GR-500-APM-500-A Operatorsoperation Manual Primatetm

Home , Griddle

Conforms to ANSI STD Z21.89-2017 Outdoor Cooking Specialty Gas Appliance GR-500-APM-500-A OperatorsOperation Manual Primatetm

Gas Griddle/Grill

SAVE THIS MANUAL FOR FUTURE USE

GrillaGrills.com R02/19/2021 PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL 1 Thank Warnings

DANGER - If you smell gas: PELIGRO - Si huele a gas: You! 1. Shut off gas to the appliance. 1. Cierre el suministro de gas al aparato. 2. Extinguish any open flames. 2. Extinga cualquier llama abierta. So you’ve purchased Grilla Grills first combination gas griddle and grill, and we can’t say thank you enough. 3. Open lid. 3. Abra la tapa. This piece of equipment is something we’ve been working on behind the scenes for YEARS. We’ve been listening to the complaints and suggestions the community had about other gas grills/griddles and doing If odor continues, keep away from the Si el olor persiste, manténgase alejado del everything we can to make this the toughest, most convenient one on the market. This grill never would appliance and immediately call your aparato y llame inmediatamente a su proveedor have been a possibility without the support and feedback that people like you have been sharing with us gas supplier or fire department. de gas o al departamento de bomberos. since we started with the OG years ago. So just one more time, we want to say thank you for everything this community has done for this company. If this is your first Grilla Grill, then we’re proud to welcome you to our ever-growing family of backyard grillers and smokers.

But hey, if you’ve got this book in your hand, that means you’ve probably got the grill at your home already. WARNING - ADVERTENCIA - So enough from us, let’s get into this. On the following pages you’ll see everything you need to know about 1. Do not store or use gasoline or other 1. No almacene ni use gasolina u otros vapores y assembly, operation and maintenance of your Primate Gas/Griddle Combo. Ensure you read this booklet flammable vapors and liquids in the vicinity líquidos inflamables cerca de este o cualquier otro carefully, in order to understand how to safely operate and care for your equipment. of this or any other appliance. aparato. 2. Un cilindro de propano líquido que no esté Our Story: 2. An LP cylinder not connected for use conectado para su uso no debe almacenarse cerca About 7 years ago, two men on a fishing trip, chowin’ down at camp on a plate of ribs. One looks over at shall not be stored in the vicinity of this de este o cualquier otro aparato. the grill (he’s the industrial designer) and says, “Why do all those pellet grills look the same, big ole barrel or any other appliance. cut in half.” The other, a metal smith by trade, answers, “Because we haven’t built one.” That’s when the light bulb went off. Why not design and build a smoker-grill that stands apart, literally, from the crowd. Cooking with pellets was hardly known. Hundreds of design hours later, the Grilla pellet smoker grill was born. THIS APPLIANCE IS FOR OUT- ESTE ELECTRODOMÉSTICO ES PARA USO Fast-forward a few successful years, same two guys. Same idea. Only this time, bring a rock solid, proven DOOR USE ONLY: If stored indoors EN EXTERIORES SOLAMENTE: Si se almacena smoker-grill to the market using the same streamlined business model that delivers savings to the consumer. detach and leave L.P. cylinder out- en el interior, sepárelo y deje el cilindro L.P. Design the grill to efficiently feed you and your friends or the entire neighborhood. Make cooking with pellets doors. easy, the flavor robust and the grill good-looking.

All Grilla products, including pellets, sauces and accessories, are available direct to the hungry consumer. No fat in this business model, just pure value meal after delicious meal. BEFORE LIGHTING - ANTES DE ENCENDER - 1. Read instructions before lighting 1. Lea las instrucciones antes de encender 2. Open the lid during lighting. 2. Retire la tapa durante el encendido. 3. If ignition does not occur in 5 seconds, turn 3. Si el encendido no ocurre en 5 segundos, apa- the burner control(s) off, wait 5 minutes, and gue los controles del quemador, espere 5 minutos repeat the lighting procedure y repita el procedimiento de encendido. e.

2 PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL 3 TABLE OF CONTENTS Getting Started

Warnings Safe and proper use of the grill depends on proper installation, location and setup of your equipment. Any alterations made to this piece of equipment will void the product’s warranty. introduction Before installation, check the serial number of your grill and only use if the type of fuel supply you have Warnings 3 will be compatible with the Primate.

Getting Started 5 Propane or Liquid Petroleum Safety & Gas Requirements 6 - 8 Your Primate is factory built for liquid petroleum, the regulator supplied is set to LP and is for use with that fuel source only. The factory supplied regulator and hose must be used with a 20 lb. liquid petroleum Cylinder. Do not use any replacement regulator other than that specified by the manufacturer.

Natural Gas o p e r a t i o n If you are going to switch to natural gas you must use the approved kit available for purchase from Grilla Grills. The regulator supplied is set for 4” WC. Do not use any replacement regulator other than the one LP & Natural Gas Hook-ups 9 - 11 specified by the manufacturer.

Regulator Conversion & Leak Test 12 - 13 Shipment Installation Guide 14 - 21 This piece of equipment was inspected before it was shipped to you. The shipping carrier assumes full responsibility for the safe delivery of the equipment. Check for possible shipping damage immediately Operating Instructions 22 after reception. If your shipment was damaged, refuse delivery and report the item damaged in transit. If no damage is present, save the packaging material in case a problem arises. Maintainance & Care 23 - 24 Unpacking Parts Diagram 25 - 26 Remove all packaging materials, labels and protective packaging before use.

Warranty Information 27 - 28

failure to follow this operational manual in its entirety will void all warranties.

4 PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL 5 Safety Requirments Safety Requirment Cont.

• The installation of this outdoor cooking gas appliance, Primate Griddle/Grill, must conform with local codes or, in the absence of local codes, either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Used and cared for properly, your Primate Gas/Griddle Combo is going to give you years of suc- Natural Gas and Propane Installation Code, CSA B149.1 or Propane Storage and Handling Code, cessful operation. Before use of your grill, please review the information in this manual thoroughly. B149.2 You’ll find a significant amount of information needed to maximize your safety, as well as the performance and lifetime of your equipment. • This outdoor cooking gas appliance shall be used only outdoors and shall not be used in a building, garage or any other enclosed area. Your Primate is so much more than just a gas grill. Your new equipment can be used to grill with direct heat or diffused heat, as a breakfast making beast or a steak searing champion! Don’t hesitate to • This outdoor cooking gas appliance is not intended to be installed in or on recreational vehicles and / experiment with new foods, try cooking old standards in a new way or pass on the family tradition or boats. to the next generation with this grill. • Minimum clearance of 24 inches from the back and sides of the griddle to adjacent combustible This grill is the culmination of years of suggestions and feedback taking into account other gas grills construction must be maintained. This outdoor cooking gas appliance shall not be located under and griddles we’ve seen. We’re proud to offer what we think is one of the most heavy-duty, intuitive overhead-unprotected combustible construction. and customer-focused gas grill/griddle combos on the market. So thank you for your purchase, and please don’t hesitate to leave us a review on our website, or reach out to us on social media with any • Keep your Primate Griddle/Grill in an area clear and free from combustible materials, gasoline and questions or suggestions! other flammable vapors and liquids.

______• DO NOT obstruct the flow of combustion and ventilation air to this appliance. Keep the ventilation openings of the unit enclosure free and clear from debris. It’s important that you read all safety information in this manual before operating your Primate. • Check all gas connections for leaks with a soapy water solution. Never use an open flame. (Reference • The unit is for outdoor use only. Never use the Primate in an enclosed area. page 13 for leak test procedure). • For safe assembly, use at least two people to unpack and assemble the grill. • Keep young children and pets away from the grill while it’s in use. • Check flexible hoses for cuts and wear that may affect safety before each use. If there is excessive • Always use heat-resistant hand wear when touching or handling the grill while it’s in use. abrasion or wear, or the hose is cut, it must be replaced prior to the outdoor cooking gas appliance • Keep the grill at least two feet away from any combustible surface. being put into operation. The replacement hose assembly shall be specified by the manufacturer. • Never use flammable liquids such as gasoline, charcoal lighter fluid, kerosene or similar liquids to start or freshen the fire in your grill. Keep all such liquids well away from the unit while it is in • The pressure regulator and hose assembly supplied with the Primate Griddle/Grill must be used. use. Replacement pressure regulators and hose assemblies must be those specified by Grilla Grills. • Clean the grill on a regular basis. Clean the unit’s grease drain often to ensure the drain is able to function properly. Should a grease fire occur close the lid, turn the gas off, and wait until the fire extinguishes. WARNING AVERTISSEMENT • Never attempt to service any part of your Primate while the unit is in use PROPOSITION 65 FOR CALIFORNIA PROPOSITION 65 POUR LES RESIDENTS • Check your Primate for gas or grease obstructions often. This will help maintain proper service. RESIDENTS DE LA CALIFORNIE • Position your grill on level ground. The grill should be kept as level as possible so that the grease Cancer and Reproductive Harm – www. Cancer et Troubles de l’appareil Reproducteur flows into the trough. P65Warnings.ca.gov - www.P65Warnings.ca.gov • Never move the unit while it is hot and/or in operation. Make sure the fire is completely out and that the grill is completely cold before being transported. • Never move the Primate when the gas valve is open. In Massachusetts: All gas products must be installed using a “Massachusetts” licensed plumber or gasfitter. A “T” handle type manual gas valve must be installed in the gas supply line to this appliance. This applies to permanently installed natu- • Ensure the gas valve is shut off when Primate is not in use. ral gas and propane installations. This does not apply to propane portable installations using a 20 pound tank.

6 PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL 7 Gas Requirments LP Gas Hook-up

Each appliance is set and tested at the factory for the type of gas supply to be used. Identify the type of Install the factory-supplied hose and regulator assembly as shown. Connect the 3/8” flare end of the gas, either natural gas or LP gas, and make sure that the marking on the rating/serial plate matches the hose to the manifold coupling using a ¾” open wrench. Do not apply pipe sealant to the 3/8” flare con- gas being supplied to the griddle. nection. Connect the regulator to the LP cylinder hand tighten it, do not use a wrench. Check for leaks using soapy water solution. (Reference page 13 for leak test procedure). All gas installations, conversions, and/or adjustments must be performed by an authorized service agent. The installation must conform with local codes or in the absence of local codes, with either the Natural Fuel Gas Code, ANSI z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA Brass Coupling 1/2 NPT x 3/8 Flare B149.1, or Propane Storage and Handling Code, B149.2. Hi-Pressure LP Hose Assembly

WARNING LP Regulator Type-1 CHECK TO ENSURE THAT THE GAS SUPPLY HOSE DOES NOT COME IN CONTACT WITH Set at 11 WC ANY HOT SURFACE OF THE APPLIANCE. NEVER CONNECT THE APPLIANCE TO AN UNREGULATED GAS SUPPLY. 20lb (5 gallon) LP cylinder do Vents required on not place more than one cylinder enclosures for LP in the enclosure at anytime. Cylinders L.P. GAS (LIQUEFIED PETROLEUM /PROPANE) If your appliance is factory built for L.P., the regulator supplied is set for 11in wc (2.7 kPa) and is for use with L.P. gas only. The factory-supplied regulator and hose must be used with a 20 lb. L.P. cylinder.

L.P. GAS SAFETY REQUIREMENT CAUTION: Provide adequate ventiltion The LP-gas supply cylinder must be constructed and marked in accordance with the Specifications for holes in the enclosure for safety purposes in LP-gas Cylinders of the U.S. Department of Transportation (D.O.T.) or the National Standards of Canada the event of a gas leak. CAN/CSA-B339, Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods, and Com- mission, as applicable; and Note: An enclosure for LP gas cylinder must be vented on the level of the cylinder valve and at floor level. The effectiveness of the opening(s) for purposes of ventilation shall be determined with the LP gas 1. Provided with a listed overfilling prevention device. supply cylinder in place. This shall be accomplished by one of the following:

2. Provided with a cylinder connection device compatible with the connection for outdoor cook- a. One side of the enclosure shall be fully open ing appliances. OR b. For a cylinder enclosure having four sides, a top and a bottom, and intended for installation 3. It must be provided with a shut-off valve terminating in gas tank valve outlet. It must include a collar to protect the cylinder valve. The cylinder supply system must be arranged for vapor 1. At least one ventilation opening shall be provided on the exposed exterior side of the enclosure withdrawal. located within 5 in (1.27mm) of the top of the enclosure and unobstructed. The opening(s) shall have a total free area of not less than 1 in²/lb (14.2 cm²/kg) of stored fuel capacity 4. If the outdoor cooking gas appliance is not in use, the gas must be turned off at the supply cylinder(s). Storage of an outdoor cooking gas appliance indoor is permissible only if the 2. At least one ventilation opening shall be provided on the exposed, exterior side of the enclosure 1 cylinder(s) is (are) disconnected and removed from the outdoor cooking gas appliance. Cylin- in. (25.4 mm) or less from the floor level and shall have a total free area of not less than ½ in²/lb ders must be stored outdoors out of the reach of children and must not be stored in a building, (7.1 cm²/kg) of stored fuel capacity. The upper edge shall be no more than 5 in (127 mm) above garage or any other enclosed area. the floor level.

3. Every opening shall have a minimum dimension so as to permit the entrance of 1/8 in (3.2 mm) rod.

8 PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL 9 Natural Gas Installation Natural Gas Installation cont.

***Refer to your Natural Gas hook-up guide included with your NG Kit purchase. Carefully follow all steps to ensure proper installation.** A typical natural gas installation is shown below. Make sure that the factory-supplied regulator is used and installed with the arrow mark on the regulator pointing towards the Primate Griddle/ Grill. Use only pipe sealants that are approved for use with natural and LP gases. An installer-supplied gas shutoff valve must be installed in an accessible location.

Regulator Set at 4 WC (Natural Gas) Typical rear gas connection.

Typical bottom gas connection Installer supplied gas shutoff valve (must be in accessible location) Installer supplied gas shutoff valve (must be in accessible location)

CAUTION: Gas valve assembly, burner orifices and regulators may be subject to alteration before using the grill with Natural Gas depending upon what version of the priamte you have. Refer to CAUTION: Provide adequate ventilation holes in the enclosure for safety purposes in the event of the guide supplied for installation. a gas leak.

Please note, when pressure testing, the following statements must be adhered to:

• This gas appliance and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at the test pressures in excess of 1/2 psi (3.5 kPa).

• This appliance must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1/2 psi (3.5 kPa).

10 PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL 11 Gas Regulator Check/Conversion Leak TEst

CAUTION BEFORE TESTING: If the Grilla Grills Primate Griddle/Grill is factory built for natural gas, the regulator supplied is set for 4” • Never use the Primate Griddle/Grill without first leak testing the gas connections. water column. The regulator is convertible to 11 in wc (2.49 kPa) for system LP application. Do not use • Warning: Do not use open flame to check for leaks. Use of an open flame could result in a fire, with a 20-lb LP cylinder. Make sure that the regulator is set for the correct gas type. To check, remove the explosion or bodily harm. brass hex cap. You will find the conversion plastic pin attached to the cap to the underside of the cap. If • Do not smoke while performing leak test! the disc (1/2 in. diameter) of the pin is close to the cap, then the regulator is set for natural gas. If the disc • To prevent fire or explosion hazard, DO NOT use or permit sources of ignition in the area while per- is at the tip of the pin, away from the brass cap, the regulator is set for system LP application. To convert forming a leak test. Perform leak test outdoors only. to natural gas, remove the plastic conversion pin and invert and replace it back in a manner such that the • Check to ensure the flexible hoses do not have any cuts or wear that may affect integrity before each disc is close to the brass cap. For both natural and LP, the maximum inlet pressure is 14 in wc (3.5 kPa). use. Only the factory supplied hose and regulator may be used. Only use replacement regulator or hose assemblies that are specified by the manufacturer. • Prepare a leak testing solution of sudsy water by mixing a 1:1 solution of soap & water in a spray bot- tle. • Confirm that all control knobs are in the OFF position. • Turn the main gas valve supply ON. WARNING • Apply leak testing solution by spraying on the pipe joints, fittings, and hose. • A gas leak is detected if; •DO NOT STORE SPARE LP-GAS CYLINDER UNDER OR NEAR THIS APPLIANCE. • There is a faint gas smell and/or growing bubbles appear on any of the connection points and/or hose, DO NOT attempt to ignite the side burner and IMMEDIATELY turn off the gas supply valve. When •NEVER FILL THE CYLINDER BEYOND 80 PERCENT FULL. FAILURE TO DO SO MAY CAUSE there is a gas leak, call a qualified service technician. DO NOT operate the unit until the leak is cor- FIRE, DEATH, OR SERIOUS INJURY MAY OCCUR. rected.

•USE ONLY A 20 LBS (5 GALLON CAPACITY) GAS CYLINDER.

•DO NOT USE A DENTED OR RUSTED LP CYLINDER. LP GAS HOOK-UP NATURAL GAS HOOK-UP •NEVER USE A CYLINDER WITH A DAMAGED VALVE.

•ALWAYS CHECK FOR LEAKS AFTER CHANGING THE LP CYLINDER.

•THE LP PRESSURE REGULATOR AND HOSE SUPPLIED WITH THIS UNIT MUST BE USED LEAK TEST WITHOUT ALTERATION.

LEAK TEST

12 PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL 13 Installation Installation cont.

PRIOR TO ASSEMBLY: The Primate is contructed with sheetmetal parts and the edges can be very sharp, please proceed with caution. It is recommended that you wear gloves during assembly to avoid any injuries.

Take Screws from bag #4 and washers from bag #3. Attach the 4 1. supplied wheels to the bottom base. Use 8mm supplied wrench to install.

X16 X16

BEFORE OPERATING: You will need 1 AA battery to complete this installation. The battery will power the automatic piezoelectric ignitor. To install unscew the knob on the left side of your grill. Insert the battery with the correct polarity and reinstall ignitor Mount the back panel to the bottom 2. base with hardware from bag #1.

14 PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL 15 Installation cont. Installation cont.

Install both left & right hand 3. side panels with supplied screws from bag #1. X8

Next take the smaller vertical shelf and mount 5. to the base of the cart upright. After take the larger shelf piece and mount to the cart horizontally. Use supplied screws from bag #1. X6

Position & secure the rear cross Take the front cross brace and 4. brace to the two side panels. X8 mount it to the side panels. Be sure Use screws from bag #1. 6. to orient the brace so the tab in the middle is in towards the base and Once complete now fasten the facing down. Use supplied screws back panel to the side panels. from bag #1. Use screws from bag #1.

16 PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL 17 Installation cont. Installation cont.

Press down and insert into cross brace.

9. Now that the lower part of the cart is complete next take the upper unit and 7. Take one cabinet door and place it with place on top of the cart base. Secure the solid pin downward at an angle. with mounting screws in bag #2. You will then have to depress the pin on each of doors for them to seat into the front cross brace properly. Repeat X6 these steps for the other door.

To mount the grease catch locate 10. Next take the left hand upper shelf and 11. and mount the grease catch install using screws from bag #2. bracket pictured (lower of the X2 8. Once lower cabinet is complete place two highlighted). Secure with heat shield ontop install on the same mounting screws from bag #1. side as the propane opening (right side X4 Once complete place the grease looking at the grill). catch reservoir onto the grease catch bracket.

18 PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL 19 Installation cont. Installation Cont. Operation Style Depending on how you configure your grill, follow these steps carefully before turning on your grill. The flame tamers supplied and pictured below are not to be used with the griddle, only the cooking grates. Vice versa the cooking grates are required to have flame tamers on to ensure proper function.

Grate Placement Griddle Placement • Ensure the grill grate ledges are clear of debris. • Ensure the griddle ledges are clear of debris. • Locate your flame tamers and install over each • Locate your griddle and install onto brackets. burner. • Pick up griddle insert using both handles, and • Place cooking grates on top gently place into grill. • Ensure solid placement. • Ensure Solid Placement.

12. Next take the right hand upper shelf and install using screws from bag #2.

Next take the towel rack and slip it into the perforated slots furthest away from the grill. X4

Caution: Do not install Flame Tamers with this setup. 13. Finally, mount the paper towel holder with screws from bag #1 X4

20 PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL 21 Operating Instructions seasoning Instructions

Lighting Instructions For best results, we recommend seasoning the Tools Needed: griddle before cooking on griddle top. • Ensure the grill is not underneath a cover. • Cooking Oil • Ensure gas supply and burner knobs are all closed. • Long BBQ Tongs • Open lid. Step 1 • Durable Rag (will be destroyed) • Open gas supply valve. • Open burner valves. • Install griddle • Press igniter button. • Wipe down with a dry rag • Check to see if flame is operating. If not, wait a mo- ment and begin this process over. Attention: Prior to igniting your grill remove Step 2 • If grill still does not light, ensure there is fuel flowing the 4 griddle screws attaching the griddle to the grill. through the unit. Contact customer service for further • Turn on heat troubleshooting and support. • Turn burners on high • Allow griddle to brown and discolor 1. Open Lid. • This should take around 10 minutes KEEP LID OPEN DURING ENTIRE SEASONING PROCESS 5. Check for flame inside To watch a video on seasoning your griddle, grill. Step 3 you can find resources at the following:

• Lay down a few tablespoons of oil in the www.youtube.com/grillagrills middle of your griddle www.grillagrills.com/primate-purchase/

Step 4 or scan this QR Code • Using your tongs and rag, evenly spread the oil out across the entire griddle surface including all sides and corners Step 5

4. Press igniter button. • Allow the oil to cook off for a couple 3. turn burner valve(s). minutes • The griddle with stop smoking when the Please Note oil has cooking off • Small variation in raw materails and manufacturing may cause griddle tops to be slightly bowed. A slight bow will disappear once the griddle is exposed to the high temperatures for 2. Open gas supply inside Step 6 cooking. cabinet. • Repeat steps 3-5 up to 3 times • Let griddle cool down between each Caution: Do not leave grill unattended during use. Do not place griddle insert into the grill when fire is active or grill is warm to the touch. application • Apply a very light coating of oil when finished

22 PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL 23 Maintenance and care Maintenance and care Cont.

General Overview Here are some maintenance and cleaning tips to help keep your Primate running and operating Grease Trough and Grease Collection Tray smoothly. It may be helpful to refer to the parts diagram in this operation manual to locate specif- Grease, food particles and other debris can collect in your grease trough and grease collection ic parts on your grill. Your Primate can run efficiently for extended periods of time at different heat tray. Grilla Grills highly recommends that this collection system be cleaned each time the grill is output levels as long as the fuel supply is uninterrupted and timely cleaning and maintenance is per- used in order to have the safest usage possible. formed. Ensure the tray and it’s contents have cooled enough to be safe to touch before cleaning. Wipe the grease tray clean with a cloth and hot soapy water. Ensure it is dry and fully returned to Ensure your Primate is off and cold before performing any maintenance or cleansing. its housing position before using the equipment.

Griddle Pan Thoroughly wipe your griddle insert with a rough cloth after every use to remove leftover food particles and residue. Hot, soapy water can be used to remove cooked-on residue. Rinse griddle pan with water if soap or cleaner is used. DO NOT flood a hot griddle with water. This could possibly lead to warping, or further damage to your griddle insert. Apply a light coat of cooking oil or non-stick cooking spray to your griddle insert after cleaning.

Grill Grates Use a circular wire brush to clean your cooking grates after use. Check the grease container before every cook and drain/clean if mostly full or clogged.

Grill Body Clean outside of the grill with automotive wax, per the product’s directions. Use a soft cloth and stainless steel polish to clean the Primate’s stainless steel portions. Grease that collects on stainless steel portions of the grill can become baked on. Remove them with Grease Trough a mild abrasive pad and stainless steel cleaner. Scrub with the grain of the grill. Using steel wool can To remove simply lift up and pull damage your grill. out. Be sure trough & contents are cooled properly. Liners can be used to make cleanup easier. Visit grillagrills.com for more info.

Caution: Storing your Primate in a coastal environment, near a swimming pool or water source with chlorinated water, or Grease Tray other corrosive environment can have longterm negative effects on your equipment. Do not allow food particles or food Slide tray out to clean up grease. Be sure grease to be left in your equipment. This can attract rodents, which may cause physical harm to your equipment, and can trough & contents are cooled properly. result in unsanitary cooking conditions. This product is made with stainless steel. It is non-rusting and non-magnetic. Never clean the stainless steel when it is hot. After usage, certain areas of the grill may become discolored. This is normal discoloration caused by stainless steel being exposed to high heat. Your grill should be kept dry and covered when not in use. Environmental conditions may pit or scratch the stainless steel causing damage and having a negative effect on the lifespan of the equipment.

24 PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL 25 Parts Diagram cont. PARTS DIAGRAM 1 Item No. Part No. Description QTY 1 THM_PM500-A Thermometer 1 2 2 LHD_PM500-A Lid Handle 1 4 3 3 LHG_PM500-A Lid Handle Grip 1 4 LID_PM500-A Lid 1 5 GRD_PM500-A Griddle 1 6 6 GRA_PM500-A Grates 3 5 7 FBS_PM500-A Flavor Bars 4 8 8 GCR_PM500-A Gas Crossover Rail 3 7 9 LRS_PM500-A Lid rear support 1 9 10 BRN_PM500-A Burners 4 11 UBS_PM500-A Upper Base Unit 1 13.1 10 15 12 IFP_PM500-A Inner front panel 1 16 13 PZI_PM500-A Pizoelectric Ignitor 1 13-1 IGN4_PM500-A Ignitor (left most) 1 19 13-2 IGN12_PM500-A Ignitor (left inner) 1 14 13-3 IGN20_PM500-A Ignitor (right inner) 1 13 21 17 11 12 13-4 IGN28_PM500-A Ignitor (right most) 1 22 14 GDM_PM500-A Gas Distribution Module 1 18 23 15 GCK_PM500-A Gill control knobs 4 27 16 BFP_PM500-A Base front panel 1 25 20 24 17 GCT_PM500-A Grease catch tray 1 30 18 GCB_PM500-A Grease catch bracket 1 19 TWH_PM500-A Towel holder 1 26 20 LHS_PM500-A Left hand side shelf 1 21 RHS_PM500-A Right hand side shelf 1 28 22 DPT_PM500-A Drip tray 1 32 23 RCM_PM500-A Rear cross member 1 24 FCM_PM500-A Front cross member 1 29 34 25 BKP_PM500-A Back Panel 1 31 26 LHP_PM500-A Left hand side panel 1 27 RHP_PM500-A Right hand side panel 1 28 CSH_PM500-A Cabinet Shelf Horizontal 1 29 CSV_PM500-A Cabinet Shelf Vertical 1 33 30 PTH_PM500-A Paper Towel holder 1 31 LHD_PM500-A Left hand cabinet door 1 32 RHD_PM500-A Right hand cabinet door 1 f o r replacement pa r t s: 33 LRB_PM500-A Lower Base 1 Call 616-392-7410 OR Visit https://store.grillagrills.com/collections/accessories-for-the-primate-gas-griddle-grill 34 WLS_PM500-A Wheels 4

26 PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL 27 LIMITED WARRANTY INFO LIMITED WARRANTY INFO (cont.)

fa h r e n h e i t technologies, i n c . state. Fahrenheit Technologies, Inc. extends a limited warranty for its products as described on this page. The limited warranty for four (4) years is in lieu of all other warranties expressed or implied, at law or LIMITED LIFETIME WARRANTY otherwise, and Grilla Grills does not authorize any person or representative to assume for Grilla Grills This limited warranty covers the Primate Griddle/Grill by Grilla Grills manufactured by Fahrenheit Technolo- any obligation or liability in connection with the sale of this product. This means that no warranties, either gies, Inc. The Primate Griddle/Grill has a 4-year limited warranty from the date of purchase by the original expressed or implied, are extended to persons who purchase the product from anyone other than Grilla owner against defects in the material and workmanship when subjected to normal residential use. Limited Grills or an authorized Grilla Grills Distributor. warranty does not apply to paint, grill cover, or damage caused from corrosion. Procedure for Warranty Service Conditions of Limited Warranty Call Grilla Grills at 616–392–7410 for repair or replacement of your covered parts. Be prepared to furnish • During the term of the limited warranty, Grilla Grills' obligations shall be limited to replacement of the following information: covered, failed components. Grilla Grills will repair or replace parts returned to Grilla Grills, freight • Purchaser’s name, model and serial number of grill and date of purchase. prepaid, if the part(s) are found by Grilla Grills to be defective upon examination. Grilla Grills shall not be liable for transportation charges, labor costs, or export duties. • Grilla Grills takes every precaution to utilize materials that retard rust, including the use of high-temperature paint where advisable. Even with these safeguards, the protective coating can be FOR YOUR RECORDS compromised by various substances and conditions beyond Grilla Grills’ control. High temperatures, excessive humidity, chlorine, industrial fumes, fertilizers, lawn pesticides, and salt are some of the Please retain a copy of your sales receipt for warranty claims. substances that can affect paint and metal coatings. For these reasons, the limited warranties DO Please record the following information and refer to them when contacting the company or an NOT COVER RUST OR OXIDATION. authorized service agent. • The warranty is based on residential use. Warranty coverage does not apply to products used in commercial applications. Model #: ______

Exceptions to the Limited Warranty Serial #: ______There is no written or implied performance warranty on Grilla Grills, as the manufacturer has no control

over the installation, operations, cleaning, maintenance, or the type of fuel burned. This limited warranty Date of Purchase: ______will not apply, nor will Grilla Grills assume responsibility if your product has not been installed, operated, cleaned and maintained in strict accordance with the manufacturer’s instructions. The warranty does not cover damage or breakage due to misuse, improper handling, or modifications. NEITHER THE MANUFAC- Place of Purchase: ______TURER NOR THE SUPPLIERS TO THE PURCHASER ACCEPTS RESPONSIBILITY, LEGAL OR OTHERWISE, FOR THE INCIDENTAL OR CONSEQUENTIAL DAMAGE TO THE PROPERTY OR PERSONS RESULTING FROM THE Type of Gas: NG LP USE OF THIS PRODUCT. ANY WARRANTY IMPLIED BY LAW, INCLUDING BUT NOT LIMITED TO IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS, SHALL BE LIMITED TO ONE (1) YEAR FROM THE DATE OF ORIGINAL PURCHASE. WHETHER A CLAIM IS MADE AGAINST THE MANUFACTURER BASED ON THE BREACH OF THIS WARRANTY OR ANY OTHER TYPE OF WARRANTY EXPRESSED OR IMPLIED BY LAW, MANUFACTURER SHALL IN NO EVENT BE LIABLE FOR ANY SPECIAL, INDIRECT, CONSEQUENTIAL OR OTHER DAMAGES OF ANY NATURE WHATSOEVER IN EXCESS OF THE ORIGINAL PURCHASE PRICE OF THIS PRODUCT. ALL WARRANTIES BY MANUFACTURER ARE SET FORTH HEREIN, AND NO CLAIM SHALL BE MADE AGAINST MANUFACTURER ON ANY ORAL WARRANTY OR REPRESENTATION. Some states do not allow the exclusion or limitation of incidental or consequential damages, or limitations of implied warranties, so the limitations or exclusions set forth in this limited warranty may not apply to you. This limited warranty gives you specific legal rights and you may have other rights, which vary from state to

28 PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL 29 save this manual for future use

VER 08242020

30 PRIMATE GAS GRILL/GRIDDLE OPERATION MANUAL