Job Item#

or perated enerat BTU O 200,000 250,000 300,000 G as G team S idth 24” 36” 36” W odel M CG-20 CG-325 CG-330 Natural Gas Gas L.P. 200,000 BTU (24” cabinet) 250,000 BTU (36” cabinet) 300,000 BTU (36” cabinet0 operation 220 VAC Pressure reducing valve Correctional package Ball float trap in “Y” strainer Water OPERATION SHALL BE BY: SHALL OPERATION Gas operated 15 psi (103 kPa) steam boiler VAC: operating on 115      COST: EXTRA AT ITEMS OPTIONAL    ACCESSORIES:   www.yatesgd.com www.yatesgraphicdesign.com www.yatesgd.com  24” (610 mm) wide 200,000 BTU.  36” (914 mm) wide 250,000 or 300,000 BTU. modular a be shall base cabinet steel stainless finish #4 Polished legs steel stainless mm) (152 6” with equipped be Shall design. counter steel stainless reinforced feet, flanged adjustable an with be shall piping All latches. magnetic with doors hinged and top, confined within cabinet. Unit shall come standard with automatic water level control, pressure gauge, water gauge glass, water pressure split valve, control relief safety with control, pressure safety secondary steam controls, boiler CSD-1 blow-down, boiler automatic line, kit, and electronic ignition. take-off Thermostatically controlled cold water shall automatically condensate exhausted steam into water before releasing it to the drain. SPECIFICATIONS: gas______, model Crown a be Shall fired steam boiler suitable for operation at any pressure from VAC. 115 5-15 psi (34-103 kPa) and to operate on Boiler shall be mounted in a cabinet base: Form CG Rev 0 (February/2019) Models:  CG-20  CG-325  CG-330

CG-14S AND CG-20S CG-314S, CG-320S, CG-325S AND CG-

SERVICE CONNECTIONS

– COLD WATER: 3/8” O.D. tubing at 25-50 PSI (170 - 345 kPa).

– DRAIN: 2” (51 mm) IPS piped to open floor drain. No solid connection. – ELECTRICAL CONNECTION: Unless otherwise specified, field wiring electrical connection to be 120V, 60 Hz, 1 Phase with ground. – STEAM TAKE-OFF CONNECTION: 3/4” (19 mm) IPS optional to operate adjacent equipment. – GAS CONNECTION: 3/4” (19 mm) IPS supply line required. Natural Gas: min 7” (178 mm) W.C., Propane: min. 11” (279 mm) W.C.

DIMENSIONS

Model BTU/Hr Units A B C D E F G H J K L M 5.75” 5” 4.75” 12.5” CG-20 200,000 (146) (127) (121) (318)

in 8.75” 5.75” 13.5” 24” 3.5” 11” 2.5” 3” CG-325 250,000 (mm) (222) (146) (343) (610) 8” (89) 6” (279) 6.75” (64) (76) 6” CG-330 300,000 (203) (152) (171) (152)

WATER QUALITY STATEMENT Water quality is the major factor affecting the performance of your appliance. If you are unsure of water quality, consult a local water treatment specialist and have the water analyzed. Your water supply must be within these general guidelines:

Total dissolved solids ...... Less than 60 PPM Total alkalinity ...... Less than 20 PPM Silica...... Less than 13 PPM Chlorine ...... Less than 30 PPM pH Factor ...... 7.0 - 8.5

Water which fails to meet these standards should be treated by installation of water conditioner.

FAILURE OR MALFUNCTION OF THIS APPLIANCE DUE TO POOR WATER QUALITY IS NOT COVERED UNDER WARRANTY. CONTACT CROWN FOR WATER QUALITY SOLUTIONS.

INTENDED FOR COMMERCIAL USE ONLY. NOT FOR HOUSEHOLD USE.

70 Oakdale Road, Toronto ON, Canada M3N IV9 (919) 762-1000 www.crownsteamgroup.com Form CG Rev 0 (February/2019)