F Q15 5E D23 4D IC3 5J IC13 9E Q5 6F Q16 4E D24 5F IC4 4H IC15 8F Q6 9D D1 5E D25 5D 12 IC5 9N IC16 3F Q7 4D D13 9M D26 4F IC6 4I IC17 4E Q8 4C D14 9M D27 10G IC7 8J IC18 5L Q10 8G D15 9M IC8 7J IC19 5N Q11 7G D16 9L IC9 8E Q1 6E Q12 4D D19 7E 13 IC10 8M Q2 5E Q13 4E D20 7E IC11 6O Q3 5F Q14 4F D22 7P

70 14 JKLMNOPQRS

PC BOARD TK-5410 1

2 CONTROL UNIT (X53-4390-XX) -11 : K2 -12 : K3 Component side view (J79-0230-09)

3 R999 R998 R25 R26 R29 R27 C25 C23 R33 R19 4 C19 C15 L5 CN1 L9 TP1003

/LCDRST C152 /WR A0 /WR 33M D0 D1 D2 D3 D4 D5 D6 33M 33M NC GND GND D7 NC NC NC NC NC NC V1 V2 V3 V4 LCDCNT NC

1 C151 30 C144 C14 R212 R211 R206 11 10 5 C148 C149 R210 R207 C150 R204 C13 IC18 IC3 CN2 C147 R209 R208 18 45

R205 IC19 R5 R201 R202 R203 C51 C146 L24 C154 C50 C143

CN3 20 1 R93 R92 C54 C12

4 1 6 TP1002 IC11 R96 R97 5 8 R84 R78 R117 R107 R106 R112 C88 R121 R190 R32 C27 R20 CN45 R18 TP14

L17 C59 C31 R80 C79

R16 C69 R83 R77 C91 R199 R111 R122

C57 L14 C67 CN21 L15 C47 R86 C21 TP12 R113 CN32 C68 C80 7 16 L19 R189

C81 TP101 R81

IC8 C72 56 C62 R105

34 C82 D22 CN47 01 C63 R188 C66 CN31 TP102

00 C136 C49 C83 L20 L21 C153 C64 R90 R172 C84 R175 C65 C48 C44 IC10 C100 C99 C102 CN44 R174

R215 C85 C73 R191 R292 8

5 1 R102 C61 6 C74 R115 R124 1

R116 R75 PF2 IC7 C75 R119 PF3 PF1 C38 CN24 KOPF L_PTT

C76 L_PTTG 6 10 R123 R192 L16

L8 C77 CN19

R54 CN23 D13 C78 C32 R37 CN38 CN43 R88 R196 R76 R193 R108 R103 CN37

R31 2 1 9 R36 R55 R56 R59 R45 IC5 R57 3 4 C30 R198 R35 R197

X1 D16 D15 D14

Component side 11 Layer 1 Layer 2 Layer 3 Layer 4 Layer 5 12 Layer 6 Layer 7 Layer 8 Foil side 13

71 14 A B C D E F G H I J

1 TK-5410 PC BOARD

2 CONTROL UNIT (X53-4390-XX) -11 : K2 -12 : K3 Foil side view (J79-0230-09)

4 D R12 D7 R13

CN22

6 D8

CN34 D6 INT MIC– INT MIC+ INT SP– INT SP– INT SP+ INT SP+

9 6 1 R11 A

11 Ref. No. Address Ref. No. Address D2 8N D8 7H D3 8O D9 5N D4 8L D10 5O 12 D5 8K D11 5L D6 9H D12 5K D7 5H

72 14 JKLMNOPQRS

PC BOARD TK-5410 1

2 CONTROL UNIT (X53-4390-XX) -11 : K2 -12 : K3 Foil side view (J79-0230-09)

D 4

36 9#

5 D12 D9 D10 D11

C 6

25 80

B D4 R7 R6 D2 R8 8 D3 D5 R9

14 7 * 9 A

Component side 11 Layer 1 Layer 2 Layer 3 Layer 4 Layer 5 12 Layer 6 Layer 7 Layer 8 Foil side 13

73 14 A B C D E F G H I J

1 TK-5410 PC BOARD

TX-RX UNIT (X57-7560-10) (A/3): TX-RX SECTION Component side view (J79-0233-09 A/3) 2

D119 + R114 C126 4 3 R116 C727 C749 R914 R173 R120 C122

C728 TP8 C724 C745 5 IC710 1 5M C188

5 1 C111 L704 IC704 R106 C186

C107 15

Q703 C162 3 3 4 R705 G X100 IC100 R907 R908

4 3 D R143 C742 C725 R142 C731 S 34 IC706 L710 R714 D702 R713 R909 C191 C114 Q111 Q1 CN707 R105 R134 C845 C843 5 1 L701 R716 R711 C177 R140

2 1 R753 L140 GND GND R182 R112 R135 C1

C714 4 3 C178 I2CSDA I2CCK C713 R146 C735 C184 R720 C116 L1 C844 GND GND C841 C707 1 5 L153 RXAF AF 4 3 Q704 C179 C181 C842 L142 C182 MICE MIC C839 TP5 C173 C180 L143 C1 C840 33C MICmain C835 C740 IC705 C732 6 1 C151 C185 L702 C838 AFC GND SCK R109 R145 C831 IC700 C155 C832 MOD AUD_VREFC C829 C711 R128 GND GND 5 1 L145 L146 D704 R141 C830 CGND ASSIST C828 C183 4 C846 RSSI GND 3 TP4 10 6 C130

C826 CP11 CP10

4 C168 C827 /SCSW THP TP11 11 5 MM ASQDET C824 SDO C128 C825 VOX TONESW C823 33M C837 BEEP W_/N IC101 R117

C125 D C822 VADAC TONE STSW AMT C821 R910 15 1 R118 Q108 C836 LCDCNT VCOSW C819 APCSW NC C818 16 20 C198 C817 /EVCS CV + C14 C813 C195 C144 PCS_RF PLD C816 TP3 Q102 C815 NC DACRST C814 R179

C761 16 R137

SCK0 SDO0 C812 DACRST C117 C911 C108 C110 C811 /SCWKUP /SCBFS R180 C197 C119 C810 R185 C809 BER_EN /SCREQ R111 R115 3 4 C807 /SCRST SCBSY C808 C762 Q104

SCMIS0 SCBCK R110

C834 Q709 C806 BER_DATA BER_CLK C805 TP6 34 16 R113 5 C804 GND BFSX2 L100 IFDET GND 5RC C196 C157 C802 GND GND C803 R731 C106 R155 R729 C751 C748 C798 5TC 5RC C801 R762 C101 C754 C796 5UC /SAVE C795 L708 R730 TP14 R178 C115 S_DET SBC GND C833 BATT DSR C794 R761 C750 C800 5M 33A C793 +B 33A C752 C799 +B 33M C792 C758 TP2 C791 +B 33M C790

+B 15M 8 5 /EVCS

C788 TH102 C789 SCTAMI 15M C741 Q103 C755 R119 3 14 IC708 IC707 C786 SPuniv– SPuniv+ C797 6 4 SPuniv+ SPuniv– R751 Q706 TP13 S Q701 C785 /UDET RTS0 C753 C736 36MC G C781 PFKEY RXD0 4 R709 3 1 4 3 TXD0 R724 RXD1 C739 TP1 C783 1 4 D C705 C787 /PTT CTS0 R127 R703

R750 R727 TP10 33C 6 RXD2 36MC R749 L703 15V 6 1 C782 /OINT TXD2 C132 R122

C780 +B GND GND C779 IC712 D706 C766 R726 C737 3 1 4 3 Q705 CV 100 99 C777 C709

C778 C776 R722 C774 C775 C730 C773 5 1 4 5 TP7 C744 SBC C428 R402 R708 R406 4 3 C704 C784 R723 R702 C429 C763 C733 R405 + 51 43 C765 IC400 + 6 1 C769

C756 C746 C426 Q700 C767 IC713 5 4 C759 R407 R404 Q308

+ R304 4 3 G R408 C770 7 R752

8 1 + L706 L705 D R300 IC709 S Q300 L707 C304

C771 5 1 R301 + C768 16

34 C308

Component side TX-RX UNIT (X57-7560-10) (B/3): TOP SECTION Layer 1 Layer 2 Component side view (J79-0233-09 B/3) 9 Layer 3 Layer 4 J79-0233-09 B/3 Layer 5 Layer 6 Foil side 10

11 S901

12 D901 S902

74 14 JKLMNOPQRS

PC BOARD TK-5410 1

TX-RX UNIT (X57-7560-10) (A/3): TX-RX SECTION Component side view (J79-0233-09 A/3) 2

R213 R216 C219 R202 C207 C209 L202 2 1 C220 R148 C211 C188 R215 D200 C111 C221 3 4

Q200 C275 R106 C202 L200 R208 C215 Q201 C203 R200 R201 C186 R210 R204

L201 R209 R150 C162 L147 C204 R203

C216 3 C213 R211 L205 R143 R212

C200 S Q202 R142 D308 C206 L203 C192

C217 C277 Q112 C201

C208 R205 C205 C222 C218 L204 G L206 R140 C365 D C189 C228 L219

C178 L148 R327 C700 R146 C279

C190 D203 L216 C184 L149 R152 L215 C276 C153 L154 R219 R218

F700 C272 C273 C193 R139 C224 C185 C194 L207 C274 R145 R221 C155 16 L145 C269 D202

L146 L155 R141 C183 C223 R234 GDQ204 R244 C259 L209 22R233 R232 34 C270 4 C168

R217 L211 Q105 +

S L208 D C109 C235 Q108 G Q100 C246

R236 C251 C249 R144 C147 TH200 R246 C260 C144 + C226 L210 L107 R247 R707 R137 C236 R220 C243 +B

R102 C238 F701 R245 R243 C225 C254 Q104 Q708

R706 C594 C716 C595 5 R223 R222 G S C706 D R651 C719 D G 15 S C577 R759 Q707 TP108 C581 IC702 +B R704 2nd LO R645

C585 TP104 C701 R700 34 R228

R701 C703 R226 R224 D505 R649 R225 C231 R230 C230 G Q203 D504 C712 4 3 14 SSW D R240 C245 S S R647 C586 SP+ C233 C234 C599 L506 SP– 45 18 C583 R231 R229 R235 IC701 MSW/CTS Q207 IC201 CF302 G S C705 R703 EMC CN505 MICE D 6 Q205 R238 Q208 L505 PTT 34 16 1 C598 5 C240 REM L502 R652 RTS1 5M R242 R636 C717 C587 CN201 R635 C570 TXD C241 C256 C720 RXD C248

D502 C242 R237 C704 R702 D201

TXD E C214 1 DSR C244 S R359 D R241 R637 C603 G R239 Q206 C574 C608 R206 TP103 C419 18 08 RXD R640 C607 D516 IC200 R207

18 C600 C575 45 7 L504 D R300 IC307 L503 R364 J79-0233-09 A/3

45 D515 C601 Q300 C416 CF303 6 R301 18 R360 4 C308 IC306 45

TX-RX UNIT (X57-7560-10) (C/3): OPTION SECTION Component side view (J79-0233-09 C/3) 9 DGND RXEO OPT1 OPT2 RXEI SB2 AGND TXI C3 TXO Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address

MDWN IC100 3I IC710 3D Q205 6Q D200 3K AGND STON TCNT OPT5 OPT4 OPT3 INH 5A DI IC101 4H IC712 6C Q206 7P D201 7Q J79-0233-09 C/3 IC200 7P IC713 7C Q207 6Q D202 4R 10 IC201 6P Q100 4K Q208 6Q D203 4R IC306 8K Q102 5I Q300 7J D308 3K IC307 7K Q103 6H Q308 7J D502 7N IC400 7H Q104 5J Q700 7J D504 6N 11 IC700 4E Q105 4J Q701 6J D505 6M IC701 6L Q108 4J Q703 3F D515 7O IC702 5K Q111 3I Q704 4F D516 7O IC704 3E Q112 3J Q705 6E D702 3E IC705 4D Q200 3L Q706 6D D704 4D 12 IC706 3D Q201 3M Q707 5L D706 6D IC707 6D Q202 3N Q708 5L D901 12C IC708 6F Q203 6Q Q709 5E IC709 7F Q204 4O D119 2I 13

75 14 A B C D E F G H I J

1 TK-5410 PC BOARD

TX-RX UNIT (X57-7560-10) (A/3): TX-RX SECTION Foil side view (J79-0233-09 A/3) 2 L313

C371 R388 R386 R389 C361 C

R384 C368 R131 XF300 C372 3 C Q309 L312

C335 C373 R387 D305 C176 L320 R126

R398 C366 C358 L321 C702 C262 C261 C367 CN300

D304 R124 R390 C301 C364

D700 L135 L311 R306 L331 C302 C334

C359 C356 R382 L316 C381 L319 L325 C353 4 3 2 L212 C360

4 C142 C362 R307 5 6 1 C307 R308 L310

D303 C414 C415 R357 IC309 IC300 C384 6 4 + C305 L700 1 3 C306

Q311 L300 R356 L309 C413 C411 C412 R355 R358 C383 C263 C355 C357 L128 C387 C349

R309 C352

L317 C354 R353 C409 C350 R395 R394 C421 C265 L308

L301 C410 R183 C316 R311 L338 C300 C309 C351 C150 C430

L213 L336 24 13

5 C347 R381 R371 C431 R319 R312 C317 C311 C266 C264

R321 R380 L327 L318 C423 C267 C390 C391

Q302 IC304 3 2 C310 L304 C392 4 1 L337 R409 R303 C399 R347

L333 C397 C315 R320 C319 R373 12 L330

L326 R361 C332 1 R335 C325 R337

L214 C389 C268 Q304 C324 S 6 4 R363 Q303 R348 C322 C345 C404 C363 1 3

Q305 R332 C323 L305 L302 R369 R302 C339 R352 C342 6 2 1 C388 C406 C400 C401 C402 C403 L335 C674 C385 R365 R362 5 4 R349 C407 6 3 R342 3 4 1 2 R341 C396 C393 C394 R323 IC310 C405 R344 R322

R248 C418 R374 C333 R338 L332 R710

L328 C420 R367 R354 C327 C433 C321 C340 L303 C343 R378 R343 R310 C721 C395 L306 C432 Q312 C341 C337 L307 R340 7 R339 CF300

J79-0233-09 A/3 R366

Component side TX-RX UNIT (X57-7560-10) (B/3): TOP SECTION Layer 1 Layer 2 Foil side view (J79-0233-09 B/3) 9 Layer 3 Layer 4 J79-0233-09 B/3 Layer 5 Layer 6 Foil side 10 11 1 33M 36M CH_D C TGL2 GND 17 1 GND VOL TGL2 CH_D GND 11 TXLED TGL0 S36M CH_B CN902 S36M CH_A CH_C CH_B TGL1 VOL CN903 CH_A BLED CH_C TGL1 ORG 33M 36M 12 KIN 2 16 2

76 14 JKLMNOPQRS

PC BOARD TK-5410 1

TX-RX UNIT (X57-7560-10) (A/3): TX-RX SECTION Foil side view (J79-0233-09 A/3) 2 R694 D500 R522 R533 R532 R530 R529 R526 D519 R535 C518 R123 C120 R136 R138 R527 L134 C143 D100 L104

C174 Q509 CN506 C622 R131 R915 C510 UNV C148 C141 S R690 C159 16 R580 20 11 R520 C511 CN508

C154 R536 R538

L501 3 C515

G GND F500 D518 34 R569 L139 L110 C100 R519 R503 R525

Q109 D C139 IC501 D106 D104 Q106 D102 D501 10 C176 R126 R562 R559 R544 R545 R546 R547 L127 C512 Q502 1 C149 R125

R108 R534 C519 L150 R528 6 4

R186 IC714

L119 IC517 R693 R507 R574 C136 C131 R521 R576 C112 R124 C156 CN509 R697 R531 C516 R695 4 3 18 13 C134 R104 3 1 MND C504 L135 R100 C507 19 12 C145 18R518 C506 5 1 R573 R757 IC503 C525 S C505 IC505 D521

Q107 C121 45 R515 R699 R541 C142 R103 C772 R698 4

L109 24 7 D101 G + R501 C621 R582 C129 R514 R754 1 6 D107 R156 R593 C140 R506 D 5 4 C503 R154 R564 R565 R579 R567 R581 IC500 R563 25OPT6 POW 26 C104 R608 R606 L128 + C124 C551 8 1 RXEI TXI R760 R505 L115 R509 R607 TXO RXEO L151 C137 C500 R577

D103 CN502

C2 OPT7 OPT2 R121 R107 + C123 R605 R183 D105 1 2 R604 R511 OPT8 OPT11

R603 R600 C150 C135 6 1 OPT9 CN501 DTI C529 R151 R601 R513 7 24

C133 C113 IC502 AGND 5V L120 R599 R517 TP9 5 R598 33A L500 AI AO R597 C509 R595 R756 DGND AGND 19 20 12 19 R594 R592 C508 13 18 CN500 OPT10 OPT5 R591 C537 UNV NC OPT4

C513 C522 IC506 C528 R550 63R654 R653 R566 C524 C532 R578 15 R556 26P_RD 26P_TD IC511 Q504 R368 R401 R618 51D512 D511 34 12OPT1 OPT3 R361 4 3 C578 C590 66R657 R656 65C606 C605 R568 Q304 4 6 R642 R614 C558 R611 R553 C536 C542 8 5 C556 C560 5 1 C557 3 1 C425 C582 R617 R612 IC507 TP12 C559 R616 R660 C591 15M Q505 R621 C564 6 R669 R667 C565 1 5 R624 R626 1 4 R36 R362 C620 Q503

R912 R913 C568 67R630 R627 18 C545 R561 R584 C538 CD300 Q507 3 4 S CF400 G S D C613 R668 R662 R665 IC515 IC513 D C418 C544 R583 5 4 G C20 R644 45 R560 R554 C579 C611 C576 R638 R641 R586 IC508 R572 R558 R655 R615 R628 R585 R571 R587 R570 C612 R663 5 4 C571 8 1 C540 Q508 R659 C609 R619 IC514 1 3

D C547 R588 C614 R643 G S R664 C561 C562 C563 C543 C539 R557 R646 4 C617 18 8 5

Q506 IC516 R575 C589 R648 C552

D R622 R620 IC510 C527 R916 R596 R670 G S C567 R671 R625 5 4

R676 C520 R629 C533 C602

C566 5 4 R672 5 IC512

1 4 R590 7 R673 R675 R589 C427 C604 R650 8 1 R602 IC509 C618 8 1

C615 R631 R403 R666 C521

R674 R610 C616 C573 R623 C610 R658 C554 C555 C546 C619 R661 D510 D517

TX-RX UNIT (X57-7560-10) (C/3): OPTION SECTION Foil side view (J79-0233-09 C/3) 9 26 2

SB TXI RXEO OPT2 MANDOWN DI NC 5A

AGND1 OPT5 OPT4 TXD1 TXDI OPT3 Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address CN923 AGND2 TCONT DGND STON

RXD1 IC300 4F IC513 6P Q502 3N D303 4C OPT1 RXEI TXO INH NC NC NC C3 IC304 5I IC514 7O Q503 6R D304 4C 25 RXDI 1 10 J79-0233-09 C/3 IC309 4D IC515 6O Q504 6N D305 3C IC310 6F IC516 7N Q505 6N D500 3M IC500 4O IC517 4O Q506 7N D501 3M IC501 3O IC714 4N Q507 6M D510 7O IC502 5O Q106 3K Q508 7M D511 6N 11 IC503 4M Q107 4K Q509 3N D512 6N IC505 4P Q109 3K D100 3L D517 8O IC506 6P Q302 6D D101 4K D518 3N IC507 6P Q303 6H D102 3L D519 3N IC508 6Q Q304 6J D103 5K D521 4Q 12 IC509 7Q Q305 6C D104 3L D700 4H IC510 7P Q309 3I D105 5K IC511 6M Q311 4C D106 3L IC512 7P Q312 7H D107 5K 13

77 14 TK-5410 INTERCONNECTION DIAGRAM

POWER SW/ CHANNEL AF VOL SELECTOR

CN902 1 36M S36M GND TOP PCB VoL 33M X57-756 B/3 CH_A TGL2 TGL1 C CH_B CH_D CH_C 12 ORG TGL0 CH_B CN903 GND KIN VoL TXLED BLED TGL2 TGL1 33M S36M 36M CH_D CH_C CH_A GND 1 17

NC MIC – + 20 1

CN35 NC VoL 33M ORG GND GND GND MICE TGL2 TGL1 TGL0 CH_C BLED CH_B 31BU CH_D CH_A L_MIC TXLED

S31BUS CN40

CN1 1 NC LCDCNT V4 V3 V2 V1 NC NC NC NC NC NC GND GND NC

LCD 33M 33M D7 D6 D5 D4 D3 D2 D1 D0 33M /WR A0 /LCDRST /WR 30

CONTROL PCB X53-439

1 CN38 SIDE2 PF2 PF3 SIDE3 KoPF PTT L_PTTG L_PTT SIDE1 PF1 6

INT SP 1 CN34 + INT SP+ INT SP+ – INT SP– + INT SP– INT MIC+ INT MIC– – 6 INT MIC (MAIN)

78 TK-5410 INTERCONNECTION DIAGRAM

ANNEL CONCENTRIC ECTOR SW

CN707 1 2 GND GND I2CCK I2CSDA GND GND AF RXAF MIC MICE MICmain 33C ANT CN201 GND AFC AUD_VREFC MOD GND GND ASSIST CGND GND RSSI THP /SCSW ASQDET MM CN505 TONESW VOX 14 W_/N BEEP SSW SP+ TONE VADAC SP- AMT STSW MSW/CTS VCOSW LCDCNT EMC MICE NC APCSW PTT CV /EVCS REM PLD PCS_RF RTS1 5M DACRST NC TXD

SDO0 SCK0 UNIVERSAL CONNECTOR RXD /SCBFS /SCWKUP TX-RX PCB E X57-756 A/3 DSR /SCREQ BER_EN 1 SCBSY /SCRST SCBCK SCMIS0 BER_CLK BER_DATA BFSX2 GND GND IFDET CN501 CN923 GND GND 1 1 5RC 5TC OPT1 OPT1 OPT3 OPT3 /SAVE 5UC 26P_RD RXD1 26P_TD TXD1 SBC S_DET NC NC OPT4 OPT4 DSR BATT OPT10 NC OPT5 OPT5 33A 5M DGND DGND AGND AGND1 33A +B AI NC Ao NC 33M +B AGND AGND2 5V 5A 33M +B OPT9 STON DTI DI 15M +B OPT8 TCONT

OPT11 MANDOWN X57-756 C/3 15M SCTAMI OPT7 INH OPTION PCB OPT2 OPT2 SPuniv+ SPuniv- TXO TXO RXEO RXEO SPuniv- SPuniv+ RXEI RXEI TXI TXI RTS0 /UDET OPT6 C3 RXD0 PFKEY POW SB 26 26 TXD0 RXD1 CTS0 /PTT 36MC RXD2 TXD2 /OINT GND GND 99 100

79 A B C D E TK-5410 SCHEMATIC DIAGRAM LCD 1 2 1

1 2 V1 D1 A0 V3 V2 V4 D2 D6 D5 D3 D0 D7 D4 NC NC NC NC NC NC NC NC /WR /WR 33M 33M 33M CONTROL UNIT GND GND LCDCNT /LCDRST (X53-4390-XX) CN1 1 2 3 5 6 8 9 4 7 21 11 12 22 19 20 23 25 26 28 29 15 16 18 30 10 13 24 27 14 17 BUS BUFFER (LCD) R203 /LCDRST C146 0 IC18 1u

C152 R201 TC7WZ245FK-F 100k 0.1u R204 C151 1u C150 1u C149 1u C148 1u C147 10k 5 4 B2 GND 2 6 3 0.1u B1 A2 /WR

220p 7 2

C144 R202 IC19 G A1 A0 TC74LCX245FK 8 1 10k VCC DIR 11 10 B8 GND 3 12 9 B7 A8 D0 C143 13 8 B6 A7 D1 14 7 0.1u B5 A6 D2 15 6 B4 A5 D3 16 5 B3 A4 D4 IC19 17 4 5V to 3.3V B2 A3 D5 18 3 LEVEL CONVERTOR B1 A2 D6 19 2 oE A1 D7 1 20 1 VCC DIR C154

0.1u L24 D1,Q1,2 R205 10k R212 10k 10k R211 R210 10k R209 10k R208 10k R207 10k R206 10k 3 AVR for /CS4 BACKLIGHT LED 33M D2-5,9-12 D6-8 33M Q1 KEY BACKLIGHT LCD BACKLIGHT 2SB798AZI(DLDK BLC +B +B Q2 5 R6 R8 R7 R9 100 R11

180 180 2SC4617(S) 180 ∗ ∗ ∗ R12 R13 A BDC C18 0.1u D2 D3 D4 D5 R21 470k ∗ ∗ ∗ D8 D6 D7 C24 D1 100p R54 1 /KEYI0 2 470 5 3 UDZW3.9(B) D9 D11 D10 1 2 3 PF1 D12 ∗ ∗ ∗ R17 2.2k PF1 5 R55 /KEYI1 470 4 5 6 PF2

L25 PF2 ∗R998 R56 /KEYI2 4 470 ∗R999 7 8 9 PF3 SIDE KEY SECTION PF3 CN38 R57 /KEYI3 PF2 1 470 SIDE2 PF2 5 0 PF3 2 KoPF SIDE3 PF3 KoPF 3 KoPF R59 /KEYI4 L_PTTG 4 R174 1k 470 PTT L_PTT 5 R175 R292 D16 D13 D15 D14 1SS388F 1SS388F 1SS388F 1SS388F D13-16 PF1 6 1k 0 4 SIDE1 PF1 REVERSE 470 470 470 470 CURRENT R31 R36 R35 R45 PREVENTION KEYO1 KEYO0 KEYO2 KEYO3 4 5 3 1 4 2

33A 33A 2 1 1 3 3 /RD /RD /WR /CS2 /CS0 A16 1 3 2 D2 D6 D3 D7 D2 D8 D5 D0 D7 D12 D14 D10 L6 A0 31BU 2 3 E1 F2 F1 E6 E5 E4 E3 1 F6 F5 F4 F3 E2 G3 G2 G1 F6 F4 F3 F1 E6 E1 C33 G1 D6 G4 D6 oE A0 CE CE NC 1u

oE A16 A15 A15 A16 A16 VCC1 NC2 NC3 DQ2 DQ2 DQ8 DQ5 DQ0 DQ6 DQ7 DQ7 L4 VSS2 DQ12 DQ10 DQ14

G2 D5 G5 VCC2 D1 D9 DQ9 A11 A11 A15 A15 VSS1 G3 D4 G6 C6 D11 DQ11 A19 A19 DQ3 DQ1 D1 LCONT G4 D3 H1 C4 VCC A20 A20 A9 A9 IC4 A5 A5 6 G5 D2 H2 C3 1 D13 DQ13 A5 A5 A10 A10 STATIC NC1 C16 G6 IC1 D1 H3 MEMORY C1 D15 DQ15 A1 A1 3 A11 A11 DQ5 D5 1u H1 C6 H4 B6 VSS1 FLASH MEMORY A14 A14 A12 A12 DQ0 D0 H2 C5 H5 B5 C17 D1 DQ1 A10 A10 A13 A13 A7 A7 H3 C4 H6 B4 0.01u D3 DQ3 A21 A21 A14 A14 A4 A4 H4 C3 D4 DQ4 A18 A18

H5 C2 A0 A1 CE2 A3 A6 A8 DQ4 A2 WE D6 DQ6 A6 A6 2 H6 C1 A1 B1 A2 B2 A3 A5 A6 B3 VSS2 A2 A2 A4 A3 A7 RY/BY WE A9 A13 A4 A17 WP/ACC RESET A8 A12 A1 A0 A3 A6 A8 A2 B1 A1 B2 A2 A5 A6 B3 B5 B6 A3 B4 A4 2 /PTT D4 RESET C22 1000p CN4 A3 A9 A8 A7 A4 A13 A12 A17 /WP /FRST

/WR 4 R30 470k 2 3 4 7 X53-4390-XX D2 D3 D4 D9 D10 D11 R6 R7R8 R998 R999 -11 K2 NO NO NO NONO NONO NO NO 0 NO -12 K3 B30-2171-05B30-2171-05 B30-2171-05 B30-2171-05 B30-2171-05 B30-2171-05 100 100 100 NO 0 80 X53-439 1/6 F G H I J SCHEMATIC DIAGRAM TK-5410 CONTROL UNIT (X53-4390-XX)

2 2 2 1 1 1 33M 15M

X2_CLKIN

33MDSP L9 L5 15MD C31 C27 0.1u 0.1u R16 C21 470k R20 100k 2 1000p 1 R32 100k R44 100 R25 47k R26 47k

A16 1k MCDIAF D1 D2 D5 D3 D0 D4 A17 R18 R38 0 E12 E13 F10 F11 F12 F13 G10 G11 G13 G12 H13 H12 H11 H10 J13 J12 J11 J10 K13 K12 K11 K10 L13 L12 M13 N13 B12 B13 C11 C12 C13 D11 D12 D13 E10 E11 X1 D1 D2 D0 D5 D3 D4 RS TDI A18 A16 A17 TDo HD2 HD3 TCK TMS BDX1 ToUT TRST EMU0 HPI16 BFSX1 DVSS2 CVSS5 DVSS3 DVSS4 CVDD3 DVDD3 HPIENA CLKoUT CLKMD1 CLKMD2 CLKMD3 X2_CLKIN

EMU1 oFF M12 1 DVSS7 N12 R39 0 BCLKX1 MCSCKAF L11 R48 100k CVSS8 M11 A13 HD1 FSDET A19 N11 A12 CVDD5 A20 C35 1u R53 100k B11 L10 CVSS9 INT3 INT3 A11 M10 DVDD5 INT2 C12 D10 D6 D6 N10 C10 INT1 /DINT 0.1u D7 D7 K9 R66 1k B10 INT0 /SYMTIM D8 D8 A10 R58 100k D9 D9 D9 33MDSP D10 D10 L9 C9 NMI /DWUP D11 D11 M9 R48 100k B9 HBIL 15MD 2 D12 D12 33MDSP A9 N9 R49 100k 9 CN3 HD4 IACK D8 K8 10 D13 D13 BDX2 BDX2 C8 L8 R40 100 D14 D14 BDX0 MCDICN B8 R60 100k D15 D15 A8 M8 HD0 HD5 HD0 N8 C13 DVSS6 R5

470k K7 33MDSP 6 0.1u DVDD4 B7 CVDD6 C36 0.1u A7 L7 R41 100 CVSS10 IC3 HRDY C7 R61 100k /RD HDS1 D7 DSP N7 DVSS8 BFSX2 BFSX2 A6 M7 R42 100 /HDS2 HDS2 BFSX0 /MCCSXCN B6 N6 15MD DVDD6 CVDD4 C14 C6 C34 0.1u A0 A0 D6 M6 0.1u 3 A1 A1 HINT A5 L6 R62 100k A2 A2 CVSS7 B5 K6 A3 A3 BCLKX2 BCLKX2 C5 N5 BCLKX0 CN2 HD6 BCLKX0 D5 A4 A4 R63 100k A4 M5 A5 A5 BDR2 BDR2 B4 L5 R51 A6 A6 HCNTL1 C4 A7 A7 K5 100k A3 BDR0 MCDOCN R64 100k C15 A8 A8 B3 N4 A9 A9 BFSR2 BFSR2 0.1u C3 M4 CVDD7 BFSR0 /MCCSRCN A2 A21 R65 100k B2 L4 DVSS9 BCLKR2 BCLKR2 K4 BCLKR0 BCLKR0 N3 DVSS5 M3 R43 HCNTL0 N2 100k R52 BCLKR1 N1 0 CVSS6 10 9 XF IAQ BIo PS DS IS MSTRB IoSTRB MSC HoLDA HoLD MP_MC DVDD2 CVSS4 BDR1 BFSR1 CVSS1 A22 CVSS2 DVDD1 A10 HD7 A12 A13 A14 A15 CVDD1 HAS DVSS1 CVSS3 CVDD2 HCS HR_W READY R_W A11 2 J1 L1 F1 J2 K1 E1 A1 B1 J3 J4 L2 L3 H1 D1 C1 F2 G1 F3 F4 K2 E2 M1 K3 E3 E4 H2 D2 C2 H3 D3 H4 D4 G2 G3 G4 M2 /MCCSAF MCDOAF 9 A11 A12 A15 A10 A13 A14 R19 R29 R33 R27 R34 100k 100k 3 2 100k 100k 100k 6 C25 C23 C19 0.1u 0.1u 0.1u

15MD /WR 5RC C29 0.1u /CS3 /DRST 33MDSP /HRDY 3 3 3 3

HD7 HD5 BER_EN LCONT LCONT

6 10 /PTT /PTT RESET RESET

10 6 4 4 4

81 X53-439 2/6 K L M N O TK-5410 SCHEMATIC DIAGRAM CONTROL UNIT (X53-4390-XX)

2 1 GPIo7

AUD_IREFC 33M

31BU AD12_IREFF 12 X2_CLKIN D5 J4 F3 R80 A4

XTALI IFIR ADC1

22 B4 MICIR XTALo A10 32K 32I A12 CN21 DSPCK B11 /RINT CKo A11 USRCKI H18 2 A0 ADD0 J18 1 A1 ADD1 K18 A2 ADD2 L18 A3 ADD3 M18 A4 ADD4 N18 3.25V A5 ADD5 CLOCK BUFFER AMP R185 J17 10 L13 A6 ADD6 K17 A7 ADD7 IC8 M17

22 A8 ADD8

R81 SM5023CNDH-G N17 X2 A9 ADD9 4 3 18.432MHz P17 Q VSS A10 ADD10 5 2 C47 3 2 K16 VDD XT oUTPUT GND A11 ADD11 1k L16

0.01u D R100 6 1 A12 ADD12

0.1u M16 C136 XTN INHN 4 1 A13 ADD13 VCC VC P16 A14 ADD14 R86 J15 A15 ADD15 5.43mV C56 R101 100k 0.1u 0.01u

470k C137 K15 A16 ADD16 M15 A17 ADD17 N15 A18 ADD18 BUFFER AMP 1 P15 (LOGIC) A19 ADD19 33MDSP L7 J16 A20 ADD20 H15 IC6 A21 ADD21 TC7SH08FU-F G17 D0 DT0 R46 100k 1 5 H16 INB VCC D1 DT1 2 G15 INA D2 DT2 3 4 F18 GND oUTY D3 DT3 F17 D4 DT4 HD0 G16 C37 D5 DT5 E18 0.01u D6 DT6 E17 D7 DT7 F16 D8 DT8 32K D18 D9 DT9 REAL-TIME D17 IC7 CLOCK D10 DT10 B15 RV5C386A D11 DT11 L8 31BU D16 1 10 D12 DT12 32KOUT VDD C15 9 D13 DT13 2 OSCIN D15 SCL D14 DT14 E15 3

X1 D15 DT15 SDA A15 8 32768Hz /WR WRITE 4 OSCOUT INTRB A16 7 33M /RD READ BCLKX0 CLKC 5 B14 VSS 6 BHE INTRA /RINT 3 C14 R50 BLE A13 /CS4 CS4 C38 47k D13 /CS3 CS3 0.1u C13 ASQDET /CS2 CS2 B13 I2CSDA I2CCK STSW CS1 8 A14 /CS0 CS0 B12 /HRDY HRADY D14 /HDS2 HDS2 C30 for ADJUSTMENT R18 BCLKR0 TXD0 TXD0 8 TP102 T18 0.01u RXD0 RXD0 TP101 R16 IC5 RTS0 RTS0 XC6109C29ANN R15 CTS0 CTS0 3 2 U15 150 R67 CD VSS /OINT TXD1 T15 RXD1 RXD1 C32 4 1 0.01u R37 33M V15 VoUT VIN TXD2 TXD2 V14 3.29V 0 RXD2 RXD2 T14 3.28V TXD3 VOLTAGE DETECTOR (RST) R75 3 10k MCSCKCN CN19 R76 TXD3 9 9 7 47k RXD3 SCK SDT SPCK0 SPo0 SPCS00 SPCS01 SPCS02 SPCK1 SPI1 SPo1 SPCS10 SPCS11 SPCS12 ADC4 SPI0 T6 T8 T5 T4 V5 A9 V6 V7 V4 U6 U5 U4 U7 TP1001 G3 C10 R14 R77 2.2k TP1002 R78 2.2k 0 TP5 TP4 TP2 R88 CN22 /FLDM 3 3 TP1003

TP14 for BOOT for ADJUSTMENT CN43 DGND 0 0 R83 R84 SDO0 TONESW /EVCS SCK0 PCS_Pot VCOSW2 CV W_/N LCONT PCS_RF LCONT 7 7

3 3 33MAS 98 I2CSDA I2CCK 8 8 32K

9 9

/PTT /PTT RESET RESET

10 10 10 6 6 6 4 4 4

82 X53-439 3/6 P Q R S T SCHEMATIC DIAGRAM TK-5410 CONTROL UNIT (X53-4390-XX)

GPIo7 GPIo7

33AA T1 N4 T17 T16 R13 F15 C18 C16 D6 D4 B16 C5 C3 A3 V2 V1 U2 U1 V18 V17 U18 U17 B18 B17 E6 G4 A18 A17 B2 B1 A2 A1 U3 M1 L3 K4 T3 H4 T2 P13 L1 K5 J5 H5 G5 F5 E5 F4 V16 E4 D3 U16 C17 C4 A5 B3 P7 P8 P12 K14 J14 NC1 NC2 NC9 NC8 NC3 NC6 NC5 NC4 NC7 NC21 NC11 NC22 NC12 NC30 NC29 NC28 NC26 NC25 NC23 NC20 NC19 NC18 NC16 NC15 NC13 NC10 NC35 NC36 NC27 NC24 NC17 NC14 NC34 AVCC1 AVCC2 AVCC9 AVCC8 AVCC6 AVCC5 AVCC4 AGND2 AGND9 AGND8 AGND6 AGND5 AGND3 AGND7 AGND4 DGND9 DGND8 DGND6 DGND5 DGND7 DGND4 AVCC10 DGND11 DGND12 DGND15 DGND13 DGND10 DGND14

IC10 ASIC BooT SQDAC ADC0 DAC0 IFR ADC3 ADC2 FCDADC IFADCP IFADCN IFVR ADC5 ADC6 ADC7 ADC8 ADC9 MICVR SPDAC MICADC0 MoDDAC MICADC1 KEYI0 KEYI1 KEYI2 KEYI3 KEYI4 KEYo0 KEYo1 KEYo2 KEYo3 KEYo4 PWM1 PWM2 TI TDI TMS TRST RTCK TDo TCK BSCAN0 BSCAN1 RSTo TEST0 TEST1 TEST2 TEST3 RST J1 F1 E1 J2 K1 J3 L2 D1 H1 F2 G1 E2 K2 E3 V3 K3 V8 P4 C2 D2 H2 H3 R9 R4 G2 T11 V11 U11 R11 L15 L17 T12 T10 T13 V12 V13 E16 P18 U12 R12 U10 R10 U13 N16 U14 H17 R17 G18 R113 R179 R181 C122

0 100k R215 47k 1k 0.01u 1k 22k R102 0 R295 3p 10u C72 C68 C67 0.1u 100k R105 R103 C118 C119 0.01u 0.01u C66 BSCAN0 BSCAN1 /KEYO1 /KEYI1 6800p /KEYO2 /KEYI2 /KEYO0 /KEYO3 /KEYI3 /KEYI0 /KEYI4 for BOOT CN31 CN32

0.1u R182 R184 C153 C49 10u C48 0.1u 47k 47k R90 100k C161 C44 6800p 0.01u C61 C121 1000p C120 0.01u /FRST 4700p 100k 100k 4 R188 R189 MIC AUD_VREFC THP AFC ASSIST BATT VOX BEEP RXAF TONE S_DET RSSI PFKEY MOD VADAC IFDET CN44 7 7 7

3 3 3 33MAS 33MAS 33AA 33AA

8 8 8 32K

9 9 9

/PTT /PTT RESET

4 10 10 10 6 6 6 4

83 X53-439 4/6 U V W X Y TK-5410 SCHEMATIC DIAGRAM CONTROL UNIT (X53-4390-XX)

GPIo7 +B

33AA D25 REVERSE CURRENT 470k R169 1SS301F VOLTAGE PREVENTION REGULATOR (3.1V) E12 R166

DGND3 C63 1u

C64 0.1u C65 0.1u DC SWITCH E11 C62 0.01u for ADJUSTMENT 10k IC17 470k DGND2 R173 Q16 S-812C31BPI-G E10 TP11 DGND1 3.29V 2SA1955A-F L5 L16 DVDIo7 33M P6 CN23 3 2 1

DVDIo6 3.3k 33M R171 DC SWITCH P11 (STCAMI) DVDIo5 NC 470k R177 L14 VIN1 DVDIo4 Q15 VoUT C74 1u C75 0.1u C76 0.1u C77 0.1u C78 0.1u 10u 10u

H14 C73 0.01u 31BU C113 C114 SSM3K15TE(F) DVDIo3 1u

CN24 C116 E13 DVDIo2 GND 3.13V 33MAS E7 1.47V TP12 VSS VIN2 oN/oFF DVDIo1 L17 5 6 M5 31BU 4 DVDD10 15M N5 Q13 DVDD9 TP9 2SA1955A-F P9 C117 DVDD8 L19 D24 D26 DC SWITCH P10 33A 1SS388F 1u 10k

DVDD7 R176 C80 1u C84 0.1u C85 0.1u C81 0.1u C82 0.1u C83 0.1u 1SS416 N14 C79 0.01u 3.3V for ADJUSTMENT DVDD6 1k M14 R172 DVDD5 D24,26 TP103 TP104 G14 REVERSE DVDD4 Q14 F14 CURRENT SSM3K15TE(F) 36M

DVDD3 PREVENTION CN37 E9 R107 DC SWITCH DVDD2 E8 10k (31BU) DVDD1 B5 GPIo11 DSR C6 SBC GPIo10 B6 16 16 GPIo9 5UC A6 R199 100k 5M GPIo8 Q7,8 U8 7 +B

GPIo7 33M 33M DC SWITCH R8 GPIo6 /WP BLC (/BINT,PSW) R7 R198 100k GPIo5 Q8 16 T7 R197 100k 100k R194 11 GPIo4 R196 100k 3 R146 SSM6N16FE-F V10 12 GPIo3 100k PSW

R108 100k 5AC U9 R157 GPIo2 R159 S36M LED_R LED_G R147 R193 100k 1k 100k 100k V9 16 18 17 16 15 14 13 470k GPIo1 AMT 11 11 R155 T9 R143

GPIo0 A0 Io1.3 Io1.6 Io1.5 C11 CN45 /MNDNU R112 Io1.7 Io1.4 100k /BINT SIMRST 12 D12 R121 100k 19 Io1.2 SIMCK PSW I2CCK SCL 11 R156 C12 R122 1k 20 Io1.1 INAMT SIMDT /BINT I2CSDA SDA IC15 470k 21 PCA9535BS 10 R144 R5 1k VDD Io1.0 EXAMT 470k SYMTIM /SYMTIM 100k R154

C91 22 I/O EXPANDER 9 R6 C88 Q7 FSDET FSDET 1000p 1000p INT VSS 23 8 SSM6N16FE-F A1 Io0.7 CN46 R2 24 7 Q10,11 100k TXRVE 5TC 8 R151 A2 Io0.6 P3 12 DC SWITCH (BLED,TXLED) TRAMP DACRST P2 TMoD /LCDRST 3 0.1u

C101 Q10 M4 Io0.0 Io0.1 Io0.2 Io0.3 Io0.4 Io0.5 PSTPA APCSW SSM6L05FU-F 1 2 3 5 6 4 R158 R293 47k R137 47k 470k 47k 3 100k R1 R192 R195 R115 R145 47k R140 47k

33M 470k PSTIF 10 R162 100k 7 100k N3 R116 R142 47k R139 47k PSTPLL MM N2 R141 47k R138 47k RXRVE /SAVE P1 RXSLT VCOSW1 R164 L4 470k PSRRF 5RC 470k M2 R191 5RC R170 PSRIF Q11 LED_R M3 100k SSM6L05FU-F LED_G ORG PSRPLL PSRPLL TGL1 TGL0 TGL2 BLED CH_B TXLED CH_A CH_D N1 CH_C 12 RSSIT /DRST VoL 15 15 D8 470k VFRM /DWUP R124 33M D7

VoINT /DINT 33MAS C7 MCo2 /UDET 11 8 47

D10 R190 R111 R74 MCCS2 R106 C8 0 0 100k MCCK2 PLD SCTAMI D9 MCCR1 /MCCSRCN ECSW B7 1M MCCX1 /MCCSXCN R117 8 8 8 C9 7 MCo1 MCDOCN B8 6 MCI1 MCDICN C40 A7 BUS BUFFER (LCD) 0.01u MCCK1 MCSCKCN B10 MCCS0 /MCCSAF R97 68k SP+ B9 IC9 MCo0 MCDOAF C69 TC7W66FK-F SP- D11 AUDIO IC11 MCI0 MCDIAF 1 8 AMP (BTL) TPA6201A1DRBR INAMT IN_oUT1 VCC A8 R119 L14 13 MCCK0 MCSCKAF 8 2 1 8 R3 0 oUT_IN1 7 SHUTDoWN Vo- AGCDAC /SCSW 3 CoNT1 C54 CoNT2 6 4 oUT_IN2 0.1u 2 7 GND 5 BYPASS GND 470k R123 100p IN_oUT2 C50 R92 3 6 IN+ VDD 0.1u 15k 5 L15 4 Vo+ IN- 93 7 C51 R93 C57 0.1u 15k 10 EXAMT R96 1u +B 68k C59 Q3,5 100p 5A 5A AVR 7 C58 D19,20 L10 5.01V R99 47k Q3 SURGE 3 2SB1132(Q,R) 1u 13 6 AUDIO IC12 ABSORPTION C60 7 33MAS AMP (BTL) TPA6201A1DRBR 33AA 1 8 100p L11 C39 0.1u SHUTDoWN Vo- SPuniv+ Q5 C55 7 UMG3N 0.1u 2 GND AVRM1005C270M

R69 BYPASS D19 6 8 8 C52 R94 3 VDD 15k IN+ 11 1k R72

R70 0.1u 15k L12 470k 4 5 9 7 Q4 IN- Vo+ SPuniv- SSM3K15TE(F) C53 R95 5AC 0.1u 15k

/PTT DC SWITCH R98 D20 (5AC) R71 100k 47k AVRM1005C270M /PTT 10 7 7 6 6 6

84 X53-439 5/6 Z AA AB AC AD SCHEMATIC DIAGRAM TK-5410 CONTROL UNIT (X53-4390-XX) TOP SW SECTION CHANNEL CONCENTRIC CN40 POWER SW/AF VOL GND 2 +B SELECTOR SW GND 1 R219 I2CCK 4 I2CCK VOLTAGE R220 100 I2CSDA 3 DETECTOR 8 I2CSDA BATT INT 100 GND 6

(/BINT) 0

R178 GND 5 AF 8 AF 1 2 RXAF 7 RXAF MIC 10

VIN MIC CH_B CH_A CH_D CH_C

VoUT MICE 9 TGL1 TGL2 8 MICE 47p C156 IC16 L27 MICmain 470p 12 C115 14 MICmain 33C 11 NC VSS XC61CC5602NR GND 14 3 4 R221 AFC 13 CH_B CH_A CH_D CH_C TX-RX UNIT : AFC TGL1 TGL2 100 AUD_VREFC 16 TOP SECTION AUD_VREFC 14 MOD 15 CN902 (X57-7560-10) (B/3) MOD GND 18 D23 Q12 GND

1 17 2 3 5 6 8 4 7 11 12 REVERSE EMD12 10 R232 ASSIST 20 CURRENT ASSIST PREVENTION C9 100 CGND 19 VoL 33M 36M GND TGL1 TGL2 S36M CH_B CH_A CH_D CH_C 7 GND 22 D23 R168 R235 RSSI 21 1SS301F 10k RSSI 100 R236 THP 24 36M THP TGL1 TGL2 S36M CH_B CH_A CH_D CH_C R237 VoL 36M 100 /SCSW 23 DC SWITCH /SCSW 470k R165 (36MC) TX/RX 100 R238 ASQDET 26 S901 LED ASQDET 10k R225 MM 25 R161 100 D901 MM SBC B30-2019-05 100 R226 TONESW 28 S902 TONESW R227 100 VOX 27 VOX +B 100 R239 W_/N 30 W_/N R240 100 BEEP 29 BEEP 100 R241 TONE 32 TONE R230 100 VADAC 31 VADAC R242 36M 100 AMT 34 VoL TGL1 TGL2 AMT S36M CH_B CH_A CH_D CH_C R243 100 STSW 33 STSW 100 R244 VCOSW 36 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 VCOSW1 S36M R231 100 LCDCNT 35 LCDCNT 100 R245 VCOSW2 38 CN903 VCOSW2 R246 100 APCSW 37 APCSW 100 R247 CV 40 CV GND CH_A CH_B CH_C CH_D 36M S36M 33M TGL0 TGL1 TGL2 BLED TXLED ORG VoL KIN GND R248 100 /EVCS 39 /EVCS 100 R249 PLD 42 PLD NC MIC R250 100 PCS_RF 41 PCS_RF C155 1000p 100 R251 DACRST 44 DACRST R252 100 PCS_Pot 43 PCS_Pot 100 R253 SDO0 46 SDO0 R254 100 SCK0 45 CN35 SCK0 100 R255 BFSR2 48 BFSR2

1 R256 2 5 6 8 9 3 7 4 100 HD7 47 11 12 20 10 13 15 16 18 19 14 17 HD7 100 R257 INT3 50 14 INT3 R258 100 BER_EN 49 BER_EN BLED CH_B CH_D CH_C R233 PSRPLL 52 TXLED 100 PSRPLL R259 HD5 10k 100 51 R167 HD5 C157 R260 BCLKR2 54

C107 4700p 100 BCLKR2 100p L22 R261 100 BDR2 53 BDR2

R160 470 R163 470 R262

33k BCLKX2 56 C108 4700p C109 4700p 4700p C110 4700p C111 C104 4700p C105 4700p C106 4700p C103 4700p 0.1u 100 C112 R287 1k BCLKX2 R152 R263 100 BDX2 55 BDX2 TX-RX SECTION : TX-RX UNIT (X57-7560-10) (A/3)-CN707 8 100 R264 BFSX2 58 0 L23

TGL1 6 BFSX2 TGL2 TGL0 MICE BLED CH_B TXLED CH_A CH_D CH_C ORG VoL 39k R148 GND 57

R288 100 15 15 7 GND 60 R267 IFDET 59 IFDET 100 GND 62 33C 33M GND 61 6 R234 5RC 64 SCTAMI 5RC R269 100 5TC 63 ECSW 5TC 100 R266 /SAVE 66 8 8 /SAVE R265 100 5UC 65 7 7 5UC 100 6 6 R270 SBC 68 R268 100 S_DET 67 S_DET R272 33C 14 100 DSR 70 DSR SP+ R271 100 BATT 69 BATT SP- 100 33A 72 33A 5M 71 TP8 5M 13 13 5M 33A 74 14 14 TP10 +B 73 7 +B +B AF 33M 76 IC13 TP1 TP3 TP6 33M MICE AUDIO AMP 33C DACRST 5RC +B 75 MICmain C70 0.1u (1/2 AUDIO PRE-AMP, 33M 78 0 2/2 NC MIC AMP) for ADJUSTMENT TP7 R285 SBC +B 77 13

22k 15M 80 R109 C86 TP13 15M 47 47 +B 79 IC13 R82 100p R125 36MC C99

D22,27 470p AK2925T 15M 82 470p

R118 C100

1 8 1u SURGE

C93 SCTAMI VDD ABSORPTION SCTAMI 81 7 R130 270k SPuniv+ 84 L20 13 SPuniv+ 2 22k R134 C96 SPuniv- 83 SPuniv- 3 6 22k 0.47u SPuniv- 86 4 5 R131 R132 SPuniv+ 85 8.2k VSS R291 22k 47k R274 RTS0 88 RTS0

D22 R275 100 /UDET 87 R133 /UDET 1.8k 27k R136 R128 47k 100 R276 RXD0 90 150k C71 R110 R120 R126 RXD0 R277 AVRM1005C270M 100 PFKEY 89 C90 0.1u 22k 270k 0.1u PFKEY 100 R278 TXD0 92 47k C92 C87 0.1u 0.1u

R129 CN34 TXD0 150k R127 470 C94 R187 0.47u R279 100 RXD1 91 1 RXD1 2 100 R280 CTS0 94 Q6 CTS0 R281 100 /PTT 93 EMD12 3 INT SP /PTT 1.8k R135 36MC 100 R282 36MC 96 4 R273 100 RXD2 95 5 RXD2 C98 D27 470p C97 470p 100 R283 TXD2 98 6 TXD2 INT MIC R284 100 /OINT 97 ECHO CANCEL /OINT

AVRM1005C270M (MAIN) 470p MIC SWITCH C102 100 GND 100 0.1u C141 GND 99 C95 1000p L21

85 X53-439 6/6, X57-756 (B/3) 1/1 AE AF AG AH AI TK-5410 SCHEMATIC DIAGRAM TX-RX UNIT : TX-RX SECTION (X57-7560-10) (A/3) 6 6 6 5 5 5 BATT DETECT S BATT +B(Y) GND(Y)

F700 L700 +B 3.15A 7.5V CN707 1 GND 5 100p 100p C702 C700 2 GND 6 D700

3 I2CCK +B 1SR154-400 I2CCK 4 I2CSDA I2CSDA 1 5 GND 33C 6 GND SB 7 AF F701 R706 AF 0 1 SB C721 100p 8 RXAF C845 47p R710 0 RXAF 0.25A Q707 C844 47p L710 470k 9 MIC R707 2SJ648-A MIC 10 MICE C843 47p DC SWITCH MICE Q708 11 MICmain C842 47p SSM3K15TE(F) MICmain 12 33C C841 47p 5M(Y) 13 GND DC SWITCH 14 AFC 5M AFC 15 AUD_VREFC C840 47p IC700 5MCS AUD_VREFC TK11250CUCB AVR (5MCS) Q704 16 MOD C839 47p C707 TPC6108-F MOD 3 1u 1 5 17 GND C838 47p 5 NP VoUT 2 18 GND 6 GND 5MCS 19 ASSIST 3 4 1u SWITCH 470k 470p R711 C713 ASSIST CoNT VIN C714 20 CGND C835 47p CGND

21 GND 1u 22 RSSI C711 RSSI Q703 23 THP C832 47p 5UC SSM3K15TE(F) THP 24 /SCSW C831 47p 5MC /SCSW 7.5V AVR (5C) 470k 25 ASQDET C830 47p IC702 R705 ASQDET +B XC6204B502MR 4.96V 26 MM C829 47p MM 1 5 27 TONESW C846 47p VIN VoUT 5C

TONESW 0.1u C706 2 28 VOX C828 47p R704 VSS

VOX 100k 3 4 1u 5C 470p 29 W_/N C827 47p /SAVE CE NC C716 C719 W_/N 30 BEEP C826 47p BEEP 0 7.5V 470k 470p C701 R759 31 TONE C825 47p R700 TONE TP1 32 VADAC C824 47p 33C VADAC 33 AMT C837 47p IC701 R910 TP11 4 AMT AVR (5T/5R) XC6209B502PR 5.0V 34 STSW C823 47p 470k 33M STSW 35 VCOSW C822 47p 1 5 VCOSW1 3.29V NC VoUT 36 LCDCNT C821 47p 2 TP7 VSS 37 NC C836 47p TP3 38 APCSW DACRST 3 4 APCSW CE VIN 1u 470p C720 39 CV C819 47p C717 CV 1 TP6

C818 47p 0.1u 470k 470p R701 C712 40 /EVCS 5RC C703 /EVCS 41 PLD C817 47p Q700 PLD TP9 SSM6L05FU-F 42 PCS_RF C816 47p 33A T : 3.28V PCS_RF R : 0V 5T 43 DACRST C815 47p DACRST TP12 5TC 44 NC C814 47p 15M 5TC 470k R708 T : 4.8V 45 SDO0 C813 47p SDO0 R : 0V 470k C704 R702 46 SCK0 C812 47p 1000p SCK0 47 BFSR2 C811 47p 5T BFSR2 48 HD7 C810 47p 3 5RC HD7 Q701 10u 49 INT3 C809 47p T : 0V C709 SSM6L05FU-F INT3 R : 3.28V 5R 50 BER_EN C808 47p BER_EN CONTROL UNIT CONTROL (X53-4390-XX)-CN40 51 PSRPLL C807 47p PSRPLL 5RC 470k 52 HD5 C834 47p R709 T : 0V HD5 C806 47p R : 4.98V 470k

BCLKR2 C705 53 R703 BCLKR2 1000p 54 BDR2 C805 47p BDR2 5R 55 BCLKX2 C804 47p BCLKX2 56 BDX2 C803 47p AVR (5M) BDX2 IC704 TP8 57 BFSX2 C802 47p TK11250CUCB 5M(Y) BFSX2 C724 58 GND C801 47p 1u 1 5 59 GND 2 NP VoUT 5M 2 60 IFDET GND

IFDET 4 3 4 1u 470p C728 61 GND C798 47p CoNT VIN C727 62 GND 63 5RC 5RC 4 +B 64 5TC C795 47p 5TC 65 /SAVE C796 47p /SAVE 1 66 5UC C794 47p SB 5UC 67 SBC C833 47p D702 R716 R713 33M 68 S_DET C793 47p 470 MA2S111-F 69 DSR C800 47p DSR 1 70 BATT C792 47p 3.29V 150k C725 560k R714 71 33A C799 47p 6800p 72 5M 5M 33M 73 33A C791 1000p -4.15V 33A 0.1u 74 +B C790 1000p C766 +B C789 1000p 2 3 75 33M 5 4 33M 1 IC713 76 +B 1M LM2682MMX C788 1000p R751 V+ +

77 33M C768

oUT 4.97V C767 1 8 2.2u16 78 +B C1- NC 2.2u16 2 7 79 15M C2+ C1+ R752 15M IC712 + 3 6 47

80 +B -t

C797 1000p R749 100k C2- VIN 5M +IN V- -IN 100k NJM2130F3-ZB 81 15M TH102 4 5

VoUT GND + 1 2 82 SCTAMI 3

SCTAMI + C771 C769 C770 1000p 1000p 83 SPuniv+ C786 1000p DC AMP 2.2u16

SPuniv+ C765 DC/DC

(LCDCNT) 2.2u16 84 SPuniv- C787 47p -9.91V CONVERTER

85 SPuniv- 12k 100p C763 SPuniv- R750 86 SPuniv+ C785 47p 87 RTS0 RTS0 33M 88 /UDET C783 47p /UDET IC511 89 RXD0 C782 47p RXD0 TC7SH126FU-F C556 90 PFKEY C781 47p 0.01u PFKEY 1 5 91 TXD0 C780 47p BER_EN G VCC TXD0 2 C779 47p BFSX2 INA 92 RXD1 10k RXD1 3 4 R618 93 CTS0 C778 47p GND oUTY CTS0 94 /PTT C777 47p /PTT 95 36MC C776 47p LOGIC SWITCH 36MC 96 RXD2 C775 47p RXD2 97 TXD2 C784 47p TXD2 98 /OINT C774 47p /OINT 99 GND C773 47p 2 3 /SCSS LCD1 100 GND 1 3 3 2 2 1 1 86 X57-756 (A/3) 1/6 AJ AK AL AM AN SCHEMATIC DIAGRAM TK-5410 TX-RX UNIT : TX-RX SECTION (X57-7560-10) (A/3)

6 6 6 /SCSW 5 /SCSW VREF

AMT C554 6 6 BUFFER AMP (AF) C537 33CA IC510 100p MIC RXAF SMF 0.1u TC75W51FK(F) SCSW (RXAF) 5 4 IC506 C547 DAC0in_MOD 5 IN+B VSS TC75S51FE(F) AF PASS CONTROL 1k 10p C555

1k 6 3 R583 AUD_VREFC

R568 IN-B IN+A 1 5 IC507 7 2 1u IN+ VDD oUTB IN-A 0.1u TC7W53FK(F) 8 1 C528 R610 AUD_VREFC 1500p 2 VDD oUTA VSS 5 4 A GND 100k 0 C522 R550 R553 R566 0 3 4 6 DC AMP/ 3 470k R616 C559 R588 RXAF IN- oUT CH1 R587 1u 56k 56k 0 7 VEE SUMMING AMP R626 18k CH0 2 8 INH C552 C536 VCC 1 C544 R586 R627 10k CoMMoN 0.01u R556 150p 0.1u 470k C568 R628 C542 C524 68k A : VREF/ 820p 18k B : RX SUM RXEo 0.01u 0.1u 33CA C571 C532 R578 5600p

RXEI 8 7 6 5 0.1u 47k R561 C538 BEEP IN-B VDD IN+B

330k 0.1u oUTB 7 8 8 10k R912 1 IC513 2 R575 C545 R585 VGS REC SEL VADAC 47k TC75W51FK(F) 1u 270k oUTA IN-A IN+A VSS C533 R557 R570 1 2 3 oPT9 SIDE TONE MUTE 4 3 2 1 0.01u 560k 220k 4 AF PASS CONTROL C520 C539 R571 IC509 C565 INH

AI VEE GND C546 0.01u TC7W53FK(F) BUFFER 0.1u 0.01u 330k IC508 100p AMP TC7W53FK(F) 0 CoMMoN AF PASS (MIC) 120k R621 R558 C540 R572 R624 1 8 CONTROL C564 TONE CoMMoN VCC TXO 100k 0.01u 330k 2 INH 7 0.01u CH1 CH0 VCC CH0 A 6.8k

10k 3 5 R913 R560 VEE 6 8 6 5 CH1 7 8 4 5 R554 TONE GND A 150k

R916 R614 TONESW SWITCH 4.7k Q503 47k 47k SSM3K15TE(F) C543 R617 R589 R602 0.1u 0.01u C558 R584 47k 270k STSW R590 1k OPT6 0.1u 100k 100k R611 C560 R612 R593 D521 47k oPT6 150k C521 1k 1SS416 R596

AO 0.1u 0.1u C527 C557 TXo 0.1u 33CA

7 8 TXI DTI 7 7 7

R756

+B 33C 15V 0 DC/DC 14.55V VREF (15V) L705 15V(Y) 68u

Q705 470k R761 SSM5H01TU-F VCO_MOD APC

C753 1u C755 1u C758 1u AF L2SF 470k R762 LCD1 IC708 Q709 XC9101D09AKR SSM6L05FU-F C750 22p R730 330k 9 7.44V 18 15V 3 EXT VSS 2 7

LSEN VoUT/FB 24 23 22 21 20 19 36 VIN CC/GAIN

10 4 5 R724

CE/SS CLK VIN6 VIN5 VoUT6 VoUT5 VoUT7 VoUT4

0 DC/DC C739 1u R727 C741 4.7u CONVERTER (15V) 1 18 1u R731 22k VIN7 VIN4 C751 470p C736

R729 12k 2 17 C748 180p VIN0 VIN3 3 16 VoUT0 IC502 VoUT3 4 AK2330 15 D706,IC707 VoUT1 VoUT2 5 DAC 14 7.5V Q706 DC/DC VIN1 VIN2 CONVERTER (3.6V) 6 13 L708 TPC6108-F L706 L703 DACRST RSTN VREF +B C513 68u D706 68u HRB0502A 100p Q706 + IC707 DC/DC C730 33u10

(3.6V) XC6365D103M CSN SCLK SDATA DVDD VSS AVDD C737 82p C733 0.1u R722 330k C762 4.7u C761 4.7u 8 9 1 5 7 9 11 12 EXIT/ VOUT/FB 10 33CA 2 VDD 3 4 3 GND CE C500 0.01u 1u 4.7u 4.7u C752 C508 C509 C754 1000p 470k 120k R726 3.29V 36M R723 R511 100 R511 R513 100 R517 100 9 33M AVR (33M) SDO0 D704 AVR CE SCK0 AVR IC710 (IC705,706, (33A) XC6204B332M IC705 33M 1SS388F IC710) XC6204B332M 3 4 3 /EVCS SCK0 3.3V NC CE 4 3 R720 SDO0 2 NC CE VSS 2 220k 3 5 1 VSS L702 33A VOUT VIN 5 1 BUFFER VOUT VIN TCXO_MOD

C745 8 7 6 5 /EVCS SCK0 SDO0 33A C749 1u 2 C735 C740 0.01u C732 36MC 1 IN-B 4.7u +B VDD IN+B oUTB TP2 TP5 TP4 TP13 TP10 1u 1u TP14 36MC L704 R501

AFC IC500 15M IC709 IC709 AVR 100k XC9235A15CM1 DC/DC TC75W51FK(F)

(33C) oUTA IN-A IN+A VSS

L707 CONVERTER (1.5V) C621

1 5 0.039u 1 2 3 VIN LX IC706 4 2 1.5V VSS XC6204B332M 3 4 4 3 L701 R509 R760 3 1 CE/MoDE VoUT NC CE 2 2 100k 56k 33C VSS 4.7u 4.7u C746 C756 C759 C744 5 1 1000p 1000p VOUT VIN C503 100p 3.3V 3 C731 R699 R506 100k 15M C742 1u 1u 33C 100k

3 3 3 2 2 2 1 1 1 87 X57-756 (A/3) 2/6 AO AP AQ AR AS TK-5410 SCHEMATIC DIAGRAM TX-RX UNIT : TX-RX SECTION (X57-7560-10) (A/3)

/SCSW VREF VREF

6 MICmain

MOD 6

DAC0in_MOD R623 33CA 0 D517 R622 22k DA221 VOX DC AUD_VREFC R630 22k 27k MM R638 R629 C566 VOX 22k 330p VOX 470k MOD R658

C563 D510 C610 R666 C615 SMF 1500p R650

5.6k RB706F-40 R641 C576

0.022u 0 68p 15k 0.039u C604 R643

4 3 2 1 R661 0 1u 100k 100k C589 0.1u R615 R648

0.22u 680k

C562 A : MIC SUM1/ VSS IN-A 0 IC514 IN+A B : VOX oUTA

R631 TC75S51FE(F)

4 3 10k IC512 oUT IN- R646 8 7 6 5 2 TC75W51FK(F) IN+B IN-B oUTB VDD VSS IC516 TC75W51FK(F) C561 100p IN-B R619 100k VDD 8 5 6 7 IN+B

51 oUTB VDD IN+ BUFFER AMP MODULATION (MIC) 0.1u

C573 C579 C602 R620 C567 0.01u 0.01u oUTA IN-A IN+A VSS

100k 100p 1 2 3 4 33CA R674 BUFFER AMP (VOX) R625 470 100k C616 0.01u INT/EXT 1.8k

R675 MIC 10u 100k 100k C619 TXO R655 R670 R673 SWITCH R642 C578 1M Q5063.3V Q508 MIC AGC MIC AGC C618 47k 0.1u 2SJ243-A 2SJ347F D511 Q504 C609 R659 C611 R664 C614 1u 2SC4738(GR)F RB706F-40 15p 47k 0.1u 47k 1u 2 1 3 R653 IC515 MIC MUTE 100k TC7S66FUF 10k SWITCH R676 33k 12k R669 R667 MIC SWITCH GND 1u 4.7k 0.1u oUT/IN 68k IN/oUT C590 (/SCSW) R672 C605 R656 R662 R665 C613 R668 R671 D512 0 68k 0.1u 560k 1k 0 C582 0.01u VCC CoNT

RB706F-40 1u 68k R660 560k C606 0.1u 0.1u R663 R657 C591 C617 5 4 R654 Q507 SSM3K15TE(F) R644 10k MIC AGC 0.1u

C612 INT/EXT 0 MIC AGC Q505 33CA 2SA1832(GR)F MIC 470p 1 2 SWITCH C620 8 8 8

7 7

IC501

D518 5M D519 Q509 TEMPERATURE 33M 5V to 3.3V 7 DETECTION 33M RXD1LEVEL CONVERTOR RXD1 DC SWITCH 5MCS RTS0 IC714 D518 LM73CIMKX-0 10

R754 C772 RXD1 4 3 0.01u R525 47k 1SS416 I2CCK SMBCLK VDD R522 R527 D519 5 2 ALERT GND 6 1 10 47k 1SS416 I2CSDA SMBDAT ADDR IC501 1 TC7MBD3245AFK Q509 0.1u 1 20 C510 SSM6N16FE-F I2CCK NC VCC I2CSDA R519 2 19 R694 100k

I2CCK A1 oE R532 4.7k R533 4.7k 3 18 0 I2CSDA A2 B1 I2CCK_5V 11 4 17 CTS0 A3 B2 I2CSDA_5V 5 16 A4 B3 CTS0_univ RTS_univ 6 15 VREF RXD0 A5 B4 9 9 7 14 DSR A6 B5 RXD0_univ 11 3 3 8 13 TXD2 A7 B6 DSR_univ 9 12 RXD2 A8 B7 26P_TD 7 3 10 11 GND B8 26P_RD 9 10k 10k 100k R576 R574 R507 47k 10k 10 7 7 470k 470k 100k R690 R526 R529 R580 R530 11 11 IC517 R695 TC7SET08FU-F TXD0_univ 100k R698 100k 1 5 9 D502,504,515,516 TXD0 INB VCC 3 R693 SURGE 2 ABSORPTION INA L505 0.1u 47k C504 CN505 100p 34 /OINT C594 GND oUTY 9 R651 14 /UDET SSW 1k L503 13 SPuniv+ SP+ BUFFER AMP 3 L504 12 (LOGIC) SPuniv- SP- R645 11 9 9 CTS0_univ MSW/CTS 1k 10 1 EMC L506 9 MICE MICE 3 3 C599 1 1 100p C601 100p D516 D515 C577 100p C581 470p C595 470p

D504 C600 100p 22 D505 R649 /PTT NNCD6.8G-A AVRM1005C270M AVRM1005C270M 1SS416 1k 8 1 10 /PTT PTT R647 7 HD5 HD7 INT3 UNIVERSAL CONNECTOR UNIVERSAL BDX2 BDR2 PFKEY REM /SCSS BFSR2

SCTAMI 470 R636 BCLKX2 PSRPLL BCLKR2 6 RTS_univ RTS1 470 L502 R652 5 5M R635 CPU TXDM(Y) 0 4 TXD0_univ TXD 470 R640 3

R592 0 R591 0 R595 0 R594 0 R598 0 R597 0 R600 0 R599 0 R604 0 R603 0 R606 0 R605 0 R608 0 R607 0 RXD0_univ RXD 1k 2 0 RXDM(Y) E R601 R637 1 DSR_univ DSR C551 1000p 1k GND GND BFSR2 HD7 BDR2 /SCSS BCLKR2 BDX2 33M SCTAMI NC GND PSRPLL INT3 RXD0 BCLKX2 SCTXD HD5 GND GND 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 C570 470p C575 470p C574 470p C585 100p C586 100p C587 100p C603 100p C607 100p C608 100p C598 3300p C583 6800p D502 NNCD6.8G-A CN502

88 X57-756 (A/3) 3/6 AT AU AV AW AX SCHEMATIC DIAGRAM TK-5410 TX-RX UNIT : TX-RX SECTION (X57-7560-10) (A/3)

RIPPLE 700M RX 4.95V FILTER Q104 800M TX,TA 2SC4617(S) Q105,108 Q108 : 4.12V 5C L107 5C VCO CONTROL 2SJ347F 470p C168 700M TX,TA SWITCH 800M RX : 0V 1.5k R137 470k 4.7u R139 VCOSW1 C147 C153

6.85V + 700M RX 100k 100p C155 R907 100p R145 ASSIST ASSIST DC Q105 800M TX,TA C144 1K 33k 1.42V 10u6.3 SSM6L05FU-F : 0V R144 VCOSW1 180k R908 3 2 1 10M

R173 R125 180k 100p C122 3 R114 L127 270n 22 700M TX,TA IC100 IN+ 15V RIPPLE oUT D100,102,104,106 800M RX GND

TLV2381IDBV D119 FILTER DA221 C141 5p : 4.23V VCO-A (LOWER) VCO (FREQUENCY DC AMP 100 R131 10M

33k CONTROL) R120 Q106 R116

14.47V 470p Q100 C149

IN- VDD Q106 C154 2SC4617(S) R100 L104 VCO 0V 0 270n D100 D102 C131 L150 2SK508NV(K52) 0.5p 5 15V 4

0.1u 33n C126 1SV325F 1SV282-F 10p 47k 100 R102 R106 0.5p

R914 C136 270n 1M 4p 13.95V 5p D104 0.5p 270n 270n 470p L110 L119 100p C100 C120 C143 C139 C134 0.74V 10p 2.7n 1u 1u L139 100p C159 C174 VCO TUNE 1SV278F C111 C109 220 D106 R123 R126

CGND R104 1SV278F 0 100k 3.73V R183 R186 R108 L128 270n 22 0 Q109 X100 R909 100p C112 100k C142 7p 2SC5636 VCO-B (UPPER) VC VCC 1k Q107 470p C150 RF AMP R103 L109 C133 L151 Q107 C156 R182 C116 VCO 0 270n D101 D103 12p 27n 2SK508NV(K52) 0.5p GND oUTPUT 4p 100p C107 1k 0.01u C176 1SV325F 1SV282-F 56 TCXO 1p C173 R105 0.5p C137 270n L135 L134 4p 6p D105 0.5p 270n 270n 470p C121 L115 L120 100p C145 C140 C135 C104 1SV278F 0.1u C191 100p C114 180 D107 3.3V R124

R107 1SV278F L100 R112 0 33C R121 10 D101,103,105,107 100k C151 100p 0.1u 0.1u 470p C101 100p C110 C108 C113 VCO (FREQUENCY 470p C148 6 10 9 8 7 CONTROL) R136 1k

3 R109 47k 47k RXLo2 R753 REFin AVDD AVDD DGND DGND 5 C130 CP10 11 RFinA TCXO_MOD 100 CE 12 4 C128 47p IC101

SCK0 CLK RFinB 56

13 3 R128 100k

ADF4111BCP7 47p R138 SDO0 DATA AGND 14 2 T : 3.23V CP11 LE PLL IC AGND 15 R : 3.23V PCS RF MUXoUT 1 C129 CPGND 0.047u35 PLD + 100 LOOP FILTER C157 C124 R154 9 560 100p C106 9 820p R156 0.68u20 2.7k 3 DVDD DVDD Vp Rset CP + R111 C195 C196 C123 1.2k 1.2k R155 R178 16 18 19 20 100 17 0.01u 0.01u 0.047u35 + R179 R180 R185 C117 0.01u 1.2k 1.2k 100 10 C911 R115 0.01u 4.7k 6.8k R118 R117 C198 C119 C197 0.01u 0.01u 0.01u 3 R119 9 470k Q103 R151 0.1u C125 4.95V 1k 2SK879-F(Y) 100k Q102 R110 SSM6L05FU-F R127 CV 47k

R122 CV PLL IC T : 2.64V 68k DETECTION RESET R : 2.65V C132 100p 3 9 0.1u 470k C115 R113 5C CV VCO_MOD 9 9 9 3 3 3 SB 5M

TX-RX UNIT : OPTION SECTION (X57-7560-10) (C/3) 7 7 F500 0.25A CN501 CN923 11 AGND POW 26 26 SB SB2 AGND2

5M oPT6 OPT6 25 25 C3 AGND L501 oPT6 C3 TXI 24 24 TXI AGND1 TXI TXI DGND RXEI 23 23 RXEI

0.1u DGND C525 RXEI RXEI oPT3 CN500 RXEo 22 22 RXEo RXEo RXEo CN508 oPT3 R562 100k R544 100k R545 100k R546 100k R547 100k R559 100k TXo 21 21 TXo oPT2 CN509 TXo TXo oPT2 20 20 oPT2 oPT2 CN506 oPT2 oPT2 oPT4 11 oPT7 19 19 INH R503 C622 oPT7 INH oPT4 7 oPT11 18 18 MANDOWN oPT1 120 1u oPT11 MDWN

18 17 16 15 14 13 oPT8 17 17 TCoNT oPT1 oPT8 TCNT oPT5

A0 DTI 16 16 DI DTI DI oPT5 Io1.6 Io1.5 Io1.3 Io1.7 Io1.4 12 oPT9 15 15 SToN SB2 19 Io1.2 oPT9 SToN I2CCK_5V SCL 11 5V 5A SB2 20 Io1.1 oPT11 14 14 I2CSDA_5V SDA IC505 5A INH 21 PCA9535BS 10 R573 C529 AGND 13 13 AGND2 VDD Io1.0 12 AGND2 INH C3 R541 22 I/O EXPANDER 9 1M 0.01u AO 12 12 NC INT VSS AO 0 23 8 C3 A1 Io0.7 oPT8 AI 11 11 NC MDWN 24 7 AI A2 Io0.6 oPT7 AGND 10 10 AGND1 MDWN AGND1 TXI L500 DGND 9 9 DGND DGND TXI Io0.4 Io0.5 Io0.0 Io0.1 Io0.2 Io0.3 oPT5 8 8 oPT5 TCNT oPT5 oPT5 1 2 5 6 3 4 R569 10k

R577 4.7k oPT10 7 7 NC TCNT R563 100k RXEI R582 10k R581 10k oPT4 6 6 oPT4 oPT4 oPT4 RXEI R567 100k R579 10k NC 5 5 NC DI R565 100k R564 100k 26P_TD 4 4 TXD1 DI RXEo 26P_RD RXD1 3 3 RXEo SToN oPT3 2 2 oPT3 oPT1 oPT2 oPT5 oPT6 oPT3 oPT4 oPT3 oPT3 SToN oPT1 1 1 oPT1 12 12 oPT1 oPT1 TXo TXo 11 5A 5A 26P_TD 26P_RD 11 11 89 X57-756 (A/3) 4/6, X57-756 (C/3) 1/1 AY AZ BA BB BC TK-5410 SCHEMATIC DIAGRAM TX-RX UNIT : TX-RX SECTION (X57-7560-10) (A/3)

T : 4.72V L206 RF AMP R : 0V 2.2n T : 1.19V T : 4.33V T : 1.48V R : 0V RF AMP Q201 C219 R215 C220 L205 C279 R : 0V R : 0V 2SK3077F 3p 12 100p 5.6n 0.75p T : 1.21V L154 D200,308 R : 0V R202 47n TX/RX C207 C209 L202 3.9k 3p 100p 10n 5p

SWITCH 470 470 1k C221 R216 R213

L200 330

C189 R152 C194 C190 C192 C202 5.6n L203 R211 8p 0 4p 4p 4p D200 100p 10n R218 Q200 4p 39 2SC5636 C211 330 6.8n

RN142S L201 R208 R204 R210 33k 10n 10k 0.1u

VCOSW1 4p L148 100p 100p 15p C215 C216 C223 C222 R219 R217 1.8k L204 R201 C203 3.3k 12n 12n 2.2k L149 L155 R150 3.3k 33 D308 R200 0 22 0.1u 1.5k 100p 100p 100p C213 C205 C206 C204 R209 R203 0 RN142S R205 R212 12p C193 5T R220 T : 0V 0.1u 100p C218 R : 2.43V C217 IC200 100p TC75W51FK(F) C208 10p 100p C225 C226 1 8 5M 3.3k R327 5R 7 C201 100p C200 0.01u 2 100k R206 100p C365 3 6 C214 4 5 0.01u 100k R207 5T BUFFER AMP (APC) APC L2SF VREF 9 9 VREF

DOUBLE AMP 4.37V 1.71V Q112 RF AMP C179 C181 L142 L145 C184 2SC5636 Q111 2p 1p 27n 10n 100p 2SC5636 1.16V L146 15p 15p 100 6.8k 1.8n 1.8n 1.5p L153 L143 R141 C182 C183 C180 0.58V R142

10n 10k R143 5p 3.9n L147 C162 270 10p C185 R146 10n 100 L140 100k 100p C177 R135 R134 100 100p C186 R148 100 100p C178 RXLo2 R140 100p C188 5T 5C 5C 5R

9 5M 5R

9 3 3 3

T : 0V Q308 5R_800 R : 4.99V 2SJ347F 5R_700

700M : 4.25mV T : 0.3V 0.1u C308 470k C341 100p C337 R300 800M : 3.29V R : 4.96V 0.01u 22k 22k R306 5R_800 L304 R303 R373 L307 470k R301 Q300,308 0 700M : 4.74V 800M : 10.34mV 470k 100p C315 C319 0.1u 3.9n R304 0.01u

RX BAND 33k L305 100p C332 C322 100k C304 SWITCH R409 R320 L302 T : 0V C339 C342 100p 6p 100p Q300 R : 3.34V R337 L335 IN OUT SSM6L05FU-F L300 0 12n C307 C316 C309 C430 C311 Q302 100p 15p 2p 100p 100p 470k 470k 100p C345 R352 700M : 4.74V IN OUT BB505CES-TL-E R363 800M : 10.35mV T : 0V 800M R : 373mV 5 4 IC310 470k R308

7.5n P1 VCTL1 470k L336 R311

68k NJG1615HA8 0 R371 2 1 56 68k R310

C431 6 R321 100p 100p 100p C302 C324 R332 RX BAND PC 3 VCTL2 P2 GND IC309 CONTROL SWITCH L331 C301 3 PC 6 NJG1615HA8 GND P2 VCTL2 5.1n 100p RX BAND

T : 0V 1 2

CONTROL 33k C321 100k 100p 5.1n R302 R322 R : 4.91V VCTL1 P1 L306 L303 SWITCH C343 R374 T : 0V 100p 5 4 R338 L332 C340 IN OUT 700M R : 3.31V 22k L301 0 15n 100p 700M : 10.76mV C306 C317 C310 C363 D305 L330 Q305 800M : 4.79V 8p 100p 2p 100p

1.0n BB505CES-TL-E 470k 470k HSM88AS-E IN OUT R354 R367 T : 0V PROTECT R307 R : 205mV 2p of RF 700M : 10.63mV C323

470k 800M : 4.79V R309 47k

POWER 22k 8.7n 470k L337 R312 R369 47 68k 100p 100p C333 C325 R335 R323 100p C305 100p C327 Q302,305 RF AMP (LNA) C349 L338 R381 C347 L333 4p 10n 18 100p 8.7n

R341 270 270 R380 R319 47 Q303 C392 C388 0.01u 100p TRIPLER C674 220n 220n L328 AMP L326 3.19V 82p Q312 R378 C390 L327 L318 C399 3.19V LOCAL AMP 680k 12p 47n 47n 0.01u Q312 C385 680k R339 R340 C432 R342 2SC5636 0.01u 47p 22p 82p 68p C423 C391 C389 0 8.2k 0.01u C397 Q303 703mV

27p 2SC5636 C433 CN300 T : 0V MIXER L325 T : 0V R : 4.79V 8.2n R : 706mV IC300 R386 C373 R390 C387 CMY210 XF300 C334 L321 L320 C335 R384 C368 560k 0.01u 0 470p L310 L309 1 6 3p 100n 180n 0.01u 100 0.01u 6.8n 5.1n RF IN IF OUT 2 5 Q309 1.8u T : 0V 1.2k L313

C360 C355 C350 C351 C300 R388

L317 GND GND 6p

10p 2SC4215-F(Y) C361 R : 4.96V C358 1p 2p 4p 4p 33p 6.8n 3 4 Lo IN Vdd IF AMP L319 0 33CSW 18p C366 R387 C371

L311 0.01u 3p 220 1p 1p 15n 8.2n R389 L308 C362 C357 C354 1u 33p 150 100p 100p C352 C353 C356 C359 C364 C367 R382 0.01u 0.01u L312 100p C372 5R

90 X57-756 (A/3) 5/6 BD BE BF BG BH SCHEMATIC DIAGRAM TK-5410 TX-RX UNIT : TX-RX SECTION (X57-7560-10) (A/3)

T : 6.99V RF AMP H : 7.34V C276 L219 R : 0V 1 (FINAL AMP) L : 7.33V T : 1.74V 100p 39n H : 1.81V R : 0V H : 7.33V L212 RF AMP L : 1.83V Q204 R244 C259 D202 C262 C263 L213 C267 C268 CN201 ANT (DRIVE AMP) L : 7.33V RD07MVS1BT132 0 100p HVC131 100p 100p 8n 6p 15p Q202 L215 C228 L216 R234 C265 RD01MUS1-T113 3.3n 6p 2.2n 0 D202,203 D203 2p 18p 12p 3.9p 3.3p C272 C275 C273 C274 C277 1p TX/RX SWITCH HVC131 82k L209 L214 R248 18.5n 1p 68n L211 3p 6p 1p C261 22p 4.7k 39n 330 C270 C269 C266 C264 R232 L207 R221

-t D303,304 270 270 18k 15k 0.1u C251 100p 100p 100p C246 C249 C260 C254 R243 R245 R246 R247 0.01u TH200 TX/RX SWITCH 33k 10k L210 100p C224 100p C235 R233 R236 L208 R398 C381 L316 0 100p H : 1.76V L : 1.78V 1u 100p C238 C243 C236 0.01u TP103 T : 0V D303 R394 D304

R : 4.99V 100k HVC131 HVC131 R229 R235 D201 GND(Y) 150k 4.7k Q311 APC SURGE R395 2SC4617(S) 2 SWITCH ABSORPTION TP104 C233 47k 100p Q207 R242 APC AMP DTA144EEB T : 4.79V 2.2k ANT 100p R : 0V C384 100p IC201 C383 150k

R228 TA75W01FUF R225 470k 100p C244 1 8 R237 4.7u D201 150k oUT1 VCC C256 RX ISOLATOR 2 7 HZU4CLL 0.22 0.22 C230 R222 VREF R223 IN1- oUT-B R226 3 6 100p IN1+ IN2- C242 150k 4 5 R239 VEE IN2+ 180k 150k 100p R230 APC SWITCH 47k R238 Q208 100p C240 150k R231 SSM3K15TE(F)

T : 2.31mV Q203 Q205 R : 7.27V SSM3K15TE(F) T : 3.24V R224 Q206 R : 0V 47k SSM3K15TE(F) 470k

C241 3 100p 100p C245 R240 APC 100p C234 C231 0.01u EMD9 100k R241 100p C248 APC DC SWITCH SWITCH (5M) 5T +B 5R 5M 5R 33C THP APCSW 3 3 3

RSSI 3 W_/N 4 5R 22 0.1u C404 R348 C405 R347 0.01u Q304 1k WIDE / NARROW 3.3V C406

22 CONTROL SWITCH

R349 0.01u 33C TP108 IC304 C407 R514 A_SQL 2nd Lo(Y) A_SQL IF IC IC503 10u 12k TC75W51FK(F) ASQ DET C516 5 4 0.01u 3 D501 IN+B VSS PLD

Q304 47k C505 6 3 R757 R365 470k 4.8V IC304 R355 EMD9 IN-B IN+A TA31137FNG 150p 720 oUTB IN-A 470k R518 C395 1 24 PLD 5 oSCIN MIXIN C506 8 1 R531 R697 IFDET 2 23 VDD oUTA 22 C413 150p 100k 100k R534 oSCOUT GND1 0.022u 0.1u ASQDET 3 22 CF300 VCC1 VREF C396 4 21 0.1u 3.9k T : 0V C507 0.1u MIXoUT RSSI R515 R521 R : 3.28V R528 D501 C400 5 20 R362 3.3k R361 220k 3.3k MA2S111-F VCC2 C-DET 2.7k 0.1u 6 19 C411 R357 3.9k 3.9k R343 R344 IF1IN N-DET CD300 150p 56k C511 1u 560k C512 C519 C401 7 18 R915 1000p DEC1 FILoUT Q502 0.1u 0 10k

0.30V R538 R536 150k R353 2SC4617(S) C393 0.1u 8 17 C412 R356 IF1oUT FILIN R520 2.2u 0.1u C418 C420 100p

C414 D500 0.1u C402 C409 150p 15k SQL AMP C515 9 16 4.7k

NDPS N-REC 0.22u 56k C518 R535 C394 0.1u 10 15 0.1u R358 C415 0.22u IF2IN AFoUT 0.1u C403 11 14 4.7k 1000p RB706F-40 DEC2 QUAD P25,NARROW : 0V 0.1u SQL 12 13 C410 WIDE,NPSPAC : 3.28V CF400 GND2 IF2oUT C421 C427 39p 0.1u R368 R401 C425 0.1u 0 1k 0.1u 22k

1k IF AMP

R408 6 IC306 IC307 R403 R406 C429 TC7W53FK(F) CF302 TC7W53FK(F) NARROW 10k 1000p

1 8 5 4 0 CoMMoN VCC A GND IC400 R407 2 7 6 3

INH CH0 CH1 VEE 33k R404 4 3 1.8k 3 6 R359 7 2 VIN- VIN+ VEE CH1 CH0 INH 3.29V 2 4 5 CF303 8 1 VSS GND A WIDE VCC CoMMoN 5 1 C426 VDD VoUT 0.1u 0.1u 0.1u RX FILTER C416 C419 RX FILTER MCP6021-E/OT 0.1u CONTROL CONTROL C428 3.9k 3.9k R360 R364 R405 10

R402 100k

33CSW R366 33C 22

Note : The components marked with a dot (•) are parts of layer 1. 91 X57-756 (A/3) 6/6 TK-5410 BLOCK DIAGRAM Control unit (X53-4390-XX) CN38 CN35 main FPC CN Q1 2SB798(DL,DK) Q2 2SC4617(S) Q10 Q11 L_MIC SSM6L05FU-F SSM6L05FU-F +B +B +B PF1~3 CH_A~D KoPF TGL0~2 LED_G BLC LED_R

D6~8 D2~5,D9~12 AF block LCD LED IC15 BACK LIGHT BACK LIGHT KEY PCA9535BS I/O EXPANDER I2CCK I2CSDA

/KEYI0~4 X1 KEYO0~3 IC7 IC19 /INT2 RV5C386A CN1 TC74LCX245FK A[0],/WR RTC LCD IC18 D[0]~D[7] CN TC7WZ245FK-F LCD BUS SW /RINT 32.768KHz 32K

/LCDRST

/CS4

IC1 FLASH IC10 ASIC IC3 DSP /CS0

/CS3

IC4 SRAM 33M IC5 RESET XC6109C29ANN CN40 RESET /CS2 100pin CN IC8 X2 SM5023CNDH-G

(Volume SW) 18.432MHz (9pin) Q13 2SA1955A-F Q16 2SA1955A-F Q14 SSM3K15TE(F) Q15 SSM3K15TE(F) +B IC17 31BU SCTAMI S-812C31BPI-G 3.1V REG

D25 1SS301F SBC CN35 main FPC IC16 CN XC61CC5602NR HARD RESET Q7 SSM6N16FE-F

33M /BINT

Q12 EMD12 D13 1SS388F 36MC SBC SB (10pin)

Q8 SSM6N16FE-F

33M PSW

AF block CN35 main FPC CN

IC13 AK2925T L_MIC MIC main MIC MICE ECSW (IC15 I/O EXPANDER) SPuniv+ SPuniv-

EXAMT (IC15 I/O EXPANDER) CN40 IC13 AK2925T CN34 100pin SP/MIC CN AF IC12 TPA6201A1DRBR CN IC11 TPA6201A1DRBR INANT SP (IC15 I/O EXPANDER)

Q3 2SB1132(Q,R) +B Q5 UMG3N 5A Q4 SSM3K15TE(F) 5V REG

5AC 92 (IC15 I/O EXPANDER) TK-5410 BLOCK DIAGRAM

TX-RX unit (X57-7560-10)

CN501 26pin IC517 TC7SET08FU-F TXD0 TXD0_univ SCTXD OPT 1~8,11 RXD1 AI AO CN502 TXI

IC505 TXO Q509 26P_RD RXEI RTS_univ 20pin PCA9535BS RXEO SSM6N16FE-F 26P_TD RTS0 I/O EXPANDER level shifter CN505 univ

I2CCK_5V I2CSDA_5V /SCSS

IC501 TC7MBD3245AFK CTS0,RXD0,DSR level shifter

IC511 TC7SH126FU-F BFSX2 BUS BUFFER Q502 2SC4617(S) BER_EN

D500 IC503 (A_SQL) DET TC75W51FK(F) RB706F-40

SCK0,SDO0,/EVCS,DACRST TCXO_MOD

IC510 TC75W51FK(F) ASQDET + DAC1 DAC1 IC500 (VCO_MOD) TC75W51FK(F) – RF block DAC2 AFC (TV1)

DAC0 DAC3 (TV2) IC512 TC75W51FK(F) DAC4 (L2SF) MOD IC512 DAC0 TC75W51FK(F) IC502 LPF IC510 DAC7 AK2330 TC75W51FK(F) (APC) DAC AUD_VREF VREF

Power supply block (LCDCNT) DAC6 IC507 IC510 TC7W53FK(F) TC75W51FK(F) RXAF IC506 TC75S51FE(F) LPF DAC5 DAC5 CN707 100pin

RXEO /SCSW RXEI VADAC BEEP

AI IC509 TC7W53FK(F) OPT9

Q503 IC508 AO AI SSM3K15TE(F) TC7W53FK(F)

TONE

OPT6 TONESW STSW TXO TXI

IC516 IC513 Q507 SSM3K15TE(F) Q506 TC75W51FK(F) IC515 TC75W51FK(F) EXMIC Q508 2SJ347F 2SJ243-A TC7S66FUF MIC main IC513 TC75W51FK(F) LPF

CTS0_univ MM /SCSW

IC514 IC516 TC75S51FE(F) TC75W51FK(F) Q504 2SC4738(GR)F Q505 2SA1832(GR)F D511,512 RB406F-40 VOX MIC AGC

MIC AF

93 TK-5410 BLOCK DIAGRAM

Q707 2SJ648-A Q708 SSM3K15TE(F) IC712 +B NJM2130F3-ZB SB IC713 Battery LM2682MMX terminal Switched Capacitor Voltage Doubling Inverter LCDCNT SBC

DAC6 IC704 5M TK11250CUCB

Q703 SSM3K15TE(F) Q704 TPC6108-F

IC700 5MCS TK11250CUCB

5UC

Q700 SSM6L05FU-F

IC701 5T XC6209B502PR

5TC

Q701 SBC SSM6L05FU-F

5RC IC702 XC6204B502MR 5C 5C

/SAVE

IC707 XC6365D103M IC706 Q706 TPC6108-F 33C XC6204B332M D706 HRB0502A

36MC

IC705 33M XC6204B332M

IC710 33A XC6204B332M

IC714 LM73CIMKX-0 IC709 TEMP IC 15M XC9235A15CM1

IC708 XC9101D09AKR 15V Q705 SSM5H01TU-F

94 TK-5410 BLOCK DIAGRAM main ANT LPF L212 IC309 NJG1615HA8 BPF BPF L300 L301 TX RX Q311 700M: 763MHz~776MHz 793MHz~806MHz 800M: 806MHz~825MHz 851MHz~870MHz 700M: 763MHz~776MHz 800M: 851MHz~870MHz 5R_800 5R_700 HVC131 RX RX 2SC4617(S) L300 D202,203,303,304 Q302 5T BB505CES-TL-E 800M: 851MHz~870MHz 700M: 763MHz~776MHz 5R_800 5R_700 BPF BPF L302 L303 1st Lo IC310 Q204 TX NJG1615HA8 Q308 2SJ347F RD07MVS1BT132 Q203 Q300 SSM6L05FU-F VCOSW1 700M: 821.05MHz~834.05MHz 800M: 792.95MHz~811.95MHz 700M: 763MHz~776MHz 793MHz~806MHz 800M: 806MHz~825MHz 851MHz~870MHz SSM3K15TE(F) 5R APCSW IC300 Vg(APC) CMY210 APC Q207 DTA144EEB IC201 TA75W01FUF RN142S Q208 SSM3K15TE(F) D200,308 5T DET Q303 Q202 2SC5636 BPF XF300 RD01MUS1-T113 2nd Lo 58.05MHz Q112 57.6MHz 2SC5636 W_/N Q205 EMD9 Q201 IC307 Q206 SSM3K15TE(F) APCSW 2SK3077F Q309 ×2 Q111 TC7W53FK(F) Doubler IF1OUT 2SC5636 2SC4215-F(Y) MIXIN IC200 TC75W51FK(F) Q109 BPF BPF IC304 FM IC CF302 CF303 (WIDE) 2SC5636 TA31137FNG MIXOUT (Narrow/P25) APC Q200 2nd IF 450KHz 2SC5636 BPF CF300 IF2IN IC306 VCO_MOD VCO_MOD TC7W53FK(F) W_/N IF1IN IF2OUT Q106 Q107 VCO-B VCO-A 2SK508NV(K52) 2SK508NV(K52) IC100 TLV2381IDBV LPF CF400 Q100 Ripple filter 2SC4617(S) Loop filter VCO-B VCO-A ASSIST 15V VCO-B(5V) VCO-A(5V) IC400 CP TX (700M): 381.500~403.000MHz TX (800M): 403.000~435.000MHz RX (800M): 396.475~405.975MHz RX (700M): 410.525~417.025MHz MCP6021-E/OT VCOSW1 IC101 RFinA PLL IC IFDET ADF4111BCP7 Q108 2SJ347F REFin Q104 Q105 SSM6L05FU-F Ripple filter 2SC4617(S) Q103 2SK879-F(Y) CV X100 TCXO TCXO_MOD 5C 19.2MHz

95 TK-5410 LEVEL DIAGRAM ANT 3W L212 SW ANT Internal SP 2Vrms External SP 2Vrms 36.1dBm 26.5dBm 17dBm IC12 IC11 3dB Attenuator 1.7Vrms 1.7Vrms 19dBm IC9 IC304 FM IC 10dBm Q200 Q201 Q202 Q204 RF (Center Frequency) 0dBm C396 –85.5dBm CF300 T/R SW D200/D308 C395 AF (1kHz) –81.5dBm DAC To make measurements in the AF section, connect the AC level meter. make measurements in the AF section, connect AC level meter. To (ANT input: –53dBm, 1kHz FM, 3kHz DEV (Wide).) In the RF section, use 470pF coupling capacitor. (The display shows the SSG input value required to obtain 12dB SINAD.) AG is set to the MIC input becomes 3kHz DEV at 1kHz MOD. make measurements in the AF section, connect AC level meter. To In the RF section, use 1000pF coupling capacitor. IC304 FM IC 1st IF (58.05MHz) 231.5mVrms 140.0mVrms -4.5dBm –94.5dBm Q109 Q111 Q112 Q309 IF Amp 238.0mVrms –114.5dBm VCO MCF XF300 –112.5dBm IC300 184mVrms ASIC DAC IC502 3dB Attenuator 551mVrms IC512 C347 IC400 IC10 IC506 IC510 IC502 IC13 –104.0dBm SPDT IC310 554mVrms IC10 ASIC –91.0dBm –71.0dBm 189.0mVrms CF400 L303 169.5mVrms –102.5dBm –102.0dBm AF (1kHz) IC304 FM IC LNA LNA Q302 Q305 IC515 IC513 SCSW RF (Center Freacency) –122.5dBm –122.0dBm 2nd IF (450kHz) –89.0dBm L300L301 L302 123mVrms C307 C316 C339 C306 C317 C340 –120.5dBm –120.5dBm CF302 CF303 Q508 IC516 SPDT IC309 800MHz 700MHz C301 13.5mVrms IC306 IC307 IC13 –120.0dBm C393 C394 C427 –87.5dBm L212 15mVrms 15mVrms MIC MIC Internal –119.0dBm External Receiver Section Section Transmitter 96 TK-5410 OPTIONAL ACCESSORIES

KNB-32N (Ni-MH Battery Pack): 7.2V 2500mAh KNB-54N (Ni-MH Battery Pack): 7.2V 2500mAh ■ External View ■ External View

■ Schematic Diagram ■ Schematic Diagram

Discharging terminals Discharging terminals

+ S – + S –

150kΩ 150kΩ Ω Ω 0.5% 0.5% 20k 20k ± ±

+ S T – + S T –

Charging terminals Charging terminals

KNB-33L (Li-ion Battery Pack): 7.4V 2000mAh KSC-32 (Rapid Charger) ■ External View ■ External View

■ Schematic Diagram KBP-6 (Battery Case)

Discharging terminals ■ External View

+ S –

47kΩ Ω 0.5% 10k ±

+ S T –

Charging terminals 97 TK-5410 SPECIFICATIONS

GENERAL Models ...... K2: 4-Key w/LCD Model K3: Full Key w/LCD Model Frequency Range ...... 763~776 MHz (TX/RX), 793~806 MHz (TX), 806~825 MHz (TX), 851~870 MHz (TX/RX) Number of Channels ...... 1024 Zones ...... 100 Max. Channels per Zone ...... 512 Channel Spacing ...... Analog: 12.5/25 kHz Digital: 12.5 kHz Operating Voltage ...... 7.5V DC ± 20% Battery Life: 5-5-90 (10-10-80) duty cycle ...... KNB-32N or KNB-54N, 7.5VDC, 2500 mAh: 12 hours (8 hours) KNB-33L, 7.5VDC, 2000 mAh: 8 hours (5 hours) KBP-6, AA Alkaline x 6 Batteries: 8 hours (5 hours) Operating Temperature Range ...... –22°F to +140°F (–30°C to +60°C) Frequency Stability (–22°F to +140°F) ...... ±1.5 ppm Antenna Impedance ...... 50Ω Dimensions (W x H x D) ...... 2.28 x 6.10 x 1.80 in. (58 x 155 x 45.7 mm) with KNB-32N or KNB-54N battery (Projections not included) ...... 2.28 x 6.10 x 1.54 in. (58 x 155 x 39.2 mm) with KNB-33L battery 2.36 x 6.10 x 1.84 in. (60 x 155 x 46.7 mm) with KBP-6 battery Weight Radio only ...... TK-5410 K2: 11.64 oz. (330g) TK-5410 K3: 11.64 oz. (330g) TK-5410 K2 with battery, antenna (KRA-32) and belt clip (KBH-11) .... 23.28 oz. (660g) with KNB-32N or KNB-54N battery 17.64 oz. (500g) with KNB-54N battery RECEIVER Sensitivity ...... Digital (5% BER): 0.25µV Digital (1% BER): 0.40µV Analog 12dB SINAD: 0.25µV Selectivity ...... Digital: –60dB Analog @25kHz: –75dB Analog @12.5kHz: –64dB Intermodulation Distortion ...... –75dB Spurious and Image ...... –75dB Audio Distortion ...... Digital: Less than 1.0% Analog: Less than 2.0% Audio Output ...... 500mW/8Ω TRANSMITTER RF Output Power ...... 3W/1W Spurious & Harmonics ...... 70dB FM Hum & Noise ...... Analog @25kHz: 45dB Analog @12.5kHz: 40dB Audio Distortion ...... Less than 2.0% Modulation Limiting ...... Analog @25kHz: ±5kHz Analog @NPSPAC: ±4kHz Analog @12.5kHz: ±2.5kHz Modulation ...... 16K0F3E, 11K0F3E, 8K10F1E, 8K10F1D, 14K0F3E

Analog measurements made per TIA/EIA-603 and speciﬁ cations shown are typical. Digital measurements made per TIA/EIA-102CAAA KENWOOD reserves the right to change speciﬁ cations without prior notice or obligation.

2967-3, Ishikawa-machi, Hachioji-shi, Tokyo, 192-8525 Japan

P.O. BOX 22745, 2201 East Dominguez Street, Long Beach, Amsterdamseweg 37, 1422 AC Uithoorn, The Netherlands CA 90801-5745, U.S.A.

Via G. Sirtori, 7/9 20129 Milano, Italy 6070 Kestrel Road, Mississauga, Ontario, Canada L5T 1S8

Bolivia, 239-08020 Barcelona, Spain Rembrücker Str. 15, 63150 Heusenstamm, Germany

Talavera Business Park Building A, 4 Talavera Road, Leuvensesteenweg 248 J, 1800 Vilvoorde, Belgium North Ryde NSW 2113 Australia

L’Etoile Paris Nord 2, 50 Allée des Impressionnistes, Unit 3712-3724, Level 37, Tower one Metroplaza, 223 Hing Fong Road, Bp 58416 Villepinte, 95944 Roissy Ch De Gaulle Cedex Kwai Fong, N.T., Hong Kong

KENWOOD House, Dwight Road, Watford, Herts., 1 Ang Mo Kio Street 63, Singapore 569110 WD18 9EB United Kingdom A B C D E F G H I JKLMNOPQRS

1 TK-5410 PC BOARD PC BOARD TK-5410 1

2 2 CONTROL UNIT (X53-4390-XX) -11 : K2 -12 : K3 CONTROL UNIT (X53-4390-XX) -11 : K2 -12 : K3 Component side view (J79-0230-09) Component side view (J79-0230-09)

3 3

14 IC16 TP7 C113 R46 C114 C115 23 L7

TP104 R168 4 3 C117 R999 R998 3 1 R25 R169 R165 R171 R178 R26

Q12 C37

6 1 IC6 Q16 16 4 5 R154 R161 TP10 R156 IC17 G IC4 C25 C23 R34 R33 R29 R27 C29 4 R19 4 C15 R144 4 3 R166 34 D C19 TP6 Q7 S Q14 R67 L5 R146 R143 6 1 C116 R176 CN1 R177

D23 R62 4 3 R157 D26 R65

G Q13 Q8 R155 L10 R61 R52 L9 TP13 R147 6 1 D S TP1003 L25 R60 R43 D25

/LCDRST C152 33M NC A0 D1 D3 NC GND /WR NC V2 V4 NC 33M D0 D5 D6 /WR D4 33M D7 NC NC NC NC V3 D2 GND V1 CN40 Q15 L4 L6 C33 R30 LCDCNT 99 100 R283 D24 C39 R42 R64 1 C151 30 R173 C144 R284 GND GND C36

R51 C14 R282 TP103 /OINT TXD2 E R212 R211 R206 11 10 5 R273 RXD2 36MC R21 5 R63 C148 C149

R280 C34 C150 R281 /PTT CTS0 R210 R207 C24 RXD1 TXD0 R278 R17 Q2 R204 R203

R279 R41 C13 PFKEY RXD0 Q3 IC18 C IC3 CN2 C147 R209 R208

R291 /UDET RTS0 R277 R276 D1 18 45 R275 SPuniv+ SPuniv– C16 R49 R40 SPuniv– SPuniv+ IC1 R205 IC19

R274 R5 R201 SCTAMI 15M B R202 C51

R48 C154 C50 +B 15M C146 L24 +B 33M C143 R66 R58 R271 +B 33M C17 R53 CN3 20 1 +B 33A R93 R92 C54 R268 R265 5M 33A R272 6 4 C35 BATT DSR R270 C12 Q5 E C B R269 S_DET SBC 1 3

R266 R39 4 1 6 5UC /SAVE R234 R194 6

5TC 5RC C22 TP1002 GND GND R264 R262 CN4 R267 IFDET GND Q1 R69 R263 IC11

GND BFSX2 R38 R96 R260 R233 R97 R261 BDX2 BCLKX2 R70 R259 BDR2 BCLKR2 5 8 R84 R72

R257 L13 R78 R117 R107 HD5 PSRPLL R185 R106 C18 R47 R44 R112 C88

R255 R121 R190 R32 R20 BER_EN INT3 R71 C27 CN45 R258 R18 R256 HD7 BFSR2 R253 D20 TP14 SCK0 SDO0 R251 L17 C59 R254 C58 S C31 R80 C79

PCS_Pot DACRST TP8 R16 C69 R83 C91 R77 R111 C137 R252 R249 D19 R199 R122

L11 D PCS_RF PLD L12

R247 C57 L14 R250 /EVCS CV C60 G C67 CN21 L15

C155 TP12 R248 APCSW VCOSW2 R245 C122 R181 R179 X2 C47 R86 C21 R246 LCDCNT VCOSW Q4 R113 CN32 C68 7 STSW AMT R244 C80 7 5 R231 R243 VADAC TONE R242 4 3 R184 R182 16 L19 BEEP W_/N R241 R99 R189

C161 Q11 C119 VOX TONESW C118 C121 C120 TP101 R230 R240 R239 R164 C81 R81 MM ASQDET IC8 C72

6 1 R105 IC12 /SCSW THP R170 C56 C62 R227 R225 RSSI GND R226 34 C82 D22 18 4 R98 R295

CGND ASSIST R238 CN47

R101 R188 C112 4 3 R287 C63 C66 R237 GND GND CN31 TP102

R235 MOD AUD_VREFC C49 C83

R236 R162 R100

R158 C136 L20 Q10 L21 C153 R288 AFC GND R232 R94 R167 C64 R90 R172 33C MICmain 6 1 C84 R175

R221 IC10 MICE MIC C55 R163 C52 R95 C102 AF L27 C65 C48 C44 C100 C99 RXAF CN44 CN46 20 GND R174 GND GND R160 R215 C85 I2CSDA I2CCK C156 GND R292 8 C53 R137 R195 C73 R191 8

VOL 5 1 R102 C61 GND GND R293 6 1 R220 4 1 12 7 C111 1 2 R138 ORG TP2 C74 R115 R124 R219 13 6 C110 TXLED R116 R75 PF1 PF3 IC7 PF2 C40 IC9 R139 BLED C75 R119 C38 CN24 KOPF TGL2 L_PTT 5 8 C109 C76 L_PTTG TP3 6 IC15

R140 10 R192 R74 TGL1 TP9 R123

TGL0 L16

C108 L8 C77 18 1 R141 CN19 R54 CN23 19 24 33M R148 L23 S31BUS C78 D13

R142 CN35 C32 R37 CN38

R82 31BU TP4 CN43

L22 R88 R196 R76 C93 R193 CH_D R108 R103 R159 R151 R145 CN37 R50 C95 C97 C92 C71 CH_C C141 2 1

R152 R31 9 C70 C90 C101 C107 CH_B 9 R36 R55 R56 R45 R59 IC5 R57 CH_A TP5 3 4 C30 R198 R35 C106 R197 GND

TP1 1 8 R136 C105 MICE C86 Q6 R118 R109 16 34 L_MIC X1 C96 C104 IC13 R134 1 NC D16 R110 R130 D15 D14 45 C103

TP1001 R135 R131

R285 C98 R125

R129 TP11 C87 C157 R127 R120 R126

R187 R133 C94 R132 10 R128 D27 10

11 Component side 11 Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address Layer 1 IC1 5H IC12 7E Q4 7F Q15 5E D23 4D Layer 2 IC3 5J IC13 9E Q5 6F Q16 4E D24 5F Layer 3 IC4 4H IC15 8F Q6 9D D1 5E D25 5D Layer 4 12 IC5 9N IC16 3F Q7 4D D13 9M D26 4F Layer 5 12 IC6 4I IC17 4E Q8 4C D14 9M D27 10G Layer 6 IC7 8J IC18 5L Q10 8G D15 9M Layer 7 IC8 7J IC19 5N Q11 7G D16 9L Layer 8 IC9 8E Q1 6E Q12 4D D19 7E Foil side 13 13 IC10 8M Q2 5E Q13 4E D20 7E IC11 6O Q3 5F Q14 4F D22 7P

14 14 A B C D E F G H I JKLMNOPQRS

1 TK-5410 PC BOARD PC BOARD TK-5410 1

2 2 CONTROL UNIT (X53-4390-XX) -11 : K2 -12 : K3 CONTROL UNIT (X53-4390-XX) -11 : K2 -12 : K3 Foil side view (J79-0230-09) Foil side view (J79-0230-09)

3 3

4 D 4 R12 36 9# D7 R13

5 5 D12 CN22 D9 D10 D11

C 6 6

D8 25 80

7 7

B D4 R7 R6 D2 R8 8 8 D3 D5 R9 CN34 D6

INT MIC– INT MIC+ INT SP– INT SP– INT SP+ INT SP+ 14 7 9 6 1 * 9 R11 A

10 10

11 Component side 11 Ref. No. Address Ref. No. Address Layer 1 D2 8N D8 7H Layer 2 D3 8O D9 5N Layer 3 D4 8L D10 5O Layer 4 12 D5 8K D11 5L Layer 5 12 D6 9H D12 5K Layer 6 D7 5H Layer 7 Layer 8 Foil side 13 13

14 14 A B C D E F G H I JKLMNOPQRS

1 TK-5410 PC BOARD PC BOARD TK-5410 1

TX-RX UNIT (X57-7560-10) (A/3): TX-RX SECTION TX-RX UNIT (X57-7560-10) (A/3): TX-RX SECTION Component side view (J79-0233-09 A/3) Component side view (J79-0233-09 A/3) 2 2

D119 + R114 C126 4 3 R116 C727 C749 R914 R173 R120 C122

C728 TP8

C724 R213 R216 C745 1 5 C219 IC710 5M R202 C207 C209 L202 2 1 C220 R148 C188 C211 R215 D200 C111 C221 5 1 L704 3 4 Q200 C275 IC704 R106 C202 L200 R208 C215 Q201 R200 R201 C203 C186 R210 R204 C107 15

L201 R209 R150 Q703 C162 L147 R203 C204 R705

3 3 X100 C216 3 4 G IC100 C213 R211 L205 R907 R908 R143 4 3 D R212 C742 C725 C200 S Q202 R142 D308 C731 S 3 4 IC706 C206 L203 C192

L710 D702 R714 R713 R909 C201 C217 C277 C191 C114 Q111 Q112 R134 C208 R205 C205 C222 CN707 C845 C843 5 1 L701 R711 R105 C177 C218 L204 G R716 L206 R140 C365 D L219 2 1 R753 L140 C228 GND GND R182 R112 R135 C189 C714 4 3 C178 L148 R327 C279 C700 I2CSDA I2CCK C713 R146 C735

C190 D203 L216 C184 R720 C116 L149 R152 C844 GND GND C841 C707 L153 L215

5 C276 RXAF AF 1 Q704 C179

4 3 R219 R218 C181 C842 L142

C182 L154 MICE MIC C839 C173 C180 L143 C153

TP5 C272 C273

C740 F700 C840 33C MICmain C835 C193 R139

C732 6 1

C151 C224 IC705 C185 L207 L702 C838 AFC GND SCK R109 C194 C274 R145 C155 C831 IC700 16 R221 MOD AUD_VREFC C711 C832 C829 R128 C269 GND GND 5 1 L145 D202 L146

D704 L155 R141 C830 CGND ASSIST C828 C183 C223 R234 GDQ204 R244 C259 L209 C270 4 C846 RSSI GND 3 TP4 10 6 C130 34 R233 R232 4

C826 CP11 CP10

4 C168 C827 /SCSW THP TP11 11 5 R217 L211 MM ASQDET C824 SDO C128 Q105 +

C825 VOX TONESW C823 33M S L208 C837 BEEP W_/N IC101 R117

C125 D C109 C822 VADAC TONE C235 C246 STSW AMT C821 R910 15 1 R118 Q108 G Q100 C836 LCDCNT VCOSW 16 20 R236 C251 C249 C819 APCSW NC R144

TH200 C260 C817 /EVCS CV C818 C198 C147 R246 + L210 C813

C195 C226 PCS_RF PLD C816 C144 TP3 Q102 L107 C815 NC DACRST R179 R247 C814 R707

C761 16 R137 R220 C243 C236 +B SCK0 SDO0 DACRST C117 C911 C108 C110

C812 R102 C238 /SCWKUP /SCBFS R180 C811 F701 C197 R185 C119 C254 C810 C225 R245 R243 C809 BER_EN /SCREQ R111 R115 3 4 /SCRST SCBSY C808 C762 Q104

C807 Q708

SCMIS0 SCBCK R110

C834 Q709 34 16 C806 BER_DATA BER_CLK C805 TP6 R113 R706 C594 5 C804 GND BFSX2 L100 C716 C595 5

IFDET GND 5RC R223 R222 C106 C196 C157 G S C802 GND GND C803 R731 R155 C706 D R651 C751 C748 R762 C719 R729 D G C798 5TC 5RC C801 C101 15 S C577 5UC /SAVE C795 C754 R730 TP14 C115 Q707 C581 C796 S_DET SBC L708 R178 R759 TP108 GND IC702 +B C833 BATT DSR C794 R761 R704 5M 33A C750 2nd LO R645

C800 C793 C585 TP104 +B 33A C752 C701 R700 34 C799 C792 R228 +B 33M C758 TP2 R701 C703 R226 R224 D505

C791 +B 33M C790 R225 C231

+B 15M 8 5 /EVCS R649 R230 G Q203

C788 TH102

C789 C741 C230 D504 SCTAMI 15M Q103 C712 C755 R119 D 3 14 IC708 SSW IC707 4 14 SPuniv– SPuniv+ C797 6 4 3 R240 C786 C245 Q706 S SPuniv+ SPuniv– R751 TP13 S Q701 S R647 C586 SP+ C233 C234 C599 /UDET RTS0 C736 L506 SP– 45 18 C785 C753 36MC G R231 C781 PFKEY RXD0 4 C583 R229 R709 3 1 R235 4 3 MSW/CTS Q207 TXD0 IC701 R724 RXD1 C739

TP1 IC201 CF302 4 1 D

C783 G S C705 C787 R703 EMC /PTT CTS0 R127 CN505 D

R750 R727 6 RXD2 36MC R749 L703 15V TP10 33C MICE 6 Q205 R238 Q208

6 1 34 16 C782 /OINT TXD2 C132 R122 L505 PTT C780 +B 1 C598 5 C240 GND GND C779 IC712 D706 C766 REM R726 C737 3 1 4 3 Q705 CV 100 99 C777 C709 L502 R652 RTS1 R242

C778 C776 R722 5M C587 R636 C774 C775 C717 CN201 C730 C570 R635 C773 5 1 4 5 TP7 TXD C256

C744 C241

C428 R402 R708 SBC C720 RXD C248 R406 4 3 D502 C242 R237 C704 R702

C784 D201 R723 TXD E C214 C429 C763 C733 R405 + 1 DSR C244 S 51 43 IC400 C765 R359 D R241 + 6 1 R637 C603 G C769 R239 Q206 C426 C756 C746 Q700 C574 C608 R206 TP103 C767 IC713 5 4 C759 R407 R404 C419 18 Q308 RXD R640 + R304 C607 D516 IC200 R207 4 3 G 18 C600 R408 R752 7 C770 C575 45 7 L504 L503 8 1 + L706 L705 D R300 IC307 IC709 S R364 J79-0233-09 A/3

45 D515 C601 Q300 C416 L707 C304 CF303 C771 5 1 R301 + C768 16 18 R360 34 C308 IC306 45

8 8

Component side TX-RX UNIT (X57-7560-10) (B/3): TOP SECTION TX-RX UNIT (X57-7560-10) (C/3): OPTION SECTION Layer 1 Layer 2 Component side view (J79-0233-09 B/3) Component side view (J79-0233-09 C/3) 9 Layer 3 9 DGND RXEO OPT1 OPT2 RXEI SB2 AGND TXI

J79-0233-09 B/3 C3 Layer 4 TXO Layer 5 Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address Layer 6

MDWN IC100 3I IC710 3D Q205 6Q D200 3K AGND STON TCNT OPT5 OPT4 OPT3 INH 5A Foil side DI IC101 4H IC712 6C Q206 7P D201 7Q 10 J79-0233-09 C/3 IC200 7P IC713 7C Q207 6Q D202 4R 10 IC201 6P Q100 4K Q208 6Q D203 4R IC306 8K Q102 5I Q300 7J D308 3K IC307 7K Q103 6H Q308 7J D502 7N IC400 7H Q104 5J Q700 7J D504 6N

11 S901 11 IC700 4E Q105 4J Q701 6J D505 6M IC701 6L Q108 4J Q703 3F D515 7O IC702 5K Q111 3I Q704 4F D516 7O IC704 3E Q112 3J Q705 6E D702 3E 12 IC705 4D Q200 3L Q706 6D D704 4D 12 D901 S902 IC706 3D Q201 3M Q707 5L D706 6D IC707 6D Q202 3N Q708 5L D901 12C IC708 6F Q203 6Q Q709 5E IC709 7F Q204 4O D119 2I 13 13

14 14 A B C D E F G H I JKLMNOPQRS

1 TK-5410 PC BOARD PC BOARD TK-5410 1

TX-RX UNIT (X57-7560-10) (A/3): TX-RX SECTION TX-RX UNIT (X57-7560-10) (A/3): TX-RX SECTION Foil side view (J79-0233-09 A/3) Foil side view (J79-0233-09 A/3) 2 2 R522 D500 R694 R530 R529 R526 R533 R532 D519 R535 C518 R123 L313 C120 R136 R138

C371 R388 R527 D100 R389 L134 C143 R386 L104 C361 C174 Q509 CN506 C622 R131 R384 C368 C510 XF300 R915 UNV C372 C148 C141 S R690 C159 16 R580 20 11 C511 R520 CN508

C154 R536 R538

3 L501 3 C515

G GND F500

L312 D518 34 R569 Q309 L139 L110 R519 R503

C335 C373 C100 R525

Q109 D C139 IC501 D104 D102 R387 D106

D305 Q106 D501 10 R126 C176 R545 R544 R546 R547 R562 R559 L320 L127 C512 1

R398 C366 Q502 R125 C149 C358 L321 R108

C702 R534 C519 L150 C262 R528

C261 CN300 6 4 R186 IC714

L119 IC517 R507 C367 R693 R574 C136 C131 R521 R576 D304 C112 R124 C156 CN509 R390 C301 R531 C364 R697 C516 R695 4 3 18 13 C134 R104 3 1 MND C504 D700 L135 R100 C507

L311 19 12 R306 L331 C302 C334 C145 R518

C359 C356 18 R382 C506 5 1 R573

L316 R757 C525 L319 IC503 C381 L325 C353 IC505 D521 4 3 2 S C505 R515 L212 Q107 C121 45 R699 C360 R541 4 C142 C772 4

C362 R698

R307 C307 R308 L310 R103

5 6 1 L109 C414 C415 D303 R357 24 7 D101 R582 IC309 IC300 G + R501 C621 C384 6 4 + C129 R514 R754 1 6 L700 C305 D107 R156 R593 C140 R506 D 5 4 C503 1 3 C306 R154 R579 R565 R564 R581 R567 Q311 L300 R356 R563 L309 C413 C411 C412 R355 R358 IC500 25OPT6 POW 26 C263 C104 C383 C355 R608 R606 C357 L128 + C124 C551 8 1 C387

C349 RXEI TXI C352

R309 R760 R509 L115 R505 L317 C354 R607 C409 R353 TXO RXEO L151 C137 C500 R577 C350 R394 R395

D103 CN502 C421

L308 OPT7 OPT2 C265 R121 R107 + C123 R605 D105 1 2 L301 C410 R183 L338 C316 R311 R604 R511 OPT8 OPT11

R603 R600 C351 C300 C150 C135 6 1 CN501 C529 C309 R513 OPT9 DTI C430 R151 R601 7 24

C133 C113 IC502 AGND 5V L213 L336 24 13 L120 R517 TP9

5 R381 R599 5 R598 L500 AI AO C431 R371 R319

C317 C311 33A R597 C509

R312 R756 C264 C266 R595 DGND AGND R321 R380 19 20 12 19 R592 C347 L327 L318 R594 C508 13 18 CN500 OPT10 OPT5

C423 C537 UNV

C267 R591 NC OPT4 C390 C391 Q302

3 2 IC304 C310 L304 C513 C522 IC506 C528 R550 R653 R578 C532 R566 C392 15 R556 C524 26P_RD 26P_TD 4 1 L337 C399 IC511 Q504 R401 R409 R303 R368 R347 R618 51D512 D511 L333 C397 12OPT1 OPT3 R320 C315 C319

R373 34 12 L330

L326 R361 4 3 1 66R657 R656 C605 C590 C578

C332 R568 R335 C325 R337

L214 C389 C268 Q304 C324 S 6 4 R642 R614 C558 R611 R553 C536 R363 Q303 C404 R348

C322 C345 C542 8 5 C556 C363 C560 5 1 C557 1 3 C425 IC507 TP12 Q305 R332 C323 C582 R617 R612 L305 L302 R302 R616 C559 R369 C606 C591 C339 R352 C342 R660 15M 6 2 1 C388 C406 C400 C401 C402 C403 R621 6

C674 Q505 C564 R669 R667 R624 1 5 C565 R626

L335 1 4 C385 R362 R365 5 4 R349 C407 C620 Q503 6 3 R912 R913 67R630 R627 R342 C568 R654

C545 R561 R584 3 4 1 2 18 C538 R341 CD300 Q507 3 4 S C396 C393 C394 R323 C405 R344 CF400 G IC310 S D R668 C613 R322 R662 R665 IC515 IC513 D R248 C418 G R374 C333 R338 L332 R710 C544 R583 5 4 L328 C420 R644 45 R354 R554 R367 C433 R560 C579 C327 C611 R641 C576 C343 R378 R343 R638 R586 IC508 R572 R558 C321 C340 L303 R655 R615 R628

R310 C721 R585

C395 R571 R587 R570 L306 C612 R663 5 4 C571 8 1 C540 Q508 R659 C609 R619 IC514 1 3

D C547 R588 C432 C614 Q312 R643 G S R664 C561 C562 C563 C543 C539 R557 R646 C341 C337 L307 4 C617 18 8 5

Q506 IC516 R575 R648 C589 R340 C552 D R622 R620 IC510 C527 R916 R670 R596 G S R625 R671 C567

CF300 5 4

R676 C520 R629 C533 R339 C602 C566 5 4 R672 5 IC512

7 1 4 R590 7 R673 R675 R589 R650 8 1 R602 IC509 R366 C427 C604 J79-0233-09 A/3 C618 8 1

C615 R631 R403 R666 C521

R674 R610 C616 C573 R623 C610 R658 C554 C555 C546 C619 R661 D510 D517

8 8

Component side TX-RX UNIT (X57-7560-10) (B/3): TOP SECTION TX-RX UNIT (X57-7560-10) (C/3): OPTION SECTION Layer 1 Layer 2 Foil side view (J79-0233-09 B/3) Foil side view (J79-0233-09 C/3) 9 Layer 3 9 26 2

SB TXI RXEO OPT2 MANDOWN DI NC 5A

AGND1 OPT5 OPT4 TXD1 J79-0233-09 B/3 OPT3 Layer 4 TXDI Layer 5 Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address CN923 AGND2 TCONT DGND STON

Layer 6 RXD1 IC300 4F IC513 6P Q502 3N D303 4C OPT1 RXEI TXO INH NC NC NC Foil side C3 IC304 5I IC514 7O Q503 6R D304 4C 25 RXDI 1 10 10 J79-0233-09 C/3 IC309 4D IC515 6O Q504 6N D305 3C IC310 6F IC516 7N Q505 6N D500 3M IC500 4O IC517 4O Q506 7N D501 3M IC501 3O IC714 4N Q507 6M D510 7O 11 1 36M CH_D C TGL2 33M GND

17 IC502 5O Q106 3K Q508 7M D511 6N 1 GND TGL2 TGL0 GND TXLED S36M CH_B 11 VOL CH_D 11 IC503 4M Q107 4K Q509 3N D512 6N CN902 S36M CH_A CH_B CH_C TGL1 VOL CN903 IC505 4P Q109 3K D100 3L D517 8O CH_A BLED CH_C TGL1 ORG 36M 33M 12 KIN 2 IC506 6P Q302 6D D101 4K D518 3N 16 2 IC507 6P Q303 6H D102 3L D519 3N 12 IC508 6Q Q304 6J D103 5K D521 4Q 12 IC509 7Q Q305 6C D104 3L D700 4H IC510 7P Q309 3I D105 5K IC511 6M Q311 4C D106 3L IC512 7P Q312 7H D107 5K 13 13

14 14 LCD TOP SW SECTION CN40 2 2 2 2 2 POWER SW/AF VOL CHANNEL CONCENTRIC SELECTOR SW GND 2 1 1 1 1 1 GPIo7 GPIo7 GPIo7 GPIo7 +B +B GND 1 R219 I2CCK 4 33AA 33AA I2CCK AUD_IREFC D25 VOLTAGE R220 100 I2CSDA 3 33M 33M 15M REVERSE CURRENT 8 I2CSDA 470k 31BU AD12_IREFF R169 1SS301F VOLTAGE DETECTOR PREVENTION BATT INT 100 GND 6 12 REGULATOR (/BINT) 0 U2 U1 V18 V17 U18 U17 B18 A18 A17 B2 B1 A2 A1 C4 A5 B3 P7 P8 P12 K14 J14 T1 N4 D4 B16 C5 C3 A3 V2 V1 B17 E6 G4 L1 K5 J5 H5 G5 F5 E5 D5 J4 F3 T17 T16 R13 F15 C18 C16 D6 U3 M1 L3 K4 T3 H4 F4 V16 E4 D3 U16 C17 T2 P13

X2_CLKIN X2_CLKIN (3.1V) R178 GND 5 E12 R166

R80 A4 DGND3 C63 1u AF 8 L9 C64 0.1u C65 0.1u DC SWITCH NC1 C62 0.01u for ADJUSTMENT IFIR NC2 NC9 NC6 NC5 NC3 NC8 33MDSP XTALI NC7 NC4 E11 10k IC17 AF 2 1 NC11 NC21 ADC1 NC22 NC12 NC10 NC30 NC29 NC28 NC26 NC25 NC23 NC20 NC19 NC18 NC16 NC15 NC13 NC35 NC36 NC14 NC27 NC24 NC17 NC34 470k

L5 R173 22 B4 MICIR DGND2 Q16 RXAF 7

AVCC1 S-812C31BPI-G AVCC2 AVCC5 AVCC9 AVCC8 AVCC6 AVCC4 AGND2 AGND9 AGND8 AGND6 AGND5 AGND3 AGND7 AGND4 DGND6 DGND5 DGND9 DGND8 DGND4 XTALo DGND7 E10 TP11 RXAF AVCC10 1 DGND11 3.29V DGND12 DGND15 DGND13 DGND10 DGND14 2SA1955A-F 15MD A10 DGND1 L16 MIC 10 2 32K 32I L5 VIN MIC CH_B CH_A CH_D CH_C C31 C27 0.1u 0.1u A12 DVDIo7 33M VoUT MICE 9 V1 TGL1 D1 A0 V3 V2 TGL2 V4 D2 D0 D6 D5 D3 D4 D7 NC NC NC NC NC NC NC NC 3 2 1 8 /WR /WR 33M 33M 33M CN21 DSPCK MICE GND CONTROL UNIT GND P6 CN23 47p B11 DVDIo6 3.3k R171 C156

LCDCNT DC SWITCH /LCDRST /RINT CKo 33M IC16 L27 MICmain P11 470p 12 (X53-4390-XX) CN1 (STCAMI) C115 NC R16

C21 DVDIo5 14 MICmain 470k A11 470k R20 R177 100k VIN1 1000p USRCKI L14 33C 11 VoUT 2 NC VSS

DVDIo4 Q15 XC61CC5602NR 1 H18 C74 1u 2 3 5 6 8 9 4 7 C75 0.1u C76 0.1u C77 0.1u C78 0.1u 10u 10u 11 21 C73 0.01u 12 22 10 15 16 18 30 13 19 20 23 25 26 28 29 14 17 24 27 BUS BUFFER (LCD) 2 A0 ADD0 H14 31BU GND 14 C113 C114 SSM3K15TE(F) 3 4 1 1u R32 J18 DVDIo3 100k R203 R44 100 CN24 C116 /LCDRST 1 A1 ADD1 E13 R221 AFC 13 R25 47k R26 47k CH_B CH_A CH_D GND CH_C TX-RX UNIT :

A16 1k MCDIAF D1 D2 D5 D3 D0 D4 K18 DVDIo2 3.13V AFC

C146 R18 0 IC18 33MAS VSS VIN2 oN/oFF TGL1 TP12 TGL2 1u A17 R38 A2 ADD2 E7 1.47V TOP SECTION 100 AUD_VREFC 16 C152 R201 TC7WZ245FK-F L18 DVDIo1 AUD_VREFC 100k 0.1u R204 L17 5 6 A3 ADD3 M5 4 MOD 15 C151 1u C150 1u C149 1u C148 1u 0 31BU (X57-7560-10) (B/3) 14 10k 5 4 M18 DVDD10 15M CN902 MOD E12 E13 F10 F11 F12 F13 G10 G11 G13 G12 H13 H12 H11 B12 B13 C11 C12 C13 D11 D12 D13 E10 E11 C147 H10 J13 J12 J11 J10 K13 K12 K11 K10 L13 L12 M13 N13 B2 GND A4 ADD4 N5 Q13 GND 18 N18 DVDD9 TP9 2SA1955A-F 0.1u 6 3 3.25V C117 D23 Q12 X1

D1 A5 ADD5 GND

P9 1 17 D26 D2 D5 D3 D0 D4 2 3 5 6 8 4 7

B1 A2 /WR RS TDI 11 A18 A16 A17 R185 L19 12 10 TDo CLOCK BUFFER AMP J17 DVDD8 D24 HD2 HD3

TCK EMD12

TMS DC SWITCH REVERSE 220p 7 2

C144 R202 1SS388F BDX1

IC19 ToUT L13 1u R232

TRST A6 ADD6 P10 ASSIST 20 G A1 A0 EMU0 HPI16 10 33A 10k BFSX1 CURRENT DVSS2 DVSS3 CVSS5 DVSS4 R176 CVDD3 DVDD3 DVDD7 ASSIST

K17 C80 1u TC74LCX245FK 8 1 C9 HPIENA CLKoUT C84 0.1u C85 0.1u C83 0.1u C81 0.1u C82 0.1u CLKMD1 1SS416 C79 0.01u CLKMD2 10k VCC DIR CLKMD3 A7 ADD7 N14 3.3V for ADJUSTMENT PREVENTION 100 CGND 19 VoL X2_CLKIN 1k 36M 33M 11 10 EMU1 oFF M12 IC8 M17 DVDD6 GND TGL1 TGL2 R172 1 S36M CH_B CH_A CH_D CH_C B8 GND 3 DVSS7 22 A8 ADD8 M14 7 GND 22 R81 SM5023CNDH-G D24,26 TP103 TP104 12 9 N12 R39 0 N17 DVDD5 D23 R168 B7 A8 D0 C143 BCLKX1 MCSCKAF X2 A9 ADD9 G14 REVERSE R235 RSSI 21 13 8 4 3 18.432MHz P17 DVDD4 Q14 1SS301F 10k RSSI B6 A7 D1 L11 R48 100k Q VSS A10 ADD10 F14 CURRENT SSM3K15TE(F) R236 THP 24 0.1u CVSS8 36M 36M 100 14 7 5 2 C47 3 2 K16 DVDD3 PREVENTION CN37 THP TGL1

M11 TGL2 S36M CH_B CH_A CH_D CH_C R237 VoL B5 A6 D2 VDD XT oUTPUT GND A11 ADD11 E9 R107 DC SWITCH 36M 100 /SCSW 23 15 6 A13 HD1 FSDET 1k L16 DVDD2 DC SWITCH /SCSW

0.01u D R100 10k (31BU) N11 470k B4 A5 D3 A19 A12 ADD12 R165 (36MC) TX/RX R238 ASQDET CVDD5 6 1 E8 100 26 16 5 A12 0.1u M16 DVDD1 ASQDET IC19 C136 XTN INHN S901 LED B3 A4 D4 A20 C35 1u R53 100k A13 ADD13 B5 10k R225 MM 25 4 1 R161 D901 100 17 4 5V to 3.3V B11 VCC VC P16 GPIo11 DSR MM B2 A3 D5 CVSS9 L10 A14 ADD14 B30-2019-05 R226 TONESW LEVEL CONVERTOR INT3 INT3 R86 C6 SBC SBC 100 28 18 3 A11 M10 J15 GPIo10 S902 TONESW B1 A2 D6 DVDD5 A15 ADD15 B6 R227 VOX 27 INT2 5.43mV C56 16 16 100 R101 100k 0.1u 0.01u 19 2 C12 D10 470k C137 K15 GPIo9 5UC VOX oE A1 D7 1 D6 D6 N10 A16 ADD16 R199 100k 5M +B R239 W_/N INT1 /DINT A6 100 30 20 1 0.1u C10 M15 GPIo8 Q7,8 W_/N VCC DIR D7 D7 K9 R66 1k A17 ADD17 U8 7 R240 100 BEEP 29 +B

B10 INT0 /SYMTIM N15 GPIo7 33M 33M DC SWITCH BEEP D8 D8 A18 ADD18 R8 100 R241 TONE 32 C154 A10 R58 100k BUFFER AMP 1 P15 GPIo6 /WP BLC (/BINT,PSW) TONE R198 100k R230 D9 D9 L7 (LOGIC) A19 ADD19 R7 100 VADAC 31 0.1u L24 D9 33MDSP 33MDSP J16 GPIo5 Q8 16 VADAC R205 10k R212 10k 10k R211 R210 10k R209 10k R208 10k R207 10k R206 10k R197 100k R242

D1,Q1,2 D10 D10 A20 ADD20 T7 36M AMT 34 100k

R194 100 L9 R196 100k 11 R146 SSM6N16FE-F VoL 3 TGL1 C9 H15 GPIo4 TGL2 AMT S36M CH_B CH_A CH_D NMI /DWUP CH_C AVR for /CS4 D11 D11 IC6 A21 ADD21 V10 12 R243 100 STSW 33 M9 R48 100k GPIo3 100k STSW BACKLIGHT LED B9 HBIL TC7SH08FU-F G17 PSW R108 100k 5AC R244 33M 15MD 2 D12 D12 D0 DT0 100 VCOSW 36 R46 33MDSP D2-5,9-12 D6-8 N9 9 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 33M 100k A9 IACK R49 100k 1 5 H16 U9 R157 VCOSW1 Q1 CN3 HD4 INB VCC D1 DT1 GPIo2 R159 S36M S36M R231 100 LCDCNT 35 LED_R KEY BACKLIGHT LCD BACKLIGHT K8 10 LED_G 2SB798AZI(DLDK BLC D8 2 G15 R147 LCDCNT +B D13 D13 BDX2 BDX2 D2 DT2 R193 100k 1k R245 VCOSW2 38 INA 100k 100k CN903 100 +B C8 L8 R40 100 3 4 F18 V9 VCOSW2 18 17 16 15 14 13

16 470k D14 D14 BDX0 MCDICN GND oUTY D3 DT3 GPIo1 AMT 11 11 R155 R246 100 APCSW 37 Q2 5 B8 F17 APCSW R6 R8 R7 R60 100k T9 R143 R9 100 D15 D15 D4 DT4 R247 CV R11 180 180 180 2SC4617(S) 40 ∗ ∗ ∗ A0 R12 R13 GPIo0 100 A BDC A8 M8 HD0 HD0 G16 CV Io1.6 Io1.5 Io1.3 C18 Io1.7 Io1.4

0.1u C37 R112 100k HD5 HD0 D5 DT5 IC10 C11 CN45 /MNDNU /BINT GND CH_A CH_B CH_C CH_D 36M S36M 33M TGL0 TGL1 TGL2 BLED TXLED ORG VoL KIN GND R248 /EVCS 39 N8 SIMRST 12 100 C13 E18 19 /EVCS D2 D3 D4 DVSS6 D12 R121 Io1.2 D5 0.01u D6 DT6 ASIC 100k R249 PLD

R21 42 R5 R156 100

470k I2CCK SCL ∗ ∗ ∗ D6 D8 D7 470k K7 33MDSP 6 E17 SIMCK PSW 11 PLD

20 NC MIC C24 0.1u R122

D1 DVDD4 C12 Io1.1 INAMT 100p R54 1 B7 D7 DT7 1k I2CSDA SDA IC15 R250 100 PCS_RF 41 C36 0.1u F16 SIMDT /BINT 10 R144 470k PCS_RF /KEYI0 2 CVDD6 21 PCA9535BS C155 1000p 5 3 R41 100 D8 DT8 R5 1k VDD Io1.0 EXAMT 100 R251 DACRST 44 A7 L7 470k

470 R154

UDZW3.9(B) 32K SYMTIM /SYMTIM D9 D18 DACRST D11

D10 100k

1 2 3 PF1 CVSS10 HRDY C91 22 I/O EXPANDER 9 C88 D12 R6 Q7 ∗ IC3 R252

∗ D9 DT9 PCS_Pot 43 1000p 1000p ∗ C7 INT VSS 100 R17 2.2k R61 100k FSDET FSDET /RD HDS1 REAL-TIME D17 SSM6N16FE-F PCS_Pot D10 DT10 23 8 CN46 R253 SDO0 PF1 D7 DSP N7 IC7 CLOCK A1 Io0.7 100 46 DVSS8 BFSX2 BFSX2 RV5C386A B15 R2 24 7 Q10,11 SDO0 100k 5 R151 R55 A6 M7 R42 100 D11 DT11 TXRVE 5TC 8 A2 Io0.6 R254 100 SCK0 45 31BU D16 P3 12 DC SWITCH (BLED,TXLED) SCK0 /KEYI1 /HDS2 HDS2 BFSX0 /MCCSXCN L8 CN35 R255 470 B6 N6 15MD 1 10 D12 DT12 TRAMP DACRST 100 BFSR2 48 4 5 6 PF2 DVDD6 CVDD4 32KOUT VDD C15 P2 BFSR2

1 R256 2 3 5 6 8 9 4 D13 DT13 TMoD /LCDRST 3 7 HD7 47

0.1u 100

C6 9 C101 Q10 C14 C34 0.1u 11 Io0.0 Io0.1 Io0.2 Io0.3 Io0.4 Io0.5 12 13 10 15 16 18 19 20 A0 A0 2 OSCIN D15 M4 14 17 HD7 M6 SCL D14 DT14 PSTPA APCSW SSM6L05FU-F R257 INT3 50 D6 1 100 2 3 5 6 L25 PF2 0.1u HINT E15 4 R158 14 INT3 ∗R998 3 A1 A1 3 R293 47k R137 47k R258 R56 L6 X1 D15 DT15 470k 100 BER_EN 49 A5 R62 100k SDA 47k 3 100k CVSS7 A15 R192 R195 R115 BER_EN /KEYI2 A2 A2 BLED R1 CH_B CH_D R145 47k R140 47k CH_C

8 33M 470k R162 K6 32768Hz /WR WRITE R233 PSRPLL 52 TXLED 100 R999 470 B5 4 OSCOUT PSTIF 10 ∗ 7 8 9 PF3 A3 A3 BCLKX2 BCLKX2 INTRB A16 100k 7 PSRPLL 7 33M 100k /RD READ R116 R142 47k R139 47k R259 HD5 C5 N3 10k 100 51 SIDE KEY N5 BCLKX0 BCLKX0 CLKC R167 CN2 HD6 5 B14 PSTPLL MM HD5 BCLKX0 6 BHE N2 C157 R260 BCLKR2 54 SECTION PF3 D5 VSS R141 47k R138 47k C107 4700p 100 A4 A4 R63 100k INTRA /RINT 3 C14 RXRVE /SAVE BCLKR2 L22 R261 CN38 R57 A4 M5 R50 BLE P1 R164 100p 100 BDR2 53 /KEYI3 A5 A5 BDR2 BDR2 A13 RXSLT VCOSW1 BDR2 470k R160 470 R163 470 R262

/CS4 CS4 L4 33k BCLKX2 56 0.1u C103 4700p PF2 1 B4 C104 4700p C105 4700p C106 4700p C108 4700p C109 4700p 4700p C110 4700p C111 100 C112

470 R51 C38 47k R287 SIDE2 PF2 5 0 A6 A6 L5 D13 PSRRF 5RC 1k BCLKX2 R152

HCNTL1 470k /CS3 CS3 M2 R191 R170 R263 100 BDX2 55 C4 5RC TX-RX SECTION : TX-RX UNIT (X57-7560-10) (A/3)-CN707 PF3 2 K5 100k 0.1u C13 PSRIF Q11 BDX2 KoPF A7 A7 ASQDET LED_R LED_G 8 SIDE3 PF3 A3 BDR0 MCDOCN /CS2 CS2 M3 100k SSM6L05FU-F 100 R264 BFSX2 58 0 L23 ORG TGL1 PSRPLL PSRPLL TGL1 6 BFSX2 TGL0 TGL0 TGL2 B13 TGL2 MICE BLED BLED TXLED TXLED CH_B CH_B CH_A CH_A I2CSDA CH_D CH_D CH_C R64 100k CH_C ORG A8 A8 VoL I2CCK

KoPF 3 12 39k C15 STSW CS1 N1 R148 GND 57 KoPF R59 B3 R288 100 /KEYI4 A9 A9 N4 8 A14 RSSIT /DRST VoL 15 15 15 15 R174 1k 0.1u BFSR2 BFSR2 /CS0 CS0 D8 7 GND 60

L_PTTG 4 C3 470k

470 R124 CVDD7 M4 B12 VFRM /DWUP 33M BFSR0 /MCCSRCN /HRDY HRADY D7 R267 IFDET 59 R175 R292 A2 R65 100k PTT L_PTT 5 D14 VoINT /DINT 33MAS IFDET D13 D16 D15 D14 A21 /HDS2 HDS2 C7 100 GND 62 B2 L4 33C 33M 1SS388F 1SS388F 1SS388F 1SS388F 11 8 1k 0 D13-16 DVSS9 BCLKR2 BCLKR2 C30 for ADJUSTMENT R18 MCo2 /UDET PF1 6 4 TXD0 TXD0 47 GND 61 SIDE1 PF1 K4 BCLKR0 BCLKR0 D10 R190 R111 R74 REVERSE BCLKR0 8 TP102 T18 MCCS2 R106 0.01u RXD0 RXD0 6 R234 5RC 64 470 470 470 470 CURRENT

R31 N3 R35 R36 R45 0 0 100k DVSS5 TP101 R16 C8 SCTAMI SCTAMI 5RC PREVENTION IC5 RTS0 RTS0 MCCK2 PLD R269 100 5TC 63 M3 R43 XC6109C29ANN R15 D9 ECSW ECSW 5TC HCNTL0 CTS0 CTS0 MCCR1 /MCCSRCN R266 /SAVE 66 B7 1M 100 100k R52 R117 /SAVE N2 3 2 U15 MCCX1 /MCCSXCN 8 8 88 8 150 BCLKR1 R67 CD VSS /OINT TXD1 R265 5UC 65

KEYO1 100 KEYO0 KEYO2 KEYO3 C9 77 7 5UC N1 0 T15 MCo1 MCDOCN 4 CVSS6 RXD1 RXD1 100 C32 B8 66 6

10 0.01u R270 SBC 4 1 R37 33M V15 MCI1 MCDICN 68 TXD2 TXD2 C40

3 1 VoUT VIN BUS BUFFER (LCD) 0.01u 9 V14 A7 R268 100 S_DET 67 4 2 3.29V 0 RXD2 RXD2 MCCK1 MCSCKCN S_DET R272 T14 33C DSR 70 3.28V 14 100 XF IAQ BIo MSTRB IoSTRB MSC HoLDA HoLD MP_MC DVDD2 CVSS4 BDR1 BFSR1 PS DS IS A11 CVSS1 A22 CVSS2 DVDD1 A10 HD7 A12 A13 A14 A15 CVDD1 HAS DVSS1 CVSS3 CVDD2 HCS HR_W READY R_W TXD3 DSR VOLTAGE B10 33A 2 MCCS0 /MCCSAF R97 68k SP+ SP+ R271 100 BATT 69 33A DETECTOR (RST) R75 B9 IC9 BATT C69 J1 L1 F1 J2 K1 A1 B1 E1 J3 J4 L2 L3 H1 C1 D1 F2 G1 F3 F4 K2 E2 M1 K3 E3 E4 C2 H2 D2 D3 H3 H4 D4 G2 G3 G4 M2 3 10k MCo0 MCDOAF TC7W66FK-F SP- SP- 100 33A 72 2 D11 AUDIO IC11 33A /MCCSAF MCSCKCN MCI0 MCDIAF 1 8 TPA6201A1DRBR 5M 71 CN19 1 1 TXD3 AMP (BTL) R76 A8 INAMT IN_oUT1 VCC TP8 5M 3 3 MCDOAF 9 9 9 MCCK0 MCSCKAF R119 2 1 8 L14 13 13 13 5M 33A 74 A11 A12 A10 A13 A15 A14 8 47k R3 0 oUT_IN1 7 SHUTDoWN Vo- 14 14 TP10 R29 R33 R19 R34 R27 7 CoNT1 100k 100k 100k 100k 100k SPCS01 SPCS02 SPCK1 SPI1 SPo1 SPCS10 SPCS11 SPCS12 ADC4 BooT SQDAC ADC0 DAC0 IFR ADC3 ADC2 FCDADC IFADCP IFADCN IFVR KEYo3 KEYo4 PWM1 PWM2 TI TDI TMS TRST RTCK TDo TCK ADC5 ADC6 ADC7 ADC8 ADC9 MICVR SPI0 RXD3 SCK SDT SPCK0 SPo0 SPCS00 BSCAN0 BSCAN1 RST RSTo TEST0 TEST1 TEST2 TEST3 SPDAC MICADC0 MoDDAC MICADC1 KEYI0 KEYI1 KEYI2 KEYI3 KEYI4 KEYo0 KEYo1 KEYo2 AGCDAC /SCSW +B 3 2 3 C54 7 +B 73 /RD /RD

/WR CoNT2 6 +B AF /CS2 /CS0 4 oUT_IN2 0.1u 2 7 33M 76 J1

F1 IC13 E1 J2 K1 J3 L2 D1 H1 TP1 TP3 TP6 F2 G1 T8 T5 T6 T4 E2 K2 E3 V8 V6 V3 V5 A9 K3 P4 V7 A16 V4 BYPASS GND C2 D2 H2 U6 H3 U5 R9 U4 R4 U7 G2 6 G3 GND 5 33M T11 MICE V11 R11 L15 U11 L17 T12 T13 T10 V12 470k V13 TP1001 E16 P18 U12 R12 R10 C10 U13 N16 U10 R14 U14 H17 R17 R123 100p 1 G18 3 R113 IN_oUT2 C50 R92 3 AUDIO AMP 33C DACRST 5RC +B 75 C23 C19 C25 0.1u 0.1u 0.1u 2 6 MICmain

15MD /WR IN+ 5RC C29 C70 0.1u 0.1u /CS3 R77 2.2k R179 R181 C122 VDD (1/2 AUDIO PRE-AMP, D2 D3 D6 D7 33M 78 0 100k 0.1u 15k 0 D2 D8 D5 D0 D7 TP1002 L15 TP7 D12 D10 D14 2/2 NC MIC AMP) for ADJUSTMENT 0 5 R215 L6 R285 R78 2.2k 1k TP5 TP4 TP2 4 +B 77 R88

CN22 47k 1k 0.01u SBC

A0 22k Vo+ /DRST /HRDY R102

33MDSP 0 /FLDM R295

31BU 3p IN- 13 10u C72 C68 C67 0.1u 22k 100k R103 TP1003 R105 15M 80 C118 C119 R109 2 0.01u 0.01u 93 7 C51 R93

C66 C57 C86 333 3 33 3 BSCAN0 BSCAN1 F6 F5 F4 F3 F2 F1 E6 E5 E4 E3 E2 G3 G2 G1 F6 F4 F3 F1 E6 E1 E1 /KEYO1 /KEYI1 15M 6800p /KEYO2 /KEYI2 /KEYO0 /KEYO3 /KEYI0 /KEYI3 /KEYI4 1 C33 for BOOT 0.1u 15k TP13 47 47

CN31 CN32 +B 79 R82 0.1u R182 R184 10 IC13 C153 EXAMT R96 R125 36MC

for BOOT 1u 100p C99

G1 D6 G4 D6 TP14 D22,27 470p oE A0 CE CE HD7 AK2925T NC 1u for ADJUSTMENT 15M 82 C49 10u A16 oE A15 A15 A16 A16 VCC1 C48 0.1u +B NC2 NC3 47k 47k DQ2 DQ2 DQ8 DQ5 DQ0 DQ6 DQ7 DQ7 CN43 DGND L4

R90 100k 68k C59

HD5 0 0 470p C161 C44 6800p C100 VSS2 0.01u R118 DQ12 DQ10 DQ14 1u G2 D5 G5 VCC2 D1 1 8 SURGE C61 C93 R83 D9 DQ9 A11 A11 A15 A15 VSS1 BER_EN R84 VDD SCTAMI SCTAMI 81 C121 1000p C120 0.01u

/FRST ABSORPTION 4700p 100k 100k 4 R188 R189 Q3,5

SDO0 100p R130 TONESW MIC /EVCS AUD_VREFC

G3 D4 G6 C6 THP AFC 7 ASSIST BATT SCK0 VOX PCS_Pot BEEP RXAF S_DET TONE 270k VCOSW2 RSSI PFKEY MOD VADAC CV W_/N PCS_RF IFDET D11 DQ11 A19 A19 DQ3 DQ1 D1 CN44 5A SPuniv+ 84 LCONT LCONT LCONT LCONT 5A AVR 13 SPuniv+ G4 D3 H1 C4 LCONT 7 77 7 7 7 22k R134 C96 L20 VCC A20 A20 A9 A9 IC4 A5 A5 C58 D19,20 2 SPuniv- 83 L10 5.01V R99 47k G5 D2 H2 C3 1 Q3 SPuniv- SURGE 3 6 22k 0.47u SPuniv- 86 D13 DQ13 A5 A5 A10 A10 STATIC NC1 3 3 3 3 3 3 2SB1132(Q,R) 1u 13 6 G6 IC1 D1 H3 MEMORY C1 AUDIO IC12 ABSORPTION C16 D15 DQ15 A1 A1 A11 A11 DQ5 D5 C60 7 4 5 R131 R132 SPuniv+ 85 3 33MAS 33MAS 33MAS 33MAS TPA6201A1DRBR 8.2k 1u H1 C6 H4 B6 AMP (BTL) VSS R291 VSS1 FLASH MEMORY A14 A14 A12 A12 DQ0 D0 98 L11 22k 47k R274 RTS0 88 33AA 33AA 33AA 1 8 100p RTS0 C39 H2 C5 H5 B5 0.1u SHUTDoWN Vo- SPuniv+ C17 D1 DQ1 A10 A10 A13 A13 A7 A7 D22 R275 100 /UDET 87 Q5 C55 R133 /UDET 1.8k

H3 C4 H6 B4 27k 7 R136 D3 DQ3 A21 A21 A14 A14 A4 A4 UMG3N R128 47k 100 R276 RXD0 90 150k 0.01u 0.1u 2 GND R126 H4 C3 AVRM1005C270M C71 R110 R120 RXD0 D19 I2CSDA BYPASS I2CCK R69 R277 D4 DQ4 A18 A18 AVRM1005C270M 100 PFKEY 89 C90 0.1u H5 C2 A0 A1 CE2 A3 A6 A8 DQ4 A2 WE C52 R94 6 0.1u 22k 270k PFKEY 8 8 8 8 8 8 8 15k 3 VDD 100 R278 TXD0 92

D6 DQ6 A6 A6 47k C92 C87 2 32K 32K IN+ 0.1u 0.1u R129

1k CN34 TXD0 150k R127

H6 C1 11 470 B1 A1 C94 R72 B2 A2 A3 A5 A6 B3 A4 R70 R187 0.1u 15k L12 0.47u R279 VSS2 A2 A2 470k 100 RXD1 91 4 5 1 RXD1

A3 A7 RY/BY WE A9 A13 A4 A17 WP/ACC RESET A8 A12 9 9 9 9 9 9 Q4 IN- Vo+ SPuniv- 7 100 R280 CTS0 94 SSM3K15TE(F) C53 R95 2 CTS0 A1 A3 A6 A8 A2 A0 Q6 A1 B1 0.1u 15k R281 A2 B2 A3 A5 A6 B3 B5 B6 B4 A4 6 10 5AC /PTT INT SP 100 93 DC SWITCH R98 D20 EMD12 3 /PTT

/PTT /PTT /PTT /PTT /PTT /PTT /PTT /PTT 1.8k 2 R135 (5AC) 36MC 100 R282 36MC 96 R71 D4 RESET RESET RESET RESET RESET RESET 100k 47k 4 AVRM1005C270M R273 100 RXD2 95 C22 5 RXD2 1000p C98 D27 470p C97 CN4 470p R283 TXD2 98 A3 A9 A8 A7 A4 4 100 /PTT A13 A12 A17 /WP /FRST /WR 4 6 TXD2 R30 470k 10 10 10 10 10 10 10 10 INT MIC R284 100 /OINT 97 2 7 7 ECHO CANCEL /OINT

AVRM1005C270M (MAIN) 470p 3 6 6 6 6 6 6 6 6 6 6 MIC SWITCH C102 100 GND 100 0.1u 44 4 4 4 4 4 4 C141 GND 99 C95 1000p X53-4390-XX D2 D3 D4 D9 D10 D11 R6 R7R8 R998 R999 L21 -11 K2 NO NO NO NONO NONO NO NO 0 NO -12 K3 B30-2171-05B30-2171-05 B30-2171-05 B30-2171-05 B30-2171-05 B30-2171-05 100 100 100 NO 0 TX-RX UNIT : TX-RX SECTION (X57-7560-10) (A/3) 6 6 6 6 6 6 L206 T : 6.99V /SCSW /SCSW 700M RX T : 4.72V RF AMP H : 7.34V C276 L219 5 5 5 5 /SCSW RIPPLE RF AMP 2.2n R : 0V BATT DETECT 4.95V 800M TX,TA R : 0V (FINAL AMP) L : 7.33V T : 1.74V 100p 39n S VREF VREF VREF FILTER Q104 T : 1.19V 2SC4617(S) L107 Q105,108 Q108 : 4.12V R : 0V T : 4.33V T : 1.48V Q201 C219 R215 C220 L205 C279 H : 1.81V R : 0V L212 BATT +B(Y) GND(Y) 5C RF AMP RF AMP H : 7.33V Q204 R244 C259 D202 C262 C263 L213 C267 C268 CN201 ANT AMT 5C VCO CONTROL 2SJ347F R : 0V R : 0V 2SK3077F 3p 12 100p 5.6n 0.75p L : 1.83V 470p L : 7.33V C168 700M TX,TA RD07MVS1BT132 0 100p HVC131 100p 100p 8n 6p 15p C554 6 6 6 MICmain D200,308 T : 1.21V (DRIVE AMP) F700 L700 SWITCH 800M RX L154 R202 BUFFER AMP (AF) R : 0V C207 C209 L202 +B C537 33CA 100p : 0V 47n TX/RX Q202 L215 C228 L216 R234 C265 IC510 1.5k R137 MIC

470k 10n D203 4.7u R139 3.9k 3p 100p

5p 3.3n 2.2n D202,203

C147 RD01MUS1-T113 6p 0 MOD 6 2p

SWITCH 470 470

RXAF SMF 1k

3.15A TC75W51FK(F) C221 18p 12p R216 R213 C153 3.9p 3.3p

7.5V L200 330 C272 C273 C275 C274 C277 0.1u VCOSW1 C189 R152 C194 C190 C192 C202 5.6n L203 R211

R218 1p CN707 SCSW (RXAF) 8p 0 4p 4p 4p 100p 10n TX/RX SWITCH HVC131 + 5 4 D200 82k 5 6.85V 700M RX L209 100k L214 100p C155 R145 C547 R907 100p R248 1 GND IC506 IN+B VSS DAC0in_MOD DAC0in_MOD 33CA Q200 18.5n R623 1p 4p 68n 100p 100p C702 C700 D700 Q105 L211

5 3p 6p

1k ASSIST ASSIST DC 1p 10p 800M TX,TA C261

6 39

AF PASS CONTROL 22p

TC75S51FE(F) C211 C144 C555 2SC5636 4.7k 39n 330 330 1k 6 3 1K C270 C269 C266 C264

GND 6.8n R232 2 R583 L201 10u6.3

AUD_VREFC RN142S L207 R221 R208 D517 33k 1.42V SSM6L05FU-F : 0V R204 R568 IN-B IN+A 0 R144 3 I2CCK +B 1SR154-400 R622 22k R210

VOX DC 33k 10n 1 5 7 2 DA221 10k

1u 0.1u

IC507 VCOSW1 VCOSW1 4p L148 180k 100p 15p 100p C215 C223 C222 C216 0.1u R219 R908 R217 I2CCK 3 2 1

IN+ VDD oUTB IN-A 1.8k L204 R201 4 I2CSDA C203 TC7W53FK(F) 8 1 -t D303,304 C528 1 R610 R630 22k 10M 3.3k

I2CSDA 270 270

AUD_VREFC AUD_VREFC 18k 15k 1500p 0.1u 33C R173 R125 12n 12n 2 C251 180k 100p 100p 100p 100p C122 C246 C249 C260 C254 2.2k R243 R245 R246 R247 R114 0.01u

VDD oUTA 27k L149 L155 R150 GND MM 5 700M TX,TA TH200 3.3k R638

VSS 5 4 3 L127 270n 33 TX/RX SWITCH VOX D308 22 R200 IN+ 0 IC100 22 0.1u 1.5k 33k oUT D100,102,104,106 10k L210 100p 100p 100p 100p C213 C205 C206 C224 C204 R203 100k R209 A GND 15V RIPPLE 800M RX 0 100p RN142S GND C235 R233 R236 6 GND R629 C566 R205 R212 0 0

SB TLV2381IDBV D119 12p C522 R550 R553 3 4 R566 6 L208 DA221 C193 DC AMP/ FILTER VCO (FREQUENCY C141 5p : 4.23V R220 R398 C381 3 470k R616 C559 R588 7 AF F701 RXAF IN- oUT CH1 R587 5T VCO-A (LOWER) T : 0V 0.1u 100 100p C218 R706 22k 330p C217

0 VEE VOX DC AMP 470k R131 R658

R626 18k 10M 0 100p

AF 7 SUMMING AMP 33k CONTROL) L316 1u 56k 56k 0 R120 Q106 1 SB MOD R116 470p

C721 14.47V R : 2.43V 100p C149 C845 47p R710 CH0 2 Q100 H : 1.76V

C563 C610 R666 C615 8 RXAF D510 IN- VDD 0 INH SMF 1500p Q106 C154 RXAF 0.25A C536 8 C552 R627 10k R650 2SC4617(S) R100 L104 VCO IC200 L : 1.78V

Q707 C544 R586 5.6k

VCC 1 RB706F-40 0V 1u R641 C576 270n D100 D102 L150 2SK508NV(K52) 0.5p 100p

0 C131 C208 0.022u 5 4 100p C238 C243 C236 C844 47p L710 CoMMoN 0 68p 15k 0.039u 15V TC75W51FK(F) 0.01u 470k 10p 9 MIC R707 2SJ648-A TP103 100p

0.01u C225 C226 MIC R556 150p 0.1u 470k C568 R628 C604 T : 0V 0.1u D303 R643 33n R394 D304 C126 1SV325F 1SV282-F 10p 1 8 5M

R : 4.99V HVC131 HVC131 4 3 2 1 10 MICE C843 47p DC SWITCH R661 3.3k

C542 0 R327 100k

A : VREF/ 47k 1u 100 R102 MICE C524 68k 820p 18k R106 Q708 0.5p 7 C842 47p B : RX SUM R914 C136 5R R229 R235 D201

RXEo 270n GND(Y) 100k 100k C589 0.1u R615 R648 11 MICmain 0.22u 680k SSM3K15TE(F) 0.01u C562 A : MIC SUM1/ MICmain 0.1u 33CA 150k 4.7k Q311 C571 C201 100p VSS C200 IN-A 0.01u 0 IC514 APC SURGE 5600p

IN+A 1M 4p C532 R578 B : VOX 13.95V 5p R395 2SC4617(S) oUTA TP104 D104 C841 47p 0.5p

33C 270n 270n 12 470p 2 L110 L119 R631 100p C143 C100 C120 C139 TC75S51FE(F) C134 0.74V SWITCH ABSORPTION 10p 8 7 6 5

5M(Y) 2.7n 1u RXEI 1u L139 100p C159 C174 47k 1SV278F 100k DC SWITCH VCO TUNE R206 C233 C111 100p C365 13 GND 0.1u 47k C109 3 6 220 R561 C538 4 3 10k 100p Q207 IC512 D106 oUT IN- R646 R123 R126 APC AMP R242 14 AFC 5M BEEP 8 7 6 5 T : 4.79V C214

0.01u DTA144EEB

1SV278F 4 5 ANT

IN-B R104 AFC VDD IN+B CGND 2.2k 100p C384 C840 47p IC700 330k 0.1u oUTB 2 100k 3.73V R : 0V 100p C383 15 AUD_VREFC TC75W51FK(F) 0 oUTB VDD IN+B AUD_VREFC AVR (5MCS) Q704 5MCS 8 8 IN-B VSS IC516 R186 IC201 100k TK11250CUCB 7 R183 R207 10k TC75W51FK(F) 150k C561 100p IN-B R619 100k R912 C839 47p C707 R228 TA75W01FUF VDD 8 5 6 7 16 MOD TPC6108-F IN+B L128 270n

oUTB R108 22 R225

1 51 5T IC513 MOD 1u 2 R575 0

1 5 470k 100p C244 3 VDD IN+ R237 17 GND NP VoUT C545 R585 VGS REC SEL BUFFER AMP Q109 BUFFER AMP 1 8

C838 47p 5 47k X100 R909 4.7u D201 100p C112 2 VADAC (MIC) 100k C142 7p 2SC5636 (APC) 150k oUT1 VCC C256 RX ISOLATOR TC75W51FK(F)

oUTA IN-A IN+A VSS MODULATION 18 GND VCO-B (UPPER) APC

L2SF 2 7 6 GND 5MCS 1u 270k HZU4CLL Q107 0.22 0.22 C230 0.1u R222 C533 R557 R570 1k R223

1u VC VCC IN1- oUT-B 470p VREF VREF C573 C150 3 4 1 C579 2 3 4 ASSIST C602 19 SWITCH 0.01u RF AMP 470k 470p R711 C713 ASSIST CoNT VIN C714 oPT9 SIDE TONE MUTE R620 C567 L109 C133 L151 Q107 C156 9 9 VREF R226 3 6 4 3 2 1 R103 oUTA IN-A IN+A VSS VCO 100p 20 CGND C835 47p 0.01u 560k 220k R182 C116 IN1+ IN2- C242 0.01u 0 270n D101 D103 12p 27n 2SK508NV(K52) 0.5p R239

4p 4 5

CGND 100k 100p 1 GND oUTPUT 150k 100p 2 3 4 C107

R674 C176 21 GND 1u C520 C539 R571 AF PASS CONTROL C565 33CA 1k 0.01u VEE IN2+

C711 IC509 INH

AI VEE BUFFER AMP (VOX) 1SV325F 1SV282-F 4.37V 1.71V Q112 180k 150k 100p GND C546 R230 22 RSSI 0.01u BUFFER R625 RF AMP

56 DOUBLE AMP TC7W53FK(F) 1p RSSI Q703 0.1u 0.01u 330k IC508 100p 470 TCXO C179 C181 L142 L145 C184 2SC5636 APC C173 AMP R105 0.5p 23 THP C832 47p SSM3K15TE(F) TC7W53FK(F) C137 2p 1p 27n 10n 100p SWITCH 0 CoMMoN 5UC 270n Q111 AF PASS (MIC) 100k L135 L134 C616 0.01u

THP INT/EXT 47k 120k R621 R238 C831 47p R558 C540 R572 R624 2SC5636 5MC 1 8 CONTROL 1.8k

24 /SCSW R675 Q208 4p MIC 6p

7.5V 10u 100p AVR (5C) C564 C240 100k 100k C619 D105 R670 R673 0.5p

/SCSW TONE CoMMoN VCC 270n 270n 470p C121 1.16V L115 L120 150k R231 100p C140 C145 C135 TXO TXO R655 SWITCH C104 SSM3K15TE(F) 470k

C830 47p IC702 R705

2 1SV278F

25 ASQDET 100k 0.01u 330k 0.1u C191 15p 15p L146 100 100p C114 6.8k 1.8n 1.8n +B 1.5p L153 L143 R141 C182 C183 C180 ASQDET XC6204B502MR 4.96V INH 7 0.01u 0.58V R142

R642 C578 1M 180 CH1 CH0 VCC A

10n 10k D107 C829 47p CH0 Q5063.3V Q508 3.3V R124 6.8k 26 MM MIC AGC R143

10k 3 T : 2.31mV 5 R913 MIC AGC

R560 C618 MM 6 R107 1SV278F

1 5 VEE 2SJ243-A 2SJ347F 5p 8 5 6 7 R : 7.27V C846 47p CH1 8 47k 0.1u L100 3.9n L147 27 TONESW VIN VoUT 5C D511 Q504 C609 R659 C611 R664 C614 1u R112 0 C162 Q203 Q205 0.1u

TONESW 4 270 10p C706 2 5 33C C185 R146 SSM3K15TE(F)

2SC4738(GR)F 10n C828 47p R704 GND RB706F-40 R121 100 L140 100k 100p C177

VOX R135 28 VSS R554 TONE A 15p 47k 0.1u 47k 1u 10 R134 2 1 3 T : 3.24V 150k

R916 R614 R653 Q206

VOX 1u 5C 100k 3 4 SWITCH D101,103,105,107 R224 470p TONESW IC515

C827 47p C716 C719 29 W_/N /SAVE CE NC MIC MUTE 100k R : 0V 47k SSM3K15TE(F)

Q503 C151 100k 100p 0.1u 0.1u 4.7k R676

W_/N 47k 470p TC7S66FUF C101 100p C108 C110 47k 10k C113

VCO (FREQUENCY 470k C241 100p 100p C245 R240 C826 47p C543 R617 SWITCH 33k 470p

SSM3K15TE(F) 12k

30 BEEP C148 R669 R667 6 10 9 8 7 0 CONTROL) APC BEEP R589 R602 MIC SWITCH GND 7.5V 0.1u C558 1u 470k 470p C701 100 4.7k 0.1u R759 C825 47p R700 0.01u R136 oUT/IN 68k 1k IN/oUT 100p 100p C590 C186 C234 R672 31 TONE (/SCSW) R148 C605 TP1 R656 C231 R109 TONE R584 47k 270k R662 R665 C613 R668 3 0.01u C824 47p 33C R671 32 VADAC 47k 100 EMD9

STSW 47k 100p C178 RXLo2 RXLo2 R140 VADAC OPT6 R590 D512 R753 REFin AVDD 1k 0 68k 0.1u 560k AVDD DGND DGND

C837 47p 0.1u 1k 0 100k 100k R611 C560 33 AMT TP11 IC701 R612 C582 0.01u VCC 4 CoNT RB706F-40 1u 100k R241 100p

R910 C130 C248

AMT AVR (5T/5R) 68k 5

47k R660

5.0V D521 560k CP10 100p C606 C188 0.1u 0.1u R663 33M XC6209B502PR R593 R657

C591 11 C823 47p C617 RFinA 34 STSW 470k TCXO_MOD 5 STSW oPT6 4 Q507 100 CE APC DC SWITCH 150k

R596 47p C822 47p 1 5 C521 1k R654 12 4 C128 35 VCOSW 1SS416 SSM3K15TE(F) IC101 SWITCH (5M)

3.29V NC VoUT SCK0 CLK RFinB 56 VCOSW1 AO 0.1u

C557 R644

13 3 R128 100k R138 5T C821 47p 10k ADF4111BCP7 47p 5T +B 5C 5C 5R 5R 5M MIC AGC 9 5M 36 LCDCNT 2 0.1u C527 0.1u C612 INT/EXT SDO0 DATA AGND TP7 VSS TXo Q505 37 NC C836 47p 33CA 33CA 0 MIC AGC MIC 14 2 T : 3.23V TP3 0.1u 2SA1832(GR)F CP11 LE PLL IC AGND

4 470p 3 1 2 38 APCSW DACRST SWITCH C620 15 R : 3.23V

CE VIN 1u C129 5R APCSW PCS RF MUXoUT 1 5R 470p C720 C717 C819 47p 33C 39 CV 7 88 8 8 CPGND 0.047u35 CV 1 TP6 PLD

C818 47p 0.1u 470k 470p

R701 + C712 40 /EVCS 5RC C703 /EVCS THP LOOP FILTER APCSW TXI 100 41 PLD C817 47p Q700 DTI C157 C124 R154 99 560 100p C106 PLD TP9 9 R156 C816 47p T : 3.28V SSM6L05FU-F 7 7 77 7 820p 0.68u20 2.7k 33 3 33 3 3 DVDD DVDD Vp Rset 42 PCS_RF 33A CP PCS_RF R : 0V 5T + 43 DACRST C815 47p R111 C195 C196 C123 1.2k 1.2k R155 R178 16 18 19 20 DACRST TP12 5TC R756 IC501 100 17 0.01u 0.01u 0.047u35 44 NC C814 47p 5TC T : 0V +B 15M 33C D518 5M D519 Q509 TEMPERATURE Q308 15V 33M 33M 470k 5R_800 R708 T : 4.8V 5V to 3.3V + R : 4.99V 45 SDO0 C813 47p 0 7 DETECTION R179 R180 R185 2SJ347F R : 0V DC/DC 14.55V VREF RXD1LEVEL CONVERTOR RXD1 DC SWITCH 5MCS 5R_700 SDO0 RSSI 3 470k W_/N C704 R702 (15V) C812 47p 1000p 15V(Y) IC714

SCK0 C117 46 L705 RTS0 0.01u 1.2k 1.2k 100 SCK0 10 10

LM73CIMKX-0 C911 R115 D518 0.01u 4.7k 6.8k C811 47p 5T R754 C772

BFSR2 R118 47 68u R117 700M : 4.25mV T : 0.3V C119 C198 C197 0.1u 0.01u 0.01u BFSR2 RXD1 0.01u

0.01u C308 470k

4 3 C341 5R 100p C337 R300 48 HD7 C810 47p 3 5RC R525 47k 800M : 3.29V R : 4.96V 0.01u 1SS416 I2CCK SMBCLK VDD 3 22k 22k Q705 470k R761 HD7 Q701 R306 10u R522 D519 5 2 L304 R373 C709 VCO_MOD R527 5R_800 R303 C809 47p L307 49 INT3 T : 0V SSM6L05FU-F SSM5H01TU-F ALERT GND R119 9

INT3 5R APC 470k R301

R : 3.28V 6 1 470k Q103 R151 C753 1u C755 1u C758 1u C808 47p 10 47k 1SS416 0.1u 0 700M : 4.74V 50 BER_EN AF L2SF I2CSDA SMBDAT ADDR C125 Q300,308 BER_EN IC501 4.95V 1k 2SK879-F(Y) CONTROL UNIT CONTROL (X53-4390-XX)-CN40

470k 800M : 10.34mV 100k R762 C807 47p R110

LCD1 470k 100p C315 C319

PSRPLL 0.1u 3.9n R304 51 0.01u

TC7MBD3245AFK RX BAND 33k L305 100p C332 5RC Q709 1 Q509 Q102 C322 100k PSRPLL IC708 R409 R320 0.1u

C510 C304 22

470k SWITCH C834 47p R709 T : 0V SSM6L05FU-F 20 SSM6N16FE-F SSM6L05FU-F L302 52 HD5 XC9101D09AKR 1 CV 0.1u I2CCK C404 C339 C342 R348

C750 22p R127

HD5 VCC 47k T : 0V R : 4.98V R730 330k NC

R122 CV C806 47p 9 I2CSDA R519 PLL IC T : 2.64V DETECTION 100p 6p 100p 470k 7.44V 19 L335 C705 53 BCLKR2 R703 18 15V 3 2 68k R : 3.34V R337 IN OUT 1000p R694 100k Q300 C405

BCLKR2 EXT VSS I2CCK A1 oE R532 4.7k R533 4.7k RESET R : 2.65V 54 BDR2 C805 47p 0 SSM6L05FU-F R347 0.01u BDR2 5R 2 7 3 18 C132 L300 0 12n Q304 24 23 22 21 20 19 C307 C316 C309 C430 C311 C804 47p LSEN VoUT/FB I2CSDA A2 B1 I2CCK_5V 11 Q302 55 BCLKX2 36 4 17 100p 15p 2p 100p 100p 1k WIDE / NARROW 470k 470k 3.3V 100p C345 R352 BCLKX2 VIN CC/GAIN CTS0 A3 B2 I2CSDA_5V 100p 700M : 4.74V IN OUT BB505CES-TL-E R363 C406 C803 47p AVR (5M) 22 CONTROL SWITCH 56 BDX2 10 4 5 5 16 3 9 0.1u R349

470k 800M : 10.35mV C115 R113 BDX2 IC704 TP8 R724 T : 0V 0.01u 33C VIN6 VIN5 5C CTS0_univ RTS_univ 5 4

CE/SS CLK A4 B3 CV VCO_MOD 57 BFSX2 C802 47p TK11250CUCB 5M(Y) VREF 800M VoUT6 VoUT5 VoUT7 VoUT4 6 15 R : 373mV BFSX2 C724 IC310

RXD0 A5 B4 470k TP108 IC304 9 9 9 9 9 R308 C407

58 GND C801 47p 7.5n P1 VCTL1 R514

470k A_SQL A_SQL L336 1u R311 1 5 7 14 68k NJG1615HA8 0 0 2nd Lo(Y) R371 IC503 2 RXD0_univ 3 3 3 3 3 2 1 NP VoUT 5M DC/DC DSR A6 B5 11 56 IF IC 59 GND C739 1u 68k R310 R727 10u C741 4.7u

C431 6 R321 100p 100p 100p C302 C324 R332 12k TC75W51FK(F) 2 CONVERTER (15V) 1 18 8 13 RX BAND PC 3 ASQ DET C516

1u GND 60 IFDET GND R731 22k VIN7 VIN4 TXD2 A7 B6 DSR_univ

C751 470p VCTL2 P2 C736

IFDET 1u CONTROL D501 3 4 R729 12k 2 17 9 12 5 4 0.01u 4 C748 180p IC309 3 470p C728 C727 SB 61 GND C798 47p CoNT VIN VIN0 VIN3 RXD2 A8 B7 26P_TD 7 3 5M L331 SWITCH IN+B VSS 3 16 10 11 C301 3 PC 6 NJG1615HA8 PLD 62 GND IC502 9 GND P2 VCTL2 Q304 47k C505 6 3 R757

26P_RD R365

VoUT0 VoUT3 GND B8 470k RX BAND R355 IN-B IN+A AK2330 10k 10k 5.1n 100p 4.8V IC304 EMD9

4 15 T : 0V 1 100k

5RC R576 63 R574 R507 TX-RX UNIT : OPTION SECTION (X57-7560-10) (C/3) 2 5RC 4 +B VoUT1 VoUT2 CONTROL 33k 150p 0

D706,IC707 C321 100k 100p 5.1n R302 R322 R : 4.91V TA31137FNG 72 C795 47p L306 L303

DAC 47k 64 5TC 5 14 10k 10 7 7 7 7 VCTL1 P1 470k 470k SWITCH oUTB IN-A 100k F500 R529 R530 R580 R690 R526 C343 0.25A R374

5TC DC/DC VIN1 VIN2 470k R518 C796 47p 7.5V Q706 CN501 CN923 T : 0V 100p C395 1 24 C506 R531 R697 PLD 5 6 13 4 L332 8 1 65 /SAVE 1 TPC6108-F L706 CONVERTER (3.6V) 11 11 11 AGND R : 3.31V R338 C340 IN OUT oSCIN MIXIN L703 IFDET /SAVE L708 DACRST RSTN VREF 700M VDD oUTA 22 SB POW 26 26 SB 22k 2 23 C413 66 5UC C794 47p IC517 R695 150p 100k 100k R534 +B 15n oSCOUT GND1 0.022u C513 SB2 AGND2 700M : 10.76mV L301 0 100p 0.1u ASQDET 5UC 68u 68u TC7SET08FU-F TXD0_univ C306 C317 C310 L330 C363 Q305 3 22 100k R698 D706 5M oPT6 AGND 67 SBC C833 47p D702 100k OPT6 25 25 C3 D305 800M : 4.79V CF300 VCC1 VREF

R716 R713 L501 8p 100p 2p 100p

1.0n BB505CES-TL-E 470k 470k 33M HRB0502A 100p oPT6 C3 HSM88AS-E IN OUT R354 R367 C396

+ 1 5 9 D502,504,515,516 4 21 0.1u MA2S111-F Q706 3.9k T : 0V C507 68 S_DET C793 47p 470 TXD0 INB VCC TXI 24 24 TXI AGND1 T : 0V 0.1u MIXoUT RSSI R515 3 D501 IC707 SURGE TXI TXI DGND PROTECT 2p R521 R : 3.28V R528 DC/DC C730 R307 R : 205mV 33u10 C800 47p R693 2 700M : 10.63mV C323 C400 5 20 R362

69 DSR 3.3k R361 220k 3.3k MA2S111-F XC6365D103M CSN SCLK SDATA DVDD VSS AVDD ABSORPTION RXEI 23 23 RXEI of RF DSR 1 (3.6V) INA L505 VCC2 C-DET C737 82p

0.1u 2.7k C733 0.1u

DGND 470k 800M : 4.79V C525 R722 330k 0.1u R309

RXEI RXEI 47k C504 C792 47p 22k 8.7n C762 4.7u C761 4.7u

CN505 POWER 470k L337

BATT R312 70 3.29V 47k oPT3 R369 0.1u 150k 100p 8 9 7 C725 560k C594

R714 C411 R357

1 5 9 34 /OINT CN500 47 6 19 6800p 3.9k 3.9k 11

RXEo 22 22 RXEo 68k 12 10 R343 9 R651 14 R344 100p 100p C333 C325 R335 71 33A C799 47p EXIT/ VOUT/FB 33CA GND oUTY RXEo RXEo R323 IF1IN N-DET CD300 100p C305 2 /UDET SSW CN508 oPT3 150p 56k C511 1u 560k C512 C519 R562 100k R544 100k R545 100k R546 100k R547 100k R559 100k TXo 21 21 TXo C401 7 18 R915 72 5M 1k L503 1000p VDD oPT2 0 100p 5M 33M 13 TXo TXo C327 DEC1 FILoUT Q502 0.1u 3 4 3 CN509 10k SPuniv+ SP+ 0.30V R538 R536 150k

C791 1000p R353 73 33A -4.15V GND CE oPT2 20 20 oPT2 oPT2 Q302,305 C393 0.1u C412 R356 2SC4617(S) 33A L504 CN506 oPT2 oPT2 8 17 C500 0.1u 0.01u 3 R520 1u BUFFER AMP 12 oPT4 IF1oUT FILIN C766 2.2u C790 1000p 0.1u C418 C420 74 +B 4.7u 4.7u RF AMP (LNA) 100p C752 C508 C509 C754 SPuniv- SP- 11 oPT7 19 19 INH C414 SQL AMP D500 +B 2 3 1000p (LOGIC) C349 L338 R381 C347 L333 0.1u C402 C409 150p 15k C515 470k 9 16 120k 3.29V 36M R726 R723 R503 C622 oPT7 INH

C789 1000p 100 R511 R513 100 R517 100 R645 4.7k 75 33M 5 4 11 oPT4 4p 18 100p IC713 7 10n 8.7n NDPS N-REC 0.22u 56k C518

MANDOWN R535 33M 1 99 9 CTS0_univ MSW/CTS oPT11 18 18 oPT1 0.22u 76 +B 1M LM2682MMX 120 1u oPT11 MDWN C394 0.1u 10 15 0.1u R358 C415 C788 1000p R751 1k 10 18 17 16 15 14 13 V+ 33M IF2IN AFoUT

+ 1 oPT8 17 17 TCoNT oPT1 77 33M C768 AVR (33M) SDO0 EMC

oUT 4.97V C767 1 8 2.2u16 D704 AVR CE oPT8 TCNT oPT5 R341 0.1u C403 4.7k 1000p RB706F-40 C1- NC SCK0 270 270 11 14 R380 78 +B L506 R319 2.2u16 2 7 AVR IC710 (IC705,706, 9 A0 DTI 16 16 DI DEC2 QUAD P25,NARROW : 0V R752 IC705 1SS388F MICE MICE DTI DI oPT5 47 SQL Io1.6 Io1.5 Io1.3 79 15M C2+ C1+ (33A) XC6204B332M IC710) Io1.7 Io1.4 0.1u WIDE,NPSPAC : 3.28V IC712 33M Q303 12 13 C410 CF400 15M + 3 6 47 XC6204B332M 33 3 C599 12 oPT9 15 15 SToN SB2 C392 C421 C427

-t GND2 IF2oUT

+B C388 80 4 3 19 0.01u 100p C674 C797 1000p R749 100k C2- VIN 5M Io1.2 oPT9 SToN +IN V- -IN

/EVCS TRIPLER 100k SCK0 NC CE 4 3 R720 SDO0 I2CCK_5V SCL 39p 0.1u 0.1u

NJM2130F3-ZB R368 R401 C425 TH102 220n 4 5 3.3V 11 SB2 220n L326 81 15M 100p 5V 14 14 5A L328 82p VoUT GND + 2 NC CE 1 1 20 Io1.1 oPT11 AMP 3.19V

1 INH 2 3 IC505 5A 82 SCTAMI VSS 2 220k 3 I2CSDA_5V SDA R573 0 1k 0.1u SCTAMI + VSS 10 C529 AGND AGND2 R378

C771 5 1 21 PCA9535BS 13 13 Q312 L327 L318

C769 C770 C390 C399

1000p 1000p L702 2.2u16 Io1.0 INH C601 100p D515 C786 1000p D516 12 22k DC AMP 33A VOUT VIN 5 1 VDD AGND2 3.19V 1k IF AMP C581 470p C595 470p 83 SPuniv+ BUFFER C577 100p TCXO_MOD C3 R408 C765 SPuniv+ DC/DC VOUT VIN R541 22 I/O EXPANDER 9 1M 0.01u LOCAL AMP 680k R403 (LCDCNT) 2.2u16 AO 12 12 NC 12p 47n 47n 0.01u IC306 IC307

84 SPuniv- C787 47p C600 100p -9.91V C745 8 7 6 5 INT VSS R406 C429 CONVERTER /EVCS SCK0 SDO0 AO CF302 33A D505 R649 D504 0 23 8 C3 Q312 C385 TC7W53FK(F) TC7W53FK(F) 85 SPuniv- 12k C749 1u 22 2 /PTT AVRM1005C270M AVRM1005C270M AI NC 11 11 680k NARROW 100p C763 R342 R750 NNCD6.8G-A A1 Io0.7 oPT8 MDWN C735

0.01u R339 R340 C432 SPuniv- 1SS416 1k 2SC5636 0.01u 47p 10k 1000p 22p 8 AI 82p 68p C423 0

24 7 C391 1 8 5 4 C389 86 SPuniv+ C785 47p C740 C732 36MC 11 10 /PTT PTT 0 8.2k 0.01u C397 IN-B 4.7u +B VDD A2 Io0.6 oPT7 AGND 10 10 AGND1 CoMMoN VCC A GND IN+B MDWN R407 oUTB TP2 TP5 87 RTS0 TP4 R647 7 AGND1 IC400 HD5 HD7 INT3 UNIVERSAL CONNECTOR UNIVERSAL TP13 TP10 1u 1u TP14 TXI Q303

RTS0 33M 36MC 2 7 6 3 BDX2 BDR2 PFKEY REM L500 L704 33k /SCSS DGND 9 9 DGND 703mV

C783 47p BFSR2 /UDET 27p 2SC5636 INH CH0 CH1 VEE 88 R404 4 3 C433 R501 SCTAMI 470 R636 1.8k BCLKX2 PSRPLL BCLKR2 6 DGND /UDET IC511 TXI R359 VIN- VIN+ IC500 Io0.0 Io0.1 Io0.2 Io0.3 AFC RTS_univ RTS1 Io0.4 Io0.5 3 6 7 2 89 RXD0 C782 47p IC709 oPT5 8 8 oPT5 TCNT CN300 RXD0 TC7SH126FU-F 15M IC709 100k 470 L502 oPT5 oPT5 VEE CH1 CH0 INH 2 AVR R652 5 1 3.29V 2 3 5 6 4 C556 C781 47p 0.01u XC9235A15CM1 T : 0V VSS R569 10k 90 PFKEY TC75W51FK(F)

DC/DC 5M R577 4.7k oPT10 7 7 NC TCNT MIXER L325 T : 0V 4 5 8 1

R563 100k CF303 (33C) oUTA IN-A IN+A VSS PFKEY 1 5 CPU TXDM(Y) R : 4.79V GND A VCC CoMMoN C426 C780 47p BER_EN G VCC L707 CONVERTER (1.5V) C621 R635 0 4 RXEI 8.2n R : 706mV WIDE 5 1 91 TXD0 1 5 0.039u R386 1 R582 10k R581 10k IC300 2 3 TXD0 2 VIN LX 4 TXD0_univ TXD oPT4 6 6 oPT4 C373 R390 C387 VDD VoUT C779 47p BFSX2 INA IC706 470 R640 oPT4 oPT4 RXEI CMY210 XF300 92 RXD1 10k 2 1.5V 3 C334 L321 L320 C335 R384 C368 0.1u 0.1u 0.1u 3 4 R618 XC6204B332M DI 560k 0.01u 0 470p R592 0 R591 0 R595 0 R594 0 R598 0 R597 0 R600 0 R599 0 R604 0 R603 0 R606 0 R605 0 R608 0 R607 0 RXD1 VSS RXD0_univ RXD R567 100k R579 10k NC 5 5 NC C416 C419 GND oUTY L701 L310 L309 3p 100n 180n 0.01u 100 0.01u RX FILTER RX FILTER MCP6021-E/OT C778 47p 3 4 3 1 2 1 6 0.1u

93 CTS0 R509 R760 1k C428 CTS0 CE/MoDE VoUT 4 3 0 RXDM(Y) E DI 6.8n 5.1n RF IN IF OUT CONTROL CONTROL NC CE R565 100k R564 100k 26P_TD 4 4 TXD1 3.9k 3.9k R601 R360 R364 R405 94 /PTT C777 47p 2 R637 RXEo /PTT 2 100k 56k 1 2 5 Q309 10 R402 1.8u 33C VSS DSR_univ DSR 1.2k

C551 T : 0V L313

C360 C355 C350 C351 C300 R388

LOGIC SWITCH 26P_RD 3 3 RXD1 L317 GND GND 6p 1000p

C776 47p 4.7u 4.7u 100k

10p 2SC4215-F(Y) C746 C756 C759 95 36MC C744 RXEo

5 1 C361 1000p 1000p 1k R : 4.96V C358 36MC VOUT VIN C503 100p SToN 1p 2p 4p 4p 33p 6.8n 3 4 96 RXD2 C775 47p oPT3 2 2 oPT3 Lo IN Vdd IF AMP oPT1 GND GND BFSR2 HD7 BDR2 /SCSS BCLKR2 BDX2 33M SCTAMI NC GND PSRPLL INT3 RXD0 BCLKX2 SCTXD HD5 GND GND 0 oPT2 oPT3 oPT5 oPT6 RXD2 3 oPT4 oPT3 oPT3 3.3V R699 R506 100k SToN 33CSW 33CSW R366 33C C784 47p C731 L319 18p

TXD2 C366 97 15M oPT1 1 1 oPT1 R387

TXo C371

L311 0.01u 3p

TXD2 220 C742 1u 1u 12 12 oPT1 oPT1 1p 1p 15n 8.2n R389 22 L308 C362 98 /OINT C774 47p 100k C357 C354 33C 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 C570 470p C575 470p C574 470p C585 100p C586 100p C587 100p C603 100p C607 100p C608 100p C598 3300p /OINT C583 6800p D502 TXo 99 GND C773 47p 2 3 NNCD6.8G-A 11 5A LCD1 /SCSS 1u 33p 100 GND 150 100p 100p C352 C353 C356 C359 C364 C367 R382 0.01u 1 0.01u 3 3 3 3 3 CN502 5A L312 100p 26P_TD C372 2 22 2 2 26P_RD 1 1 1 1 1 11 11 5R POWER SW/ CHANNEL CONCENTRIC AF VOL SELECTOR SW

CN902 1 36M S36M GND TOP PCB VoL 33M X57-756 B/3 CH_A TGL2 TGL1 C CH_B CH_D CH_C 12 KIN ORG TXLED BLED TGL1 TGL0 S36M 36M CH_C CH_B CH_A GND 33M TGL2 CN903 GND VoL CH_D 1 17

NC MIC – + 20 1

CN35 NC VoL 33M ORG GND GND GND MICE TGL2 TGL1 TGL0 CH_C BLED CH_B 31BU CH_D CH_A L_MIC TXLED

S31BUS CN40 CN707 1 2 GND GND I2CCK I2CSDA GND GND AF RXAF CN1 1 NC MIC MICE LCDCNT V4 MICmain 33C ANT V3 CN201 V2 GND AFC V1 NC AUD_VREFC MOD NC NC GND GND NC NC ASSIST CGND NC GND GND RSSI GND NC THP /SCSW

LCD 33M 33M ASQDET MM CN505 D7 14 D6 TONESW VOX D5 SSW D4 W_/N BEEP D3 SP+ D2 TONE VADAC SP- D1 D0 AMT STSW MSW/CTS 33M VCOSW LCDCNT EMC /WR MICE A0 NC APCSW /LCDRST PTT /WR 30 CV /EVCS REM PLD PCS_RF RTS1 5M DACRST NC TXD

SDO0 SCK0 UNIVERSAL CONNECTOR RXD CONTROL PCB /SCBFS /SCWKUP TX-RX PCB E X53-439 X57-756 A/3 DSR /SCREQ BER_EN 1 SCBSY /SCRST SCBCK SCMIS0 BER_CLK BER_DATA BFSX2 GND GND IFDET 1 CN38 CN501 CN923 SIDE2 PF2 GND GND PF3 1 1 SIDE3 KoPF 5RC 5TC OPT1 OPT1 PTT L_PTTG L_PTT /SAVE 5UC OPT3 OPT3 PF1 26P_RD RXD1 SIDE1 26P_TD TXD1 6 SBC S_DET NC NC OPT4 OPT4 DSR BATT OPT10 NC OPT5 OPT5 33A 5M DGND DGND AGND AGND1 33A +B AI NC Ao NC 33M +B AGND AGND2 5V 5A 33M +B OPT9 STON DTI DI 15M +B OPT8 TCONT

OPT11 MANDOWN X57-756 C/3 15M SCTAMI OPT7 INH OPTION PCB INT SP CN34 1 SPuniv+ SPuniv- OPT2 OPT2 + INT SP+ TXO TXO INT SP+ SPuniv- SPuniv+ RXEO RXEO – INT SP– RXEI RXEI + INT SP– TXI TXI INT MIC+ RTS0 /UDET OPT6 C3 INT MIC– POW SB – 6 RXD0 PFKEY INT MIC 26 26 TXD0 RXD1 (MAIN) CTS0 /PTT 36MC RXD2 TXD2 /OINT GND GND 99 100