DOCSLIB.ORG

Corporate Safety Policy and Procedure

Total Page：16

File Type：pdf, Size：1020Kb

Download full-text PDF Read full-text
Corporate Safety Policy and Procedure Corporate Safety, Health and Environmental Policies and Procedures Manual REVISED: JANUARY 1, 2019 ©2016 Structure Tone All rights reserved *The information contained herein is property of the Structure Tone Organization and its members; and is intended solely for the use of its employees during their employment. TABLE OF CONTENTS 1. Structure Tone Corporate Commitment ............................................................................................ 6 a. Safety Organizational Chart ............................................................................................................ 7 2. Safety 360 Structure Tone ................................................................................................................... 8 3. Code of Conduct .................................................................................................................................. 9 4. Administration .................................................................................................................................... 11 a. Structure Tone Responsibilities .................................................................................................... 13 b. Subcontractor Contract Responsibilities ....................................................................................... 17 c. Subcontractor Pre-Moblization Meeting ........................................................................................ 21 d. Safety Inspections ......................................................................................................................... 22 e. Visitors on the Project ................................................................................................................... 23 f. Disciplinary Policy ......................................................................................................................... 24 g. Zero Tolerance Policy ................................................................................................................... 25 h. Safety Violation Fining Policy ........................................................................................................ 26 i. Safety Violation Fine Schedule ..................................................................................................... 27 j. Safety Violation Fine Form ............................................................................................................ 29 k. OSHA Inspection Procedure ......................................................................................................... 32 l. Safety Complaint Procedures ....................................................................................................... 35 5. Project Safety File Documentation................................................................................................... 36 a. On-site Safety Representative / Competent Person ..................................................................... 36 b. Safety Orientation Record ............................................................................................................. 37 c. Visitor Release .............................................................................................................................. 38 d. Subcontractor Safety Data Compliance Log ................................................................................. 39 e. Project Start-up Safety Checklist .................................................................................................. 40 f. Fall Protection Inspection Report .................................................................................................. 41 g. Subcontractor Safety Program Review Checklist ......................................................................... 43 h. Superintendent Safety Checklist ................................................................................................... 44 6. Safety Training and Education for Structure Tone Employees .................................................... 46 a. OSHA Training Requirements....................................................................................................... 46 7. Personal Protective Equipment (PPE) ............................................................................................. 48 a. Hand Protection (Glove Policy) ..................................................................................................... 50 8. Tool Safety .......................................................................................................................................... 51 a. Powder Actuated Tools ................................................................................................................. 52 9. Job Hazard Analysis Procedure ....................................................................................................... 53 a. Job Hazard Analysis Form ............................................................................................................ 54 10. Accident Recordkeeping ................................................................................................................... 55 a. Accident/Incident Reporting Policy ............................................................................................... 56 b. Personal Injury and Property Damage Documentation ................................................................ 57 c. Personal Injury and Property Damage Documentation ................................................................ 58 2 d. OSHA Recordable Injuries ............................................................................................................ 60 e. Emergency Services ..................................................................................................................... 61 11. Crisis Response Protocol ................................................................................................................. 62 12. Site Specific Safety Plan ................................................................................................................... 66 13. Site Logistics ...................................................................................................................................... 67 14. Sign Posting ....................................................................................................................................... 69 15. Traffic Control .................................................................................................................................... 70 a. Flagger Procedures ....................................................................................................................... 71 b. Working Over Or Near Water ........................................................................................................ 72 16. Environmental Management Plan .................................................................................................... 73 a. Environmental Plans and Procedures ........................................................................................... 74 b. Environmental Issues on a Typical Construction Site................................................................... 75 c. Lead Requirements ....................................................................................................................... 78 d. Hazardous Waste Operation & Emergency Reponse (HAZWOPER) .......................................... 80 17. Hazard Communication Program ..................................................................................................... 81 a. Structure Tone Haz-Com Program ............................................................................................... 81 b. GHS Labels ................................................................................................................................... 84 18. Project Security .................................................................................................................................. 88 a. Active Shooter ............................................................................................................................... 89 19. Utility Shut-Down Procedures .......................................................................................................... 91 20. Powered Industrial Trucks ................................................................................................................ 92 21. Earthwork, Excavations and Trenching .......................................................................................... 93 a. Daily Excavation Inspection Checklist .......................................................................................... 95 b. Pile Driving Requirements ............................................................................................................. 96 c. Caissons ........................................................................................................................................ 97 d. Blasting Procedure ........................................................................................................................ 98 e. Blasting Checklist ........................................................................................................................ 100 22. Demolition .........................................................................................................................................101
Load more

Recommended publications
  • Rubbermaid HYGEN™ 2/2/09
    ™ FINAL PROOF Rubbermaid HYGEN 2/2/09 MICROFIBER CLEANING SYSTEM SMARTER CLEANING FOR HEALTH RCP 519 HYGEN 24pp Brochure.indd 1 2/2/09 2:36:08 PM FINAL PROOF Rubbermaid HYGEN™ 2/2/09 n Superior microfiber textiles proven to remove microorganisms1 BleaCH- Cleans floors n Helps reduce cross-transmission* Proven Performance n Withstands up to 500 commercial launderings % TO ENSURE HEALTHY, SAFE ENVIRONMENTS n Patents pending Safe 45 in hot & cold water better than Certified to tolerate CDC hot and cold string mops** water laundering requirements n Reduces chemical consumption up to 95% vs. traditional mopping % n Reduces water consumption up to 90% vs. traditional mopping 25 2 ProPrietary ZIG-ZAG Complete System n Cleans floors more than 3 times faster than traditional string mops better than Weave PACKS TO MAXIMIZE PRODUCTIVITY AND value n Proven to reduce worker strain conventional n Unique innovative tools to maximize productivity % microfiber n Features legendary Rubbermaid durability 17 flat mops more microfiber n Dedicated Rubbermaid HYGEN™ Training Team in every mop n Detailed guidelines for approved cleaning procedures (Patents Pending) Training & Support n Comprehensive on-site implementation and training TO DELIVER OPTIMAL results on topics including: • Patient Room Cleaning • Restroom Cleaning • Operating Room Cleaning • Guest Room Cleaning • MRI Room Cleaning • Classroom Cleaning n Ongoing training support Proven to remove over % Rubbermaid HYGEN™ 1 95 When used with detergent or QUAT cleaners. Detergent cleaner w/microfiber mop - 94.5% of microorganisms System provides Detergent cleaner w/standard string mop - 67.8% (vs. as low as 67% with innovative solutions QUAT cleaner w/microfiber mop - 95.3% standard string mops)1 QUAT cleaner w/standard string mop - 94.8% and proven superior William A.
    [Show full text]
  • Generic Procedures for Assessment and Response During a Radiological
    IAEA-TECDOC-1162 Generic procedures for assessment and response during a radiological emergency August 2000 The originating Section of this publication in the IAEA was: Radiation Safety Section International Atomic Energy Agency Wagramer Strasse 5 P.O. Box 100 A-1400 Vienna, Austria Emended version, March 2013. Details of revisions are available at: www.pub.iaea/books/ GENERIC PROCEDURES FOR ASSESSMENT AND RESPONSE DURING A RADIOLOGICAL EMERGENCY IAEA, VIENNA, 2000 IAEA-TECDOC-1162 ISSN 1011–4289 © IAEA, 2000 Printed by the IAEA in Austria August 2000 FOREWORD One of the most important aspects of managing a radiological emergency is the ability to promptly and adequately determine and take actions to protect members of the public and emergency workers. Radiological accident assessment must take account of all critical information available at any time and must be an iterative and dynamic process aimed at reviewing the response as more detailed and complete information becomes available. This manual provides the tools, generic procedures and data needed for an initial response to a non-reactor radiological accident. This manual is one out of a set of IAEA publications on emergency preparedness and response, including Method for the Development of Emergency Response Preparedness for Nuclear or Radiological Accidents (IAEA-TECDOC-953), Generic Assessment Procedures for Determining Protective Actions During a Reactor Accident (IAEA-TECDOC-955) and Intervention Criteria in a Nuclear or Radiation Emergency (Safety Series No. 109). The procedures and data in this publication have been prepared with due attention to accuracy. However, as part of the ongoing revision process, they are undergoing detailed quality assurance checks; comments are welcomed, and following a period of time that will have allowed for a more extensive review, the IAEA will revise the publication as part of the process of continuous improvement.
    [Show full text]
  • Cricothyrotomy
    NURSING Cricothyrotomy: Assisting with PRACTICE & SKILL What is Cricothyrotomy? › Cricothyrotomy (CcT; also called thyrocricotomy, inferior laryngotomy, and emergency airway puncture) is an emergency surgical procedure that is performed to secure a patient’s airway when other methods (e.g., nasotracheal or orotracheal intubation) have failed or are contraindicated. Typically, CcT is performed only when intubation, delivery of oxygen, and use of ventilation are not possible • What: CcT is a type of tracheotomy procedure used in emergency situations (e.g., when a patient is unable to breathe through the nose or mouth). The two basic types of CcT are needle CcT (nCcT) and surgical CcT (sCcT). Both types of CcTs result in low patient morbidity when performed by a trained clinician. Compared with the sCcT method, the nCcT method requires less time to set up and is associated with less bleeding and airway trauma • How: Ideally, a CcT is performed within 30 seconds to 2 minutes by making an incision or puncture through the skin and the cricothyroid membrane (i.e., the thin part of the larynx [commonly called the voice box])that is between the cricoid cartilage and the thyroid cartilage) into the trachea –An nCcT is a temporary emergency procedure that involves the use of a catheter-over-needle technique to create a small opening. Because it involves a relatively small opening, it is not suitable for use in extended ventilation and should be followed by the performance of a surgical tracheotomy when the patient is stabilized. nCcT is the only type of CcT that is recommended for children who are under 10 years of age - A formal tracheotomy is a more complex procedure in which a surgical incision is made in the lower part of the neck, through the thyroid gland, and into the trachea.
    [Show full text]
  • Are You Still Using a Mop and Bucket? Nilfisk Has a Better Solution
    Are you still using a mop and bucket? Nilfisk has a better solution The Problem • You have a small, hard surface area in a high-traffic location • This space is highly visible and it is critical to keep it clean sanitary, presentable and safe Typical Solution: Mop & Bucket • One of the most common solutions for a space like this is a mop and bucket. But this approach isn’t ideal. • Unsanitary: Each dip of the mop contaminates 18-20% of the clean water (after 5 dips, the entire bucket has been contaminated) • Ineffective: The mop is merely spreading dirt, grime and chemicals around the area, leaving a dirty, hazy and sticky residue • Dangerous: After mopping, the area remains wet, increasing the risk of slip-and-falls ADVANCE SC100™ ADVANCE SC351™ Cord Electric Upright Scrubber Battery Operated Micro Scrubber Nilfisk’s Recommended Solution: Automatic micro scrubbers • Efficiency: Clean 4,873 square feet per hour with • Visitor safety: Floors are left clean and dry in one pass a 14” scrubber, while a 24-oz mop will cover only • Operator safety: Recovery tanks and accessories limit 2,564 in the same amount of time contact with germs and waste • Portability: Battery power can make these • Containment: Fewer contaminants are released machines just as portable as a mop and bucket into the air, protecting both visitors and operators • Storage: Compact footprint allows for • Sanitary: Use anti-bacterial detergents for easy storage maximum impact Nilfisk, Inc. 9435 Winnetka Avenue North Phone 800.989.2235 Brooklyn Park, MN 55445 Fax 800.989.6566
    [Show full text]
  • Print Catalog
    Product Catalog 2017—2018 Janitorial—Sanitation—Maintenance—Equipment—Supplies Keep Clean Products Product Catalog Table of Contents A. Paper .................................................................................................... 2 B. Skin Care .............................................................................................. 9 C. Safety .................................................................................................. 14 D. Food Service ....................................................................................... 17 E. Trash Liners ....................................................................................... 20 F. Receptacles / Trash ............................................................................ 21 G. Cleaning Supplies .............................................................................. 25 H. Matting ............................................................................................... 51 I. Cleaning Equipment .......................................................................... 53 J. Absorbents & Sweeping Compounds ............................................... 64 K. Chemicals ........................................................................................... 65 L. Batteries .............................................................................................. 81 M. Restroom ........................................................................................... 83 N. Tapes & Adhesive .............................................................................
    [Show full text]
  • Mop Bucket Vs Micromatic
    ™ Mop and Bucket vs. Micromatic 13E Concern Mop and Bucket Micromatic™ 13E Overall Floor The first time the mop is dipped into the mop bucket, the water becomes dirty and The Micromatic 13E floor scrubber always dispenses a solution mixture of Cleanliness contaminated. The cleaning chemical in the mop bucket water will start to lose its clean water and active chemicals. Brushes on the scrubber provide intense effectiveness. The dirty water is then spread on the floor and left to dry. The floor agitation to loosen and break up tough soils. The vacuum on the scrubber is left wet with dirt and grime still in the water. then removes the water and dirt, leaving the floor clean, dry, and safe. Grout Cleanliness Cotton or microfiber mops are unable to dig down and reach into grout lines on tile Micromatic 13E uses brushes and the weight of the machine to push the & Restoration floors to loosen the soil or remove the dirty water. Mop fibers skim over the tile brush bristle tips deep into the grout lines to loosen embedded soils. The surface and glide over the top of grout lines. Dirty water then fills the grout lines vacuum and squeegee system is then able to suck the water up and out of and when left to dry, will leave behind dirt. the grout lines, leaving them clean and dry. Regular use of the Micromatic 13E helps prevent the time consuming and expensive project work of grout restoration. Baseboard and While swinging mops back and forth over a floor, the mop will sling dirty water up The semi-enclosed scrub deck of the Micromatic 13E keeps the dirty water Floor Fixtures against baseboards, table legs, and other on the floor fixtures.
    [Show full text]
  • Emergency Plan Checklist Center Name: License ID
    Emergency Plan Checklist Center Name: License ID: Prepare written emergency procedures delineating the following: Location of the first aid kit and additional first aid supplies Name, address and telephone number of the physician retained by the center or of the health facility used in emergencies Procedure for obtaining emergency transportation Hospital and or clinic to which injured or ill children will be taken Phone numbers for police, fire, ambulance and Poison Control (National Poison Emergency Hotline at 800-222- 1222) Location of written authorization from parent(s) for emergency medical care for each child Diagram indicating how the center is to be evacuated in an emergency from each classroom and the outdoor play area Location of fire alarms and fire extinguishers Procedures for ensuring children’s safety and communicating with parents in the event of evacuation, lockdown, natural or civil disaster and other emergencies Plan for informing parents of their children’s whereabouts The local law enforcement agency or emergency management office that has been notified of the center’s identifying information as listed below: The center’s name and location The number and ages of children enrolled The number of staff The need for emergency transportation; the location to which children will be evacuated The plan for a lockdown The plan for reuniting children with their parents To Find Your County’s Office of Emergency Management Coordinators, Visit: http://ready.nj.gov/about-us/county-coordinators.shtml Other: Ensure emergency plan is posted for reference or is readily accessible in a designated location in the center Maintain 1 evacuation crib per 4 enrolled non-ambulatory infant/toddler children (if applicable) Staff have been trained in procedures for operating locking devices used for lockdown procedures (if applicable) Notes for Emergency Plan: OOL/10.28.2017 .
    [Show full text]
  • Torrington Brush Works “Working Brushes for Working People” #5/2019
    Torrington Brush Works “Working Brushes for Working People” #5/2019 FREE SHIPPING On Orders Over $100 See page 2 for details. Call Toll Free: 1-800-262-7874 1-800-525-1416 Fax Toll Free: Visit us at: 1-800-528-0109 www.torringtonbrushes.com We Make It Easy To Order Table Of Contents Bristle Paint Brushes ..............................................................................3-8, 13-15, 17, 25 Call Toll Free: Synthetic Paint Brushes ................................................................................8-12, 14 & 25 Vehicle Wash Brushes and Flow Thru Handles................................................51 & 59 1-800-525-1416 Automotive Parts Cleaning & Detail Brushes............................................................ 25 Floor Sweeps & Street Brooms.................................................................................54-57 1-800-262-7874 Staple Set Vat and Floor Scrub Brushes ..................................................................... 62 Staple Set Scratch, Platers & Welders Brushes ...................................................63-65 Staple Set Bench, Counter and Shop Dusters ................................................ 52 & 53 Visit Us at: Artist Brushes & Quills .................................................................................................26-35 “Twisted-in-Wire Tube” and Gun Cleaning Brushes .......... 25, 36-40, 43-48 & 66 www.torringtonbrushes.com Corn & Fiber Brooms & Whisks ................................................................................ 19,
    [Show full text]
  • Wood Fruitticher Has Cooper/Atkins Thermometers
    Smallwares & Supply Office: 2900 Alton Road Birmingham, AL. 35210 Phone# 205-836-9663 Visit us on the web @ www.woodfruitticher.com SAN STACKABLE™ TUMBLERS Item# Pack Color 820753 72/5oz. Clear Tumbler 820837 72/8oz. Clear Tumbler Disposable Lids To 820878 72/9oz. Squat Clear Tumbler Fit Tumblers 820803 72/9.5oz. Clear Tumbler 820902 72/12oz. Clear Tumbler 834952 Fits San16oz. & 9oz. Squat 821009 72/16oz. Clear Tumbler 800813 Fits San 5oz. 821017 72/20oz. Clear Tumbler 800839 Fits San 8oz. 807446 48/32oz. Clear Tumbler 843193 Fits San 20oz. 859843 72/5oz. Amber Tumbler 819888 Fits Pebble Optic 20oz. 820829 72/8oz. Amber Tumbler Cambro Tumbler 826347 72/9oz. Squat Amber Tumbler 910810 72/9oz Squat Tumbler 820852 72/9.5oz. Amber Tumbler Cambro Disposable Lids 820951 72/12oz. Amber Tumbler 832485 Lid for Laguna 6oz Tumbler 821058 72/16oz. Amber Tumbler 834960 Lid for 950P Tumbler w/straw slot 821066 72/20oz. Amber Tumbler (also fits same as Dinex 1198) 821074 48/32oz. Amber Tumbler 820845 72/8oz Ruby Tumbler 820795 72/9.5oz Ruby Tumbler 820969 72/12oz. Ruby Tumbler Coffee Decanters Glass 821025 72/16oz. Ruby Tumbler 821041 72/20oz. Ruby Tumbler Item# Pack 832519 48/32oz Ruby Tumbler 062646 3ea Decaf 062604 3ea Regular CARLISLE® VERSAPOUR™ 60oz Bounce Pitchers Item# Pack Color Item# Pack Color 860510 6/60oz. Clear 825620 1/ea Granite 825463 6/60oz. Amber 32oz Bounce Pitchers Item# Pack Color 825638 6/32oz. Clear Insulated Swirl Decanters Item# Pack Color 825547 1/ea White 20oz 825562 1/ea White 40oz Beer Pitcher #862342-Clear 64oz Camwear® Pitcher Item# Pack Color 860452 1/ea Clear 64oz In-Stock Glassware (New Orleans Matches Libbey Gibraltar Pattern) New Orleans Mixing Glass Cardinal Mixing Glass 16 oz.
    [Show full text]
  • CONFINED SPACE ENTRY PROGRAM Owner: Risk Management Document Number: EHS S-004 Revision No: 01 Date Last Revised: 08-2-2018
    CONFINED SPACE ENTRY PROGRAM Owner: Risk Management Document number: EHS S-004 Revision No: 01 Date last revised: 08-2-2018 Contents 1.0 Applicability ......................................................................................................................................................2 2.0 Scope ...............................................................................................................................................................2 3.0 Definitions ........................................................................................................................................................2 4.0 Core Information and Requirements ...............................................................................................................4 5.0 Roles and Responsibilities ............................................................................................................................ 29 6.0 Goals, Objectives and Performance Measures ............................................................................................ 32 7.0 Training ......................................................................................................................................................... 33 8.0 Program Evaluation ...................................................................................................................................... 34 9.0 Resources ....................................................................................................................................................
    [Show full text]
  • Emergency Procedures Manual
    Emergency Procedures Manual Table of Contents I. Purpose ............................................................................................................................................ 3 II. Scope ........................................................................................................................................... 3 III. Procedures ................................................................................................................................... 3 III.A. Emergency Notification Process ........................................................................................... 3 III.A.1. Emergency Notification Diagram...................................................................................... 5 III.A.2. Emergency Numbers ........................................................................................................ 5 III.B. Categories of Emergencies (Threat Levels) ........................................................................... 6 III.B.1. Threat Level 1 .................................................................................................................. 7 III.B.2. Threat Level 2 .................................................................................................................. 7 III.B.3. Threat Level 3 .................................................................................................................. 7 III.C. Organization........................................................................................................................
    [Show full text]
  • Model SOP Standard Operating Procedure
    Model SOP for Training Purposes Only Firetactics.com Model SOP Standard Operating Procedure Firetactics.com Paul Grimwood FIFireE ‐ SOP 1/Version 2/2009 1. TACTICAL DEPLOYMENT INTO FIRE INVOLVED STRUCTURES Sections 1. Purpose 1. Purpose The following bulletin serves as a training 2. Pre‐planning document that covers a range of critical 3. Information ‘in’ tasking issues associated with the safe 4. Risk Management and effective deployment of firefighters 5. Information ‘out’ into fire involved structures. It is not a 6. Situation Awareness complete SOP by any means but simply 7. Staffing stands to inform of a risk‐assessed 8. Water Supply process for compartment and structural 9. Primary Attack fire‐fighting. 10. Search & Rescue However, this document may serve as a 11. Securing Team Safety model upon which more detailed 12. Tactical Ventilation operational procedures may be 13. Primary (First Response) Command & Control developed. 14. Accountability 15. BA Emergency Procedure All students are strongly advised to follow 16. Communication their own departmental SOPs at all times. 17. Principal Officer (First Chief) Command & Control Any deviation from such procedure must 18. Large Volume Structures only be made with good reason and 19. High‐rise Buildings should be held accountable at a later stage. 20. The Most Common Reasons for Traumatic Fire‐fighter Life Losses 2. Pre‐planning It is essential that familiarization visits are made to all large volume structures, or those presenting excessive or unusual risks, so that plans may are organised and provided on‐site in special premises information boxes located at main entry points. Alternatively, these may be held on computer terminals and down loaded into a fire engine’s computer system as they arrive on‐scene.
    [Show full text]