Handsfree, GSM Ericsson 628, 688, T28, T20 / Nokia 6110 Handsfree, GSM Ericsson 628, 688, T28, T20 / Nokia 6110 Installation

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Instruction No Version Part. No. 8685564 1.0

Handsfree, GSM Ericsson 628, 688, T28, T20 / Nokia 6110

B3602146

Side 1 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Equipment

A0000162 A0000163 A0000161

A3602154

Side 2 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

A3602155

Side 3 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

A3903163

Side 4 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

M3903606

Side 5 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

A3602125

Side 6 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

INTRODUCTION

Read through all of the instructions before starting installation.

Notifications and warning texts are for your safety and to minimise the risk of something breaking during installation.

Ensure that all tools stated in the instructions are available before starting installation.

Certain steps in the instructions are only presented in the form of images. Explanatory text is also given for more complicated steps.

In the event of any problems with the instructions or the accessory, contact your local Volvo dealer.

Note!

The upholstery for the driver's seat head restraint (tailored for handsfree) must be purchased separately for cars with leather upholstery.

Note!

Install the aerial according to the separate instructions.

Preparations

1 Preparations

Turn the ignition key to position 0

Make a note of the radio code if applicable.

Side 7 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Remove the screws and clips (A)

Remove the soundproofing panel on the passenger side.

H8701741

Detach the radio by fully pressing in and releasing the latch handles

Pull out the latch handles. Pull out the radio

Disconnect the connectors. Remove the radio

Where applicable: Remove the storage compartment from the centre console.

H8802427

Side 8 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Remove the screws (1)

Remove the side panels from the right and left-hand sides of the centre console.

H8503297

Carefully insert the special tool (P/N 9814071) between the dashboard and the lower edges of the heater control panel. Pull the lower section of the heater control panel towards you (1)

Press the entire panel upwards slightly. Carefully pull the top edge of the panel towards you (2). Remove the panel.

H8703376

Side 9 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Remove the three retaining screws for the radio tray

Where applicable: Disconnect the connectors

Remove the radio tray.

H8802428

7A Illustration A applies to the Ericsson 628 and 688

Remove the cover (1) from the carphone holder. Unscrew the mounting (2).

Illustration B applies to the Ericsson T28

Remove the lower section of the carphone holder by first pressing upwards and then outwards. See the arrows in the illustration.

Illustration C applies to the Ericsson T28

Remove the screw and mounting (1) from the carphone holder.

Illustration D applies to the Ericsson T20

Remove the carphone holder (1) from the mounting (2) by A3602156 snapping up the catches on the reverse. Pull the carphone 7B holder from the mounting

Remove the mounting from the mounting plate (3) by removing the screw (4) and the washer.

M3903167 7C

Side 10 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

A3903172 7D

M3903886

Installing the bracket

Side 11 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

8 Installing the bracket

Install the mounting plate (1) and the metal bracket (2) on the plastic bracket (3)

Secure the clip (4) on the underneath of the plastic bracket as illustrated

Do not tighten the screws yet.

A3602157

Open the glove compartment

Position the plastic bracket next to the centre console as illustrated

Adjust the plastic bracket up or down so that it follows the shape of the centre console. Check that the glove compartment is not impeded

Mark out the underside (2) of the metal bracket (1) as illustrated Remove the plastic bracket

Drill a hole (2) using a 2 mm (5/64") diameter drill bit according to the marking

Install the stop screw (A) in the drilled hole. Leave approximately 2 mm (5/64") of the threads visible.

H3602467

Side 12 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Reinstall the radio tray (1). The metal bracket must be positioned on the reverse of the radio tray

Screw the radio tray (1) into place. Press down the plastic holder towards the stop screw (A) behind the centre console to obtain the correct position

Tighten the screws.

B3602148

Press the plastic bracket (1) towards the dashboard

Drill two holes. Use a 7 mm (9/32") diameter drill bit as illustrated. Install the clip (2)

Reinstall the panel for the rear heater control

Check that the glove compartment can be closed.

A3602158

Installing the carphone holder

12A Installing the carphone holder

Illustration A applies to the Ericsson 628 and 688

Install the carphone holder (1) on the mounting (2). Install the cover (3)

Route the wiring from the carphone holder under the plastic bracket to the centre console as illustrated

Secure the wiring in the clip on the plastic bracket (4).

Illustration B applies to the Ericsson T28

Install the carphone holder (1) on the mounting (2)

Side 13 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Reinstall the lower section (3) of the carphone holder

Route the wiring from the carphone holder under the plastic bracket to the centre console as illustrated

Secure the wiring in the clip on the plastic bracket (4).

Illustration C applies to the Ericsson T20

Install the carphone holder mounting (1) on the mounting plate (2) using the screw (3)

Press the carphone holder onto the mounting (1)

Route the wiring from the carphone holder under the plastic bracket to the centre console as illustrated

Secure the wiring in the clip on the plastic bracket (4).

Illustration D applies to the Nokia 6110

A3602159 Install the carphone holder (1) on the mounting (2). Install the 12B cover (3)

Route the wiring from the carphone holder under the plastic bracket to the centre console as illustrated

Secure the wiring in the clip (4) on the plastic bracket.

A3903173 12C

M3903885 12D

Side 14 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

G3602171

Connect the cable harness (1) from the kit to the cable harness for the radio and the power supply cable (2).

G3602465

Side 15 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

14A Illustration A applies to left-hand drive cars, (LHD)

Illustration B applies to right-hand drive cars, (RHD)

Remove the sill trim panel at the left front door

Slide the driver's seat as far back as possible

Push the carpet at the centre console to one side. Route the cable from the carphone holder and radio under the carpet and out by the air vent as illustrated.

Applies to kits with an extra 5 m single cable in the cable harness

The long single cable will not be used. Cut off and insulate the end of the cable using a piece of foam tape.

B3602149

14B

B3602150

Head restraint preparations

15A Head restraint preparations

Mark out for holes in the driver's seat head restraint. See illustration 15A, 15B or 15C (depending on the type of head restraint upholstery). Illustrations A and B display the older model years. Illustration C displays the 2003- model year.

Note!

Special upholstery must be ordered for cars with leather upholstery. See the accessories catalogue.

Illustration A (headrest upholstery with an extra side seam)

Illustration B

Side 16 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Illustration C applies to cars from model year 2003- (chassis number 920 000 - )

H3901449 15B

H3903592 15C

H3904388

Side 17 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Position the hole punch opposite the marking

Press and turn the hole punch to make holes in the head restraint upholstery.

H3901451

Remove the driver's seat head restraint by first pressing it down slightly. Then press in both the catches. Pull up the head restraint.

H3901453

Side 18 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Unzip the zip fastener. Remove the head restraint upholstery.

H3901454

Carefully thread the upholstery over the microphone and the new head restraint

Close the zip fastener. Push the ends of the zip fastener inside the upholstery.

H3901455

Installing the head restraint

Side 19 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

20 Installing the head restraint

Open the zip fastener (1) on the under side of the backrest

Insert a curtain wire from the top and down the reverse of the backrest between the upholstery and the padding

Tape the microphone cable to the curtain wire. Pull the cable down through the backrest

Install the head restraint

Zip the zip fastener closed for the backrest.

B3602151

21A Illustration A applies to Ericsson, left-hand drive cars, (LHD)

Connect the cable (1) from the kit to the cable (2) from the head restraint. Connect the cable (3) to the cable (4) for the radio

Secure the cable under the seat using tie straps as illustrated. Check that the driver's seat can be adjusted.

Illustration B applies to Nokia, left-hand drive cars, (LHD)

Connect the cable (1) from the kit to the cable (2) from the head restraint

Secure the cable under the seat using tie straps as illustrated. Check that the driver's seat can be adjusted.

B3602153

21B

A3701762

Side 20 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Installing the hands free box

22 Installing the hands free box

Slide the driver's seat forwards

Bend the bracket 90°.

H3602458

Side 21 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

23A Illustration A applies to Ericsson

Install the handsfree box on the bracket as illustrated.

Illustration B applies to Nokia

Install the mounting (1) on the bracket (2) for the handsfree box

Push the floor carpet to one side

Screw the bracket into the existing holes under the floor carpet using the screw (3).

A3602160

23B

H3602468

Side 22 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

24A Illustration A applies to Ericsson

Connect the wiring to the handsfree box as illustrated. Connect the 2-pin connector from the power supply cable (1) to the 4 pin connector, the 12-pin connector (2) for the carphone holder and the 5-pin (3) and 1 pin (4) connectors from the head restraint

Screw the bracket with the handsfree box into the existing holes under the floor carpet.

Illustration B applies to Nokia

Connect the wiring to the handsfree box as illustrated, from the head restraint (4), the carphone holder (5) and the radio (6)

Remove the cover (1). Secure the hands free box on the mounting (2). Use the screw (3). Reinstall the cover (1).

H3903887

24B

G3602217

25 Applies to right-hand drive cars, (RHD)

Remove the rubber mat (1)

Remove the gear selector lever lock (2) by pressing in the centre of the catches. Applies to manual gearboxes: Press in the clips. Remove the boot

Apply the handbrake

Remove the cover (3) and the four screws (4)

Disconnect the grey (GR) connector. Pull up the rear section of the centre console at the front edge

Remove the rear section of the centre console completely.

G8503321

Side 23 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

26 Applies to right-hand drive cars, (RHD)

Route the cable from the driver's seat head restraint over the bracket. Connect the connector from the handsfree box

Clamp the cable so that it is not trapped. Check that the driver's seat can be adjusted

Reinstall the rear section of the centre console and the centre console locker.

H3602177

Connect the antenna cable from the carphone holder to the antenna. Secure the cable using a tie strap.

G3602174

Side 24 / 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

File a cut-out in the side panel to a size suitable for the lead-in for the carphone cable as illustrated

Reinstall the side panels on the centre console (passenger side and driver's side)

Install and tighten the screw (1).

H3602466

Reinstall the passenger side soundproofing panel, centre console locker and radio

Where applicable: Reinstall the radio and the centre console locker

Where applicable: Reset the anti-theft radio code

Check the function of the radio and the carphone.

Note!

It must be possible to adjust the seat without stretching or breaking the cables.

30 Reducing noise and echoing

The Ericsson Handsfree GSM 628 and 688 contains a device which reduces buzzing and echoing which can interfere with carphone calls. To reduce buzzing and echoes, adjustments must be carried out until the required acoustics of the car are obtained. The adjustment occurs automatically during the test call and takes approximately 4 minutes. During this time buzzing and echoing can occur.

Note!

The procedure to reduce buzzing and echoes must be carried out every time the power supply has been broken.

Side 25 / 25