Limited Warranty → Refer to Pages 2 to 27

12_Non-turbo_MMNA_3rd.book Page 1 Tuesday, August 2, 2011 9:59 AM 12_Non-turbo_MMNA_3rd.book Page 2 Tuesday, August 2, 2011 9:59 AM

IMPORTANT

This manual contains warranties for two markets: (a) The United States (territory covered by MMNA) and (b) U.S. territories and possessions except Puerto Rico and the U.S. Virgin Islands. Please read the warranty that applies to your location. (a) For the United States (territory covered by MMNA): Limited warranty → Refer to pages 2 to 27. (b) For U.S. territories and possessions except Puerto Rico and the U.S. Virgin Islands: Limited warranty → Refer to pages 28 to 33. The maintenance schedule applies to both markets. Good maintenance is necessary to protect your investment and ensure proper performance. For information on correct maintenance, refer to pages 34 to 63. The warranty information in this manual does not apply to the Mitsubishi Lancer Evolution, Lancer RALLIART, Lancer Sportback RALLIART, Mitsubishi Raider truck or Mitsubishi i-MiEV. Please consult the individual warranty manual for those vehicles for applicable coverage terms.

Important Note (for the customers of Mitsubishi Motors North America Inc. (MMNA)):

Mitsubishi Motors also provides owners with a wide range of useful information, answers to FAQs (Frequently Asked Questions) and important contact numbers over the internet. Please visit our website at: http://www.mitsubishicars.com 12_Non-turbo_MMNA_3rd.book Page 1 Tuesday, August 2, 2011 9:59 AM

TABLE OF CONTENTS For the United States (MMNA) For U.S. territories and posses- Limited Warranty sions Limited Warranty (Except Introduction ...... 2 Puerto Rico and U.S.Virgin Islands) Customer Satisfaction...... 2 INTRODUCTION ...... 28 Warranty at a Glance ...... 4 Anti-Corrosion Perforation New Vehicle Limited Warranty ...... 6 Limited Warranty ...... 31 10/100 Powertrain Limited Warranty ...... 9 Emission Control System ...... 32 Anti-Corrosion Perforation Defect Warranty Limited Warranty...... 11 Performance Warranty Federal Emission Warranty...... 13 “California” Emission Warranty* ...... 17 Maintenance Notice to Consumers and Service precautions ...... 34 Customer Satisfaction...... 24 Selecting the proper Roadside Assistance...... 27 maintenance schedule ...... 34 Emission control system maintenance...... 35 Service station checks...... 35 Regular maintenance schedule...... 36 Severe maintenance schedule ...... 46 * Vehicles equipped with a California Certified Emission Control System and registered in the states of California, Connecticut, Maine, Maryland, Massachusetts, New Jersey, Oregon, Pennsylvania, Rhode Island, Vermont or Washington are also entitled to the California Emission Warranty. 12_Non-turbo_MMNA_3rd.book Page 2 Tuesday, August 2, 2011 9:59 AM

INTRODUCTION INTRODUCTION IMPORTANT: You must use the National Center for Dispute Settlement Mitsubishi Motors North America, Inc. (MMNA) wants to (NCDS) prior to seeking remedies through a court action thank you for purchasing one of our quality products. We pursuant to the Magnuson-Moss Warranty Act (“the Act”). are committed to assuring your satisfaction with your new However, if you choose to seek remedies that are not cre- 2012 Mitsubishi passenger car or sport utility vehicle. ated by the Act, you are not required to use NCDS, MMNA also wants you to be completely satisfied and although that option is still available to you. You must also invites you to visit a Mitsubishi Dealership for all your ser- use NCDS if you are seeking remedies under the “Lemon vice needs, both during and after the warranty period. Laws” of your state if your state statute requires you to do so. Please consult the Customer Satisfaction section of this CUSTOMER SATISFACTION manual and the Dispute Resolution Process brochure for MMNA and your Authorized Mitsubishi Motors Dealer are vitally more information about the NCDS program. interested in your satisfaction with our products and service. In the event a warranty or any other matter is not handled WARRANTY START DATE to your satisfaction, please discuss the matter with your This warranty starts on the date of original retail delivery or Mitsubishi Motors Dealership Management. original use, whichever occurs first. All references to mile- MMNA is also available to assist you with all your automo- age limitations are for actual odometer miles. tive needs. If you have questions or concerns your dealership cannot answer, please call MMNA’s Customer OBTAINING WARRANTY SERVICE Relations Department toll-free number1-888-648-7820 . To obtain warranty service, you must return your Vehicle to any Authorized Mitsubishi Motors Dealer or Authorized Dispute Resolution Process Service Center where such service will be performed with- If a problem persists, we encourage you to use Mitsubishi’s out charge for parts and/or labor. informal third party Dispute Resolution Process described in the brochure that can be found in your glove box of your new vehicle. An application describing your concern should be submitted to: National Center for Dispute Settlement Dispute Resolution Process P. O. Box 485 Mt. Clemens, MI 48046 1-866-WE-RESOLVE 2 (1-866-937-3765) 12_Non-turbo_MMNA_3rd.book Page 3 Tuesday, August 2, 2011 9:59 AM

INTRODUCTION

OBTAINING WARRANTY SERVICE IN COUNTRIES terms of this warranty and may be brought to Mitsubishi OTHER THAN THE UNITED STATES dealers in Canada or Puerto Rico for warranty covered repairs. 1. In U.S. Territories and Possessions: • When a Vehicle purchased in the United States is Should an Authorized Mitsubishi Motors Dealer charge for registered in U.S. territories and possessions, the warranty repairs, you should obtain a detailed receipt cov- Mitsubishi warranty in that territory and possessions ering the work performed and, upon returning to the U.S., will apply. contact an Authorized Mitsubishi Motors Dealer for reim- • In the event you are temporarily traveling in U. S. terri- bursement consideration. tories and possessions (e.g. vacation), the warranty issued with this vehicle will apply and warranty service IMPORTANT: will be provided by an Authorized Mitsubishi Motors Vehicles registered or normally operating outside of the Dealer in U.S. territories and possessions. United States are not covered under the terms of this 2. In Canada or Puerto Rico: limited warranty. Vehicles registered in the United States, but temporarily traveling in Canada or Puerto Rico are covered by the

3 12_Non-turbo_MMNA_3rd.book Page 4 Tuesday, August 2, 2011 9:59 AM

WARRANTY AT A GLANCE

NEW VEHICLE LIMITED WARRANTY 12 months/ 5 years/ 7 years/ 10 years/ Coverage 12,000 miles 60,000 miles 100,000 miles 100,000 miles New Vehicle Limited Coverage ** 10/100 Powertrain Coverage* * Adjustments

Anti-corrosion Powertrain components are covered for this time and mileage period under the New Vehicle Limited Warranty.

NOTE: * 10/100 Powertrain Coverage Applies only to the original owners of new, non-turbocharged, retailed vehicles. Subsequent owners receive 5-year/60,000-mile coverage under the New Vehicle Limited Warranty. ** Restraint System For the vehicles sold and registered in the states except Kansas, seatbelts and related components are covered by 5-year/60,000- mile coverage under the New Vehicle Limited Warranty. For the vehicles sold and registered in the state of Kansas, seatbelts and related components are covered for 10 years, regardless of mileage.

4 12_Non-turbo_MMNA_3rd.book Page 5 Tuesday, August 2, 2011 9:59 AM

WARRANTY AT A GLANCE

EMISSION CONTROL SYSTEM WARRANTY 2 years/ 3 years/ 5 years/ 7 years/ 8 years/ Coverage 24,000 miles 50,000 miles 60,000 miles 70,000 miles 80,000 miles Defect warranty • Emission-related parts Federal *1 (For 50 states • Specific Components and District of Performance warranty Columbia) • Emission-related parts • Specific Components *1 Defect warranty • Emission-related parts • Long-term California*2 Performance warranty • Emission-related parts • Long-term

*1: Specific Components : Engine Control Module, Transmission Control Module, Catalytic Converter(s) and Onboard Emission Diagnostic Device (OBD) *2: Applies to the vehicles, equipped with a California Certified Emission Control System and registered in the states of California, Connecticut, Maine, Maryland, Massachusetts, New Jersey, Oregon, Pennsylvania, Rhode Island, Vermont or Washington.

5 12_Non-turbo_MMNA_3rd.book Page 6 Tuesday, August 2, 2011 9:59 AM

NEW VEHICLE LIMITED WARRANTY NEW VEHICLE COVERAGE APPLICATION This coverage applies to all owners of this Vehicle during the LIMITED WARRANTY stated time and mileage limitations. This Limited Warranty applies only to Mitsubishi passenger cars and sport utility WHAT IS COVERED vehicles that are registered in the United States and normally operated in the United States or temporarily traveling NEW VEHICLE LIMITED WARRANTY COVE- in U.S. territories and possessions, Canada or Puerto Rico. RAGE AND TERM BATTERY MMNA warrants that all parts of this Vehicle supplied by During the first 24 months from the vehicles’ in–service MMNA (except batteries, adjustments required as a result of date, with unlimited mileage, a defective original equipment a manufacturing deficiency, air conditioner refrigerant battery will be replaced free of charge. charge, tires and items listed under the headings“ OTHERS” Should the battery fail after 24 months but before the 37th and “WHAT IS NOT COVERED”) are free from defects in month of service, it will be replaced under warranty at a materials or workmanship at the time of delivery. If such a 50% charge to customer. Labor to test, remove and install defect in materials or workmanship appears during the first 5 the warranty replacement battery will be covered at 100%. years or 60,000 odometer miles, the part will be repaired or A battery that is merely discharged is not considered to be replaced by any Authorized Mitsubishi Motors Dealer or defective. Authorized Service Center, using new or remanufactured Authorized Mitsubishi parts. The remedy described above ADJUSTMENT PERIOD shall be the sole and exclusive remedy for breach of war- Adjustments required as a result of a manufacturing defi- ranty, either express or implied. ciency are covered for 12 months or 12,000 odometer NOTE miles, whichever occurs first. •“New or Remanufactured Authorized Mitsubishi Motors OTHERS Parts” when used in connection with Mitsubishi vehicles, The following factory, port or dealer installed items are means parts manufactured by or approved by Mitsub- covered for 3 years or 36,000 odometer miles, whichever ishi, designed for use on Mitsubishi vehicles and distrib- occurs first: uted by MMNA or any division or subsidiary of MMNA. • Audio units, amplifiers, navigation systems, CD chang- • Aftermarket parts or accessories not supplied or ers, DVD video players and other vehicle entertainment approved by MMNA are NOT covered by this war- systems. ranty. • Bulbs (all filament bulbs). 6 12_Non-turbo_MMNA_3rd.book Page 7 Tuesday, August 2, 2011 9:59 AM

NEW VEHICLE LIMITED WARRANTY

AIR CONDITIONER REFRIGERANT CHARGE • Disconnecting or altering the odometer, where the actual mileage cannot be determined The air conditioner refrigerant charge is covered for 1 year • Use of contaminated or improper fuel, fluids or lubricants or 12,000 odometer miles, whichever occurs first. After • Damage due to customer-applied chemicals (For exam- that, refrigerant charge is only covered as part of a war- ple: abrasive waxes, polishes, sealants, etc.) ranty covered repair to the air conditioning system. TIRES DAMAGE CAUSED BY USE AND/OR THE ENVIRON- MENT The tires on your new Mitsubishi vehicle are warranted Examples are: independently from this limited warranty by the individual • Airborne fallout • Salt tire manufacturer. The individual tire manufacturer’s war- • Industrial fallout • Stones ranty statement has been provided with your Vehicle. To • Chemicals • Road hazards obtain tire warranty service, you must follow the procedures outlined in the tire warranty statement. • Acid rain • Hail • Tree sap • Insects WHAT IS NOT COVERED • Bird droppings • Lightning • Sand • Floods ALTERATION, MISUSE, OR ACCIDENT DAMAGE MODIFICATIONS Examples are: Damage or performance problems resulting from modifica- • Any vehicle previously declared a total loss and/or trans- tions to or racing of your vehicle are not covered under war- ferred or title branded as salvage, due to an accident or ranty. other catastrophic event • Collision, fire, theft, freezing, vandalism, riot, explosion, Examples of modifications to your vehicle that can cause or objects striking your Vehicle damage or performance problems include the following: • Misusing your Vehicle, such as, but not limited to, driving • Failure to use Mitsubishi Motors genuine parts over curbs, overloading, racing, or using your Vehicle as • Failure to use required fuel and fluids a stationary power source • Failure to use proper size tires and wheels • Alteration of your Vehicle, including, but not limited to, the • Modification of the fuel, intake, exhaust, emission, sus- body, chassis, braking system, software programming or pension, engine, drive train or electrical wiring systems other components • Modification of any onboard computer/control module, • Tampering with, or alteration of the emission control sys- including reprogramming, or replacing/adding chips to tems or other parts that affect these systems any onboard computer/control module 7 12_Non-turbo_MMNA_3rd.book Page 8 Tuesday, August 2, 2011 9:59 AM

NEW VEHICLE LIMITED WARRANTY

DAMAGE CAUSED BY IMPROPER MAINTENANCE players, tablets, laptops and other audio, video and data OR FAILURE TO FOLLOW THE RECOMMENDED sources. MAINTENANCE SCHEDULE PAINT AND OTHER APPEARANCE ITEMS The repair of damages, which are caused because parts or services used were not those prescribed in this manual’s Defects in paint, trim or other appearance items are nor- recommended maintenance schedule, are not covered mally noted and corrected during the new vehicle inspec- under warranty. It is the owner’s responsibility to maintain tion. For your protection, should you find any paint or appearance item which you suspect is defective, advise the Vehicle as more fully set forth in, and in accordance your Authorized Mitsubishi Motors Dealer without delay, as with, the maintenance schedules outlined in this manual. normal deterioration due to use and exposure is not Be advised that Warranty coverage may be denied if proper covered by this warranty. maintenance is not followed.

MAINTENANCE / WEAR / UPDATE OTHER Parts and labor needed to maintain the vehicle and the Incidental or consequential damages such as loss of use of replacement of parts due to normal wear and tear are not Vehicle, loss of time, inconvenience, expense for gasoline, covered by warranty and are the owner’s responsibility telephone, travel or lodging, loss or damage to personal property, commercial loss of revenue or other matters not (unless those costs result from a warranty covered repair). specifically included are not covered. Examples are: • Batteries of keyless entry remote fob • Brake pads/shoes WARRANTY REPAIR ORDER • Cleaning and polishing If you should have warranty service performed on this • Clutch disc facings Vehicle, you are entitled to receive a copy of the repair • Engine tune-ups order listing the warranty service performed. RETAIN • Lubrication THESE COPIES FOR YOUR RECORDS. • Replacing filters, coolant or fuses Receipts covering the performance of maintenance ser- • Replacing spark plugs vices should be retained in the event questions arise con- • Wiper blades cerning maintenance. These receipts should be transferred • Software and map updates for Navigation systems (such to each subsequent owner of this vehicle. MMNA reserves updates are considered an owner responsible expense) the right to deny warranty coverage if the vehicle has not • Hardware or software updates needed to support and/or been properly maintained. However, denial will not be interface your vehicle with non-Mitsubishi supplied based solely on the absence of maintenance records. devices (such as, but not limited to, cell phones, music 8 12_Non-turbo_MMNA_3rd.book Page 9 Tuesday, August 2, 2011 9:59 AM

NEW VEHICLE LIMITED WARRANTY

PRODUCTION CHANGES For original owners of retailed vehicles only, this 10- year/100,000-mile Powertrain Limited Warranty will MMNA and its Authorized Mitsubishi Motors Dealers cover the listed powertrain components up to 10 years reserve the right to make changes in Vehicles sold by them from the original in-service date or date of first use, or at any time without incurring any obligation to make the 100,000 miles, whichever occurs first. This Powertrain same or similar changes on Vehicles previously sold by Limited Warranty is NOT transferable to any subse- them. quent owner. Subsequent owners will receive the balance of the Powertrain Components coverage under the New Vehicle Limited Warranty of 5-year/60,000- 10-YEAR/100,000-MILE POWERTRAIN mile, whichever occurs first, as set forth in this man- LIMITED WARRANTY COVERAGE & TERM ual. The “original owner” is defined as the first retail pur- NOTE: chaser of the vehicle who took delivery of the eligible Applies only to the original owner of all new, retailed vehicle on its original in-service date. This original vehicles. Subsequent owners receive the balance of owner designation will also apply if the vehicle was coverage remaining under the 5-year/60,000-mile first placed in lease service and is purchased at the “New Vehicle Limited Warranty”. end of the lease by original lessee. This 10-year/100,000-mile Powertrain Limited War- This limited warranty covers the repair or replacement ranty applies only to original owners of vehicles of covered powertrain components listed, originally retailed and registered in the United States or District manufactured or installed by Mitsubishi Motors that of Columbia and excludes vehicles placed in commer- are found to be defective in material or factory work- cial use (e.g. taxi, route delivery, rental, livery service, manship under normal use and maintenance (except etc.). those items and/or situations specifically referred to in the section “What is Not Covered”).

9 12_Non-turbo_MMNA_3rd.book Page 10 Tuesday, August 2, 2011 9:59 AM

NEW VEHICLE LIMITED WARRANTY

COVERED POWERTRAIN LIMITED WARRANTY COM- TRANSAXLE/TRANSMISSION & TRANSFER CASE: PONENTS: • Torque Converter (Including Ring Gear) • Transaxle Case and All Internal Parts, Gaskets & Seals NOTE: • Transaxle, Transmission and Transfer Case Mounts • Coverage applies only to the repair or replace- • Transfer Case and All Internal Parts, Gaskets and Seals ment of powertrain components originally manu- • Transmission Case and All Internal Parts, Gaskets & factured and installed by Mitsubishi Motors that Seals are defective in material or factory workmanship OTHER POWERTRAIN COMPONENTS: under normal use and maintenance or Authorized Mitsubishi Powertrain Components parts sourced • Axle Housing and All Internal Parts, Gaskets and Seals from and installed by an Authorized Mitsubishi • Axle Shaft Bearings Motors Dealer. • Differential Carrier Assemblies and All Internal Parts, • Non-authorized aftermarket parts and/or Mitsu- Gaskets and Seals bishi parts not obtained from and installed by an • Drive Shaft and Axle Shaft Assemblies (Including Con- Authorized Mitsubishi Motors Dealer are not stant Velocity Joints) covered by this Warranty. • Propeller Shaft Assemblies and Yokes (Including Con- stant Velocity Joints and/or Universal Joints) ENGINE: • Propeller Shaft Center Bearings • Balancer Belt and Related Parts WHAT IS NOT COVERED UNDER THIS 10-YEAR/ • Balancer Shafts • Cylinder Block and Internal Parts 100,000-MILE POWERTRAIN LIMITED WARRANTY: • Cylinder Head Assemblies and Gaskets • Any subsequent owner • Engine Mounts • Commercial use (e.g. taxi, route delivery, rental, livery • Flywheel or Drive Plate (Including Ring Gear) service, etc.) • Fuel Pump See the “New Vehicle Limited Warranty” section of this • Intake Manifold manual for examples and further details of what is NOT • Oil Pan and Oil Pump covered (Page 7). • Timing Belt and Related Parts • Valve Covers and Valve Cover Gaskets • Water Pump

10 12_Non-turbo_MMNA_3rd.book Page 11 Tuesday, August 2, 2011 9:59 AM

NEW VEHICLE LIMITED WARRANTY

ANTI-CORROSION PERFORATION LIMITED THIS WARRANTY DOES NOT COVER: WARRANTY • Corrosion due to accident, damage, abuse, abnormal use, Vehicle alteration or failure to properly maintain this MMNA warrants to the owner of each 2012 Mitsubishi vehi- Vehicle cle that any Authorized Mitsubishi Motors Dealer or Autho- rized Service Center will repair or replace at no charge any • Payments for loss of use of the Vehicle during warranty body sheet metal panel found to have developed perfora- repairs tion (metal rust-through) due to corrosion in normal use. • Surface corrosion, such as that caused by industrial fall- This warranty begins on the date of original retail delivery out, sand, salt, hail and stones or original use, whichever occurs first, and extends for 5 • Corrosion due to extensive and/or abnormal transporta- years regardless of mileage. tion of corrosive material such as, but not limited to, In addition, outer panel rust-through protection coverage is chemicals, acid, fertilizer extended as follows: • Corrosion other than perforation (metal rust-through) due to defects in material or workmanship that is otherwise • New 2012 Vehicles are covered for 7 years or 100,000 covered by the 5 years or 60,000 odometer miles MMNA odometer miles, whichever occurs first. New Vehicle Limited Warranty It is the owner’s responsibility under the terms of this war- • The section titled ranty to maintain the Vehicle as specified in this manual “OTHER TERMS” stated in the MMNA and in the Owner’s Manual. New Vehicle Limited Warranty also applies to this limited warranty. NOTE: This anti-corrosion perforation warranty covers perforation due to corrosion only. Perforation means a rust-through condition, such as an actual hole in a sheet metal panel. This Limited Warranty applies only to Mitsubishi passenger cars and sport utility vehicles that are registered in the United States and normally operated in the United States or temporarily traveling in U.S. territories and possessions, Canada or Puerto Rico.

11 12_Non-turbo_MMNA_3rd.book Page 12 Tuesday, August 2, 2011 9:59 AM

NEW VEHICLE LIMITED WARRANTY

THINGS YOU SHOULD KNOW ABOUT YOUR MMNA Underbody Maintenance: ANTI-CORROSION PERFORATION LIMITED WAR- Corrosive materials used for ice removal and dust control RANTY: can collect on underbody surfaces. If these materials are not removed, accelerated corrosion can occur on the under- REPAIRING YOUR MITSUBISHI VEHICLE body parts, such as fuel lines, frame, floor pan and exhaust If your Vehicle is damaged and requires sheet metal repair system. At least twice a year, thoroughly flush these materi- or replacement, be sure anti-corrosion materials are als from the underbody with plain water. Take care to clean applied to the parts repaired or replaced. any areas where mud and other debris can collect. Finish Damage: MAINTAINING YOUR MITSUBISHI VEHICLE Any stone chips, fractures or deep scratches in the finish Washing: should be repaired promptly. Bare metal will corrode The best way to preserve your Vehicles’ finish and aid in quickly and can develop into a major repair expense. Minor avoiding rust is to keep the Vehicle clean by washing it fre- chips and scratches can be repaired with touch-up materi- quently. Wash the Vehicle only with lukewarm or cold water. als available from your Authorized Mitsubishi Motors Dealer Do not wash the Vehicle in the direct rays of the sun, or use or Authorized Service Center. The cost of such repairs is strong soap or chemical detergents. Any cleaning agents considered the responsibility of the owner. used should be washed off promptly and not allowed to dry on the finish. OTHER TERMS Foreign Material Deposits: ANY IMPLIED WARRANTY APPLICABLE TO THIS VEHI- Calcium chloride and other salts, ice melting agents, road CLE IS LIMITED IN DURATION TO THE LENGTH OF oil and tar, tree sap, bird droppings, chemicals from indus- THIS WRITTEN WARRANTY. MMNA SHALL NOT BE LIA- trial chimneys, acid rain, and other foreign matter may BLE FOR ANY INCIDENTAL, CONSEQUENTIAL, SPE- damage the Vehicle finish if left on the painted surfaces. CIAL OR EXEMPLARY DAMAGES FOR BREACH OF Prompt washing may not completely remove all these THIS WARRANTY OR ANY IMPLIED WARRANTY. deposits. Some states do not allow the exclusion or limitation of inci- Additional cleaners may be needed. When using chemical dental or consequential damages or limitation on how long cleaners developed for this purpose, be sure they are safe an implied warranty lasts, or limitations on available reme- for use on painted surfaces. dies, so the above limitations or exclusions may not apply to you. This warranty gives the owner specific legal rights and the owner may also have other rights which vary by state. 12 12_Non-turbo_MMNA_3rd.book Page 13 Tuesday, August 2, 2011 9:59 AM

FEDERAL EMISSION WARRANTY FEDERAL EMISSION WARRANTY FEDERAL EMISSION CONTROL SYSTEM PERFOR- MANCE WARRANTY FEDERAL EMISSION CONTROL SYSTEM DEFECT Some states and local jurisdictions have established peri- WARRANTY odic vehicle inspection and maintenance (I/M) programs to MMNA warrants to the owner of each new 2012 Mitsubishi encourage proper maintenance of your Vehicle. vehicle, (1) that the Vehicle, was designed, built and If an I/M Program in your area has the U.S. Environmental equipped so as to conform at the time of sale to applicable Protection Agency (EPA) approval, you may be eligible for regulations of the National Emission Standards Act, as MMNA’s performance warranty coverage under the follow- amended, and (2) the Vehicle is free from defects in mate- ing conditions: rial and workmanship at the time of sale which would cause 1. The Vehicle has been maintained and operated in the Vehicle to fail to conform with such regulations for a accordance with the scheduled maintenance period of 5 years or 60,000 odometer miles, whichever instructions described in this manual and Owner’s occurs first. MMNA additionally warrants the Engine Con- Manual provided with your Vehicle. trol Module, Transmission Control Module, Catalytic Con- 2. The Vehicle fails to conform for a period of 2 years verter(s) and Onboard Emission Diagnostic Device as or 24,000 odometer miles, whichever occurs first, Specific Components for 8 years or 80,000 odometer to the applicable emission standards of EPA, as miles, whichever occurs first. judged by an EPA approved I/M Test. Any part of this Vehicle covered under this limited emission MMNA additionally warrants the Engine Control defect warranty and which proves to be defective will be Module, Transmission Control Module, Catalytic repaired or replaced at no charge by any Authorized Mit- subishi Motors Dealer or Authorized Service Center, using Converter(s) and Onboard Emission Diagnostic new or remanufactured Authorized Mitsubishi Motors Device as Specific Components for 8 years or Parts. 80,000 odometer miles, whichever occurs first. The limited warranty period begins on the date of original 3. The failure to conform to I/M test standards may retail delivery or original use, whichever occurs first. result in the owner of the Vehicle having to bear a This limited emission defect warranty shall not apply to penalty or other sanctions, including the denial or parts other than Authorized Mitsubishi Motors Parts. the right to use the Vehicle under local, state or federal law.

13 12_Non-turbo_MMNA_3rd.book Page 14 Tuesday, August 2, 2011 9:59 AM

FEDERAL EMISSION WARRANTY

If all the foregoing conditions are met, MMNA warrants that EMISSION WARRANTY PARTS any Authorized Mitsubishi Motors Dealer or Authorized • Catalytic Converter(s) Service Center will replace, repair or adjust to Mitsubishi’s • Electronic Spark Control specifications at no charge, any of the components listed • Evaporative Emission Canister, Evaporative Emission below or parts thereof, which may be necessary to cause Liquid Separator and Controls your Vehicle to conform to the applicable emission stan- • Exhaust Gas Recirculation Valve and Control System dards. Parts “Certified to EPA Standards” shall be covered • Fuel Tank Filler Tube and Cap by this performance warranty. This performance warranty • Induction Control Valve Assembly period begins on the date of original retail delivery or origi- • Multiport Fuel Injection System nal use, whichever occurs first. • Positive Crankcase Ventilation Valve NOTE: • Timing Advance/Retard System Vehicles equipped with a California Certified Emission • Hoses, Clamps, Brackets, Pipes, Gaskets, Belts, Seals Control System and registered in the states of California, and Connectors used in the above systems Connecticut, Maine, Maryland, Massachusetts, New Jer- • Vacuum, Temperature, Altitude, Speed and Time Sensi- sey, Oregon, Pennsylvania, Rhode Island, Vermont or tive Valves and Switches for the above systems Washington are also entitled to the California Emission • Any other components necessary to assure conformity. Warranty. (See page 17 of this manual) If failure of one of these components results in failure of another part, both will be covered by the performance warranty. WHAT IS NOT COVERED • Noncompliance caused by defective replacement parts not certified in accordance with aftermarket parts certification regulations. • Noncompliance caused by the use of replacement parts not equivalent to original equipment parts. Other provisions specified under the“ WHAT IS NOT COV- ERED” section in the New Vehicle Limited Warranty are also applicable to this warranty.

14 12_Non-turbo_MMNA_3rd.book Page 15 Tuesday, August 2, 2011 9:59 AM

FEDERAL EMISSION WARRANTY

THE EMISSION CONTROL SYSTEM DEFECT WAR- THINGS YOU SHOULD KNOW ABOUT BOTH THE EMIS- RANTY AND THE EMISSION CONTROL SYSTEM PER- SION CONTROL SYSTEM DEFECT WARRANTY AND FORMANCE WARRANTY SHALL NOT APPLY TO: THE EMISSION CONTROL SYSTEM PERFORMANCE WARRANTY • Conditions resulting from contaminated fuel, misuse, improper adjustments, modifications, accidents, alter- The emission control system of your new 2012 Mitsubishi ations, tampering, acts of God, improper or inadequate vehicle was designed, built and tested using Authorized maintenance, or failure to use recommended fuel Mitsubishi Motors Parts and the Vehicle is certified as • The replacement of maintenance parts used in regular being in conformity with applicable emission regulations. maintenance services Accordingly, it is recommended that any replacement parts • Loss of time, inconvenience, loss of use of the Vehicle, or used for maintenance or for the repair of emission control other consequential damages systems be new or remanufactured Authorized Mitsubishi • Any Vehicle on which the odometer reading has been Motors Parts. changed so that mileage cannot be readily determined. THE WARRANTY OBLIGATIONS ARE NOT DEPENDENT MMNA does not authorize any person to create for it any UPON THE USE OF ANY PARTICULAR BRAND OF other obligations or liability in connection with these sys- REPLACEMENT PART. THE OWNER MAY ELECT TO tems. These warranties are in addition to MMNA’s New USE NON-AUTHORIZED MITSUBISHI MOTORS PARTS Vehicle Limited Warranty for 2012 Vehicles. FOR REPLACEMENT PURPOSES. THE USE OF REPLACEMENT PARTS WHICH ARE NOT EQUIVALENT MAY IMPAIR THE EFFECTIVENESS OF EMISSION CON- TROL SYSTEMS. If other than Authorized Mitsubishi Motors Parts are used for maintenance replacements or for the repair of components affecting emission control, the owner should determine that such parts are warranted by the manufacturer to be equivalent to Authorized Mitsubishi Motors Parts in performance and durability.

15 12_Non-turbo_MMNA_3rd.book Page 16 Tuesday, August 2, 2011 9:59 AM

FEDERAL EMISSION WARRANTY required period may obligate MMNA to remedy the noncon- MAINTENANCE REPLACEMENT OR REPAIR OF THE formity under the Emission Control Systems Performance EMISSION CONTROL DEVICES AND SYSTEMS MAY Warranty except: BE PERFORMED BY ANY QUALIFIED AUTOMOTIVE REPAIR ESTABLISHMENT OR INDIVIDUAL USING ANY • When delay is requested by the vehicle owner. PART CERTIFIED PURSUANT TO APPLICABLE EMIS- • When delay is caused by factors beyond the control of SION REGULATIONS; HOWEVER, WARRANTY SER- MMNA or Authorized Mitsubishi Motors Dealers or VICE MUST BE PERFORMED BY AN AUTHORIZED Authorized Service Centers. MITSUBISHI MOTORS DEALER OR AUTHORIZED SER- VICE CENTER. Further information can be obtained from and complaints registered with: Claims under the Emission Control Systems Performance Warranty may not be denied due to the failure of a properly Manager, Vehicle Compliance Programs Group installed certified non-Authorized Mitsubishi Motors Part. Vehicle Programs and Compliance Division Receipts covering the performance of maintenance ser- Environmental Protection Agency 401 vices should be retained in the event questions arise con- “M” Street, S.W. cerning maintenance. These receipts should be transferred NMS-6405J to each subsequent owner of this Vehicle. MMNA reserves Washington, D.C. 20460 the right to deny warranty coverage if the Vehicle has not been properly maintained. However, denial will not be NOTE: based solely on the absence of maintenance records. “New or Remanufactured Authorized Mitsubishi Motors These warranties apply only to Vehicles manufactured to Parts” when used in connection with Mitsubishi vehicles, United States specifications and registered and normally means parts manufactured by or approved by MITSU- operated in the 50 United States or Washington, D.C. BISHI, designed for use on Mitsubishi vehicles and dis- Vehicles manufactured to other specifications or registered tributed by MMNA or any division or subsidiary of MMNA. and normally operated elsewhere, shall be entitled to service of emission control systems on the basis of the warranty applicable to such other country or territory. If an owner’s warranty claim under the Emission Control Systems Performance Warranty is denied, MMNA will provide the owner with a written explanation of why the claim was denied within 30 days unless a shorter time period is required by law. Failure to provide an explanation within the 16 12_Non-turbo_MMNA_3rd.book Page 17 Tuesday, August 2, 2011 9:59 AM

“CALIFORNIA” EMISSION WARRANTY

FOR ALL JURISDICTIONS THAT HAVE ADOPTED MANUFACTURER’S WARRANTY COVERAGE: CALIFORNIA EMISSION CONTROL SYSTEMS AND 1. For 3 years or 50,000 odometer miles, whichever WARRANTY REQUIREMENT. occurs first: If your Vehicle fails a Smog Check inspection, all nec- “CALIFORNIA” EMISSION essary repairs and adjustments will be made by MMNA WARRANTY to ensure that your Vehicle passes the inspection. This is your emission control system PERFORMANCE YOUR WARRANTY RIGHTS AND OBLIGATIONS WARRANTY. The California Air Resources Board and MMNA are 2. For 5 years or 60,000 odometer miles, whichever pleased to explain the emission control system warranty on occurs first: your 2012 Mitsubishi vehicle. If any emission-related part on your Vehicle is defec- In California, Connecticut, Maine, Maryland, Massachu- tive, the part will be repaired or replaced by MMNA. setts, New Jersey, New York*, Oregon, Pennsylvania, This is your short-term emission control system Rhode Island, Vermont and Washington, new motor vehi- DEFECTS WARRANTY. cles must be designed, built and equipped to meet Califor- 3. For 7 years or 70,000 odometer miles, whichever nia’s stringent anti-smog standards. occurs first: * 2012 Mitsubishi vehicle sold in New York is warranted by Federal Emission Warranty. If an emission-related part specially noted in this warranty manual with coverage for 7 years or 70,000 MMNA warrants the emission control system on your Vehi- odometer miles is defective, the part will be repaired or cle for the periods of time listed below, provided there has replaced by MMNA. been no abuse, neglect or improper maintenance of your This is your Long-term emission control system PER- Vehicle. FORMANCE and DEFECTS WARRANTY. Your emission control system may include parts such as the fuel-injection system, the ignition system, catalytic con- 4. For 8 years or 80,000 odometer miles, whichever verter, and engine control module. Also included may be occurs first, under the Federal Emission Warranty: hoses, belts, connectors and other emission-related If an emission-related part listed in this warranty man- assemblies. ual specially noted with coverage for 8 years or 80,000 odometer miles is defective, the part will be repaired or Where a warrantable condition exists, MMNA will repair replaced by MMNA. your Vehicle at no charge to you including diagnosis, parts and labor. 17 12_Non-turbo_MMNA_3rd.book Page 18 Tuesday, August 2, 2011 9:59 AM

“CALIFORNIA” EMISSION WARRANTY

OWNER’S WARRANTY RESPONSIBILITIES: CALIFORNIA VEHICLE INSPECTION PROGRAM: As the Vehicle owner, you are responsible for the perfor- If the Vehicle fails an emission test conducted under the mance of the required maintenance listed in this manual. Smog Check Program, it should be brought to an Autho- MMNA recommends that you retain all receipts covering rized Mitsubishi Motors Dealer or Authorized Service Cen- maintenance on your Vehicle. Coverage will not be denied ter for appropriate service. The owner will not be charged solely because there is no record of maintenance. How- for the adjustments, repair or replacement of parts, includ- ever, failures caused by lack of required maintenance are ing diagnosis, necessary to make the Vehicle pass the not covered by the warranty. Smog Check test for 3 years or 50,000 odometer miles, whichever occurs first. You are responsible for presenting your Vehicle to an After the 3 years or 50,000 odometer miles performance Authorized Mitsubishi Motors Dealer or Authorized Service warranty period has passed, a Smog Check test failure due Center as soon as a problem exists. to a defect in a part which is warranted for either 5 years or The warranty repairs should be completed in a reasonable 60,000 odometer miles, or 7 years or 70,000 odometer amount of time, not to exceed 30 days. miles is covered. As the Vehicle owner, you should also be aware that MMNA additionally warrants the Engine Control Module, MMNA may deny you warranty coverage if your Vehicle or Transmission Control Module, Catalytic Converter(s) and a part has failed due to abuse, neglect, improper mainte- Onboard Emission Diagnostic Device as Specific Compo- nance or unapproved modifications. nents for 8 years or 80,000 odometer miles, whichever occurs first, under the Federal Emission Warranty. If as the If you have any questions regarding your warranty rights result of a vehicle inspection failure the owner elects to and responsibilities, you should contact MMNAs’ Customer have the vehicle repaired at an independent service outlet, Relations Department at 1-888-648-7820 or if in California, MMNA will not reimburse the owner for service performed the California Air Resources Board, P.O. Box 8001 at 9528 by the independent service outlet unless such work is Telstar Avenue, El Monte CA 91734-8001. deemed an “EMERGENCY SERVICE” and the repair is a covered item under the terms of the Emission Control War- WARRANTY START DATE: ranty. (See topic “EMERGENCY SERVICE”). The limited warranty period begins on the date of original retail delivery or original use, whichever occurs first.

18 12_Non-turbo_MMNA_3rd.book Page 19 Tuesday, August 2, 2011 9:59 AM

“CALIFORNIA” EMISSION WARRANTY

WARRANTY SERVICE: DEFECT WARRANTY: To obtain warranty service, the owner must return the Vehi- For the 5 years/60,000 odometer miles Defects Warranty, if cle to any Authorized Mitsubishi Motors Dealer or Autho- any part which can affect emissions fails, MMNA will repair rized Service Center where such service will be performed or replace it at an Authorized Mitsubishi Motors Dealer or at no charge to the owner. In case of emergency, see Authorized Service Center. Any other parts damaged by EMERGENCY SERVICE instructions. If you are not noti- the failure of a defective part will also be repaired or fied by the dealer within 30 days that the repair is not replaced. Listed below are some of the parts covered by covered under warranty, then MMNA must repair the Vehi- the warranty. The parts shown with the asterisk (*) are cle free of charge. In addition, the owner should take a covered for specific models under the 7 years/70,000 copy of the Smog Check test printout to the dealer when odometer miles Emission-Related Parts Warranty Long obtaining warranty service. Term and additionally, the 8 years/80,000 odometer miles Federal Emission Warranty, as described on the following EXCLUSIONS: page. The repair and/or replacement described above will This Warranty shall not apply to failures caused by abuse, be made at no charge to the owner including diagnosis and neglect or improper maintenance. Nor shall this Warranty labor. The defects warranty coverage shall apply until the apply to any vehicle on which the odometer mileage has first scheduled replacement point specified by MMNA for been altered so that the Vehicle’s actual mileage cannot be any part listed below, and shall apply for the remaining war- determined. Vehicles registered in states other than Cali- ranty period of any such part repaired or replaced under fornia, Connecticut, Maine, Maryland, Massachusetts, New warranty. Where no replacement point is specified, the cov- Jersey, Oregon, Pennsylvania, Rhode Island, Vermont and erage shall apply for the warranty period identified under Washington shall be entitled to the emission control system the section entitled “New Vehicle Limited Warranty” of this warranty issued pursuant to the Federal Clean Air Act. warranty statement. This Warranty and any other warranties otherwise expressed under applicable California emissions laws and regulations are the only warranties in addition to the stan- dard MMNA Warranty in the warranty statement applicable to the Vehicle, and are EXPRESSLY IN LIEU OF ANY WARRANTY OR CONDITIONS IMPLIED IN LAW PER- TAINING TO EMISSION OR EMISSION CONTROLS SYS- TEMS. No dealer, or any agent or employee thereof, is authorized to extend or enlarge this warranty.

19 12_Non-turbo_MMNA_3rd.book Page 20 Tuesday, August 2, 2011 9:59 AM

“CALIFORNIA” EMISSION WARRANTY

• Accelerator Position Sensor • Spark Plugs • Air Flow Sensor • *Throttle Body • *Air Intake Surge Tank • *Transmission Control Module • Camshaft Position Sensor • Control Relay, Registers and Solenoids used with the • *Catalytic Converter(s) above systems • Crankshaft Position Sensor • *Engine Control Module used with the above systems • Emission Solenoid Valve • Oxygen Sensor(s) used with the above systems • Evaporative Emission Canister • Temperature Sensors used with the above systems • Exhaust Gas Recirculation Valve and Control System • Vacuum Hoses, Clamps, Fittings and Tubing used with • *Exhaust Manifold(s) the above components and systems • *Exhaust Manifold(s) with Catalytic Converter(s) • Vacuum Sensor(s) used with the above systems • Exhaust Pipe(s) between Exhaust Manifold and Catalytic Converter • *Exhaust Pipe(s) with Catalytic Converter(s) • Fuel Filter/Evaporative Emission Separator • Fuel Injectors • Fuel Level and Fuel Pressure Sensors • Fuel Pressure Regulator • *Fuel Pump • *Fuel Tank • *Fuel Tank Filler Tube • Fuel Tank Filler Cap • Ignition Coil(s), High Voltage Wires and Boots • Induction Control Valve Assembly • *Intake Manifold • Knock Sensor • *Liner A/F Sensor • MAP Sensor • *Oil Control Valve • Oil Filler Cap • *Onboard Emission Diagnostic Device • Positive Crankcase Ventilation Valve 20 12_Non-turbo_MMNA_3rd.book Page 21 Tuesday, August 2, 2011 9:59 AM

“CALIFORNIA” EMISSION WARRANTY

This TABLE details the specific parts and components covered and the warranty duration for the components in years or miles, whichever occurs first. TABLE

Eclipse/ Models Outlander 2.4 L Outlander 3.0 L Outlander Lancer/ Ter m Eclipse Spyder Galant 2.4 L Warranted Part Sport Lancer Sportback 2.4 L 3.8 L 2WD 4WD 2WD 4WD Upper ✔ Upper ✔ Intake Manifold* ✔ ✔ ✔ ✔ ✔ ✔ ✔ Lower ✔ Lower ✔ Air Intake Surge Tank ✔

Throttle Body ✔ ✔ ✔ ✔ ✔ ✔ ✔ ✔

Exhaust Manifold(s) ✔✔ ✔ ✔ 7 years/ 70,000 miles Fuel Pump* ✔ ✔ ✔ ✔ ✔ ✔ Fuel Tank ✔✔✔✔✔✔✔✔ ✔

Fuel Tank Filler Tube ✔ ✔

Oil Control Valve ✔

Liner A/F Sensor ✔ ✔ ✔ ✔

Engine Control Module (including OBD II) ✔✔✔✔✔✔✔✔ ✔

8 years/ Transmission Control Module (including OBD II) ✔ ✔ ✔ ✔ ✔ ✔ ✔ ✔ ✔ 80,000 miles ✔✔✔✔✔✔✔✔ ✔ (under the Catalytic Converter(s) Federal Exhaust Pipe(s) with Catalytic Converter(s) ✔ ✔ ✔ ✔ ✔ ✔ ✔ ✔ ✔ Emission Warranty) Exhaust Manifold(s) with Catalytic Converter(s) ✔✔✔ ✔✔

Onboard Emission Diagnostic Device ✔ ✔ ✔ ✔ ✔ ✔ ✔ ✔ ✔ * Note: Covered to 10 years/100,000 miles for the original retail purchaser by 10-YEAR/100,000-MILE POWERTRAIN LIMITED WARRANTY

21 12_Non-turbo_MMNA_3rd.book Page 22 Tuesday, August 2, 2011 9:59 AM

“CALIFORNIA” EMISSION WARRANTY

WHAT THE OWNER MUST DO: PARTS: It is the owner’s responsibility to have the required mainte- IT IS RECOMMENDED THAT ANY REPLACEMENT nance performed and use the Vehicle in accordance with PARTS USED FOR MAINTENANCE OR FOR THE MMNA’s written instructions. Coverage WILL NOT be REPAIR OF THE EMISSION CONTROL SYSTEMS BE denied solely because there is no record of maintenance. NEW OR REMANUFACTURED, AUTHORIZED MITSU- However, failures or non-compliance caused by lack of BISHI MOTORS PARTS. required maintenance are not covered by the warranty. To However, the warranty obligations ARE NOT dependent avoid questions as to whether the vehicle maintenance has upon the use of any particular brand of replacement parts. been performed, MMNA urges that the owner retain all The owner may elect to use non-Authorized Mitsubishi receipts and/or maintenance records’ indicating that ser- Motors Parts for replacement purposes. Use of replace- vice has been performed on the vehicle and these receipts ment parts which are not of equivalent quality to Authorized and maintenance records should be transferred to any sub- Mitsubishi Motors Parts may impair the effectiveness of sequent owner of the vehicle. emission control systems. SERVICE: NOTE: MAINTENANCE SERVICE CAN BE PERFORMED BY “New or Remanufactured Authorized Mitsubishi Motors ANY QUALIFIED SERVICE OUTLET OR BY THE Parts” when used in connection with Mitsubishi vehicles, OWNER OR BY SOMEONE OF THE OWNER’S CHOOS- means parts manufactured by or approved by MITSU- ING. BISHI, designed for use on Mitsubishi vehicles and dis- HOWEVER, WARRANTY SERVICE MUST BE PER- tributed by MMNA or any division or subsidiary of MMNA. FORMED BY AN AUTHORIZED MITSUBISHI MOTORS DEALER OR SERVICE CENTER, IN ORDER TO BE PERFORMED AT NO CHARGE TO YOU.

22 12_Non-turbo_MMNA_3rd.book Page 23 Tuesday, August 2, 2011 9:59 AM

“CALIFORNIA” EMISSION WARRANTY

WHAT IS NOT COVERED: EMERGENCY SERVICE: The Warranty does not cover: If emergency emission control system warranty service is required and the owner is unable to readily locate an • Malfunction in any part caused by abuse, misuse, alter- Authorized Mitsubishi Motors Dealer or Authorized Service ation, tampering, disconnection or improper or inade- Center or if a warranted part is not available within 30 days, quate maintenance. then, repairs may be performed at any available service • Damage to catalytic converters or oxygen sensors due to establishment, or by the owner, using any replacement use of leaded gasoline or any additives. part. • Damage resulting from fire, accident, negligence, acts of MMNA will reimburse the owner for the owner’s expenses God or other events beyond the control of MMNA. including diagnostic charges for such emergency repair or • Maintenance replacement parts (such as spark plugs) replacement at MMNAs’ suggested retail price for all war- beyond the first scheduled replacement point. ranted parts replaced and labor charges based on the • Incidental or consequential damages such as loss of use MMNA’s recommended time allowance for the warranty of the vehicle, loss of time, inconvenience, expenses for repair and the geographically appropriate hourly labor rate. gasoline, telephone, travel or lodging. Replaced parts and copies of paid original receipts must be • Any vehicle on which the odometer mileage has been available for presentation to MMNA as a condition of reim- altered so that actual vehicle mileage cannot readily be bursement for these emergency repairs. In addition, the determined. owner must provide MMNA a detailed description indicat- • Loss or damage to personal property, loss of revenue, ing why the situation was considered an emergency and commercial loss. why an Authorized Mitsubishi Motors Dealer or Authorized • Damages resulting from a defect in a part not designated Service Center was not available. Additional information by MMNA; see owner responsibilities stated above. may be obtained by calling 1-888-648-7820. A repair not Other provisions specified under the“ WHAT IS NOT COV- being completed within 30 days due to the inability to ERED” by the Federal Emission Warranty are also applica- obtain a warranted part or the unavailability of an autho- ble to this warranty. rized Mitsubishi Motors Dealer or Authorized Service Cen- ter constitutes an emergency.

23 12_Non-turbo_MMNA_3rd.book Page 24 Tuesday, August 2, 2011 9:59 AM

NOTICE TO CONSUMERS

NOTICE TO CONSUMERS To file a claim, complete the Dispute Resolution Process MMNA is committed to assuring your satisfaction with application, which includes the following information: your vehicle. • Your name and address, • Your vehicle model and Vehicle Identification Num- If you have a concern that is not resolved to your satisfac- ber (VIN), and tion, we encourage you to use Mitsubishis’ informal third • The nature of your concern. party Dispute Resolution Process, administered by the National Center for Dispute Settlement (NCDS). While you Once your claim is submitted, NCDS will review your may use the Process at any time, we suggest that you first request for arbitration and inform you if your concern meets follow Mitsubishi Motors’ normal complaint handling pro- the program criteria for the Dispute Resolution Process. If cess: your concern meets the program criteria, it will be referred to an NCDS decision-maker (arbitrator) for hearing. If you Dispute Resolution Process requested an oral hearing, you will be contacted by an First, contact your dealership to discuss your concern; if NCDS representative to arrange a mutually agreeable date the dealer can not resolve your concern, contact Mitsubishi and location to conduct the hearing. If you selected a three- Customer Relations at 1-888-648-7820. A Mitsubishi person panel and a “documents only” hearing, NCDS will regional representative will work with you to address your notify you of the date all your documents must be received concern. by NCDS (Arkansas customers may choose a single arbitrator or panel regardless of format). The arbitrator or panel If you are not satisfied after contacting your dealership and will render a decision on your case. You may accept or Mitsubishi Customer Relations, and wish to pursue the reject the decision. If you accept the decision it will be bind- matter further, submit an application (which can be found in ing on MMNA. The entire process will normally take no the Dispute Resolution Process brochure located in the longer than forty (40) days from the date your application is glove box of your vehicle), describing your concern. received to the date the decision is rendered. National Center for Dispute Settlement In the event your vehicle does not conform to MMNA’s Dispute Resolution Process express warranty after a reasonable number of repair P. O. Box 485 attempts, the federal Magnuson-Moss Warranty Act and Mt. Clemens, MI 48046 state lemon laws permit owners to obtain a replacement 1-866-WE-RESOLVE vehicle or a refund of the purchase price under certain cir- (1-866-937-3765) cumstances. The provisions of state laws vary from state to state. There is no cost to you for submitting your application. 24 12_Non-turbo_MMNA_3rd.book Page 25 Tuesday, August 2, 2011 9:59 AM

NOTICE TO CONSUMERS

Some states require that written notification be given to the OTHER TERMS manufacturer before the consumer may be eligible for a ANY IMPLIED WARRANTY APPLICABLE TO THIS VEHI- refund or replacement vehicle. Therefore, MMNA requests CLE IS LIMITED IN DURATION TO THE LENGTH OF that you first provide us with written notification of any such THIS WRITTEN WARRANTY. MMNA SHALL NOT BE LIA- non-conformities so that we may have an opportunity to BLE FOR ANY INCIDENTAL, CONSEQUENTIAL, SPE- make final repairs to the vehicle before you pursue lemon CIAL OR EXEMPLARY DAMAGES FOR BREACH OF law remedies. THIS WARRANTY OR ANY IMPLIED WARRANTY. Please send your correspondence to: Some states do not allow the exclusion or limitation of incidental or consequential damages or limitation on how long Mitsubishi Motors North America, Inc. an implied warranty lasts, or limitations on available reme- Attn: Customer Relations dies, so the above limitations or exclusions may not apply P.O. Box 6400 to you. This warranty gives the owner specific legal rights Cypress, CA 90630-0064 and the owner may also have other rights which vary by state. Please include the following information in your correspondence: • Your name, address, and contact phone number • Your vehicle year, model and 17-character Vehicle Identi- fication Number (VIN) • The nature of your concern

25 12_Non-turbo_MMNA_3rd.book Page 26 Tuesday, August 2, 2011 9:59 AM

CUSTOMER SATISFACTION

CUSTOMER SATISFACTION Step 2: Contact MMNA’s Customer Relations At MMNA, we are proud of the quality and of the workman- Department ship that is built into every MMNA Vehicle. We are equally CALL->1-888-648-7820 proud of our corporate commitment to promote the highest After the completion of Step 1 and in the event your Autho- possible degree of customer satisfaction with our products rized Mitsubishi Motors Dealer or Authorized Service Cen- and services. ter has been unable to provide an adequate resolution, Today’s automobiles are extremely complex and are com- contact MMNA’s Customer Relations Department. prised of an enormous number of individual parts. Occa- Be sure to have your 17-character Vehicle Identification sionally, a problem with one of these parts can occur. Number (VIN) available when you call. Should you experience such a problem, we are confident that you will find your Authorized Mitsubishi Motors Dealer If you choose to write us, please send your correspon- or Authorized Service Center prepared to provide you with dence to the following address: high quality service repairs. Every Authorized Mitsubishi Motors Dealer or Authorized Service Center has Mitsu- Mitsubishi Motors North America, Inc. bishi-trained personnel, plus the tools and equipment nec- Customer Relations Department essary to provide for your various service needs. P.O. Box 6400 In the event a problem arises, we ask that you follow the Cypress, CA 90630 procedure outlined on the following pages. Please be sure to include your name, address and tele- Step 1: Contact the Nearest Authorized Mitsubishi phone number along with your 17-character vehicle identifi- Motors Dealer or Authorized Service Center: cation number. The VIN (vehicle identification number) can This is the most direct and expedient way to obtain service. be found in the upper corner of the dashboard on the Authorized Mitsubishi Motors Dealers or Authorized Ser- driver’s side of the vehicle and on your vehicles’ registra- vice Centers have the ultimate responsibility for providing tion. the service and repairs you may need. We recommend that MMNA’s Customer Relations Department will be prepared you contact the Dealership Service Advisor or Service to investigate your concern and provide you with assis- Manager for assistance. In the event that you feel addi- tance. tional assistance is required, ask to speak to the Dealer- ship owner. Since it is his or her business, he or she will be Step 3: Dispute Resolution very interested in your continued satisfaction and patron- (See “Notice to Consumers” on Page 24.) age. 26 12_Non-turbo_MMNA_3rd.book Page 27 Tuesday, August 2, 2011 9:59 AM

ROADSIDE ASSISTANCE

ROADSIDE ASSISTANCE FOR 5 YEARS/ Should your Mitsubishi Vehicle become inoperable due to a warrantable failure after the expiration of 5 years/Unlimited UNLIMITED MILEAGE mileage roadside service, MMNA will arrange for the vehi- Should you ever need it, you have access to 24-hour emer- cle to be towed to the nearest Mitsubishi Motors Dealer or gency roadside assistance for 5 full years from the date of other approved service point. the original retail delivery or original use, whichever is ear- Please retain all towing receipts; you will be reimbursed for lier, regardless of mileage. Covered services include tow- towing expenses if it is determined that the vehicle became ing, jump starts, flat tire service, emergency fuel and fluid inoperable due to a warrantable failure. delivery, and much more. NOTE: CALL-> 1-888-648-7820 • ROADSIDE ASSISTANCE FOR 5 YEARS/UNLIMITED Please have your 17-character Vehicle Identification Num- MILEAGE and TOWING-AFTER EXPIRATION OF 5 ber (VIN) available when you call. YEARS/UNLIMITED MILEAGE ROAD ASSISTANCE are a service which is provided to you at no charge as You are covered for: part of the purchase of your Mitsubishi vehicle. Gener- ally, there is no charge for any of the Roadside Assis- • Towing to the nearest Mitsubishi Motors Dealer or other tance services listed for the five full years, without approved service point from the point of disablement if regard to mileage. However, you will be responsible for your vehicle is not drivable (Please retain all towing the cost of non-warrantable parts, lost-key replacement, receipts.) and non-warrantable tire repair. • Jump-starts in the event of a dead battery • These programs are NOT a warranty and are subject to • Exchange of a flat tire with your inflated spare change without notice. MMNA reserves the right to limit • Emergency fuel and fluid delivery and/or change available services. • Lockout assistance to gain entry into your vehicle • Roadside Assistance excludes winching of vehicles off • Mechanical “first aid” for minor roadside repairs or adjust- road, vehicles disabled in rally, racing or other competi- ments tive events, and vehicles used for commercial purposes such as police, taxi, route delivery, livery, or daily rental TOWING-AFTER EXPIRATION OF 5 YEARS/ services. • ALL TOWING services are only one-way from the point UNLIMITED MILEAGE ROAD ASSISTANCE of disablement to the nearest Mitsubishi Motors Dealer CALL-> 1-888-648-7820 or other approved service point; you are responsible to Please have your 17-character Vehicle Identification Num- pick up your vehicle from the Mitsubishi Motors Dealer ber (VIN) available when you call. or approved service point after it has been repaired.

27 12_Non-turbo_MMNA_3rd.book Page 28 Tuesday, August 2, 2011 9:59 AM

U.S. territories and possessions (Except Puerto Rico and U.S. Virgin Islands)

INTRODUCTION MITSUBISHI warrants to the owner of each New 2012 MITSUBISHI passenger car and sport utility vehicle (hereinafter referred tos a“Vehicle”) that the Vehicle and any part of the Vehicle (except tires and items listed under the headings“ OTHERS” and “WHAT IS NOT COVERED”) shall be free, under normal use and maintenance from defects in material and workmanship, subject to the following terms and conditions: WARRANTY START DATE This warranty starts on the date of original retail delivery or original use, whichever occurs first. OBTAINING WARRANTY SERVICE To obtain warranty service, you must return your Vehicle to any Authorized Mitsubishi Motors Dealer or Authorized Service Center where such service will be performed without charge for parts and/or labor. OBTAINING WARRANTY SERVICE IN U.S. When a Vehicle purchased in the United States territories and possessions is registered in U.S., the Mitsubishi warranty in U.S. will apply. In the event you are temporarily traveling in U.S. (e.g. vacation), the warranty issued with this Vehicle will apply and warranty service will be provided by an Authorized Mitsubishi Motors Dealer in U.S. Should an Authorized Mitsubishi Motors Dealer charge for warranty repairs, you should obtain a detailed receipt covering the work performed and, upon return home, contact the selling Authorized Mitsubishi Motors Dealer for reimbursement consideration. NEW VEHICLE LIMITED WARRANTY 12 months/ 5 years/ 7 years/ Coverage 12,000 miles 60,000 miles 100,000 miles New Vehicle Limited Coverage Adjustments Anti-corrosion

EMISSION CONTROL SYSTEM WARRANTY 2 years/ 5 years/ 8 years/ Coverage 24,000 miles 60,000 miles 80,000 miles Defect warranty • Emission-related parts • Engine Control Module, Transmission Control Module, Catalytic Converter(s) and Onboard Emission Diagnostic Device Performance warranty • Emission-related parts • Engine Control Module, Transmission Control Module, Catalytic Converter(s) and Onboard Emission Diagnostic Device

28 12_Non-turbo_MMNA_3rd.book Page 29 Tuesday, August 2, 2011 9:59 AM

U.S. territories and possessions (Except Puerto Rico and U.S. Virgin Islands)

NEW VEHICLE LIMITED WARRANTY COVERAGE AND TERM ADJUSTMENT PERIOD Adjustments required as a result of the manufacturing deficiency are covered for the For the first 5 years or 60,000 miles, whichever occurs first, any part of this Vehicle first 12 months or 12,000 miles, whichever occurs first. supplied by MITSUBISHI (except batteries, adjustments required as a result of a manufacturing deficiency, air conditioner refrigerant charge, tires and items listed WHAT IS NOT COVERED under the headings “OTHERS” and “WHAT IS NOT COVERED”), which proves ALTERATION, MISUSE, OR ACCIDENT DAMAGE defective in normal use will be repaired or replaced by any Authorized Mitsubishi Motors Dealer or Authorized Service Center, using new or remanufactured Autho- Examples are: • Any Vehicle previously declared a total loss and/or transferred or title branded as rized Mitsubishi Motors parts. salvage, due to an accident or other catastrophic event • Collision, fire, theft, freezing, vandalism, riot, explosion, or objects striking the Vehi- NOTE: cle Aftermarket parts or accessories not supplied or approved by MITSUBISHI are • Misusing the Vehicle, such as, but not limited to, driving over curbs, overloading, NOT covered by this warranty. racing, or using the Vehicle as a stationary power source • Alteration of the Vehicle, including, but not limited to, the body, chassis, braking COVERAGE APPLICATION system, software programming or other components This coverage applies to all owners of this Vehicle during the stated time and mileage • Tampering with, or alteration of the emissions control systems or other parts that limitations. This Limited Warranty applies only to Vehicle registered and normally affect these systems • Disconnecting or altering the odometer, where the actual mileage cannot be determined operated in United States territories and possessions. • Contaminated or improper fuel/fluids BATTERY • Damage due to customer-applied chemicals (For example: Abrasive waxes, Pol- ishes, Sealants, etc.) During the first 24 months, with unlimited mileage, a defective original equipment battery will be replaced free of charge. Should the battery fail after 24 months but DAMAGE CAUSED BY USE AND/OR THE ENVIRONMENT before the 37th month of service, it will be replaced under warranty at a 50% charge Examples are: to the customer. Labor to test, remove and install the warranty replacement battery • Airborne fallout • Salt will be covered at 100%. A battery that is merely discharged is not considered defec- • Industrial fallout • Stones tive. • Chemicals • Road hazards OTHERS • Acid rain • Hail • Tree sap • Insects The following factory installed items are covered under warranty for 3 years or • Bird droppings • Lightning 36,000 miles, whichever occurs first. • Sand • Floods • Audio units, amplifiers, navigation systems, CD changers, DVD video players and other vehicle entertainment systems. MODIFICATIONS • Bulbs (All filament bulbs) Damage or performance problems resulting from modifications to or racing of your AIR CONDITIONER REFRIGERANT CHARGE Vehicle are not covered under warranty. The air conditioner refrigerant charge is covered for 1 year or 12,000 miles, which- Examples of modifications to your Vehicle that can cause damage or performance ever occurs first. After that, refrigerant charge is only covered as part of a warranty problems include the following: covered repair to the air conditioning system. • Failure to use Mitsubishi Motors genuine parts • Failure to use required fuel and fluids TIRES • Failure to use proper size tires and wheels The tires on your Vehicle are warranted independently from this limited warranty by • Modification of the fuel, intake, exhaust, emission, suspension, engine, drive train the individual tire manufacturer. The individual tire manufacturer’s warranty state- or electrical wiring systems ment has been provided with your Vehicle. To obtain tire warranty service, you must • Modification of any onboard computer/control module, including reprogramming, or follow the procedures outlined in the tire warranty statement. replacing/adding chips to any onboard computer/control module

29 12_Non-turbo_MMNA_3rd.book Page 30 Tuesday, August 2, 2011 9:59 AM

U.S. territories and possessions (Except Puerto Rico and U.S. Virgin Islands)

DAMAGE CAUSED BY IMPROPER MAINTENANCE OR FAILURE TO PAINT AND OTHER APPEARANCE ITEMS FOLLOW THE RECOMMENDED MAINTENANCE SCHEDULE Defects in paint, trim or other appearance items are normally noted and corrected The repair of damages which are in fact caused because parts or service used were during the new vehicle inspection. For your protection, should you find any paint or not those prescribed in this manual’s recommended maintenance schedule. appearance item which you suspect is defective, advise your Authorized Mitsubishi Maintenance services are not covered under warranty as it is the owner’s responsi- Motors Dealer without delay, as normal deterioration due to use and exposure is not bility to maintain your Vehicle as more fully set forth in, and in accordance with, the covered by this warranty. maintenance schedules outlined in this manual. OTHER Incidental or consequential damages such as loss of use of Vehicle, loss of time, MAINTENANCE / WEAR inconvenience, expense for gasoline, telephone, travel or lodging, loss or damage to Parts and labor needed to maintain the Vehicle and the replacement of parts due to personal property, commercial loss of revenue or other matters not specifically normal wear and tear are not covered by warranty and are the owners’ responsibility included are not covered. (unless those costs result from a covered repair). • Batteries of keyless entry remote fob WARRANTY REPAIR ORDER • Brake pads/shoes If you should have warranty service performed on this Vehicle, you are entitled to • Cleaning and polishing receive a copy of the repair order listing the warranty service performed. RETAIN • Clutch disc facings THESE COPIES FOR YOUR RECORDS. • Engine tune-ups • Lubrication • Replacing filters, coolant, or fuses PRODUCTION CHANGES • Replacing spark plugs MITSUBISHI and its Authorized Mitsubishi Motors Dealers reserve the right to make • Wiper blades changes in Vehicles sold by them at any time without incurring any obligation to • Software and map updates for Navigation systems (such updates are considered an make the same or similar changes on Vehicles previously sold by them. owner responsible expense) EMERGENCY ROAD SERVICE/TOWING Receipts covering the performance of the maintenance services should be retained Should your Vehicle become inoperable due to a warrantable failure during the first 5 in the event questions arise concerning maintenance. These receipts should be years or 60,000 miles, MITSUBISHI will authorize the Vehicle to be towed to the transferred to each subsequent owner of this Vehicle. MITSUBISHI reserves the right nearest Authorized Mitsubishi Motors Dealer or Authorized Service Center at no to deny warranty coverage if the Vehicle has not been properly maintained. However, charge. Contact the nearest Authorized Mitsubishi Motors Dealer or Authorized Ser- denial will not be based solely on the absence of maintenance records. vice Center to make arrangements. Towing will not be covered if your Vehicle is driveable and driving would not pose a safety problem or cause further damage to the Vehicle. Towing will not be covered if your Vehicle is inoperable as a result of an accident, owner abuse, lack of maintenance, or driver error.

Towing beyond the 5 years or 60,000 miles limit for Emergency Road Service will still be considered a covered condition if the problem that caused the need for the tow is still covered under an applicable MITSUBISHI warranty such as for a powertrain or emission’s warranty covered component. Covered towing conditions beyond 5 years or 60,000 miles, whichever occurs first, will be reimbursed by your servicing Mitsu- bishi Motors Dealer or Authorized Service Center.

30 12_Non-turbo_MMNA_3rd.book Page 31 Tuesday, August 2, 2011 9:59 AM

U.S. territories and possessions (Except Puerto Rico and U.S. Virgin Islands)

ANTI-CORROSION PERFORATION LIMITED WARRANTY THINGS YOU SHOULD KNOW ABOUT YOUR MITSUBISHI ANTI- MITSUBISHI warrants to the owner of each Vehicle that any Authorized Mitsubishi CORROSION PERFORATION LIMITED WARRANTY: Motors Dealer or Authorized Service Center will repair or replace at no charge any body sheet metal panel found to have developed perforation (metal rust-through) due REPAIRING YOUR MITSUBISHI VEHICLE to corrosion in normal use. This warranty begins on the date of original retail delivery If your Vehicle is damaged and requires sheet metal repair or replacement, be sure or original use, whichever occurs first, and extends for 5 years regardless of mileage. anti-corrosion materials are applied to the parts repaired or replaced. In addition, outer panel rust-through protection coverage is extended as follows: • Vehicles are covered for 7 years or 100,000 miles, whichever occurs first. It is the MAINTAINING YOUR MITSUBISHI VEHICLE owner’s responsibility under the terms of this warranty to maintain the Vehicle as Washing: specified in this manual and in the Owner’s Manual. The best way to preserve your Vehicle’s finish and aid in avoiding rust is to keep the Vehicle clean by washing it frequently. Wash the Vehicle only with lukewarm or cold NOTE: water. Do not wash the Vehicle in the direct rays of the sun, or use strong soap or This anti-corrosion perforation warranty covers perforation due to corrosion only. chemical detergents. Any cleaning agents used should be washed off promptly and Perforation means a rust-through condition, such as an actual hole in a sheet not allowed to dry on the finish. metal panel. This warranty applies to Vehicles registered and normally operated in the United Foreign Material Deposits: States territories and possessions. Calcium chloride and other salts, ice melting agents, road oil and tar, tree sap, bird droppings, chemicals from industrial chimneys, acid rain, and other foreign matter may damage the Vehicle finish if left on the painted surfaces. Prompt washing may WARRANTY DOES NOT COVER: not completely remove all these deposits. Additional cleaners may be needed. When using chemical cleaners developed for this purpose, be sure they are safe for use on • Corrosion due to accident, damage, abuse, abnormal use, Vehicle alteration or fail- painted surfaces. ure to properly maintain this Vehicle • Payments for loss of use of the Vehicle during warranty repairs Underbody Maintenance: • Surface corrosion, such as that caused by industrial fallout, sand, salt, hail and Corrosive materials used for ice removal and dust control can collect on underbody stones surfaces. If these materials are not removed, accelerated corrosion can occur on the • Corrosion due to extensive and/or abnormal transportation of corrosive material underbody parts, such as fuel lines, frame, floor pan and exhaust system. such as, but not limited to, chemicals, acid, fertilizer At least twice a year, thoroughly flush these materials from the underbody with plain • Corrosion other than perforation (metal rust-through) due to defects in material or water. Take care to clean any areas where mud and other debris can collect. workmanship that is otherwise covered by the 5 years or 60,000 miles MITSUBISHI New Vehicle Limited Warranty Finish Damage: • Any implied warranty applicable to this Vehicle is limited in duration to the length of Any stone chips, fractures or deep scratches in the finish should be repaired this written warranty. MITSUBISHI shall not be liable for any incidental, consequen- promptly. tial, special or exemplary damages for breach of this warranty or any implied war- Bare metal will corrode quickly and can develop into a major repair expense. Minor ranty. chips and scratches can be repaired with touch-up materials available from your Authorized Mitsubishi Motors Dealer or Authorized Service Center.

31 12_Non-turbo_MMNA_3rd.book Page 32 Tuesday, August 2, 2011 9:59 AM

U.S. territories and possessions (Except Puerto Rico and U.S. Virgin Islands)

EMISSION CONTROL SYSTEM DEFECT WARRANTY EMISSION WARRANTY PARTS MITSUBISHI warrants to the owner of each Vehicle, (1) that the Vehicle, was • Catalytic Converters designed, built and equipped so as to conform at the time of sale to applicable regu- • Electronic Spark Control lations of the National Emission Standards Act, as amended, and (2) the Vehicle is • Evaporative Emission Canister, Evaporative Emission Liquid Separator and Con- free from defects in material and workmanship at the time of sale which would cause trols the Vehicle to fail to conform with such regulations for a period of 5 years or 60,000 • Exhaust Gas Recirculation Valve and Control System • Fuel Tank Filler Tube and Cap miles, whichever occurs first. • Induction Control Valve Assembly MITSUBISHI additionally warrants the Engine Control Module, Transmission Control • Multiport Fuel Injection System Module, Catalytic Converter(s) and Onboard Emission Diagnostic Device for 8 years • Positive Crankcase Ventilation Valve or 80,000 miles, whichever occurs first. • Timing Advance/Retard System Any part of this Vehicle covered under this limited emission defect warranty and • Hoses, Clamps, Brackets, Pipes, Gaskets, Belts, Seals and Connectors used in the which proves to be defective will be repaired or replaced at no charge by any Autho- above systems rized Mitsubishi Motors Dealer or Authorized Service Center, using new or remanu- • Vacuum, Temperature, Altitude, Speed and Time Sensitive Valves and Switches for factured Authorized Mitsubishi Motors Parts. The limited warranty period begins on the above systems the date of original retail delivery or original use, whichever occurs first. • Any other components necessary to assure conformity This limited emission defect warranty shall not apply to parts other than Authorized Mitsubishi Motors Parts. If failure of one of these components results in failure of another part, both will be covered by the performance warranty. EMISSION CONTROL SYSTEM PERFORMANCE WAR- WHAT IS NOT COVERED RANTY • Noncompliance caused by defective replacement parts not certified in accordance Some states and local jurisdictions have established periodic vehicle inspection and with aftermarket parts certification regulations. maintenance (I/M) programs to encourage proper maintenance of your Vehicle. • Noncompliance caused by the use of replacement parts not equivalent to original If an I/M Program in your area has the U.S. Environmental Protection Agency (EPA) equipment parts. approval, you may be eligible for MITSUBISHI’s performance warranty coverage Other provisions specified under the“ WHAT IS NOT COVERED” section in the New under the following conditions: Vehicle Limited Warranty are also applicable to this warranty. 1. The Vehicle has been maintained and operated in accordance with the scheduled maintenance instructions described in this manual provided with your Vehicle. THE EMISSION CONTROL SYSTEM DEFECT WARRANTY AND THE EMISSION 2. The Vehicle fails to conform for a period of 2 years or 24,000 miles, whichever CONTROL SYSTEM PERFORMANCE WARRANTY SHALL NOT APPLY TO: occurs first, to the applicable emission standards of EPA, as judged by an EPA • Conditions resulting from contaminated fuel, misuse, improper adjustments, modifi- approved I/M Test. cations, accidents, alterations, tampering, acts of God, improper or inadequate MITSUBISHI additionally warrants the Engine Control Module, Transmission maintenance, or failure to use recommended fuel Control Module, Catalytic Converter(s) and Onboard Emission Diagnostic Device • The replacement of maintenance parts used in regular maintenance services for 8 years or 80,000 miles, whichever occurs first. • Loss of time, inconvenience, loss of use of the Vehicle, or other consequential dam- 3. The failure to conform results, or will result, in the owner of the Vehicle having to ages bear a penalty or other sanctions, including the denial or the right to use the Vehi- • Any Vehicle on which the odometer reading has been changed so that mileage can- cle under local, state or federal law. not be readily determined. If all the foregoing conditions are met, MITSUBISHI warrants that any Authorized Mit- subishi Motors Dealer or Authorized Service Center will replace, repair or adjust to MITSUBISHI’s specifications at no charge, any of the components listed below or MITSUBISHI does not authorize any person to create for it any other obligations or liability in connection with these systems. These warranties are in addition to MIT- parts thereof, which may be necessary to cause your Vehicle to conform to the appli- SUBISHI’s New Vehicle Limited Warranty for Vehicles. cable emission standards. Parts “Certified to EPA Standards” shall be covered by this performance warranty. This performance warranty period begins on the date of original retail delivery or original use, whichever occurs first. 32 12_Non-turbo_MMNA_3rd.book Page 33 Tuesday, August 2, 2011 9:59 AM

U.S. territories and possessions (Except Puerto Rico and U.S. Virgin Islands)

If an owner’s warranty claim under the Emission Control Systems Performance War- THINGS YOU SHOULD KNOW ABOUT BOTH THE EMISSION CON- ranty is denied, MITSUBISHI will provide the owner with a written explanation of why TROL SYSTEM DEFECT WARRANTY AND THE EMISSION CON- the claim was denied within 30 days unless a shorter time period is required by law. TROL SYSTEM PERFORMANCE WARRANTY Failure to provide an explanation within the required period may obligate MITSUB- ISHI to remedy the nonconformity under the Emission Control Systems Performance The emission control system of your Vehicle was designed, built and tested using Warranty except: Authorized Mitsubishi Motors Parts and the Vehicle is certified as being in conformity with applicable emission regulations. Accordingly, it is recommended that any * When delay is requested by the Vehicle owner. replacement parts used for maintenance or for the repair of emission control systems * When delay is caused by factors beyond the control of MITSUBISHI or Authorized be new or remanufactured Authorized Mitsubishi Motors Parts. Mitsubishi Motors Dealers or Authorized Service Centers. Further information can be obtained from and complaints registered with: THE WARRANTY OBLIGATIONS ARE NOT DEPENDENT UPON THE USE OF ANY PARTICULAR BRAND OF REPLACEMENT PART. THE OWNER MAY ELECT Manager, Vehicle Compliance Programs Group TO USE NON-AUTHORIZED MITSUBISHI MOTORS PARTS FOR REPLACEMENT Vehicle Programs and Compliance Division PURPOSES. THE USE OF REPLACEMENT PARTS WHICH ARE NOT EQUIVA- Environmental Protection Agency LENT MAY IMPAIR THE EFFECTIVENESS OF EMISSION CONTROL SYSTEMS. 401 “M” Street, S.W. NMS-6405J If other than Authorized Mitsubishi Motors Parts are used for maintenance replace- Washington, D.C. 20460 ments or for the repair of components affecting emission control, the owner should determine that such parts are warranted by the manufacturer to be equivalent to Authorized Mitsubishi Motors Parts in performance and durability. NOTE: “New or Remanufactured Authorized Mitsubishi Motors Parts” when used in con- MAINTENANCE REPLACEMENT OR REPAIR OF THE EMISSION CONTROL nection with Vehicles, means parts manufactured by or approved by MITSUBISHI, DEVICES AND SYSTEMS MAY BE PERFORMED BY ANY QUALIFIED AUTOMO- designed for use on Vehicles and distributed by MITSUBISHI or any division or TIVE REPAIR ESTABLISHMENT OR INDIVIDUAL USING ANY PART CERTIFIED subsidiary of MITSUBISHI. PURSUANT TO APPLICABLE EMISSION REGULATIONS; HOWEVER, WAR- RANTY SERVICE MUST BE PERFORMED BY AN AUTHORIZED MITSUBISHI MOTORS DEALER OR AUTHORIZED SERVICE CENTER. IF YOU HAVE ANY QUESTIONS Claims under the Emission Control Systems Performance Warranty may not be MITSUBISHI and Authorized Mitsubishi Motors Dealers are vitally interested in your denied due to the failure of a properly installed certified non-Authorized Mitsubishi satisfaction with our products and service. Motors Part. In the event a warranty or any other matter is not handled to your satisfaction, please discuss the matter with your Mitsubishi Motors Dealer Management. Receipts covering the performance of maintenance services should be retained in the event questions arise concerning maintenance. These receipts should be transferred to each subsequent owner of this Vehicle. MITSUBISHI reserves the right to deny warranty coverage if the Vehicle has not been properly maintained. However, denial will not be based solely on the absence of maintenance records. These warranties apply only to Vehicles manufactured to United States specifications and registered and normally operated in the United States territories and possessions. Vehicles manufactured to other specifications or registered and normally operated elsewhere, shall be entitled to service of emission control systems on the basis of the warranty applicable to such other country.

33 12_Non-turbo_MMNA_3rd.book Page 34 Tuesday, August 2, 2011 9:59 AM

Maintenance Service precautions Selecting the proper maintenance

Vehicle maintenance is an important yet frequently schedule neglected item. Proper maintenance will aid in retaining the level of performance that has been engineered into your There are two maintenance schedules that show proper Mitsubishi vehicle and it will guard against major repair service for your vehicle. expenses resulting from neglect. Good maintenance is First is “Regular maintenance schedule”. necessary to protect your investment and ensure proper Follow the Regular maintenance schedule only if none of performance. the driving conditions in the Severe maintenance section Your Mitsubishi Motors Dealership is in the best position to apply. provide proper maintenance service through Mitsubishi’s exclusive “Triple Diamond Service”. Second is “Severe maintenance schedule”. Follow the severe maintenance schedule only if your vehi- • Factory Trained Technicians cle is frequently driven under one or more of the following • Advanced Diagnostic Equipment road conditions. • Quality Workmanship • Mitsubishi Genuine parts • Driving on dusty, rough, muddy or salt-spread roads • Mitsubishi Authorized Accessories • Towing or police, taxi or commercial operation • Competitive Prices • Extensive idling and /or low speed operation • Fast Service • Repeated short-trip operation at freezing temperatures • Commitment to Customer Satisfaction (engine not thoroughly warmed up) • Extended use of brakes while driving • Driving in sandy areas • More than 50 % operation in heavy city traffic during hot weather above 90 °F (32 °C)

34 12_Non-turbo_MMNA_3rd.book Page 35 Tuesday, August 2, 2011 9:59 AM

Maintenance Emission control system mainte- Service station checks

nance The following items should be inspected by either you or a service station attendant each time fuel is added: The “scheduled” maintenance services, listed inbold type must be done at the times or mileages specified to assure • Engine oil level. Add if needed. Check Owner’s Manual- the continued proper functioning of the emission control See index and look under “Engine Oil” for detailed infor- system. These, and all other maintenance services mation. included in this manual, should be done to provide the best • Engine coolant level. Add coolant to reservoir tank along vehicle performance and reliability. with the proper mix if needed. Replace coolant if dirty or Inspection and service also should be done any time a mal- rusty in color. Check Owner’s Manual-See index and look function is suspected. under “Coolant” for detailed information. • Windshield washer fluid level. Add fluid to washer tank if To ensure proper emission control performance, you necessary. should continue scheduled maintenance beyond the 10 • Tire inspection. Inspect for unusual tire wear and proper year period shown, by following the same schedule pattern inflation. Check Owners’ Manual-See index and look as for the first 10 years. under “Tire” for detailed information.

35 12_Non-turbo_MMNA_3rd.book Page 36 Tuesday, August 2, 2011 9:59 AM

Regular Maintenance Schedule

Enter Your Original In-Service Date Here: 15,000 Miles (24,000 km) Rotate tires. MILEAGE/ DEALERSHIP REPAIR DATE Month Day Year MONTHS NAME/CODE ORDER #

Original In-Service Date

15,000 Miles (24,000 km) or at 12 months Regular maintenance schedule Change engine oil. The content and mileage interval can vary depending on Replace engine oil filter. model. Inspect disc brake pads and rotors for wear. Check brake hoses for deterioration or leaks. Mileage or Time-Whichever occurs first Inspect drive shaft boots for grease leaks and damage. 7,500 Miles (12,000 km) Replace air purifier filter (if so equipped). Rotate tires. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

22,500 Miles (36,000 km) 7,500 Miles (12,000 km) or at 6 months Rotate tires. Change engine oil. MILEAGE/ DEALERSHIP REPAIR DATE Replace engine oil filter. MONTHS NAME/CODE ORDER # MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

36 12_Non-turbo_MMNA_3rd.book Page 37 Tuesday, August 2, 2011 9:59 AM

Regular Maintenance Schedule

Mileage or Time-Whichever occurs first Check and service exhaust system (connection 22,500 Miles (36,000 km) or at 18 months portion of muffler, muffler pipes and converter heat Change engine oil. shields). *1 Replace engine oil filter. Change engine oil. MILEAGE/ DEALERSHIP REPAIR Replace engine oil filter. DATE MONTHS NAME/CODE ORDER # Check manual transaxle/transmission oil level and condition. Check transfer oil level and condition. Inspect coolant hoses condition 30,000 Miles (48,000 km) (radiator hose, heater hose). Rotate tires. Inspect disc brake pads and rotors for wear. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # Inspect rear drum brake linings and rear wheel cylin- ders (except vehicles with disc brakes) for wear and leaks of all wheels. Check brake hoses for deterioration or leaks. 30,000 Miles (48,000 km) or at 24 months Inspect ball joint and steering linkage seals for grease Check fuel hoses condition. *1 leaks and damage. *1 This maintenance is recommended but is not Inspect drive shaft boots for grease leaks and damage. required to maintain the emissions warranty. Inspect suspension system for looseness and dam- Replace air cleaner filter. age. Inspect and adjust intake and exhaust valve clear- Check rear axle oil level. ance. [4G6-MIVEC engine and 6G7/6B3-MIVEC Replace air purifier filter (if so equipped). engine (intake side) only] MILEAGE/ DEALERSHIP REPAIR DATE If valve noise increases, adjust valve clearance.* MONTHS NAME/CODE ORDER # * This maintenance is not “scheduled” service, should be done any time. Check drive belts condition (for the generator, water pump, power steering pump). 37 12_Non-turbo_MMNA_3rd.book Page 38 Tuesday, August 2, 2011 9:59 AM

Regular Maintenance Schedule

Mileage or Time-Whichever occurs first 45,000 Miles (72,000 km) or at 36 months 37,500 Miles (60,000 km) Change engine oil. Rotate tires. Replace engine oil filter. MILEAGE/ DEALERSHIP REPAIR DATE Inspect disc brake pads and rotors for wear. MONTHS NAME/CODE ORDER # Check brake hoses for deterioration or leaks. Inspect drive shaft boots for grease leaks and damage. Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR 37,500 Miles (60,000 km) or at 30 months DATE MONTHS NAME/CODE ORDER # Change engine oil. Replace engine oil filter. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # 52,500 Miles (84,000 km) Rotate tires. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # 45,000 Miles (72,000 km) Rotate tires. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # 52,500 Miles (84,000 km) or at 42 months Change engine oil. Replace engine oil filter. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

38 12_Non-turbo_MMNA_3rd.book Page 39 Tuesday, August 2, 2011 9:59 AM

Regular Maintenance Schedule

Mileage or Time-Whichever occurs first Check and service exhaust system (connection 60,000 Miles (96,000 km) portion of muffler, muffler pipes and converter heat Rotate tires. shields). MILEAGE/ DEALERSHIP REPAIR Change engine oil. DATE MONTHS NAME/CODE ORDER # Replace engine oil filter. Check manual transaxle/transmission oil level and condition. Change transfer oil. 60,000 Miles (96,000 km) or at 48 months Change engine coolant (4G6 and 6G7 engines). Check fuel system for leaks (tank, pipe line and connection, and fuel tank filler Inspect coolant hoses condition tube cap). (radiator hose, heater hose). Inspect disc brake pads and rotors for wear. Check fuel hoses condition. Inspect rear drum brake linings and rear wheel cylin- Replace air cleaner filter. ders (except vehicles with disc brakes) for wear and Check evaporative emission control system for leaks of all wheels. leaks and clogging (except evaporative emission canister). Check brake hoses for deterioration or leaks. Inspect ball joint and steering linkage seals for grease Inspect and adjust intake and exhaust valve clear- leaks and damage. ance (4B1 engine). Inspect drive shaft boots for grease leaks and damage. Inspect and adjust intake and exhaust valve clearance. [4G6-MIVEC engine and 6G7/6B3-MIVEC Inspect suspension system for looseness and dam- engine (intake side) only] age. If valve noise increases, adjust valve clearance. * Check rear axle oil level. * This maintenance is not “scheduled” service, should Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR be done any time. DATE Check drive belts condition (for the generator, MONTHS NAME/CODE ORDER # water pump, power steering pump).

39 12_Non-turbo_MMNA_3rd.book Page 40 Tuesday, August 2, 2011 9:59 AM

Regular Maintenance Schedule

Mileage or Time-Whichever occurs first 75,000 Miles (120,000 km) or at 60 months 67,500 Miles (108,000 km) Change engine oil. Rotate tires. Replace engine oil filter. MILEAGE/ DEALERSHIP REPAIR DATE Inspect disc brake pads and rotors for wear. MONTHS NAME/CODE ORDER # Check brake hoses for deterioration or leaks. Inspect drive shaft boots for grease leaks and damage. Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR 67,500 Miles (108,000 km) or at 54 months DATE MONTHS NAME/CODE ORDER # Change engine oil. Replace engine oil filter. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # 82,500 Miles (132,000 km) Rotate tires. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # 75,000 Miles (120,000 km) Rotate tires. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # 82,500 Miles (132,000 km) or at 66 months Change engine oil. Replace engine oil filter. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

40 12_Non-turbo_MMNA_3rd.book Page 41 Tuesday, August 2, 2011 9:59 AM

Regular Maintenance Schedule

Mileage or Time-Whichever occurs first Inspect coolant hoses condition 90,000 Miles (144,000 km) (radiator hose, heater hose). Rotate tires. Inspect disc brake pads and rotors for wear. MILEAGE/ DEALERSHIP REPAIR DATE Inspect rear drum brake linings and rear wheel cylin- MONTHS NAME/CODE ORDER # ders (except vehicles with disc brakes) for wear and leaks of all wheels. Check brake hoses for deterioration or leaks. Inspect ball joint and steering linkage seals for grease 90,000 Miles (144,000 km) or at 72 months leaks and damage. Check fuel hoses condition. Inspect drive shaft boots for grease leaks and damage. Replace air cleaner filter. Inspect suspension system for looseness and dam- Inspect and adjust intake and exhaust valve clear- age. ance. [4G6-MIVEC engine and 6G7/6B3-MIVEC Check rear axle oil level. engine (intake side) only] If valve noise increases, adjust valve clearance. * Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE * This maintenance is not “scheduled” service, should MONTHS NAME/CODE ORDER # be done any time. Check drive belts condition (for the generator, water pump, power steering pump). Check and service exhaust system (connection portion of muffler, muffler pipes and converter heat shields). Change engine oil. Replace engine oil filter. Check manual transaxle/transmission oil level and condition. Check transfer oil level and condition. Change engine coolant (4G6 and 6G7 engines). 41 12_Non-turbo_MMNA_3rd.book Page 42 Tuesday, August 2, 2011 9:59 AM

Regular Maintenance Schedule

Mileage or Time-Whichever occurs first 105,000 Miles (168,000 km) or at 84 months 97,500 Miles (156,000 km) Replace spark plugs, iridium-tipped type. Rotate tires. Change engine oil. MILEAGE/ DEALERSHIP REPAIR DATE Replace engine oil filter. MONTHS NAME/CODE ORDER # Inspect disc brake pads and rotors for wear. Check brake hoses for deterioration or leaks. Inspect drive shaft boots for grease leaks and damage. 97,500 Miles (156,000 km) or at 78 months Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR Change engine oil. DATE MONTHS NAME/CODE ORDER # Replace engine oil filter. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

112,500 Miles (180,000 km) Rotate tires. MILEAGE/ DEALERSHIP REPAIR 105,000 Miles (168,000 km) DATE MONTHS NAME/CODE ORDER # Replace timing belt (except 4B1 engine). Rotate tires. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # 112,500 Miles (180,000 km) or at 90 months Change engine oil. Replace engine oil filter. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

42 12_Non-turbo_MMNA_3rd.book Page 43 Tuesday, August 2, 2011 9:59 AM

Regular Maintenance Schedule

Mileage or Time-Whichever occurs first Check and service exhaust system (connection 120,000 Miles (192,000 km) portion of muffler, muffler pipes and converter heat Rotate tires. shields). MILEAGE/ DEALERSHIP REPAIR Change engine oil. DATE MONTHS NAME/CODE ORDER # Replace engine oil filter. Check manual transaxle/transmission oil level and condition. Change transfer oil. 120,000 Miles (192,000 km) or at 96 months Change engine coolant (4G6 and 6G7 engines). Check fuel system for leaks (tank, pipe line and connection, and fuel tank filler Change engine coolant (4B1 and 6B3 engines*). tube cap). * Change at first 120,000 Miles (192,000 km) or at 96 months, thereafter every 90,000 Miles (144,000 km) Check fuel hoses condition. or 72 months. Replace air cleaner filter. Inspect coolant hoses condition Check evaporative emission control system for (radiator hose, heater hose). leaks and clogging (except evaporative emission Inspect disc brake pads and rotors for wear. canister). Inspect rear drum brake linings and rear wheel cylin- Inspect and adjust intake and exhaust valve clear- ders (except vehicles with disc brakes) for wear and ance (4B1 engine). leaks of all wheels. Inspect and adjust intake and exhaust valve clear- Check brake hoses for deterioration or leaks. ance. [4G6-MIVEC engine and 6G7/6B3-MIVEC Inspect ball joint and steering linkage seals for grease engine (intake side) only] leaks and damage. If valve noise increases, adjust valve clearance. * Inspect drive shaft boots for grease leaks and damage. * This maintenance is not “scheduled” service, should Inspect suspension system for looseness and dam- be done any time. age. Check drive belts condition (for the generator, water pump, power steering pump). Check rear axle oil level.

43 12_Non-turbo_MMNA_3rd.book Page 44 Tuesday, August 2, 2011 9:59 AM

Regular Maintenance Schedule

Replace air purifier filter (if so equipped). 135,000 Miles (216,000 km) or at 108 months MILEAGE/ DEALERSHIP REPAIR Change engine oil. DATE MONTHS NAME/CODE ORDER # Replace engine oil filter. Inspect disc brake pads and rotors for wear. Check brake hoses for deterioration or leaks. Mileage or Time-Whichever occurs first Inspect drive shaft boots for grease leaks and damage. 127,500 Miles (204,000 km) Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR Rotate tires. DATE MONTHS NAME/CODE ORDER # MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

142,500 Miles (228,000 km) 127,500 Miles (204,000 km) or at 102 months Rotate tires. MILEAGE/ DEALERSHIP REPAIR Change engine oil. DATE MONTHS NAME/CODE ORDER # Replace engine oil filter. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

142,500 Miles (228,000 km) or at 114 months Change engine oil. 135,000 Miles (216,000 km) Replace engine oil filter. MILEAGE/ DEALERSHIP REPAIR Rotate tires. DATE MONTHS NAME/CODE ORDER # MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

44 12_Non-turbo_MMNA_3rd.book Page 45 Tuesday, August 2, 2011 9:59 AM

Regular Maintenance Schedule

Mileage or Time-Whichever occurs first Inspect coolant hoses condition 150,000 Miles (240,000 km) (radiator hose, heater hose). Rotate tires. Inspect disc brake pads and rotors for wear. MILEAGE/ DEALERSHIP REPAIR DATE Inspect rear drum brake linings and rear wheel cylin- MONTHS NAME/CODE ORDER # ders (except vehicles with disc brakes) for wear and leaks of all wheels. Check brake hoses for deterioration or leaks. Inspect ball joint and steering linkage seals for grease 150,000 Miles (240,000 km) or at 120 months leaks and damage. Check fuel hoses condition. Inspect drive shaft boots for grease leaks and damage. Replace air cleaner filter. Inspect suspension system for looseness and dam- Inspect and adjust intake and exhaust valve clear- age. ance. [4G6-MIVEC engine and 6G7/6B3-MIVEC Check rear axle oil level. engine (intake side) only] If valve noise increases, adjust valve clearance. * Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE * This maintenance is not “scheduled” service, should MONTHS NAME/CODE ORDER # be done any time. Check drive belts condition (for the generator, water pump, power steering pump). Check and service exhaust system (connection portion of muffler, muffler pipes and converter heat shields). Change engine oil. Replace engine oil filter. Check manual transaxle/transmission oil level and condition. Check transfer oil level and condition. Change engine coolant (4G6 and 6G7 engines). 45 12_Non-turbo_MMNA_3rd.book Page 46 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Severe maintenance schedule 7,500 Miles (12,000 km) or at 6 months The content and mileage interval can vary depending on Change engine oil. model. Replace engine oil filter. Mileage or Time-Whichever occurs first Inspect disc brake pads and rotors for wear. Inspect suspension system for looseness and dam- 3,750 Miles (6,000 km) age. Rotate tires (Lancer 2.4 L with 18" wheels only). Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE MILEAGE/ DEALERSHIP REPAIR MONTHS NAME/CODE ORDER # DATE MONTHS NAME/CODE ORDER #

3,750 Miles (6,000 km) or at 3 months 11,250 Miles (18,000 km) Change engine oil. Rotate tires (Lancer 2.4 L with 18" wheels only). Replace engine oil filter. MILEAGE/ DEALERSHIP REPAIR DATE Inspect air purifier filter for clogging (if so equipped). MONTHS NAME/CODE ORDER # MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

11,250 Miles (18,000 km) or at 9 months Change engine oil. 7,500 Miles (12,000 km) Replace engine oil filter. Rotate tires. Inspect air purifier filter for clogging (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE MILEAGE/ DEALERSHIP REPAIR MONTHS NAME/CODE ORDER # DATE MONTHS NAME/CODE ORDER #

46 12_Non-turbo_MMNA_3rd.book Page 47 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Mileage or Time-Whichever occurs first 18,750 Miles (30,000 km) 15,000 Miles (24,000 km) Rotate tires (Lancer 2.4 L with 18" wheels only). Rotate tires. MILEAGE/ DEALERSHIP REPAIR DATE MILEAGE/ DEALERSHIP REPAIR MONTHS NAME/CODE ORDER # DATE MONTHS NAME/CODE ORDER #

18,750 Miles (30,000 km) or at 15 months 15,000 Miles (24,000 km) or at 12 months Change engine oil. Replace air cleaner filter. Replace engine oil filter. Change engine oil. Inspect air purifier filter for clogging (if so equipped). Replace engine oil filter. MILEAGE/ DEALERSHIP REPAIR DATE Check automatic transaxle/transmission fluid level and MONTHS NAME/CODE ORDER # condition. Inspect disc brake pads and rotors for wear. Inspect rear drum brake linings and rear wheel cylin- ders (except vehicles with disc brakes) for wear and 22,500 Miles (36,000 km) leaks of all wheels. Rotate tires. MILEAGE/ DEALERSHIP REPAIR Check brake hoses for deterioration or leaks. DATE MONTHS NAME/CODE ORDER # Inspect drive shaft boots for grease leaks and damage. Inspect suspension system for looseness and damage. Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

47 12_Non-turbo_MMNA_3rd.book Page 48 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Mileage or Time-Whichever occurs first 30,000 Miles (48,000 km) 22,500 Miles (36,000 km) or at 18 months Rotate tires. Change engine oil. MILEAGE/ DEALERSHIP REPAIR DATE Replace engine oil filter. MONTHS NAME/CODE ORDER # Inspect disc brake pads and rotors for wear. Inspect suspension system for looseness and damage. 30,000 Miles (48,000 km) or at 24 months Replace air purifier filter (if so equipped). Check fuel hoses condition. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # Replace air cleaner filter. Inspect and adjust intake and exhaust valve clearance. [4G6-MIVEC engine and 6G7/6B3-MIVEC engine (intake side) only] 26,250 Miles (42,000 km) If valve noise increases, adjust valve clearance. * Rotate tires (Lancer 2.4 L with 18" wheels only). * This maintenance is not “scheduled ”service, should be done any time. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # Check drive belts condition (for the generator, water pump, power steering pump). Check and service exhaust system (connection portion of muffler, muffler pipes and converter heat 26,250 Miles (42,000 km) or at 21 months shields). Change engine oil. Change engine oil. Replace engine oil filter. Replace engine oil filter. Inspect air purifier filter for clogging (if so equipped). Change manual transaxle/transmission oil. Change automatic transaxle/transmission fluid. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # Change transfer oil. Inspect coolant hoses condition (radiator hose, heater hose). 48 12_Non-turbo_MMNA_3rd.book Page 49 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Inspect disc brake pads and rotors for wear. 33,750 Miles (54,000 km) or at 27 months Inspect rear drum brake linings and rear wheel cylin- Change engine oil. ders (except vehicles with disc brakes) for wear and Replace engine oil filter. leaks of all wheels. Inspect air purifier filter for clogging (if so equipped). Check brake hoses for deterioration or leaks. MILEAGE/ DEALERSHIP REPAIR DATE Inspect ball joint and steering linkage seals for grease MONTHS NAME/CODE ORDER # leaks and damage. Inspect drive shaft boots for grease leaks and damage. Inspect suspension system for looseness and damage. 37,500 Miles (60,000 km) Check rear axle oil level. Rotate tires. Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE MILEAGE/ DEALERSHIP REPAIR MONTHS NAME/CODE ORDER # DATE MONTHS NAME/CODE ORDER #

Mileage or Time-Whichever occurs first 37,500 Miles (60,000 km) or at 30 months Change engine oil. 33,750 Miles (54,000 km) Replace engine oil filter. Rotate tires (Lancer 2.4 L with 18" wheels only). Inspect disc brake pads and rotors for wear. MILEAGE/ DEALERSHIP REPAIR DATE Inspect suspension system for looseness and dam- MONTHS NAME/CODE ORDER # age. Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

49 12_Non-turbo_MMNA_3rd.book Page 50 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Mileage or Time-Whichever occurs first 45,000 Miles (72,000 km) or at 36 months 41,250 Miles (66,000 km) Replace air cleaner filter. Rotate tires (Lancer 2.4 L with 18" wheels only). Change engine oil. MILEAGE/ DEALERSHIP REPAIR Replace engine oil filter. DATE MONTHS NAME/CODE ORDER # Check automatic transaxle/transmission fluid level and condition. Inspect disc brake pads and rotors for wear. Inspect rear drum brake linings and rear wheel cylin- 41,250 Miles (66,000 km) or at 33 months ders (except vehicles with disc brakes) for wear and Change engine oil. leaks of all wheels. Replace engine oil filter. Check brake hoses for deterioration or leaks. Inspect air purifier filter for clogging (if so equipped). Inspect drive shaft boots for grease leaks and damage. MILEAGE/ DEALERSHIP REPAIR DATE Inspect suspension system for looseness and dam- MONTHS NAME/CODE ORDER # age. Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # 45,000 Miles (72,000 km) Rotate tires. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # 48,750 Miles (78,000 km) Rotate tires (Lancer 2.4 L with 18" wheels only). MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

50 12_Non-turbo_MMNA_3rd.book Page 51 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Mileage or Time-Whichever occurs first 56,250 Miles (90,000 km) 48,750 Miles (78,000 km) or at 39 months Rotate tires (Lancer 2.4 L with 18" wheels only). Change engine oil. MILEAGE/ DEALERSHIP REPAIR DATE Replace engine oil filter. MONTHS NAME/CODE ORDER # Inspect air purifier filter for clogging (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # 56,250 Miles (90,000 km) or at 45 months Change engine oil. Replace engine oil filter. 52,500 Miles (84,000 km) Inspect air purifier filter for clogging (if so equipped). Rotate tires. MILEAGE/ DEALERSHIP REPAIR DATE MILEAGE/ DEALERSHIP REPAIR MONTHS NAME/CODE ORDER # DATE MONTHS NAME/CODE ORDER #

60,000 Miles (96,000 km) 52,500 Miles (84,000 km) or at 42 months Rotate tires. Change engine oil. MILEAGE/ DEALERSHIP REPAIR DATE Replace engine oil filter. MONTHS NAME/CODE ORDER # Inspect disc brake pads and rotors for wear. Inspect suspension system for looseness and damage. Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

51 12_Non-turbo_MMNA_3rd.book Page 52 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Mileage or Time-Whichever occurs first Replace engine oil filter. 60,000 Miles (96,000 km) or at 48 months Change manual transaxle/transmission oil. Check fuel system for leaks Change automatic transaxle/transmission fluid. (tank, pipe line and connection, and fuel tank filler Change transfer oil. tube cap). Change engine coolant (4G6 and 6G7 engines). Check fuel hoses condition. Inspect coolant hoses condition Replace air cleaner filter. (radiator hose, heater hose). Check evaporative emission control system for Inspect disc brake pads and rotors for wear. leaks and clogging (except evaporative emission Inspect rear drum brake linings and rear wheel cylin- canister). ders (except vehicles with disc brakes) for wear and Inspect and adjust intake and exhaust valve clear- leaks of all wheels. ance (4B1 engine). Check brake hoses for deterioration or leaks. Inspect and adjust intake and exhaust valve clear- Inspect ball joint and steering linkage seals for grease ance. [4G6-MIVEC engine and 6G7/6B3-MIVEC leaks and damage. engine (intake side) only] Inspect drive shaft boots for grease leaks and damage. If valve noise increases, adjust valve clearance. * Inspect suspension system for looseness and dam- * This maintenance is not “scheduled” service, should age. be done any time. Check drive belts condition (for the generator, Check rear axle oil level. water pump, power steering pump). Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR Check and service exhaust system (connection DATE MONTHS NAME/CODE ORDER # portion of muffler, muffler pipes and converter heat shields). Change engine oil.

52 12_Non-turbo_MMNA_3rd.book Page 53 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Mileage or Time-Whichever occurs first 67,500 Miles (108,000 km) or at 54 months 63,750 Miles (102,000 km) Change engine oil. Rotate tires (Lancer 2.4 L with 18" wheels only). Replace engine oil filter. MILEAGE/ DEALERSHIP REPAIR DATE Inspect disc brake pads and rotors for wear. MONTHS NAME/CODE ORDER # Inspect suspension system for looseness and damage. Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR 63,750 Miles (102,000 km) or at 51 months DATE MONTHS NAME/CODE ORDER # Change engine oil. Replace engine oil filter. Inspect air purifier filter for clogging (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE 71,250 Miles (114,000 km) MONTHS NAME/CODE ORDER # Rotate tires (Lancer 2.4 L with 18" wheels only). MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

67,500 Miles (108,000 km) Rotate tires. MILEAGE/ DEALERSHIP REPAIR DATE 71,250 Miles (114,000 km) or at 57 months MONTHS NAME/CODE ORDER # Change engine oil. Replace engine oil filter. Inspect air purifier filter for clogging (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

53 12_Non-turbo_MMNA_3rd.book Page 54 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Mileage or Time-Whichever occurs first 78,750 Miles (126,000 km) 75,000 Miles (120,000 km) Rotate tires (Lancer 2.4 L with 18" wheels only). MILEAGE/ DEALERSHIP REPAIR Rotate tires. DATE MONTHS NAME/CODE ORDER # MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

78,750 Miles (126,000 km) or at 63 months 75,000 Miles (120,000 km) or at 60 months Change engine oil. Replace air cleaner filter. Replace engine oil filter. Change engine oil. Inspect air purifier filter for clogging (if so equipped). MILEAGE/ DEALERSHIP REPAIR Replace engine oil filter. DATE Check automatic transaxle/transmission fluid level and MONTHS NAME/CODE ORDER # condition. Inspect disc brake pads and rotors for wear. Inspect rear drum brake linings and rear wheel cylin- 82,500 Miles (132,000 km) ders (except vehicles with disc brakes) for wear and Rotate tires. leaks of all wheels. MILEAGE/ DEALERSHIP REPAIR DATE Check brake hoses for deterioration or leaks. MONTHS NAME/CODE ORDER # Inspect drive shaft boots for grease leaks and damage. Inspect suspension system for looseness and damage. Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

54 12_Non-turbo_MMNA_3rd.book Page 55 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Mileage or Time-Whichever occurs first 90,000 Miles (144,000 km) 82,500 Miles (132,000 km) or at 66 months Rotate tires. Change engine oil. MILEAGE/ DEALERSHIP REPAIR DATE Replace engine oil filter. MONTHS NAME/CODE ORDER # Inspect disc brake pads and rotors for wear. Inspect suspension system for looseness and damage. 90,000 Miles (144,000 km) or at 72 months Replace air purifier filter (if so equipped). Check fuel hoses condition. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # Replace air cleaner filter. Inspect and adjust intake and exhaust valve clearance. [4G6-MIVEC engine and 6G7/6B3-MIVEC engine (intake side) only] 86,250 Miles (138,000 km) If valve noise increases, adjust valve clearance. * Rotate tires (Lancer 2.4 L with 18" wheels only). * This maintenance is not “scheduled” service, should MILEAGE/ DEALERSHIP REPAIR be done any time. DATE MONTHS NAME/CODE ORDER # Check drive belts condition (for the generator, water pump, power steering pump). Check and service exhaust system (connection portion of muffler, muffler pipes and converter heat 86,250 Miles (138,000 km) or at 69 months shields). Change engine oil. Change engine oil. Replace engine oil filter. Replace engine oil filter. Inspect air purifier filter for clogging (if so equipped). Change manual transaxle/transmission oil. MILEAGE/ DEALERSHIP REPAIR DATE Change automatic transaxle/transmission fluid. MONTHS NAME/CODE ORDER # Change transfer oil. Change engine coolant (4G6 and 6G7 engines).

55 12_Non-turbo_MMNA_3rd.book Page 56 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Inspect coolant hoses condition 93,750 Miles (150,000 km) or at 75 months (radiator hose, heater hose). Change engine oil. Inspect disc brake pads and rotors for wear. Replace engine oil filter. Inspect rear drum brake linings and rear wheel cylin- Inspect air purifier filter for clogging (if so equipped). ders (except vehicles with disc brakes) for wear and MILEAGE/ DEALERSHIP REPAIR DATE leaks of all wheels. MONTHS NAME/CODE ORDER # Check brake hoses for deterioration or leaks. Inspect ball joint and steering linkage seals for grease leaks and damage. Inspect drive shaft boots for grease leaks and damage. 97,500 Miles (156,000 km) Inspect suspension system for looseness and dam- Rotate tires. MILEAGE/ DEALERSHIP REPAIR age. DATE MONTHS NAME/CODE ORDER # Check rear axle oil level. Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # 97,500 Miles (156,000 km) or at 78 months Change engine oil. Replace engine oil filter. Mileage or Time-Whichever occurs first Inspect disc brake pads and rotors for wear. 93,750 Miles (150,000 km) Inspect suspension system for looseness and dam- Rotate tires (Lancer 2.4 L with 18" wheels only). age. MILEAGE/ DEALERSHIP REPAIR Replace air purifier filter (if so equipped). DATE MONTHS NAME/CODE ORDER # MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

56 12_Non-turbo_MMNA_3rd.book Page 57 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Mileage or Time-Whichever occurs first 105,000 Miles (168,000 km) or at 84 months 101,250 Miles (162,000 km) Replace air cleaner filter. Rotate tires (Lancer 2.4 L with 18" wheels only). Replace spark plugs, iridium-tipped type. MILEAGE/ DEALERSHIP REPAIR DATE Replace timing belt (except 4B1 engine). MONTHS NAME/CODE ORDER # Change engine oil. Replace engine oil filter. Check automatic transaxle/transmission fluid level and 101,250 Miles (162,000 km) or at 81 months condition. Change engine oil. Inspect disc brake pads and rotors for wear. Replace engine oil filter. Inspect rear drum brake linings and rear wheel cylin- ders (except vehicles with disc brakes) for wear and Inspect air purifier filter for clogging (if so equipped). leaks of all wheels. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # Check brake hoses for deterioration or leaks. Inspect drive shaft boots for grease leaks and damage. Inspect suspension system for looseness and damage. 105,000 Miles (168,000 km) Replace air purifier filter (if so equipped). Rotate tires. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

57 12_Non-turbo_MMNA_3rd.book Page 58 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Mileage or Time-Whichever occurs first 112,500 Miles (180,000 km) or at 90 months 108,750 Miles (174,000 km) Change engine oil. Rotate tires (Lancer 2.4 L with 18" wheels only). Replace engine oil filter. MILEAGE/ DEALERSHIP REPAIR DATE Inspect disc brake pads and rotors for wear. MONTHS NAME/CODE ORDER # Inspect suspension system for looseness and damage. Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR 108,750 Miles (174,000 km) or at 87 months DATE MONTHS NAME/CODE ORDER # Change engine oil. Replace engine oil filter. Inspect air purifier filter for clogging (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE 116,250 Miles (186,000 km) MONTHS NAME/CODE ORDER # Rotate tires (Lancer 2.4 L with 18" wheels only). MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

112,500 Miles (180,000 km) Rotate tires. MILEAGE/ DEALERSHIP REPAIR DATE 116,250 Miles (186,000 km) or at 93 months MONTHS NAME/CODE ORDER # Change engine oil. Replace engine oil filter. Inspect air purifier filter for clogging (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

58 12_Non-turbo_MMNA_3rd.book Page 59 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Mileage or Time-Whichever occurs first Check and service exhaust system (connection 120,000 Miles (192,000 km) portion of muffler, muffler pipes and converter heat Rotate tires. shields). MILEAGE/ DEALERSHIP REPAIR Change engine oil. DATE MONTHS NAME/CODE ORDER # Replace engine oil filter. Change manual transaxle/transmission oil. Change automatic transaxle/transmission fluid. Change transfer oil. 120,000 Miles (192,000 km) or at 96 months Change engine coolant (4G6 and 6G7 engines). Check fuel system for leaks (tank, pipe line and connection, and fuel tank filler Change engine coolant (4B1 and 6B3 engines*). tube cap). * Change at first 120,000 Miles (192,000 km) or at 96 months, thereafter every 90,000 Miles (144,000 km) Check fuel hoses condition. or 72 months. Replace air cleaner filter. Inspect coolant hoses condition Check evaporative emission control system for (radiator hose, heater hose). leaks and clogging (except evaporative emission Inspect disc brake pads and rotors for wear. canister). Inspect rear drum brake linings and rear wheel cylin- Inspect and adjust intake and exhaust valve clear- ders (except vehicles with disc brakes) for wear and ance (4B1 engine). leaks of all wheels. Inspect and adjust intake and exhaust valve clear- Check brake hoses for deterioration or leaks. ance. [4G6-MIVEC engine and 6G7/6B3-MIVEC Inspect ball joint and steering linkage seals for grease engine (intake side) only] leaks and damage. If valve noise increases, adjust valve clearance. * Inspect drive shaft boots for grease leaks and damage. * This maintenance is not “scheduled” service, should Inspect suspension system for looseness and dam- be done any time. Check drive belts condition (for the generator, age. water pump, power steering pump). Check rear axle oil level.

59 12_Non-turbo_MMNA_3rd.book Page 60 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Replace air purifier filter (if so equipped). 127,500 Miles (204,000 km) or at 102 months MILEAGE/ DEALERSHIP REPAIR DATE Change engine oil. MONTHS NAME/CODE ORDER # Replace engine oil filter. Inspect disc brake pads and rotors for wear. Inspect suspension system for looseness and dam- Mileage or Time-Whichever occurs first age. 123,750 Miles (198,000 km) Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR Rotate tires (Lancer 2.4 L with 18" wheels only). DATE MONTHS NAME/CODE ORDER # MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

131,250 Miles (210,000 km) 123,750 Miles (198,000 km) or at 99 months Rotate tires (Lancer 2.4 L with 18" wheels only). MILEAGE/ DEALERSHIP REPAIR Change engine oil. DATE Replace engine oil filter. MONTHS NAME/CODE ORDER # Inspect air purifier filter for clogging (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # 131,250 Miles (210,000 km) or at 105 months Change engine oil. Replace engine oil filter. 127,500 Miles (204,000 km) Inspect air purifier filter for clogging (if so equipped). MILEAGE/ DEALERSHIP REPAIR Rotate tires. DATE MONTHS NAME/CODE ORDER # MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

60 12_Non-turbo_MMNA_3rd.book Page 61 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Mileage or Time-Whichever occurs first 138,750 Miles (222,000 km) 135,000 Miles (216,000 km) Rotate tires (Lancer 2.4 L with 18" wheels only). MILEAGE/ DEALERSHIP REPAIR Rotate tires. DATE MONTHS NAME/CODE ORDER # MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

138,750 Miles (222,000 km) or at 111 months 135,000 Miles (216,000 km) or at 108 months Change engine oil. Replace air cleaner filter. Replace engine oil filter. Change engine oil. Inspect air purifier filter for clogging (if so equipped). MILEAGE/ DEALERSHIP REPAIR Replace engine oil filter. DATE Check automatic transaxle/transmission fluid level and MONTHS NAME/CODE ORDER # condition. Inspect disc brake pads and rotors for wear. Inspect rear drum brake linings and rear wheel cylin- 142,500 Miles (228,000 km) ders (except vehicles with disc brakes) for wear and Rotate tires. leaks of all wheels. MILEAGE/ DEALERSHIP REPAIR DATE Check brake hoses for deterioration or leaks. MONTHS NAME/CODE ORDER # Inspect drive shaft boots for grease leaks and damage. Inspect suspension system for looseness and damage. Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

61 12_Non-turbo_MMNA_3rd.book Page 62 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Mileage or Time-Whichever occurs first 150,000 Miles (240,000 km) 142,500 Miles (228,000 km) or at 114 months Rotate tires. Change engine oil. MILEAGE/ DEALERSHIP REPAIR DATE Replace engine oil filter. MONTHS NAME/CODE ORDER # Inspect disc brake pads and rotors for wear. Inspect suspension system for looseness and damage. 150,000 Miles (240,000 km) or at 120 months Replace air purifier filter (if so equipped). Check fuel hoses condition. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # Replace air cleaner filter. Inspect and adjust intake and exhaust valve clearance. [4G6-MIVEC engine and 6G7/6B3-MIVEC engine (intake side) only] 146,250 Miles (234,000 km) If valve noise increases, adjust valve clearance. * Rotate tires (Lancer 2.4 L with 18" wheels only). * This maintenance is not “scheduled ”service, should be done any time. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # Check drive belts condition (for the generator, water pump, power steering pump). Check and service exhaust system (connection portion of muffler, muffler pipes and converter heat 146,250 Miles (234,000 km) or at 117 months shields). Change engine oil. Change engine oil. Replace engine oil filter. Replace engine oil filter. Change manual transaxle/transmission oil. Inspect air purifier filter for clogging (if so equipped). Change automatic transaxle/transmission fluid. MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER # Change transfer oil. Change engine coolant (4G6 and 6G7 engines).

62 12_Non-turbo_MMNA_3rd.book Page 63 Tuesday, August 2, 2011 9:59 AM

Severe Maintenance Schedule

Inspect coolant hoses condition (radiator hose, heater hose). Inspect disc brake pads and rotors for wear. Inspect rear drum brake linings and rear wheel cylin- ders (except vehicles with disc brakes) for wear and leaks of all wheels. Check brake hoses for deterioration or leaks. Inspect ball joint and steering linkage seals for grease leaks and damage. Inspect drive shaft boots for grease leaks and damage. Inspect suspension system for looseness and damage. Check rear axle oil level. Replace air purifier filter (if so equipped). MILEAGE/ DEALERSHIP REPAIR DATE MONTHS NAME/CODE ORDER #

63 12_Non-turbo_MMNA_3rd.book Page 64 Tuesday, August 2, 2011 9:59 AM 12_Non-turbo_MMNA_3rd.book Page 65 Tuesday, August 2, 2011 9:59 AM 2012 Non-Turbos MSSP010D12 9290D_____ TBD