DOCSLIB.ORG

Pilot Operating Handbook RV 4 Example

Total Page：16

File Type：pdf, Size：1020Kb

Download full-text PDF Read full-text
Pilot Operating Handbook RV 4 Example Pilots Operating Handbook RV-4 C-GFEW VANS RV-4 C-GFEW PILOT’S OPERATING HANDBOOK SERNO. 2794 Constructed: 1999 Builder: Mike Toews Last Revision: 9 January 2003 1 Pilots Operating Handbook RV-4 C-GFEW Table of Contents Section .........................................................................................................Page No. 1. GFEW DESCRIPTION.....................................................................................................6 1.1 General.......................................................................................................................6 1.2 Cockpit.......................................................................................................................8 1.3 Station Diagram.........................................................................................................9 1.3.1 Fuselage .............................................................................................................9 1.3.2 Wing/Tail .........................................................................................................10 1.4 Engine ......................................................................................................................10 1.5 Propeller...................................................................................................................10 1.6 Fuel ..........................................................................................................................11 1.7 OIL...........................................................................................................................11 1.8 Abbreviations and Acronyms ..................................................................................12 1.8.1 Conversion Factors..........................................................................................13 2. LIMITATIONS................................................................................................................14 2.1 Airspeed ...................................................................................................................14 2.2 Weight......................................................................................................................15 2.2.1 Center of Gravity .............................................................................................15 2.2.2 Load Factors....................................................................................................15 2.3 Engine ......................................................................................................................15 2.3.1 Placards............................................................................................................16 2.4 Types of Approved Operation .................................................................................17 3. EMERGENCY PROCEDURES......................................................................................18 2 Pilots Operating Handbook RV-4 C-GFEW 3.1 General.....................................................................................................................18 3.2 Emergency Procedures.............................................................................................18 3.3 Stall and Spin Recovery...........................................................................................20 3.3.1 Stalls.................................................................................................................20 3.3.2 Spins & Spin Recovery....................................................................................20 4. NORMAL PROCEDURES.............................................................................................22 4.1 Operating Speeds.....................................................................................................22 4.2 Entry Speeds – Aerobatic Flight..............................................................................23 4.3 Engine Operation.....................................................................................................23 4.3.1 Starting.............................................................................................................24 4.3.2 Shutdown .........................................................................................................24 4.4 Check Lists..............................................................................................................25 5. PERFORMANCE............................................................................................................27 5.1 General.....................................................................................................................27 5.2 Airspeed Calibration................................................................................................27 5.2.1 Take off & Landing .........................................................................................27 5.3 Aerobatics ................................................................................................................27 6. WEIGHT & BALANCE..................................................................................................29 6.1 General.....................................................................................................................29 6.2 Moment Arms ..........................................................................................................29 7. SYSTEMS and OPERATION .........................................................................................30 7.1 Airframe...................................................................................................................30 7.2 Engine and Propeller................................................................................................30 7.3 Landing gear............................................................................................................30 3 Pilots Operating Handbook RV-4 C-GFEW 7.4 Flight Controls.........................................................................................................31 7.5 Fuel System..............................................................................................................32 7.6 Electrical System.....................................................................................................32 7.7 Instrument Panel......................................................................................................32 7.8 Static Air Pressure System.......................................................................................33 7.9 Heating and Ventilation...........................................................................................33 7.10 Cockpit and Baggage features .................................................................................33 7.11 Canopy .....................................................................................................................34 8. GROUND HANDLING, SERVICE & MAINTENANCE .............................................35 8.1 General.....................................................................................................................35 8.2 Ground Handling.....................................................................................................35 8.3 Inspection Panels.....................................................................................................35 8.4 Cowling Removal ....................................................................................................36 8.4.1 Tools Required.................................................................................................36 8.4.2 Procedure .........................................................................................................37 8.5 Fuel Tank .................................................................................................................39 8.5.1 Removal (one side) ..........................................................................................39 8.5.2 Installation .......................................................................................................39 8.6 Flight Control Access..............................................................................................39 8.6.1 Fwd Cockpit.....................................................................................................39 8.6.2 Aft Cockpit.......................................................................................................40 8.6.3 Aft Fuselage.....................................................................................................40 8.7 Maintenance and Service.........................................................................................40 8.8 Service Notices and Special Inspections .................................................................42 4 Pilots Operating Handbook RV-4 C-GFEW 9. EQUIPMENT LISTING..................................................................................................43 9.1 Engine, accessories & Instruments ..........................................................................43 9.2 Suppliers List...........................................................................................................45 Engine Lubrication ........................................................................................................65 List of Figures Figure 3 – Canopy Operation ..................................................................................
Load more

Recommended publications
  • General Aviation Managing Sumped Aviation Gas (Avgas)
    DEPARTMENT OF ENVIRONMENTAL HEALTH HAZARDOUS MATERIALS DIVISION P.O. BOX 129261, SAN DIEGO, CA 92112-9261 Phone: (858) 505-6700 or (800) 253-9933 Fax: (858) 505-6786 www.sdcdeh.org GENERAL AVIATION MANAGING SUMPED AVIATION GAS (AVGAS) County of San Diego Pollution Prevention Summary: Small amounts of AvGas fuel are “sumped” (sampled) during pre-flight safety inspections If safe to do so, clean AvGas may be returned to the aircraft fuel tank AvGas may be recycled by filtering with devices such as the GATS jar AvGas may be repurposed for use in certain motorized ground equipment If not recycled, waste AvGas must be disposed of lawfully as a hazardous waste Any water sumped from a fuel tank must be disposed of lawfully as a hazardous waste If you sump AvGas you must have a legal means of hazardous waste disposal readily available California law prohibits disposing of aviation gasoline (AvGas) to the ground, sewer, or storm drain. Violators are subject to fines up to $25,000 per incident. Refer to the California Health and Safety Code [HSC §25100] for more details. INTRODUCTION According to Federal Aviation Administration (FAA) data, there were approximately 140,000 active piston-powered General Aviation (GA) aircraft in the United States with over 12.9 million hours flown in 2014. Each of those aircraft rely on aviation gas (AvGas) to fuel their engines. AvGas is a highly flammable liquid containing organic lead and is a hazardous material. During the mandatory pre-flight safety inspection, pilots sample the fuel in the aircraft and inspect the fuel for contaminants.
    [Show full text]
  • Aviation Maintenance Alerts
    ADVISORY CIRCULAR 43-16A AVIATION MAINTENANCE ALERTS ALERT SEPTEMBER NUMBER 2007 350 CONTENTS AIRPLANES BEECH ........................................................................................................................................1 CESSNA ......................................................................................................................................3 MAULE .......................................................................................................................................7 HELICOPTERS EUROCOPTER ...........................................................................................................................7 SIKORSKY..................................................................................................................................7 ACCESSORIES AEROTECH ALTERNATOR.....................................................................................................9 ECI CYLINDER........................................................................................................................10 WIPAIRE...................................................................................................................................10 AIR NOTES INTERNET SERVICE DIFFICULTY REPORTING (iSDR) WEB SITE...............................10 IF YOU WANT TO CONTACT US.........................................................................................11 AVIATION SERVICE DIFFICULTY REPORTS ...................................................................12 September
    [Show full text]
  • 767, Awl, D622t001-9-01
    767-200/300/300F/400ER AIRWORTHINESS LIMITATIONS 767-200/300/300F/400ER AIRWORTHINESS LIMITATIONS (AWLs) D622T001-9-01 JUNE 2019 This document has EAR data with an Export Control Classification Number (ECCN) of 9E991. Export of this technology is controlled under the United States Export Administration Regulations (EAR) (15 CFR 730-774). An export license may be required before it is used for development, production or use by foreign persons from specific countries. The controller of this data has the individual responsibility to abide by all export laws. Boeing claims copyright in each page of this document on to the extent that the page contains copyrightable subject matter. Boeing also claims copyright in this document as a compilation and/or collective work. This document includes proprietary information owned by the Boeing Company and/or one or more third parties. Treatment of the document and the information it contains is governed by contract with Boeing. For more information, contact the Boeing Company, P.O. Box 3707, Seattle WA 98124. Boeing, the Boeing signature, the Boeing symbol, 707, 717, 727, 737, 747, 757, 767, 777, 787, BBJ, DC-8, DC-9, DC-10, MD-10, MD-11, MD-80, MD-88, MD-90, and the red-white-blue Boeing livery are all trademarks owned by The Boeing Company; no trademark license is granted in connection with this document unless provided in writing by Boeing. COMPILED AND PUBLISHED BY: MAINTENANCE PROGRAMS ENGINEERING BOEING COMMERCIAL AIRPLANE GROUP SEATTLE, WASHINGTON D622T001-9-01 JUN 2019 BOEING PROPRIETARY - Copyright
    [Show full text]
  • Aviation Investigation Report A06q0157 Engine Failure
    AVIATION INVESTIGATION REPORT A06Q0157 ENGINE FAILURE CESSNA 172M C-FFRV MONTRÉAL, QUEBEC 10 SEPTEMBER 2006 The Transportation Safety Board of Canada (TSB) investigated this occurrence for the purpose of advancing transportation safety. It is not the function of the Board to assign fault or determine civil or criminal liability. Aviation Investigation Report Engine Failure Cessna 172M C-FFRV Montréal, Quebec 10 September 2006 Report Number A06Q0157 Summary A Cessna 172M, registration C-FFRV, serial number 17262394, with the pilot and two passengers on board, took off at 1545 eastern daylight time from Saint-Hubert Airport, Quebec, for a flight according to visual flight rules over Montréal, Quebec. About 15 minutes after take-off, when the aircraft was over the city, the engine (Lycoming O320-H2AD) lost power and stopped. The pilot tried to restart it, but without success. The pilot transmitted a distress message and quickly reported the situation to the control tower. The aircraft was approximately 1250 feet above ground level at the time. The pilot landed the aircraft on the northbound side of Parc Avenue, in Montréal. On landing, the left wing tip struck a traffic light post before the aircraft came to rest. The aircraft was substantially damaged, but there were no injuries. Ce rapport est également disponible en français. - 2 - Other Factual Information The pilot was certified and qualified for the flight in accordance with existing regulations. He had over 30 years of flying experience, including 22 years on this aircraft, and had about 5000 flying hours. The weather observation taken at 1600 eastern daylight time1 was as follows: visibility 9 statute miles, light winds and a few scattered clouds.
    [Show full text]
  • Issue No. 4, Oct-Dec
    Focal Product Support: Commitment, Cooperation, Communication A SERVICE PUBLICATION OF The Lockheed Aeronautical Systems Company LOCKHEED AERONAUTICAL Product Support organization is determined to provide SYSTEMS COMPANY the highest level of service to each of our customers and every one of our airplanes. This level of support Editor is focused toward our personal commitment to our Charles I. Gale customers, quick and open lines of communication to provide information and receive feedback from our Art Director customers, and full cooperation with our customers Cathy E. Howard to develop a team approach to support. Vol. 20, No. 4, October-December 1993 The support arena has undergone vast change in John Gaffney recent years and LASC Product Support has had to CONTENTS evolve to keep pace and meet our customers’ needs. This evolution has resulted in the customer becoming 2 Focal Point more and more prominent in the market place, competition intensifying, and change John L. Gaffney, Director itself becoming constant. LASC Product Support Product Support has made changes and continues to make changes to respond 3 Ramp Hook Retainer to market conditions. Our customers indicated they wanted: Mislocation Playing mix and match with the A “one-stop shop” for all support services. We have become that “one- hook retainers makes cargo ramp stop shop.” Any element of support needed by a customer can be rigging an exercise in frustration. obtained from a single source within LASC Product Support. 10 Making a Ramp Hook Retainer Competitive prices. We are finalizing teaming arrangements which will Identification Tool allow us to offer customers a full spectrum of parts-new, used, and This locally manufactured shop aid overhauled-at competitive prices, all under the auspices of the original can correctly identify the retainers equipment manufacturer.
    [Show full text]
  • DA+40+POH.Pdf
    AIRPLANE FLIGHT MANUAL DA40 Airworthiness Category : Normal, Utility Requirement : JAR-23 Serial Number :40.698 Registration :N216DG , Doc. No. : 6.01.01-E Date of Issue : 26 June 2000 Signature Authority Stamp A-1 030 Wim, Sclmirchgassc 11 Date of approval 0 9. DEZ . Z.Oa4 This Flight Manuaj has been verified for EASA by the Austrian Civil Aviation Authority J Austro Control (ACG) as Primary Certification Authority (PCA) in accordance with the I valid Certifica1ion Procedures and approved by EASA with approval no ..2.004 :- A~3Zf, f This Flight Manual has been approved by EASA on behalf of CAAC-MD. DIAMOND AIRCRAFT INDUSTRIES GMBH N.A OTTO-STR. 5 A-2700 WIENER NEUSTADT A USTRIA page 0 - 0, R~v. 6 ~V/U~/UO mun U~:~O ~AA OD~ 0~/ ~~!U ~AA LAA~U ANM-lUUL ~3 ~011 AmSafe, Inc. Inflatable Restraints Division 1043 N. 47'" Avenue Phoenix, AZ., 85043 Document No.: E509609 r FAA APPROVED AIRPLANE FLIGHT MANUAL SUPPLEMENT to PILOT'S OPERATING HANDBOOK AND FAA APPROVED AIRPLANE FLIGHT MANUAL for Diamond Aircraft Industries, Inc. Model DA40 Aircraft Reg. No. N 2 16 DG Aircraft SIN: 4 0 • 6 9 8 This supplement must be attached to the Pilot's Operating Handbook and FAA Approved Airplane Flight Manual for Diamond Aircraft Model DA 40 when the. Airplane Is modified by the installation of AmSafe Aviation Inflatable Restraint (AAIR,.) System, V23 Version in accordance with STC SA01918LA. The information contained herein supplements or supersedes the basic manual only in those areas listed herein. For limitations, procedures, and performance information not contained in this supplement, consult c the basic Airplane Flight Manual.
    [Show full text]
  • Top Flite Models Inc
    Product Support (Do Not Remove From Department) INTRODUCTION TOP FLITE MODELS, INC. is proud to introduce the new Elder 40. This design is a direct result of popular demand after the great little Elder 20 was introduc- ed. Modelers loved the design, still do, but wanted something "larger" and "while you're at it, give it ailerons." So, here it is and does it ever fly nice'. The Elder 40 was designed and sized expressly for .40 engines and this includes the popular .40- .45 and .49 engines. The design turns in great performance with the four-stroke power plants and there is plenty of power margin left over for the aerobatic- minded pilot. However, the real "kick" of this design, like its smaller brother, is the the design with 4-cycle engines is an absolute delight. realistic, slow-speed flights that allow you to actually Give it a try in your Elder 40. Note that the motor mount see the airplane instead of just a blur. we have provided in the kit may not fit some 4-cycle The design lends itself to all kinds of detailing, if you're engines and it may be necessary to visit your local retail so inclined. For the beginner, nothing fancy is needed; hobby shop to get the right one for your engine. go out and fly it. The Elder 40 makes a remarkably good training aircraft with gentle and totally honest flying IMPORTANT NOTE: characteristics. A big bonus here is that your trainer is TOP FLITE MODELS, INC. would certainly recommend just not going to look like everyone else's high-wing, the Elder 40 as a first R/C powered aircraft.
    [Show full text]
  • The Wing Is the Principal Structural Unit of the Airplane. It Has Several Functions Beyond That of Providing Lift. for a Wing To
    1 WING The wing is the principal structural unit of the airplane. It has several functions beyond that of providing lift. For a wing to produce "lift", it must be oriented at a suitable angle of attack relative to the flow of air past the wing. In aerodynamics, angle of attack (AOA) specifies the angle between the chord line of the wing of a fixed-wing aircraft and the vector representing the relative motion between the aircraft and the atmosphere. On larger airplanes the engines are mounted in nacelles either attached to the wing or mounted in the wing. The nacelles also provide a housing for the landing gear when it is retracted. The space within the wing is usually used for fuel storage. The main geometrical features of a wing are its span; the area of the wing; its dihedral angle; its sweepback angle; and the wing section. Dihedral angle is the upward angle of an aircraft's wing, from the wing root to the wing tip. The amount of dihedral determines the amount of inherent stability along the roll axis. Although an increase of dihedral will increase inherent stability, it will also decrease lift, and increase drag. The design of the wing depends on the size, weight, and use of the airplane. Generally, there are two kinds of wing design: cantilever and semi-cantilever. The semi-cantilever usually has one, or perhaps two, supporting wires or struts attached to each wing and the fuselage. As far as the internal structure is concerned, there are three general types of conventional wings: monospar, two-spar, and multispar.
    [Show full text]
  • Chapter 28 Fuel
    EXTRA - FLUGZEUGBAU GmbH SERVICE MANUAL EXTRA 300 Chapter 28 Fuel PAGE DATE: 31. January 1995 CHAPTER 28 PAGE 1 EXTRA - FLUGZEUGBAU GmbH SERVICE MANUAL EXTRA 300 TABLE OF CONTENTS Chapter Titl 28-00-00 GENERAL . 3 28-01-00 MAINTENANCE PRACTICES . 6 28-01-01 Refueling/Defueling . 6 28-01-02 Reduction of Fuel Tank Vapor Hazards . 6 28-10-00 STORAGE . 8 28-11-00 MAINTENANCE PRACTICES . 10 28-11-01 Center Tank Removal/Installation . 10 28-11-02 Center Tank Flop Tube Removal/Installation . 11 28-11-03 Wing Tank Inspection Door Removal/Installation . 12 28-11-04 Wing Tank Outlets Removal/Installation . 13 28-11-05 Filler Neck Removal/Installation . 14 28-11-06 Filler Neck Sealing Lip Replacement . 14 28-11-07 Ventilation Line Replacement . 15 28-20-00 DISTRIBUTION . 17 28-21-00 MAINTENANCE PRACTICES . 19 28-21-01 Shut-Off Valve and Control Rod Removal/Installation . 19 28-21-02 Shut-Off Valve Lubrication . 19 28-21-03 Gascolator Removal/Installation . 22 28-21-04 Electrical Boost Pump Removal/Installation . 23 28-21-05 Fuel Line Replacement . 24 28-40-00 INDICATING . 27 28-41-00 MAINTENANCE PRACTICES . 29 28-41-01 Fuel Quantity Indicator Removal/Installation . 29 28-41-02 Fuel Quantity Indicator Calibration (Center Tank) . 30 28-41-03 Tubular Tank Unit (Center Tank) Removal/Installation . 30 28-41-04 Lever-type Tank Unit (Wing Tank) Removal/Installation . 31 28-41-05 Float Wire Adjustment . 32 PAGE DATE: 31. January 1995 CHAPTER 28 PAGE 2 EXTRA - FLUGZEUGBAU GmbH SERVICE MANUAL EXTRA 300 28-00-00 GENERAL The fuel system (refer to Figure 1 Page 4) consists of one center (acro) tank (1) with a drain (2) on its bottom, two wing tanks (8), a shut-off valve (7), a gascolator (6) with drain (5), an electrically driven auxiliary pump (3) and an engine driven rotary pump (4).
    [Show full text]
  • Airframe & Aircraft Components By
    Airframe & Aircraft Components (According to the Syllabus Prescribed by Director General of Civil Aviation, Govt. of India) FIRST EDITION AIRFRAME & AIRCRAFT COMPONENTS Prepared by L.N.V.M. Society Group of Institutes * School of Aeronautics ( Approved by Director General of Civil Aviation, Govt. of India) * School of Engineering & Technology ( Approved by Director General of Civil Aviation, Govt. of India) Compiled by Sheo Singh Published By L.N.V.M. Society Group of Institutes H-974, Palam Extn., Part-1, Sec-7, Dwarka, New Delhi-77 Published By L.N.V.M. Society Group of Institutes, Palam Extn., Part-1, Sec.-7, Dwarka, New Delhi - 77 First Edition 2007 All rights reserved; no part of this publication may be reproduced, stored in a retrieval system or transmitted in any form or by any means, electronic, mechanical, photocopying, recording or otherwise, without the prior written permission of the publishers. Type Setting Sushma Cover Designed by Abdul Aziz Printed at Graphic Syndicate, Naraina, New Delhi. Dedicated To Shri Laxmi Narain Verma [ Who Lived An Honest Life ] Preface This book is intended as an introductory text on “Airframe and Aircraft Components” which is an essential part of General Engineering and Maintenance Practices of DGCA license examination, BAMEL, Paper-II. It is intended that this book will provide basic information on principle, fundamentals and technical procedures in the subject matter areas relating to the “Airframe and Aircraft Components”. The written text is supplemented with large number of suitable diagrams for reinforcing the key aspects. I acknowledge with thanks the contribution of the faculty and staff of L.N.V.M.
    [Show full text]
  • Structural Certification of the F-16 Block 52+ Aircraft 29 November 2005 2005 USAF Aircraft Structural Integrity Program Conference
    Structural Certification of the F-16 Block 52+ Aircraft 29 November 2005 2005 USAF Aircraft Structural Integrity Program Conference Robert J. Burt Director and Deputy F-35 Structural Development and Integrity Lockheed Martin Aeronautics Company Fort Worth © 2005 LOCKHEED MARTIN CORPORATION Lockheed Martin Aeronautics Company Structural Certification of the F-16 Block 52+ Aircraft Abstract This presentation will describe in some detail the process followed by Lockheed Martin Aeronautics – Fort Worth for the structural certification of the new production F-16 Block 52+ aircraft for foreign military sales (FMS). The F-16 Block 52+ aircraft are structurally upgraded from the USAF Block 50/52 aircraft due to carriage of the fuselage shoulder mounted conformal fuel tanks and due to the addition of numerous advanced systems. The structural requirements and their methods of verification are set forth in the program contract and subsequent program documents such as the weapon system specification and air vehicle specification. Every USAF and FMS F-16 has an Aircraft Structural Integrity Program (ASIP) based upon program contractual requirement and tailored to MIL-STD-1530B Aircraft Structural Integrity Program. An ASIP Master Plan has been written for the Block 52+ aircraft which has been coordinated with and approved by the USAF F-16 System Group. This ASIP Master Plan states in specific terms how all the tasking outlined in the “five pillars” is accomplished. An overall design process will be discussed in depth pointing out how all historical structural analysis, structural test and field information has been used in the structural design of the Block 52+ aircraft.
    [Show full text]
  • Technical Order 00-105E-9, 1 February 2006, Revision 11
    WELCOME TO TECHNICAL ORDER 00-105E-9, 1 FEBRUARY 2006, REVISION 11. THIS IS SEGMENT 11 COVERING CHAPTER 8 FROM THE QF-4 TO F-16. TO NAVIGATE CLICK ON THE CONTINUE BOOKMARKS AND CLICK ON THE (+) SYMBOLS, THEN NOTICE CLICK ON SUBJECT LINKS TO GO TO SPECIFIC VIEWS CONTACT IN THIS SEGMENT. TO GO DIRECTLY TO THE TECHNICAL ORDER, CLICK ON THE CONTINUE BUTTON. TO SEE THE SEGMENT INFORMATION CHANGE NOTICE, CLICK ON THE NOTICE BUTTON. TO CONTACT THE TECHNICAL CONTENT MANAGER , CLICK ON THE CONTACT BUTTON. TECHNICAL ORDER 00-105E-9 TECHNICAL CONTENT MANAGER WRITTEN CORRESPONDENCE: HQ AFCESA/CEXF ATTN: Fire and Emergency Services Egress Manager 139 Barnes Drive Suite 1 Tyndall AFB, Florida 32403-5319 E-MAIL: [email protected] INTERNET: HQ AFCESA Fire and Emergency Services PUBLIC WEB PAGE: http://www.afcesa.af.mil/CEX/cexf/index.asp Safety Supplements: http://www.afcesa.af.mil/CEX/cexf/_firemgt.asp PHONE: (850) 283-6150 DSN 523-6150 FAX: (850) 283-6383 DSN 523-6383 For technical order improvements, correcting procedures, and other inquiries, please use the above media most convenient. SEGMENT 11 INFORMATION CHANGE NOTICE This page is provided to notifiy the user of any informational changes made to Technical Order 00-105E-9 in this Segment and the current Revision. Informational changes will be referenced in the Adobe Reader’s Bookmark tool as a designator symbol illustrated as a <[C]> for quick reference to the right of the affected aircraft. The user shall insure the most current information contained in this TO is used for his operation.
    [Show full text]