Gujarat Pollution Control Board Regional Office-Palanpur, Dist-Banaskantha, Gujarat

339

GUJARAT POLLUTION CONTROL BOARD REGIONAL OFFICE-PALANPUR, DIST-BANASKANTHA, GUJARAT

INDEX

SR.NO SUBJECT PAGE NO

1, Action Taken Report (ATR) 1to8

2. Annexure-A, Inspection Report of Regional 9to9 Office- GPCB Palanpur

Annexure-B, Copy of the Letter dated 10 to 10 13.10.2020

3. Annexure-C, Inspection Report of Regional 11 to 16 Office- GPCB Palanpur

4. Annexure-D, Inspection Report of Regional 17 to 17 Office- GPCB Palanpur

5. Annexure-E, Analysis report 18 to 23

GUJARAT POLLUTION CONTROL BOARD 340

(Regional office-Palanpur) Room No: 20 to24, 3Floor, JillaSevaSadan-2,Joravar Palace, Palanpur-385001, Dist.-Banaskantha Phone: (02742)251300,251301 WebSite:-gpcb.gujarat.gov.in Email:[email protected] XGN Site:-gpcbxgn.gujarat.gov.in

Action Taken Report

M/S Stagot Potartoes Products LLP, Survey No. 675/1, At — Sundha, Ta — Palanpur, Dist — Banaskantha was inspected with reference to Hon’ble National Green Tribunal, Principal Bench,New Delhi in O.ANo.108/2019(WZ) (I.A.No-162/2019) Gangarambhai Narsinhbhai Karnavat Vs. Stagot Potatoes Products LLP &Ors. order dated 26.06.2020 directed Regional Officer, State Pollution Control Board to visit the place and submit factual and action taken report to the Hon'ble court. The Regional Office, Gujarat Pollution Control Board, Palanpur has submitted Action Taken Report to the Hon’ble NGT, ngt-pune@gov.in, judicial- [email protected], [email protected] along with the copies of a) Inspection reports (b) Directions issued to the industry (C) Bank guarantee forfeit letter (d) Consent to operate order of unit (e) Analysis report of Bore well samples through E-mail on dated 22.09.2020.

Again the Hon’ble courts order on dated 28.09.2020 the Regional Officer, State Pollution Control Board is directed to monitor further and submit action taken report to the Hon’ble NGT. The unit was visited on 08/10/2020, it was found totally closed. Copy of the visitinspection report is Annexure-A. The person contacted informed that the production plant was totally closed due to nonavailiblity of raw materials. On dated 13/10/2020 the industry has submitted a letter stating that the last production was taken on 09.07.2020 for 22 Hrs in operation than after there was no production has been taken till date. The next expected production will be month of January-2021. Copy of the letter dated 13/10/2020is Annexed-B. Again the unit was visited on 07/11/2020 by the Regional Officer, Gujarat Pollution Control Board Shri.M.S.Dasari and Shri T.A.Trivedi, Scientific Officer, Gujarat Pollution Control Board, Palanpur. The industrial plant is found totally closed. No smell/odour was not felt in and around the industry. Copy of the inspection report is Annexure-C.

Again the unit was visited on 31/12/2020 by Regional Office, Gujarat Pollution Control Board, Palanpur. The contacted person informed that the plant is shutdoun from July- 2020 due to nonvailablity of raw material (potatoes). No smell was found in and around factory premises. Instruction was given to the contacted person that whenever production plant start inform to the department. Copy of the inspection report is Annexure-D.

Permission given to M/S Stagot Potatoes ProductsLLP: M/S Stagot Potatoes Products LLP, Survey No. 675/1, At — Sundha, Ta — Palanpur, Dist — Banaskantha, Gujarat has obtained Consent to Establish (CTE) from Gujarat Pollution Control Board for manufacturing of Starch from Potatoes @ 1080 MT/M vide CTE No — 77473, dated — 28/03/2016 (copy of the same is enclosed as Annexure—B). Further the unit was granted Consent to Operate vide letter dated 08/04/2019 up to 30/06/2022 to operate industrial plant for manufacturing of starch from potatoes.

GUJARAT POLLUTION CONTROL BOARD 341 ea (Regional office-Palanpur) oe Room No:20 to24, 3" Floor,JillaSevaSadan-2,Joravar Palace, Palanpur-385001,Dist.-Banaskantha Sr Phone: (02742)251300,251301 WebSite:-gpcb.gujarat.gov.in Email:[email protected] XGN Site:-gpcbxgn.gujarat.gov.in

Rater |, tue. 5Pat | tetygon_) Cate | amesth x2 poboon | Measxe the dicunfareKe or acea of a chcie on the gp ois 508.43 Mebats 8190 Heciees 3,395.59 Meters

3.1 Location of the industry showing on google map (500 meters radius)

The map showsthe nearestvillage is Sundha @500meters away from unit and the otherside of the unit/Plant area are agriculture land/fields. The village school is also beyond the 500 meter from the location of the unit/plant. 6. Manufacturing process The raw material potatoes washing with water to remove coarse particles and sand, then after the potatoes are crushed in a Rasping machinetill it becomes potato slurry is a mixture of starch granules, fiber and water. The potatoes slurry is then fed to hydro cyclone machine where the starch particles, fibers and water part (i.e. process effluent) are separated. Starch with moisture content is then fed to spin flash dryer to get final product, i.e. white starch powder. Entire processcycle time is about 22 hours. 7. Source of waste water/fibre waste generation: At full capacity of plant a) Washing of potatoes — 25 KL/D (Diluted stream) b) Process waste water (Concentrated effluent stream) —275KL/D(Waste water seprated from hydro cyclones). Total waste water generation- 300 KL/Day. c) Fibre waste — Approx. 7MT/Day (Fiber separated from hydro cyclones) 8. Treatment of Waste Water The waste water generated from the washing section of the raw material is being directly collected in collection tank, another waste water stream generated from process after removal of the fibre content in the decanter is being sent to collection tank for further treatment. The industry has provided Effluent TreatmentPlat consisting of following units. e Collection tank Flash Mixer (Not in use) Flocculation Tank (Notin use) Primary Clarifier (Not in use) Conditioning Tank — Anaerobic digester(CSTR- 2 nos) First stage Aeration tank XY First stage Secondary settling tank i Second stage Aeration tank Second stage secondary settling tank Treated waste water holding tank Sandfilter (Not in use) Carbonfilter (Not in use) Decanter 342

9. Disposal of Treated waste water: Treated waste water from the ETP is discharged onto the agricultural farms of 42 Acres through undergroundpipeline surrounding the units. Unit has made MoU with Farmers.

| tne f Path seygon frde Sopa open | Meanore the cctance Bemenen aspornen the ound | MopLeng . i GreyLarge | Hexdag: 12: Moume Pavtgeenn

4,082.45 Haters ; sezipecams |

Treated wastewaterdisposal agriculture land adjoining to the factory/industry

10. Managementof Fiber Waste & ETP Sludge: The fiber waste is generated from the manufacturing process, which is supplied through tankers to M/s Goverdhan nathji Energies LLP, Vill-Pij, Ta-Vaso, Dist-Nadiad, Gujarat which is Bio Gas generation plant. The sludge generated from the Effluent Treatment Plant is also being disposed along with fiber waste. At the time of visit, no stock of fiber waste and ETP sludge are observed stored in the unit. Month wise quantities of fiber waste send to M/s Goverdhan nathji Energies

LLP are shownbelow. Month Fiber Waste sent to M/s Goverdhannathji Energies LLP (Quantity in MT) January-2020 Nil February-2020 50

March-2020 130 April-2020 Nil

-3 GUJARAT POLLUTION CONTROL BOARD 343

(Regional office-Palanpur)

Room No: 20 to24, 3" Floor,JillaSevaSadan-2, Joravar Palace, Palanpur-385001, Dist.-Banaskantha Phone:(02742)251300,251301 WebSite:-gpcb.gujarat.gov.in Email:[email protected] XGN Site:-gpcbxgn.gujarat.gov.in

May-2020 Nil

June -2020 300

July-2020 Nil

Aug-2020 Nil

Sept-2020 Nil

Oct-2020 Nil

Nov-2020 Nil

Dec-2020 Nil

Jan-2021 Nil

. Air Pollution: Unit has one boiler having capacity of 2 TPH, using imported coal as a fuel. Unit has provided Dust collector (Multi Cyclone Separator) as Air Pollution Control Device. Unit has also provided stack monitoring facility. There is no process emission from the manufacturing process. As no activity other than unloading of potatoes is going on, noise level is the industry is found normal during thevisit. . Odour control Management: The industry has provided fogger system for control of odour. in fogger system the industry is using Rose Fragrance Liquid (1 Liter in 1000 Liter of Water) for continues spraying on the top of Anaerobic reactor/Digester. . Quality of Ground Water: The industry has provided one numberof bore well within the premises and entire fresh water requirement of industry is met by the bore well water. Bore wells are also there in the surrounding farms. Physical characteristics of the water abstracted from the said bore wells is apparently normal. a) Four no of ground water sample are collected by the Regional office palanpur on dated 04/07/2020 from following points. The results are as under.

Locations

Parameters GPCB Borewell Borewell Borewell Borewell prescribed located sample sample sample standards within collected from collected from collected from in consent M/S nearby nearby borewell order Stagot borewell borewell located Potatoes toward south towards North within Products side of stagot side agreement LLP unit potato unit of stagot agricultural 1 2 potato land, unit, which is which is about 200m about 1.1 away Km away from the unit from the 3 unit. 4

pH# 6.5 to 8.5 7.44 7.79 7.20 8.34

Total 2100 758 1170 728 866 Dissolved solid (TDS) mg/1 Chloride mg/l 600 90 300 110 140

Sulphate mg/l 1000 55 168 78 63

COD mg/l 100 7 11 14 6

BOD (3 days 30 0.75 0.72 1.42 0.89 at 27 C) mg/l

Sodium 26 7 12 7 12 Absorption Ratio (SAR)

GUJARAT POLLUTION CONTROL BOARD 344 (Regional office-Palanpur) ———— Room No: 20 to24,3"Floor, JillaSevaSadan-2, Joravar Palace, Palanpur-385001, Dist.-Banaskantha SS Phone: (02742)251300,251301 WebSite:-gpcb.gujarat.gov.in Email:[email protected] XGN Site:-gpcbxgn.gujarat.gov.in

b) Two ground water samples are collected during the visit by the vigilance team, GPCB, Gandhinagar on dated 17/07/2020 from the following sources, The results are as under: Locations Parameters GPCB Bore well located Bore well water sample prescribed within premises of located in the farm of Shri standards M/s Stagot Potatoes Ambarambhai P Gothi in consent Products LLP toward south side behind order (800 Ft) unit. (500 Ft) 1 2 pH# 6.5 to 8.5 7.37 7.52 Total Dissolved 2100 674 1318 solid (TDS) mg/l Chloride mg/1 600 120 460 Sulphate mg/1 1000 202 151 COD mg/l 100 6 9 BOD(3 daysat 30 0.68 0.8 27 C) mg/l Sodium 26 8 18 Absorption Ratio (SAR) Copiesof the analysis reports are enclosed Annexure-E. The analysis reports of water samples of bore weils, all parameters are within GPCB prescribed norms as mentioned in Consent order.

Latest Position of the plant 1. The unit was visited on 05.03.2021. Production plant was found in operation. The person contacted Shri Bharat Gothi (CEO) of the plant informed that the production plant was started from 19.02.2021 and given the following details like quantity of raw material used, quantity of final product manufactured, generation of fiber/disposed and waste water generation and discharge after treatment.

: . Treated Raw Final Fiber ——s rons)nin material Product generate/disposed ca waer used (ton) (ton) (Ton) (KL)

19.02.2021 11 110 15.4 41 145

20.02.2021 13 113 18.2 45 185

22.02.2021 14 140 19.6 55 200

24.02.2021 12 120 18 42 170

25.02.2021 12 120 17.6 44 175

26.02.2021 11 110 15.2 41 145

28.02.2021 12.5 125 17.5 42 177

03.03.2021 13 130 18.2 46 180

02.03.2021 13.5 135 18.9 47 190

04.03.2021 14 140 19 52 200

GUJARAT POLLUTION CONTROL BOARD 345 (Regional office-Palanpur) war Room No: 20 to24, 3" Floor,JillaSevaSadan-2,Joravar Palace, Palanpur-385001,Dist.-Banaskantha WF Phone: (02742)251300,251301 WebSite:-gpcb.gujarat.gov.in Email:[email protected] XGN Site:-gpcbxgn.gujarat.gov.in

During visit all the ETP units are found in operation. The treated waste water is being discharged in to near by agriculture farms. One sampleis collected for further analysis to know the quality of treated waste water. They have provided about 100 nos of fogger system around the ETP and periphery of the factory to control odour are found in operation. Some photographsare given below.

Photo showing spraying of fragrance

GUJARAT POLLUTION CONTROL BOARD 346 ee (Regional office-Palanpur) Room No: 20 to24, 3 Floor, JillaSevaSadan-2, Joravar Palace, Palanpur-385001, Dist.-Banaskantha = Phone:(02742)251300,251301 WebSite:-gpcb.gujarat.gov.in Email:[email protected] XGN Site:-gpcbxgn.gujarat.gov.in

3. The fiber waste generated from the manufacturing process which is being directly dumpingin to truck to dispose at M/S Green Earth Biogas Pvt.Ltd, located at plot no-442, village-Kukda, Ta- Muli, Dist-Surendranagar. (which is Biogas generation plant) the photographs waste dumpingin to truck. oo te Photographs showingfiber waste dumpingin to truck

4. Industry has planted trees along with the periphery of the plant. 5. Industry has 1 boiler having capacity of 2 TPH, using imported coal as a fuel. Provided Multi cyclone separatoras Air pollution control device. One flue gas sample from stack/chimney was collected for analysis. 6. No Air pollution generation source from manufacturing process. 7. Industry has providedflare stack for flaring of gases generated from the Anaerobic Digesters.

Photographs showingflare 4- — GUJARAT POLLUTION CONTROL BOARD 347

(Regional office-Palanpur) es Room No: 20 to24, 3" Floor, JitllaSevaSadan-2, Joravar Palace, Palanpur-385001, Dist.-Banaskantha waaay Phone: (02742)251300,251301 WebSite:-gpcb.gujarat.gov.in Email:[email protected] XGN Site:-gpcbxgn.gujarat.gov.in

Observations: ® Nosmell/odour wasfelt outside the factory premises. e Slight smell wasfelt near effluent treatment plant. ® Contacted few people in the nearest village Sundha regarding foul smell of the factory. The following contacted persons were informed that presently no smell wasfelt from the factory. Shri Bhikhabhai Narsinhbhai Patel (Ex.Sarpanch) Shri Babubhai Dosajibhai Prajapati Shri Hiteshbhai Chamanbhai Pancha! (Mahavir Welding Works) Shri Manubhai devabhai Antiya

Shri Becharbhai Pasvabhai Patel panos Shri Jayeshbhai Ishwarbhai sambad Shri Shantibhai Shankarbhai Vora

Shri Sombhai Devabhai Patel rae ® Contacted few personat Primary Health Center (PHC)in village Sundha regarding foul smell of the factory. They informed that no foul smell was observed/felt. The PHC is located near to the factory. ® We also contacted applicant Shri Gangarambhai Narsinhbhai Karnavat (applicant) who has madeapplication in the Hon’ble NGT . He has informed that foul smell wasfelt for the last 15 days.

Date:- 05/03/2021 Place:- village- Sundha, Palanpur me inols (T.A.Trivdei) (M.S.Dasari) Scientific Officer Regional Officer 348

Annexure-A es =5 Sa4 SS re LE WSS teres -_ 349

Inspection Report

Name and Adrees ofthe unit:- M/S Stagot Potatoes Products LLP, Survey No. 675/1, At Sundha, Ta-Palanpur, Dist-Banaskantha. Date of visit:- 08/10/2020 Person contacted:- Mr. Vipul Gothi (Manager) Visited by:- 1, M.S.Dasari (Regional Officer) 2. N.P.Chaudhary (Sr. Scientific Assistant),

Observations:-

M/S Stagot Potatoes Products LLP (PCB ID: 49934) was visited on dated 08/10/2020 wrt Hon’ble National Green Tribunal, Principal Bench, New Delhiin O.A No. 108/2019 (WZ) -— order dated on 28/09/2020 Gangarambhai Narsinhbhai Karnavat Vs. Stagot Potatoes Products LLP & Ors, During visit unit is found not in operation. Person contacted informed that the plant is totally shut downfromJ uly-2020 due to non-avai lability of raw materials. ETP was foundidle condition. No smell was felt in and around the factory premises. The following instructions issued at the time of inspection. |. At present your production plant notin operation. Whenever Start the production inform to the Board.

Ww Wheneverstart the production plant all deodorant system should be in operation efficiently to control odour/foul smell .

\ : bevel (N.P,Chaudhary) (M.S.Dasari) Sr. Scientific Assistant), Regional Officer 350

Annexure-B 351

otagot Potatoes Product LLP

DATE:- 13/10/2020

To,

Regional Officer

Gujarat Pollution Control Board,

lilla Seva Sadan — 2, Third Floor,

Jorawar Palace,

Palanpur-385001.

Subject: - Production status

Respected sir,

Weare informing the production Status of STAGOT POTATOES PRODUCTLLP- SUNDHA.

TA-PALANPUR,That the last production was taken on 9"of July-2020 For 22 hrs, After that no

production has been taken place due to raw material short fall.

202.4 . The next expected production will be in January Howeverin case we found raw material

hefcre that than we will inform to the board prior to preduction

This information has been given to the board of productionstatus. le cr nh Ce OO None Regards » 16 fe 2 2 w

Thanking you LLP For, Stagot Potatoes Product

(lle Partner

74, Shree Arcade, Abu Highway, Palanpur - 385001, Dist. B.K., Gujarat, India.

Lo i”

352

Annexure-C *e GUJARAT POLLUTION CONTROL BOARD 353 (Regional office-Palanpur) Room No: 20 to24, 3Floor, JillaSevaSadan-2, JoravarPalace, Palanpur-385001, Dist.-Banaskantha Phone: (02742)251300,251301 WebSite:-gpcb.gujarat.gov.in Email:[email protected] XGN Site:-gpcbxgn.gujarat.gov.in Action Taken Report Subject:- Hon. NGT Matter No. OA 108/2019(W2) (1.A. No-162/2020)in the Principal Bench, New Delhi- Gangarambhai Narsinhbhai Karnavat Vs. Stagot Potatoes Products LLP &Ors. ’ Reference:- 1. Hon’ble NGT order dated 26/06/2020 2. Hon’ble NGT order dated 28/09/2020

M/S Stagot Potartoes Products LLP, Survey No. 675/1, At — Sundha, Ta — Palanpur, Dist - Banaskantha was inspected on 04/07/2020: with reference to Hon’ble National Green Tribunal, Principat Bench,New Delhi in O.ANo.108/2019(WZ) {I.A.No-162/2019) Gangarambhai Narsinhbhai Karnavat Vs. Stagot Potatoes Products LLP &Ors. order dated 26.06.2020 directed Regional Officer, State Pollution Control Board to visit the place and submit factual and action taken report to the Hon’ble court. The Regional Office, Gujarat Pollution Contro! Board, Palanpur has submitted Action Taken Report to the Hon’ble NGT, [email protected], [email protected], [email protected] along with the copies of (a) Inspection reports (b) Directions issued to the industry (C) Bank guarantee forfeit letter (d) Consent to operate order of unit (e) Analysis report of Bore well samples through E-mail on dated 22.09.2020. Again the Hon’ble courts order on dated 28.09.2020 the Regional Officer, State Pollution Control Board is directed to monitor further and submit action taken report to the Hon’ble NGT. Shri M.S.Dasari (Regional Officer), Shri N.P.Chaudhary(Sr. Scientific Assistant), Regional Office, Gujarat Pollution Control Board, Palanpur, Gujarat was visited the industry on 08/10/2020 and it was found totally closed and no smell/odour was felt in around the factory. Copy of the visit/inspection report is Annexure-A The person contacted informed that the production plant wastotally closed due to nonavailiblity of raw materials. On dated 13/10/2020 the industry has submitted a letter stating that the last production was taken on 09.07.2020 for 22 Hrs in operation than after there was no production has been taken til! date. The next expected production will be in the month of January-2021. Copy of the letter dated 13/10/2020 is Annexed-B. Again the unit was visited on 07/11/2020 by the Regional Officer, Shri.M.S.Dasari and Shri T.A.Trivedi, Scientific Officer, Regional Office, Gujarat Poilution Contro! Board, Palanpur, Gujarat, the industrial plant is found totally closed due to nonavailiblity of raw materials (Potatoes). No smell/odour was felt in and around the industry. Permissions given to M/S Stagot Potatoes Products LLP: M/S Stagot Potatoes Products LLP, Survey No. 675/1, At — Sundha, Ta — Palanpur, Dist — Banaskantha, Gujarat has obtained Consent to Establish (CTE) from Gujarat Pollution Control Board for manufacturing of Starch from Potatoes @ 1080 MT/M vide CTE No — 77473, dated — 28/03/2016. Further the unit was granted Consent to Operate vide letter dated 08/04/2019 up to 30/06/2022 to operate industrial plant for manufacturing of starch from potatoes. Subjected to the canditions specified in the order.

44 Location of the industry showing on google map (500 meters radius) 354

Putes en une Path Polygon Co che 3C path =D pohygcn Mare Te Cour Mere ne ca a ee Pa them On dle Grosed 1 > Radian: S0C.as Metery ~

: ara S140 Hecores Ag D Sreurterenee: 3,195.69 “ers

Y Mouse Navigation

eA ace t f 114 |SERaN ERS: yey a The map showsthe nearest village is Sundha @500meters away from unit and the other side of the unit/Plant area are agriculture land/fields. The village schoolis also beyond the 500 meter from the location of the unit/plant. 4. Manufacturing process The raw material potatoes washing with water to remove coarse particles and sand, then after the potatoesare crushed in a Rasping machinetill it becomes potato slurry is a mixture of starch granules, fiber and water. The potatoes slurry is then fed to hydro cyclone machine where the starch particles, fibers and water part (i.e. process effluent) are separated. Starch with moisture content is then fed to spin flash dryer to get final product, ie. white starch powder. Entire process cycle time is about 22 hours. 5. Source of waste water/fibre waste generation: Atfull capacity of plant a) Washing of potatoes — 25 KL/D(Diluted stream) b) Process waste water (Concentrated effluent stream) -275KL/D(Waste water seprated from hydro cyclones). Total waste water generation- 300 KL/Day. c) Fibre waste - Approx. 7MT/Day(Fiber separated from hydro cyclones) 6. Treatment of Waste Water The waste water generated from the washing section of the raw material is being directly collectedin collection tank, another waste water stream generated from process after removal of the fibre content in the decanter is being sent to collection tank for further treatment. The industry has provided Effluent TreatmentPlat consisting of following units. ® Collection tank Flash Mixer (Notin use) Flocculation Tank (Notin use) Primary Clarifier (Not in use) Conditioning Tank Anaerobic digester(CSTR- 2 nos) First stage Aeration tank First stage Secondary settling tank Second stage Aeration tank Second stage secondary settling tank Treated waste water holding tank Sandfilter (Not in use) Carbonfilter (Not in use) Decanter

7. Disposal of Treated waste water Treated waste water from the ETP is discharged onto the 355 agricultural farms of 42 Acres through undergroundpipeline surrounding the units. Unit has made MoU with Farmers.

Ling Path | Patyonn { Ceste ‘ Mpath | 3X) polygon {Measure the distance or rea af a.geanemé shane on me ground | 1081.95 Meke = 3.52; Hectares of

te J mo Eeoe a Treated wastewater disposal agriculture land @ 1.2 Km away from factory/industry

Treated wastewaterdisposal agriculture land adjoining to the factory/industry 8. Managementof Fiber Waste & ETP Sludge: The fiber waste is generated from the manufacturing process, which is supplied through tankers to M/s Goverdhan nathji Energies LLP, Vill-Pij, Ta-Vaso, Dist-Nadiad, Gujarat which is Bio Gas generation plant. The sludge generated from the Effluent Treatment Plantis also being disposed along with fiber waste. At the time of visit, no stock of fiber waste and ETP sludge are observed stored in the unit. Month wise quantities of fiber waste send to M/s Goverdhan nathji Energies LLP are shownbelow.

Month Fiber Waste sent to M/s Goverdhannathji Energies LLP (Quantity in MT)

January-2020 Nil February-2020 50

March-2020 130

April-2020 Nil

May -2020 Nil

June -2020 300 July-2020 Nil Aug-2020 Nil

Sept-2020 Nil

Oct-2020 Nil

9. Air Pollution: Unit has oneboiler having capacity of 2 TPH, using importedcoalas a fuel. Unit has provided Dust collector (Multi Cyclone Separator) as Air Pollution Control Device. Unit has also provided stack monitoring facility. There is no process emission from the manufacturing process. As no activity other than unloading of potatoesis going on, noise level is the industry is found normal during the visit. 10. Odour control Management: The industry has provided fogger system for control of odour. In fogger system the industry is using Rose Fragrance Liquid (1 Liter in 1000 Liter of Water) for continues spraying on the top of Anaerobic reactor/Digester. Industry has also provided Decanter to remove/ reduce/minimize fibre particles from process waste water before enteringin to effluent treatment plant collection tank so that there should not be any septic condition in the collection tank.

11. Quality of Ground Water: 356 The industry has provided one number of bore well within the premises and entire fresh water requirement of industry is met by the bore well water. Bore wells are also there in the surrounding farms. Physical characteristics of the water abstracted from the said bore wells is apparently normal. a) Four no of ground water sample are collected by the Regional office palanpur on dated 04/07/2020 from following points. The results are as under. Locations Parameters GPCB Borewell Borewell Borewell Borewell prescribed located sample sample sample standards within collected from collected from collected from in consent M/S nearby nearby borewell order Stagot borewell borewell located Potatoes toward south towards North within Products side of stagot side agreement LLP unit potato unit of stagot agricultural ] 2 potato land, unit, whichis which is about 200m about 1.1 away Km away from the unit from the 3 unit. 4 pH# 6.5 to 8.5 7.44 7.79 7.20 8.34 Total 2100 758 1170 728 866 Dissolved solid (TDS) mg/l Chloride mg/| 600 90 300 110 140 Sulphate mg/l 1000 55 168 78 63 COD mg/1 100 7 11 14 6 BOD (3 days 30 0.75 0.72 1.42 0.89 at 27 C) mg/l Sodium 26 7 12 7 12 Absorption Ratio (SAR) b) Two ground water samples are collected during the visit by the vigilance team, GPCB, Gandhinagar on dated 17/07/2020 from the following sources, The results are as under. Locations Parameters GPCB Bore well located Bore well water sample prescribed within premises of| located in the farm of Shri standards M/s Stagot Potatoes Ambarambhai P Gothi in consent Products LLP toward south side behind order (800 Ft) unit. (500 Ft) 1 2 pH# 6.5 to 8.5 7.37 7.52 Total Dissolved 2100 674 1318 solid (TDS) mg/I Chloride mg/l 600 120 460 Sulphate mg/l 1000 202 151 COD mg/| 100 6 9 BOD(3 days at 30 0.68 0.8 27 C) mg/l Sodium 26 8 18 Absorption Ratio (SAR)

The analysis reports of water samples of bore wells, all parameters are within GPCB prescribed norms as mentioned in Consent order.

Lh 12. Action taken by Gujarat Pollution Control Board sofar for non compliance of the conditions 357 specified in the consent order are as under:

Sr.No Date of Inspection Action taken

1 21-22/08/2017 Directions under section 33 A of the water act — 1974 for disconnection of power supply

2 26/12/2017 Directions under section 33 A of the water act — 1974 for disconnection ofpower supply

3 28/03/2019 Directions undersection 33 A of the water act — 1974 for disconnection of power supply 4 28/03/2019 Forfeit of Bank Guarantee of amount Rs 250000/-

13. Photographs showing effluent treatment plant units found empty at the time of visit on 07/11/2020

= a i mr a2

Flash Mixer & Flocculation Tank Aeration Tanks

Clarifier Treated Waste Water Tank

1S 358

Photographs showing Fogger System on Anerobic Digester

14. The following suggestions/written remarks given to the industry on 07/11/2020 to control odour/smell. a) Potatoes fiber should be disposed off within 24 Hrs from the factory to Bio Gas Plant. b) Effluent primary collection should be empty after the production batch is completed by transfer the effluent in to Anaerobic Digester/Reactor so that the to avoid septic condition of effluentin the collection tank. c) The effluent collection tank should be covered completely to control odour/smell before starting the production. d) Increase fogger system in ETP area and operate efficiently and also provide fogger system along the periphery of the factory before starting the production. e) Operate effluent treatment plant efficiently and improve effluent handling system to minimize leakages. f) Monitor VOC's in the factory premises and submit report to the board after starting the production. g) Plant more trees along the periphery of the factory.

tise hnJi Date:- 07/11/2020 T.A.Trivedi M.S.Dasari Place:- Sundha, Palanpur Scientific Officer Regional Officer

16 359

Annexure-D 360

Inspection Report

Nameand Address of the unit:- M/s. Stagot Potatoes Products LLP, Survey No. 675/1,At: Sungha, Ta: Palanpur, Dist: Banaskantha. Dateof Visit:31/12/2020 Person Contacted: Mr,BharatbhaiGothi (Partner) Visited by: 1. T. A. Trivedi (Scientific Officer) 2. N. P. Chaudhary (Sr. Scientific Assistant)

Observations: M/S Stagot Potatoes Products LLP (PCB ID: 49934) wasvisited on dated 31/12/2020 wrt Hon‘ble National Green Tribunal, Principal Bench, New Delhi in 0.A No. 108/2019 (WZ)- GangarambhaiNarsinhbhaikarnavat Vs. Stagot Potatoes Products LLP &Ors. During visit unit is found not in operation. Person contacted informed thatplant is totally shut down from July-2020 due to non-availability of raw materials. No smell was felt in and around factory the premises. The following instructions issued at the time of inspection. ° At Present your production plant not in Operation. Wheneverstart the production inform to the board.

(yp. eas N. P. Chaudhary T. A. Trivedi (Sr. Scientific Assistant) (Scientific Officer)

(- 361

Annexure-E 362

aia893 ANALYSIS REPORT FOR Gujarat Pollution Control Board, REaSe, WATER / WASTE WATER SAMPLE Central Laboratory,EigEig )) Paryavaran Bhavan© oe Sample 11D:284704 - Analysis Completion:04/08/2020 f Sector-10A wt“eewest

Manufacturing of Starch/Sago / LAB Inward : 73306 Gandhinagar-382010 /aa

Accreditation Standards & NABL Certificate Details : T-2105 / ISO/LEC 17025:2005 / 21/12/2011 / 20/12/2013 . TEST REPORT .

| Test Report No. : 73306 Date: 04/08/2020

1. Nameof the Customer ; Stagot Potatoes Product - 49934 2. Address : Survey No. 675/1,At Sundha,- Palanpur-385518, Taluka : Palanpur, District : Banaskantha, GIDC : Not In Gide 3. Nature of Sample : REP-Representative/Grab, (Insp Type : VIG-By Vigilance Team) 4. Sample Collected By : J.M. Mahida, D.E.E 5. Quantity of Sample Received : S lit. 6. Code No.of the Sample : 284704 7. Date & Time of Collection & Inwarding : 17/07/2020 , (1230 to 1230) & 18/07/2020 8. Date of Start & Completion ofAnalysis : 18/07/2020 & 04/08/2020 9. Sampling Point : From Borewell water Sample located in thefarm of Shri Ambarambhai ?.Gothi toward 10. Flow Details (Remarks) i= 11. Modeof Disposal : used for irrigation purpose. 12. Ultimate Receiving Body : Ground Dischsrge 13. Temperature on Collection : 30 & pH Range on pH Strip :7 to 8 14, Carboys Nos for : & Color & Appearance :Colourless 15. Water Consumption & W.W.G (KLPD) : Ind :325.000 , Dom :10.000 & Ind :300.000 , Dom 28.000 ‘sr Parameter Unit Test Method __ | Range of Testing | Result “|

1| Temperature Centigrade 1S: 3025 (Part — 9) — 1984(Reaffinned 2006) \_LAmbient oC - 60 oC 30 |_2|pH : ___|_PHUntts _|4500 H+ B APHA StandardMethods 22ndedi.2012 |1-14 pHvalueAsor| 7.52

| 5|Suspended Solids mil | Gravimetric method. (2540 D APHA Standard Method| 2 — 10000‘mg/L | 04

€ Ammonical Nitrogen | mgil 1).Titrimetric method (4500 NH3 8 &C APHA Standal| 1 - 2000 mg. 0.25

10Ol & Grease mgfl | Liquid — Liquid Partition Gravimetric method. (6520 B 01 -— 1000 mg/l BDL 11/Sulphide mg ‘|APHA (22nd Edi.)4500-62-F-iodometric Method | 1-500.0 mgt | 005

12B.0D {3 Days 270C) mgf i3—~Day BODtest. (IS 3025 (Part 44) 1993 Reaffirmec| 05-50000 mg/l | 0.80 13 Sodium AbsorptionRatio(SAR) ____|__SAR__|1811624-1986(Reaffirmed 2009) [1-50 vMedi. | 4

Laboratory : Approved By:682-aee_682 Dt.: 04/08/2020

Dr. &. N. Agravat

Fleld Observation :

Note : 1.* - These parameters are NOT covered under the scope of NABL. 2. The resulis refer only to the tested samples and applicable parameters. Endorsement of products is neitherinferred nor implied. 3. Samples will be destroyed after 10 days from the data of issue of test report unless otherwise specified. 4, This report is not to be reproduced wholly or in part or used In any advertising media without the permissian of the Board in writing. 5. The Board is not responsible for the authenticity for the samples not collected by the Board’s officials. 6. Total liability of our laboratory is limited to the invoiced amount. Anydispute arising out of this report is subject to Gujarat Jurisdiction only. 7. Permissible Limits: as per Schedule VI of EPA Rules, 1986 as ammended by Ser:-4 and Third ammendment 1993 for Effiuents

Perea ANALYSIS REPORT FOR Gujarat Pollution Control Board, fea, WATER/ WASTE WATER SAMPLE Central Laboratory,fs)i Paryavaran Bhavan \\ Sample ID:284703 - Analysis Com»letion:04/08/2020 I Sector-10A eye Gandhinagar-382010 7 x Manufacturing of Starch/Sago / LAB Inward : 73307

Accreditation Standards & NABL Certificate Details : T-2105 / ISOAEC 17025:2005 / 21/12/2011 / 20/12/2013

TEST REPORT —_——. Test ReportNo. : 73307 _ ———__ Date: 04/08/2020 |

1. Name of the Customer : Stagot Potatoes Product - 49934 2. Address : Survey No. 675/1,At Sundha,- Palanpur-385518, Taluka : Palanpur, District : Banaskantha, GIDC : Not In Gide 3. Nature of Sample : REP-Representative/Grab, (Insp Type : VIG-By Vigilance Team) 4. Sample Collected By : J.M. Mahida, D.E.E 5. Quantity of Sample Received : Slit. 6, Code No. of the Sample : 284703 7. Date & Time of Collection & Inwarding : 17/07/2020 , (1130 to 1130) & 18/07/2020 8. Date of Start & Completion ofAnalysis : 18/07/2020 & 04/08/2020 9. Sampling Point : From Borewell located within premises of M/s Stagott Potatoes Products LLP Unit. ~ 10. Flow Details (Remarks) ie 11. Mode of Disposal : Used for industrial and domestic purposes within plant 12. Ultimate Receiving Body : Ground Dischsrge 13. Temperature on Collection : 30 & pH Range on pH Strip :7 to & 14, Carboys Nos for : & Color & Appearance :Colourless 15, Water Consumption & W.W.G (KLPD) : Ind :325.000 , Dom :10.000 & Ind :300.000 , Dom :8.006

Unit Test Method Range of Testing Result | Gentigrade IS: 3025 (Part 9) — 1984(Reaffirmed 2006) AmbientoC - 600C | 30 PH Units 4500 H+ B APHA Standard Methods 22nd edi.2012 [1-14 pHvalueAsor 7.87 PLCo.Sc. (2120BAPHA Standard Methods 22nd edi 2012 (2-to8Hazen&1-50' ‘5 | 4 Total Dissolved Solids mg Gravimetric method. (2540 C APHA Standard Method|10— 200000 mg/L | 674 | 5|Suepended Solids mgl Gravimetric method. (2540 D APHA Standard Method] 2 — 10000 mg/L oC 6Ammonical Nitrogen | mgil 1).Titrimetric method (4500 NH3 B & GC APHA Standes| 1 - 2000 mgi. 0,22

7 |(Chioride | mgt _—|Argentometric method. (4500 CI? B APHA Standard hi 1 - 50000 mg/l 120 | 8|Sulphate | mgs APHA(22nd edi}4500 SO4 E - '2-40mgi 202 “9|Chemical Oxygen Demand | mgt | APHA (22nd _Edition}- 5220 B Open Reflux Method-2! 5.0- 50000 mail 60

|100U&Grease | mgt |Liquid= Liquid Partition Gravimetric method. (5520 B [01 - 1000 mg/l BDL

| 14]Suiphide ___|__ mot |APHA@2nd Ed}4500-s2-F~iodometric Method | 1-600.0 mgt 007 | 12B.0.D (3 Days 2700) mg |DayBODtest. (1S 3025(Part 44) 1993 Reaffirmec| 05-50000 mg/l 0.88

| 13,Sodium Absorption Ratio(SAR) SAR _|1S11624-1986(Reaffirmed 2009) 1-50 vMeqt =|_—s08

Laboratory Remarks : Approved By:682-aee_682 Dt: 04/08/2020 ~ Ayes

Dr. S. N, Agravat

Fteld Observation :

Note : 1.* - Thase parameters are NOT covered under the scope of NABL. 2. The results refer only to the tested samples and applicable parameters. Endorsement of products is neither inferred nor implied. 3. Samples will be destroyed after 10 days from the date of issue of test report unless otherwise specified. 4. This report Is not to be reproduced wholly orin part or used in any advertising media without the permission of the Board In writing. 5. The Board is not responsible for the authenticity for the samples not collected by the Board's officials. 6. Totalliabllity of our laboratory is limited to the invoiced amount. Any dispute arising out of this report is subject to Gujarat Jurisdiction only. 7. Permissible Limits: as per Schedule Vi of EPA Rules, 1286 as ammended by Second and Third ammendment 1993 for Effuents

14 364

ANALYSIS REPORT FOR Gujarat Pollution Control Board, <¢.eee WATER / WASTE WATER SAMPLE Central Laboratory / Eiel e yy \ Paryavaran Bhavan 5 f i Sample ID:283658 - Analysis Completion:20/07/2020 J Sector-10A —Seae

Manufacturing of Starch/Sago / LAB Inward : 73008 Gandhinagar-382010 po \

Accreditation Standards & NABL Certificate Details : T-2165 / ISOAEC 17025:2005 / 21/12/2011 / 20/12/2013

TEST REPORT = das Test Report No.: 73008 a 7 Date: 21/07/2020

1. Nameof the Customer : Stagot Potatoes Product - 49934 2, Address : Survey No. 675/1,At Sundha,- Palanpur-385518, Taluka : Palanpur, District : Banaskantha, GIDC : Not In Gide 3. Nature of Sample : REP-Representative/Grab, (Insp Type : OTH-Others/Higher Authority) 4. Sample Collected By : Muralikrishna.Dasari, R.O Head §. Quantity of Sample Received : Slit. 6. Code No.of the Sample : 283658 7. Date & Time of Collection & Inwarding : 04/07/2020 , (1015 to 1020) & 07/07/2020 8. Date of Start & Completion ofAnalysis : 07/07/2020 & 20/07/2020 9. Sampling Point : Borewell sample collected from nearby borewell toward North side of stagot potato uni 10. Flow Details (Remarks) :- 11. Mode of Disposal to 12. Ultimate Receiving Body : Ground Dischsrge 13. Temperature on Collection : 34& pH Range on pH Strip :@ 7 - on pH strip 14, Carboys Nos for : 3& Color & Appearance :Colorless 15. Water Consumption & W.W.G (KLPD) : Ind :325.000 , Dom :10.000 & Ind :300.000 , Dom 28,000

Sr! Parameter Unit Test Method | Range ofTesting Result “{|Temperature | Centigrade 1S: 3025 (Part —9) — 1984(Reaffirmed 2006) |AmbientoC - 600C 34 _2/pH - | pH Uns [4500 H+ B APHA Standard Methods 22nd edi.2012 [1-14 pHvelueAsor| 7.20

3 | Colour | PL.Co.8c. 2120 B APHA Standard Methods 22nd edi. 2012 2-to 99 Hazen & 1-50 05

7 |Chioride - | _mgi__| Argentometric method, (4500 Ci? B APHA Standard Kt - 60000 mgf 110 8 Sulphate a [| mg APHA(22ndedi)4500 S04 E 2-40mgil | 78

_9| Chemical OxygenDemand ‘mg —_|APHA (22nd Edition} 6220 B Open Reflux Method-2/5.0-50000mgh = | 14 100 & Grease mol Liquid — Liquid Partition Gravimetric method. (8520B|01 - 1000 mii | BDL | mgl | APHA (22ndEdl.)4500-s2-F —lodometric Method 1-800.0 mg/l | BDL | ‘11\Sulphide 12.B.0.D (3 Days 270C) = mg 3— Day BODtest. (IS 3025.(Part444) 1993 Reaffirmec| 05-50000mgi | 142

13/Sodium Absorption Ratio(SAR) [SAR _|1S11624-1986(Reaffirmed 2009) 1-50 vMeq/L [7|

Laboratory : Approved. By:682-aee_682 Dt: 21/07/2020

Dr. S. N. Agravat

Field Observation: borewell sample collected from nearby borewell toward north side of stagot potato unit (holding tank)

Note : - These parameters are NOT covered under the scope of NABL. 2. The results refer only to the tested samples and applicable parameters. Endorsement of products is neither inferred nor implied. 3. Samples will be destroyed after 10 days from the date of issue of test report unless otherwise specified. 4, This report is not to be reproduced wholly or In part or used In any advertising media without the permission of the Board In writing. 5. The Board Is not responsible for the authenticity for the samples not collected by the Board's officials. 6. Totalliability of our faboratory Is limited fo the inveiced amount. Any dispute arising out of this report Is subject to Gujarat Jurisdiction only. 7. Permissible Limits: as per Schedule Vi of EPA Rules, 1986 as ammended by Second and Third ammendment 1993 for Effiuents

2). O

365

etUPT gras ANALYSIS REPORT FOR Gujarat Polintion Control Board, «¢ PEERcN WATER / WASTE WATER SAMPLE Central Laboratory |£4(éi SS3 : Paryavaran Bhayan ve wes ; Sample 1D:283656 - Analysis Completion:20/07/2020 fi Sector-10A ee” Manutacturing of Starch/Sage / LAB Inward : 73012 Gandhinagar-362610 i} \ N

Accreditation Standards & NABL Certificate Details : T-2105 / ISO/IEC 17025:2005 21/12/2011 / 20/12/2013 a TESTREPORT ee Test Report No. : 73042 __ Date: 21/07/2020 1, Nameof the Customer Stagot Potatoes Product - 49934

2. Address eoSurvey oe No. 675/1,At Sundha,- Palanpur-385518, Taluka : Palanpur, District : Banaskantha, GIDC : Not In Gide 3. Nature of Sample : REP-Representative/Grab, (Insp Type : OTH-Others/Higher Authority) 4, Sample Collected By : Muralikrishna.Dasari, R.O Head 5. Quantity of Sample Received : Slit. 6. Code No.of the Sample : 283656 7. Date & Time of Collection & Inwarding 04/07/2020 , (0930 to 0935) & 07/07/2020 8. Date of Start & Completion ofAnalysis : 07/07/2020 & 20/07/2020 9. Sampling Peint : -Borewell Sample collected from Borewell of Stagot unit (Within premises) ~ 10, Flow Details (Remarks) i 11. Modeof Disposal i 12, Ultimate Receiving Body : Ground Dischsrge 13. Temperature on Collection : 34 & pH Range on pH Strip :@ 7 - 8 on strip 14, Carboys Nos for : 1 & Color & Appearance :Colorless 15. Water Consumption & W.W.G (KLPD) ? Ind :325.600 , Dom :10.000 & Ind :300.000 , Dom :8.000

Sr Parameter Unit Test Method Range of Testing Result 1|Temperature a Centigrade IS: 3025 (Part — 8) — 1984(Reaffirmed 2006) _ AmblentoC - 600C | 34 2 |pH pH Units 4500 H+ BAPHA Standar’ “sthods 22nd edi.2012 1-14 pHvalueAsor| 7.44

3 Colour : PLCo.Sc. | 2120 BAPHA Standard Methods 22nd edi. 2012. |2-to99Hazen&1-50| 05

4 Total Dissolved Solids mol Gravimetricmethod, (2540 C APHA Standard Method 10 - 200000 mg/L 758 5 | Suspended Solids | mgt Gravimetric method. (2540 D APHA Standard Method| 2 — 10000 mg/L 02

| 8 Sulphate magi APHA(22nd edi)4500 S04 E |2-40mgii [ §5 8|Chemical Oxygen Demand =| ~~|APHA(22nd Edition} 5220B Open RefluxMethod-2)/5.0-50000mgl = 7 | 10 Oil & Grease mg Liquid — Liquid Partition Gravimetric method. (5520 B 0t — 1000 mg | BDL 11| Sulphide mgi APHA (22ndEdi.}4500-82-F iodometric Method 1-500.0 mg/l | BDL 12B.0.D(3 Days 270C) rogi 3— Day BODtest. (IS 3025(Part 44) 1893 Reaffirmec| 05-6000 mg/ | 0.76 | 13SodiumAbsorption Ratio(SAR) SAR 1$11624-1986(Reaffirmed 2009) 1-60 vMeqi/L. 7

Laboratory : Approved. By:682-aee_682 DL: 21/07/2020 adsro

Dr. S. N. Agravat

Field Observation: borewell sample collected from borewellof stagot unit (within premises)

Note : .* - These parameters are NOT covered under the scope of NABL. 2, The results refer only to the tested samples and applicable parameters. Endorsement of products is neither inferred nor implied, 3. Samples will be destroyed after 10 days from the date of Issue of test report unless otherwise specified. 4. This report Is not to be reproduced wholly or in part or used in any advertising media without the permission of the Board In writing. 5. The Board is not responsible for the authenticity for the samples not collected by the Board's officials. 6, Totaltlability of our laboratory is limited to the Invoiced amount. Any dispute arising out of this report Is subject to Gujarat Jurisdiction only. 7. Permissible Limits: as per Schedule Vi of EPA Rules, 1986 as ammended by Second and Third ammendment 1993for Effluents

a Z| 366

ANALYSIS REPORT FOR Gujarat Pollution Control Board, BeaOTa WATER / WASTE WATER SAMPLE Central Laboratory £( SY Paryavaran Bhavan |” (G Sample ID:283657 - Analysis Completion:20/07/2020 fi Sector-10A — ea? ie

Manufacturing of Starch/Sage / LAB Inward : 73007 Gandhinagar-382010 é

Accreditation Standards & NABL Certificate Details : T-2105 / ISO/IEC 17025:2005 / 21/12/2011 / 20/12/2013 ma ___TEST REPORT . ee . | Test Report No. : 73007 __ Date: 21/07/2020 / 1. Name of the Customer : Stagot Potatoes Product - 49934 2. Address : Survey No. 675/1,At Sundha,- Palanpur-385518, Taluka : Palanpur, District : Banaskantha, GIDC : Not In Gide 3. Nature of Sample : REP-Representative/Grab, (Insp Type : OTH-Others/Higher Authority) 4. Sample Collected By : Muralikrishna.Dasari, R.O Head §. Quantity of Sample Received : 5 lit. 6. Code No.of the Sample : 283657 7. Date & Time of Collection & Inwarding : 04/07/2020 , (0950 to 0955) & 07/07/2020 8. Date of Start & Completion ofAnalysis : 07/07/2020 & 20/07/2020 9. Sampling Point : Borewell samplecollected from nearby borewell teward south side of stagot potato unit 10. Flow Details (Remarks) : 11. Mode of Disposal 7 memeee 12. Ultimate Receiving Body : Ground Dischsrge 13. Temperature on Collection : 34& pH Range on pH Strip :@ 7 - 8 on pH strip 14, Carboys Nos for 2 & Color & Appearance :Colorless 15. Water Consumption & W.W.G (KLPD) Ind :325.000 , Dom :10.000 & Ind :300.000 , Dom :8.000

Sr. Parameter Unit Test Method Range of Testing | Result

‘1 Temperature , Centigrade |1S: 3025 (Part - 9)—1984(Reaffirmed 2006) |AmbientoC - 600C | 4

4 TotalDissolved Solids mgi | Gravimetric method.(2540 C APHA Standard Method] 10 — 200000 mg/L 4970 | 5 | Suspended Solids mg Gravimetric method. (2540 D APHA Standard Method! 2 ~ 10000 mg/L. | 02 __ 6Ammonical Nitrogen - mgt 1).Tirimetric method (4500 NH3 B & C APHA Standar|1 - 2000 moi O17 | 7[Chloride _ mgi —‘| Argentometric method.(4500 Ci? B APHA Standard hi1- 50000 mgl | 300. 8[Sulphate a mgil APHA(22nd edi}4500 SO4 E |2-40mg/ \ 468 |_9| Chemical Oxygen Demand ‘magi —_|APHA(22nd Edition} 5220 B Open RefluxMethod-2|6.0-50000mgi =| 1 10 Oil &Grease mf _| Liquid— LiquidPartition Gravimetricmethod.(5520B |01- 1000 mgf / BL 11|Sulphide mg —_—-| APHA(22nd Edi.}4500-a2-F lodomatric Method —_—_| 1-500.0 mgil | BDL

Laboratory : Approved. By:682-aee_682 Dt: 21/07/2020

Dr. S. N. Agravat

Fleld Observation: borewell sample collected from nearby borewell toward south side of stagot potato unit (holding tank)

Note : 1.* - These parameters are NOT covered underthe scope of NABL. 2. The results refer only to the tested samples and applicable parameters. Endorsement of products is neither inferred norimplied. 3. Sampleswill be destroyed after 10 days from the date of issue of test report unless otherwise specified. 4. This report Is not to be reproduced wholly or in part or used In any advertising media without the permissionof the Board in writing. 5. The Board Is not responsible for the authenticity for the samples not collected by the Board's officials. 6. Total lability of our laboratory Is limited to the involced amount. Any dispute arising out of this report is subject to Gujarat Jurisdiction only. 7. Permissible Limits: as per Schedule VI of EPA Rules, 1986 as ammmendad by Second and Third ammendment 1993 for Effluents

7)2- 367

pA 9 ANALYSIS REPORT FOR Gujarat Pollution Control Board, } 6FER WATER / WASTE WATER SAMPLE Central Laboratory Ei ‘3 Paryavaran Bhavan Na A , yy Sample 1D:283659 - Analysis Completion:20/07/2020 I Sector-10A RNa is

Manufacturingof Starch/Sago/ LAB Inward : 73011 Gandiinapsi362010 re

Accreditation Standards & NABL Certificate Details : T-2105 / ISO/IEC 17023:2005 / 21/12/2011 / 20/12/2013 TEST REPORT

TestReportNo.:73011 Date: 21/07/2020 1. Nameof the Customer Stagot Potatoes Product - 49934 2, Address Survey No. 675/1,At Sundha,- Palanpur-385518, Taluka : Palanpur, District : Banaskantha, GIDC : Not In Gide 3. Nature of Sample : REP-Representative/Grab, (Insp Type : OTH-Others/Higher Authority) 4, Sample Collected By : Muralikrishna.Dasari, R.O Head §. Quantity of Sample Received : Slit. 6. Code No. of the Sample : 283659 7. Date & Time of Collection & Inwarding : 04/07/2020 , (1050 to 1055) & 07/07/2020 8, Date of Start & Completion ofAnalysis : 07/07/2020 & 20/07/2020 9, Sampling Point : Borewell sample collected from borewell located within agreemented land (Holding tan 10. Flow Details (Remarks) t- 11. Mode ofDisposal i_— 12. Ultimate Receiving Bedy Ground Dischsrge 13. Temperature on Collection 34 & pH Range on pH Strip :@ 7 - § on pH strip 14. Carboys Nosfor 4& Color & Appearance :Slightly greenish 15. Water Consumption & W.W.G (KLPD) Ind :325.000 , Dom :10.000 & Ind :300.000 , Dom -8.000

| 6|Ammonical Nitrogen mgl | 4),Titrimetric method (4600 NH3 B & C APHA Standar| 1 - 2000 mg/l. 0.20

| 7| Chloride ‘mi —_—| Argentometric method, (4500 CI? BAPHA Standard §[1-50000mg s|S140

| 8|Sulphate magi APHA(22nd edi)}4500 $04 E 2-40mgil 63 |_8|Chemical Oxygen Demand | __ mai |APHA (22nd Edition)- 5220 B Open Reflux Method-2/ 5.0- 50000 mg 6 | 10 Oil & Grease maf Liquid — Liquid Partition Gravimetric method. (5520 B 01 — 1000 mail BDL

| 44/Sulphide mgf APHA (22nd Edi.)4500-s2-F iodometric Method 1-500.0 mg/l BOL | 12.B.0.D (3 Days 270C) omg 3— Day BODtest. (IS 3025 (Part 44) 1993 Reaffinmex| O5—60000 mg/l 089 | 43 Sodium Absorption Ratlo{SAR) SAR _|1S11624-1886(Reaffirmed 2009) 1-60 v Meq/L 12

Laboratory : Approved. By:662-aee_662 Dt: 21/07/2020 —Agpeniarss0 Dr. S. N. Agravat

Fletd Observation : borewell sample collected from borewell located within agreemented land use for disposai of treated wastewater (holding tank)

Note : 1.* - These parameters are NOT covered under the scope of NABL. 2. The results refer only to the tested samples and applicable parameters. Endorsement of products is neither inferred nor implied. 3. Sampleswill be destroyed after 10 days from the date of issue of test report unless otherwise specified. 4, This report Is not to be reproduced wholly or in part or used in any advertising media without the permission of the Board In witing. §. The Board is not responsible for the authenticity for the samples not collected by the Board's officials. 6. Totaltiabillty of our laboratory Is limited to the Involced amount. Any dispute arising out of this report is subject to Gujarat Jurisdiction only. 7. Permissible Limits: as per Schedule VI of EPA Rules, 1986 as ammended by Second and Third ammendment 1993 for Effluents