DOCSLIB.ORG

Asotin County Regional Landfill MRW Facility Operations Plan

Total Page：16

File Type：pdf, Size：1020Kb

Download full-text PDF Read full-text
Asotin County Regional Landfill MRW Facility Operations Plan Asotin County Regional Landfill MRW Facility Operations Plan February 2019 Prepared for Asotin County Solid Waste Division Prepared by This document was prepared under the direct supervision of Travis A. Pyle, a registered Professional Engineer in the State of Washington, employed at Great West Engineering, Inc. Table of Contents Abbreviations .............................................................................................. iv Definitions .................................................................................................... v 1.0 Introduction ......................................................................................... 7 1.1 Purpose of This Document ............................................................................................. 7 1.2 Waste Handling Performance Standards .................................................................... 10 1.3 MRW Location Requirements ....................................................................................... 10 1.4 MRW Design Standards ................................................................................................ 10 1.5 Facility Description ........................................................................................................ 12 2.0 Safety and Personal Protection ...................................................... 16 2.1 General Safety Precautions .......................................................................................... 16 2.2 Purpose of Personal Protective Equipment ................................................................. 16 2.3 Levels of Personal Protection Equipment .................................................................... 17 2.4 Limitation of Personal Protective Equipment .............................................................. 18 2.5 References for Health Risks and Personal Protection Equipment ............................ 19 2.6 Personal Protection Equipment Requirements for Facility Duties ............................. 19 2.7 Facility General Supplies and Personal Protection Equipment Supplies/Stocking .. 20 2.8 Hygiene .......................................................................................................................... 20 2.9 Security .......................................................................................................................... 20 3.0 Acceptable Hazardous Wastes ........................................................ 21 3.1 Permitted Types and Quantities of Hazardous Waste ................................................ 21 3.2 Guidelines for Identifying Acceptable Household Hazardous Waste ......................... 21 3.2.1 Load Types.............................................................................................................. 21 3.3 Non-Hazardous Wastes ................................................................................................ 23 3.4 Unacceptable Wastes ................................................................................................... 23 3.5 Special Wastes – Asbestos........................................................................................... 24 4.0 Receiving Hazardous Wastes .......................................................... 25 4.1 Attendant Responsibilities ............................................................................................ 25 4.2 Accepting Hazardous Wastes ....................................................................................... 25 4.3 General Material Management/Housekeeping .......................................................... 26 4.4 Safety Systems and Containment Systems ................................................................. 26 4.4.1 Secondary Containment ........................................................................................ 26 4.4.2 Ventilation System/Explosion-Proof Wiring .......................................................... 27 4.4.3 Flammable Gas Monitoring System ...................................................................... 28 ASOTIN COUNTY | MRW Facility Operations Plan i 4.5 Material Intake and Sorting .......................................................................................... 28 4.6 Material Handling/Processing Options ........................................................................ 29 4.6.1 Non-Lab Packed Materials .................................................................................... 30 4.6.2 Lab Packed Materials ............................................................................................ 30 4.6.3 Loose Packed Materials ........................................................................................ 31 4.7 Categorizing and Testing of Unknowns ........................................................................ 31 4.8 Waste Re-Use and Recycling ........................................................................................ 31 5.0 Waste Handling/Processing and Shipping ..................................... 32 5.1 Material Bulking ............................................................................................................ 32 5.1.1 Used Oil ................................................................................................................... 32 5.1.2 Antifreeze ................................................................................................................ 33 5.1.3 Gasoline .................................................................................................................. 33 5.1.4 Aerosols .................................................................................................................. 33 5.1.5 Latex Paint .............................................................................................................. 33 5.1.6 Batteries ................................................................................................................. 34 5.2 Lab Packing ................................................................................................................... 35 5.2.1 Lab Packing Procedures ........................................................................................ 35 5.3 Loose Packing................................................................................................................ 37 5.3.1 Loose Packing Procedures .................................................................................... 37 5.4 Shipping Hazardous Waste ........................................................................................... 37 5.4.1 Shipping Procedures .............................................................................................. 37 5.4.2 Documenting Shipments ....................................................................................... 38 6.0 Facility Equipment, Maintenance and Inspections ........................ 39 6.1 General Facility Inspections.......................................................................................... 39 6.2 General Facility Inspections.......................................................................................... 40 6.3 Equipment Inspections and Maintenance ................................................................... 40 6.3.1 Flammable and Explosive Gas Monitoring System .............................................. 40 6.3.2 Ventilation System ................................................................................................. 40 6.3.3 Fire Suppression Systems ..................................................................................... 41 6.3.4 Safety Shower/Eye Wash Station ......................................................................... 41 6.3.5 Can Crusher Unit .................................................................................................... 41 7.0 Emergency Response ....................................................................... 42 7.1 Fire and Vapor Releases ............................................................................................... 42 7.2 Injuries ........................................................................................................................... 43 ASOTIN COUNTY | MRW Facility Operations Plan ii 7.3 Spills ............................................................................................................................... 43 7.3.1 Small Liquid Spills .................................................................................................. 44 7.3.2 Large Liquid Spills .................................................................................................. 44 7.3.3 Spills of Solid Materials ......................................................................................... 44 7.4 Decontamination of Facility .......................................................................................... 45 7.5 Evaluation After an Emergency Response ................................................................... 45 8.0 Training .............................................................................................. 48 8.1 Training Courses ............................................................................................................ 48 8.1.1 Hazard Communications Program ........................................................................ 48 8.1.2 Respiratory Equipment Training ............................................................................ 49 8.1.3 EMS Course ...........................................................................................................
Load more

Recommended publications
  • Solid Waste in Washington State, 16Th Annual Status Report
    Solid Waste In Washington State Sixteenth Annual Status Report Solid Waste and Financial Assistance Program December 2007 Publication #07-07-048 Solid Waste in Washington State Sixteenth Annual Status Report Prepared by: Washington State Department of Ecology Solid Waste and Financial Assistance Program December 2007 Publication No. 07-07-048 This report and the supporting database information can be accessed at: http://www.ecy.wa.gov/programs/swfa/solidwastedata/ For additional copies of this document, contact: Department of Ecology Solid Waste & Financial Assistance Program PO Box 47600 Olympia, WA 98504-7600 Telephone: (360) 407-6900 The Department of Ecology is an equal opportunity agency and does not discriminate on the basis of race, creed, color, disability, age, religion, national origin, sex, marital status, disabled veteran's status, Vietnam Era veteran's status or sexual orientation. If you need this publication in another format, please call the Solid Waste & Financial Assistance Program at (360) 407-6900. Persons with hearing loss can call 711 for Washington Relay Service. Persons with a speech disability can call 877-833-6341. Table of Contents Acknowledgments .........................................................................................................................................v Chapter I Issues Facing Solid Waste...........................................................................................................1 Beyond Waste ........................................................................................................................................1
    [Show full text]
  • 2013 Survey of Waste Production and Management at European Refineries
    report no. 12/17 2013 survey of waste production and management at European refineries report no. 12/17 2013 survey of waste production and management at European refineries Prepared for the Concawe Refinery Waste Special Taskforce (WQ/STF-36): D. Withinshaw (Chair) G. Cricchi P. Eyraud P. Gerritsma E. Marin J. Negroni T. Nolte R. Polc P. Roach K. Seidler T. Still R. Vazquez Perez M. Spence (Science Executive) M. Hjort (Research Associate) Prepared by NewFields Consultants: J. Oehrig W. Odle Reproduction permitted with due acknowledgement Concawe Brussels November 2017 I report no. 12/17 ABSTRACT This report provides a statistical analysis of waste production by Concawe member company refineries in 2013, based on survey data returned from 74 member company refineries (71% response rate) situated in the EU-28 countries + Norway and Switzerland. It includes a breakdown of waste tonnage according to the origin of the waste, how it was managed and how it was classified under the 2008 Waste Framework Directive (2008/98/EC). This findings from the survey, together with those of previous Concawe waste surveys for 1993 (Concawe; 1-95) and 1986 (Concawe; 5-89), show how the sector has responded to developments in EU waste legislation over the past 30 years. In addition, the data constitute a modern baseline for the future assessment of performance. Total waste production reported by the refining sector in 2013 was 1.2 million tonnes, of which 43% was classified as hazardous. The top 3 reported hazardous wastes types by tonnage are sludges (comprising tank bottoms, physical/chemical treatment, biological treatment and other), followed by spent chemicals/acids/bases and then contaminated soil/stones/aggregate/concrete (with approximately one third of these arising from remediation activities).
    [Show full text]
  • Waste Types to Avoid on Litter Picks
    Document 3 - Waste types to avoid on litter picks Contents: • List of waste types to avoid on litter picks and at all other times. • Teacher / litter pick leader notes, including definitions of hazardous waste, fly-tipping and information on asbestos. • Possible questions to ask your group whilst looking at the example pictures. • Pictures to use in discussions in advance of litter pick: Waste types to avoid. • Pictures to use in discussions in advance of litter pick: Please collect these items on your litter pick. If you come across any of these things, please avoid them. Take a picture from a distance if you can and then report them. • Asbestos • Chemical containers / drums • Vehicle waste such as batteries or oil • Gas canisters and fluorescent tubes • Drugs related litter • Animal waste (see picture with notes for further information) • Glass (see pictures with notes for further information) • Any items that are too big or heavy to collect with the litter pickers and may rip the collection bags • Nappies • Plastic bags with things inside • Dead animals • Any items that you are unsure about Teacher / litter pick leader notes Definitions to support your discussions: What is Hazardous Waste? Health and Safety Executive “Waste is considered 'hazardous' under environmental legislation when it contains substances or has properties that might make it harmful to human health or the environment. This does not necessarily mean it is an immediate risk to human health, although some waste can be.” August 2016 What is Asbestos? Asbestos is a naturally occurring fibrous material that has been a popular building material since the 1950s (Asbestos can be found in any building built before the year 2000- HSE) It was used as an insulator (to keep in heat and keep out cold), has good fire protection properties and protects against corrosion.
    [Show full text]
  • Incident Waste Decision Support Tool (I-WASTE), V.6.3
    Incident Waste Decision Support Tool (I-WASTE), v.6.3 EPA/600/R-13/160 | August 15, 2013 www.epa.gov/ord Office of Research and Development National Homeland Security Research Center Incident Waste Decision Support Tool (I-WASTE), v.6.3 U.S. Environmental Protection Agency Office of Research and Development National Homeland Security Research Center Decontamination and Consequence Management Division Research Triangle Park, NC NOTICE The U.S. Environmental Protection Agency (EPA), through its Office of Research and Development’s (ORD’s) National Homeland Security Research Center (NHSRC) and National Risk Management Research Laboratory (NRMRL), directed and managed this work through Contract Number EP-D-11-006, Work Assignment 3-10 with Eastern Research Group. This report has been subjected to the Agency’s administrative review and approved for publication. The views expressed in this report are those of the authors and do not necessarily reflect the views or policies of the Agency. Mention of trade names or commercial products does not constitute endorsement or recommendation for use. Questions concerning this document or its application should be addressed to: Susan Thorneloe National Risk Management Research Laboratory Office of Research and Development U.S. Environmental Protection Agency Mail Code E343-02 Research Triangle Park, NC 27711 919-541-2709 i EXECUTIVE SUMMARY In the event of an incident of national significance involving the deliberate or accidental contamination of buildings, outdoor areas, transportation infrastructure,
    [Show full text]
  • Management of Solid Residues in Waste-To-Energy and Biomass Systems
    Forschungszentrum Karlsruhe in der Helmholtz-Gemeinschaft Wissenschaftliche Berichte FZKA 7347 Bioenergy NoE Management of Solid Residues in Waste-to-Energy and Biomass Systems J. Vehlow, B. Bergfeldt, C. Wilén, J. Ranta, H. Schwaiger, H.J.M. Visser, S. Gu, E. Gyftopoulou, J. Brammer Institut für Technische Chemie Dezember 2007 Forschungszentrum Karlsruhe in der Helmholtz-Gemeinschaft Wissenschaftliche Berichte FZKA 7347 MANAGEMENT OF SOLID RESIDUES IN WASTE-TO-ENERGY AND BIOMASS SYSTEMS J. Vehlow, B. Bergfeldt, C. Wilén*, J. Ranta*, H. Schwaiger**, H.J.M. Visser***, S. Gu****, E. Gyftopoulou****, J. Brammer**** Institut für Technische Chemie * VTT Technical Research Centre of Finland, Espoo, Finland ** Joanneum Research Forschungsgesellschaft mbH, Graz, Austria *** ECN Energy Research Centre of the Netherlands, Petten, The Netherlands **** Aston University, Birmingham, United Kingdom Forschungszentrum Karlsruhe GmbH, Karlsruhe 2007 Prepared by members of the EU Network of Excellence Bioenergy J. Vehlow, B. Bergfeldt, Forschungszentrum Karlsruhe GmbH, Germany C. Wilén, J. Ranta, VTT Technical Research Centre of Finland, Espoo, Finland H. Schwaiger, Joanneum Research Forschungsgesellschaft mbH, Graz, Austria H.J.M. Visser, ECN Energy Research Centre of the Netherlands, Petten, The Netherlands S. Gu, E. Gyftopoulou, J. Brammer, Aston University, Birmingham, United Kingdom Sponsored by the EC DG Research. Bioenergy NoE is a partnership of eight leading bioenergy institutes that are integrating their expertise and activities to foster excellence
    [Show full text]
  • Electrotechnologies for Waste and Water Treatment
    8"8Rp53 1.7 Topics: y43 EPRl EM-5418 Waste processing F Project 2416-25 EPRl Water treatment Final Report Electric Power Resource recovery October 1987 Research Institute Industrial wastes Electrotechnology End use Electrotechnologies for Waste and Water Treatment Prepared by Science Applications International Corporation Los Altos, California REPORT SUMMARY ~ S U BJ ECTS Industrial electric technologies / Land and water quality / Hazardous and toxic waste management TOPICS Waste processing Industrial wastes Water treatment Electrotechnology Resource recovery End use AUDIENCE R&D engineers / Marketing managers ~ Electrotechnologies for Waste and Water meatment Recent environmental regulations have created a potential new market for electrotechnologies-treatment of industrial and mu- nicipal waste and water. This report describes a wide range of such processes and applications. BACKG R 0U N D Stricter environmental protection regulations and the decrease of available space for waste disposal have motivated an ongoing reevaluation of waste management technologies and an emerging interest in innovative waste ~ processing methods. ~ OBJECTIVES To identify and examine waste and water treatment technologies, particu- larly electricity-intensive processes. To identify specific areas where R&D could have a significant impact on the near- to intermediate-term implementation of electrotechnologies for waste and/or water treatment. APPROACH The investigators gathered information on waste and water treatment tech- nologies and processes through extensive library searches and from their own company files. They solicited similar information, including technology growth projections, from industrial sources. To compile a summary of past and present research in waste management, they examined databases con- taining EPRl reports and government documents. Discussions with govern- ment agency experts confirmed industrial sources of hazardous and non- hazardous wastes and clarified relevant regulations.
    [Show full text]
  • ASTSWMO Beneficial Use Survey 2000
    ASTSWMO Beneficial Use Survey April 2000 Association of State and Territorial Solid Waste Management Officials 444 North Capitol Street, N.W., Suite 315 ASTSWMO Beneficial Use Survey April 2000 Washington, D.C. ACKNOWLEDGEMENTS The Task Force wishes to thank all those who helped complete the survey. Without their cooperation, this report would not be possible. Even so, the Task Force takes full responsibility for the information and conclusions presented in this report. Information from the survey has already helped the Task Force to better understand how individual States and Territories approach decision-making about the beneficial use of solid wastes. The Task Force and ASTSWMO will continue to use this information in developing additional tools to assist States and Territories. Dale Thompson, Chair ASTSWMO Beneficial Use Task Force Please direct questions regarding this report to: Kerry Callahan ASTSWMO 444 North Capitol Street, N.W., Suite 315 Washington, D.C. 20001 Phone: 202/624-5828 Fax Number: 202/624-7875 E-Mail: [email protected] ASTSWMO Beneficial Use Survey April 2000 TABLE OF CONTENTS I. Introduction................................................................................................. 1 II. Beneficial Use Survey Results A. Status of Beneficial Use Programs and Processes in Responding States and Territories............................................... 2 B. Administrative Aspects of Beneficial Use Programs and Processes................................................................. 4 C. Factors in Making Beneficial
    [Show full text]
  • Industrial Landfill Guidance
    Industrial Landfill Guidance June 2009 MPCA contributors Neal Wilson, Solid Waste Hydrogeologist, Principal Document Author Brett Ballavance, Solid Waste Permit Engineer Johnna Benke, Financial Assurance Coordinator Jim Chiles, Policy Coordinator Nathan Cooley, Rules Coordinator Robert Criswell, Solid Waste Permit Engineer Theresa Gaffey, Formatting Editor Kris Hulsebus, Compliance and Enforcement Julie Henderson, Solid Waste Permit Engineer Gary Pulford, Solid Waste Program Manager David Richfield, Policy/Rules Supervisor Mark Rust, Solid Waste Permitting Supervisor Mark Rys, Solid Waste Hydrogeologist Ainars Silis, Land Permits Supervisor Susanne Spitzer, Planner Lisa Thorvig, Municipal Division Director Michael Tibbets, Industrial Section Manager Richard Thul, Process Facilitator Stakeholder list The MPCA thanks the representatives from the following stakeholders for their participation in developing this guidance. Jim Adrian, Grinning Bear Demolition Landfill Marc Hugunin, Friends of Washington County Jim Aiken, BARR Terry Johnson, Waste Management, Incorporated Bill Bangsund, BARR Michael Lynn, Dakota County, Environmental Christopher Basgall, Veolia Environmental Management Department Gary Bruns, Washington County Terry Muller, Dakota County Manny Castillo, Xcel Energy John R. McCain, McCain and Associates, Inc. John Domke, SKB Environmental Ryan O’Gara, SKB Environmental Chuck Donkers, Xcel Energy Daniel Peña, Minnesota Department of Health Fred J. Doran, R.W. Beck Jim Eidem, BARR Kevin Pylka, Polymet Mining/Mining Minnesota Jeffrey Ellerd, Veolia Environmental Jo Spear, J. Spear, Associates Dave Engstrom, Minnesota Association of Small Mark St. Lawrence, St. Louis County Environmental Cities Services Department Jan Falteisek, Minnesota Dept. Natural Resources Bob Tipping, Minnesota Geological Survey, John M. Friel, BARR University of Minnesota Mike Fullerton, SKB Environmental Contact Information For more information on industrial landfills, the first point of contact should be: Minnesota Pollution Control Agency, 520 Lafayette Road, St.
    [Show full text]
  • Waste Characterization Study Presented To
    Waste Characterization Study Presented to: City of Sausalito, California Department of Public Works 420 Litho Street Sausalito, CA 94965 Presented by: SCS ENGINEERS 6601 Kilroy Center Parkway, Suite 140 Pleasanton, CA 94566 June 11, 2013 File No. 01213077.00 Offices Nationwide www.scsengineers.com City of Sausalito, CA Waste Characterization Study Results Table of Contents Section Page 1 Executive Summary ................................................................................................................................ 1 2 Introduction .............................................................................................................................................. 3 3 Waste Generating Sectors .................................................................................................................. 4 4 Number Of Samples ............................................................................................................................. 5 5 Waste Sampling .................................................................................................................................... 6 5.1 Manual Sorting ............................................................................................................................. 6 5.2 Visual Characterization ........................................................................................................... 10 6 Data Analysis .......................................................................................................................................
    [Show full text]
  • Consolidated List of Waste
    Appendix A: Consolidated List of Waste The aim of this Appendix is to reproduce in full the List of Waste, including the legal instructions on its use, and give additional guidance on certain aspects of its use. The outcome of choosing the most appropriate entry in the list will help you decide whether you have a waste that is automatically hazardous, a waste that is automatically non-hazardous or a waste that you will have to do a full assessment on – a so-called 'mirror entry' waste. A1.1 The structure of the List of Waste (LoW) The LoW was established by Commission Decision 2000/532/EC1. It consists of 20 chapters that must be used in a certain order of precedence. Some chapters relate to processes that generate waste and some refer to specific waste types. The chapter headings are given a two-digit number as shown in table A1.1 below. An example of a chapter is: 20 MUNICIPAL WASTES (HOUSEHOLD WASTE AND SIMILAR COMMERCIAL, INDUSTRIAL AND INSTITUTIONAL WASTES) INCLUDING SEPARATELY COLLECTED FRACTIONS. Each chapter of the LoW contains sub-chapters that are identified by four-digits, for example: 20 01 Separately collected fractions (except 15 01) Within each sub-chapter is a list of waste types each given a unique six digit code, for example: 20 01 01 paper and cardboard AN2 For a waste to be given a particular LoW code, reference must be made to the 2, 4 and 6 digit entries. In the case of 20 01 01 the waste must: be paper or cardboard or a mixture of paper and cardboard be kept separately from other wastes when collected from a household (or is waste similar to that produced by a household), and not be packaging waste (which would be coded in sub-chapter 15 01 even if from a household) If the waste does not meet all four of the above criteria 20 01 01 would not be the most appropriate code.
    [Show full text]
  • 2019 Waste Data Quality Report Waste Landfilled In
    2019 WASTE DATA QUALITY REPORT WASTE LANDFILLED IN SCOTLAND 29 September 2020 Table of Contents Table of Contents .................................................................................................... 2 Introduction ............................................................................................................. 3 Revisions Policy .................................................................................................... 4 Progress against targets ......................................................................................... 5 Introduction ......................................................................................................... 5 Biodegradable municipal waste to be sent to landfill ............................................. 6 Waste Landfilled in Scotland .................................................................................. 7 Introduction ......................................................................................................... 7 Waste disposed via landfill ................................................................................... 7 Further information ................................................................................................. 9 Appendix 1 ............................................................................................................. 10 European Waste Catalogue ................................................................................. 10 European Waste Catalogue List of Waste (EWC 2000) .........................................
    [Show full text]
  • Waste Data Quality Report Waste Incinerated in Scotland
    2019 WASTE DATA QUALITY REPORT WASTE INCINERATED IN SCOTLAND 29 September 2020 Table of Contents Table of Contents ............................................................................................. 2 Introduction ...................................................................................................... 3 Revisions Policy ..................................................................................... 4 Waste Incinerated in Scotland ......................................................................... 5 Introduction ............................................................................................ 5 Recovery by incineration and co-incineration within Scotland ............... 5 Disposal by incineration in Scotland ...................................................... 6 Further information ........................................................................................... 7 Contacting Us ........................................................................................ 7 Appendix 1 ....................................................................................................... 8 Datasets used in the 2019 methodology ................................................ 8 Appendix 2 ....................................................................................................... 9 European Waste Catalogue ................................................................... 9 European Waste Catalogue List of Waste (EWC 2000) ......................... 9 European Waste Catalogue
    [Show full text]