Authorized Materials for Fuel Alcohol

Total Page：16

File Type：pdf, Size：1020Kb

Authorized Materials for Fuel Alcohol Under 27 CFR 19.746(b), the following materials are approved to render spirits unfit for beverage use and thus acceptable for withdrawal from alcohol fuel plants as fuel alcohol: 1. The materials listed in 27 CFR 19.746(b), in the quantities specified there. 2. The following additional materials, in the following quantities, corresponding to the following specifications: Quantity added Material to 100 gallons Specifications of distilled spirits Natural Gasoline 2 gallons or more 1. Natural gasoline (drip gas) is a mixture of butane, pentane, and hexane hydrocarbons extracted from natural gas. 2. Distillation range: No more than 10% of the sample may distill below 97° F.; at least 50% shall distill at or below 156° F.; and at least 90% shall distill at or below 209° F. Ethyl Tertiary Butyl 2 gallons or more Ether (ETBE) Raffinate 2 gallons or 1. Octane (R+M/2): 66-70 more 2. Distillation, in Degrees F: 10%: 120-150 50%: 144-180 90%: 168-200 End Point: 216-285 3. API Gravity: 76-82 4. Reid Vapor Pressure: 5-11 Naphtha 2 gallons or more 1. API Gravity @ 60/60 Degrees F: 64-70 2. Lb/Gal: 5.845-6.025 3. Density: .7022-.7238 4. Reid Vapor Pressure: 8 P.S.I.A. Max. 5. Distillation, in Degrees F: I.B.P.: 85 Max. 10%: 130 Max. 50%: 250 Max. 90%: 340 Max. End Point: 380 6. Copper Corrosion: 1 Last updated: 04/30/12 7. Sabolt Color: 28 Min. Straight Run 2 gallons or more 1. Straight run gasoline is a mixture Gasoline (TTB Rul. consisting predominantly (greater than 2008-2) 60% by volume) of C4, C5, C6, C7 and/or C8 hydrocarbons, and is either (1) a petroleum distillate coming straight from an atmospheric distillation unit without being cracked or reformed or (2) a condensate coming directly from an oil/gas recovery operation. 2. API gravity: 72° Min., 85° Max. 3. Reid vapor pressure: 15 psi Max. 4. Sulfur: 120 ppm Max. 5. Benzene: 1.1% by volume Max. 6. Distillation: 10%: 97° F Min., 158° F Max. 50%: 250° F Max. Final Boiling Point: 437° F Max. Toluene 5 gallons or more See 27 CFR 21.132. Last updated: 04/30/12 .

Copy Link

Recommended publications

Natural Gas Processing Plants. 2
→ Linde Engineering Natural Gas Processing Plants. 2 Contents. 3 Introduction 4 Components and pretreatment of natural gas 5 Natural gas plants 6 Extraction of hydrocarbons and LPG plants 7 References for LPG/C3+ recovery plants 8 NGL plants 8 References for NGL/C2+ recovery plants 10 Extraction of non hydrocarbons Nitrogen rejection units (NRU) Helium recovery and liquefaction plants 11 References for nitrogen rejection and helium plants 12 Contact 3 Introduction. Natural gas is valuable both as a clean source of energy and as a chemical feedstock. Before reaching the customer, it has to pass several processing steps. These steps are partly neces- sary to be able to transport the gas over long distances and partly necessary for the recovery of valuable components contained in the gas. Linde AG´s Engineering Division has world-class experience in the entire natural gas processing chain. Linde offers engi- neering as well as technical and commercial services, includ- ing feasibility studies, pre-FEED, FEED, detail engineering and turnkey plant construction. Plant design and scope of supply typically includes specialized and tailor made cryogenic equipment manufactured in Linde workshops such as plate- fin and coil-wound heat exchangers. Linde´s competence in project development, planning, exe- cution and construction of turn-key plants is clearly demon- strated by the fact that it has built more than 4,000 plants world-wide. 4 Components and pretreatment of natural gas. Components of natural gas Pretreatment of natural gas Natural gas is a mixture of gases containing Natural gas pretreatment typically consists of primarily hydrocarbon gases. It is colorless and mercury removal, gas sweetening and drying.
[Show full text]
Natural Gas Liquids in North America: Overview and Outlook to 2035
Study No. 130 July 2012 CANADIAN NATURAL GAS LIQUIDS IN ENERGY RESEARCH NORTH AMERICA: OVERVIEW INSTITUTE AND OUTLOOK TO 2035 Canadian Energy Research Institute | Relevant • Independent • Objective NATURAL GAS LIQUIDS IN NORTH AMERICA: OVERVIEW AND OUTLOOK TO 2035 Natural Gas Liquids in North America: Overview and Outlook to 2035 Copyright © Canadian Energy Research Institute, 2012 Sections of this study may be reproduced in magazines and newspapers with acknowledgement to the Canadian Energy Research Institute ISBN 1-927037-09-6 Author: Carlos A. Murillo Acknowledgements: The author wishes to acknowledge Rick Funk of Funk & Associates Inc. and Paul Kralovic of Kralovic Economics Inc.; as well as those involved in the production, reviewing, and editing of the material, including but not limited to Peter Howard and Megan Murphy. CANADIAN ENERGY RESEARCH INSTITUTE 150, 3512 – 33 Street NW Calgary, Alberta T2L 2A6 Canada www.ceri.ca July 2012 Printed in Canada Front cover photo courtesy of ATCO Midstream. Natural Gas Liquids in North America: Overview and Outlook to 2035 iii Table of Contents LIST OF FIGURES ............................................................................................................. v LIST OF TABLES .............................................................................................................. xi REPORT HIGHLIGHTS & SUMMARY ................................................................................ xiii INTRODUCTION ............................................................................................................
[Show full text]
Property Analysis of Ethanol−Natural Gasoline−BOB Blends to Make
Property Analysis of Ethanol− Natural Gasoline−BOB Blends to Make Flex Fuel Teresa L. Alleman National Renewable Energy Laboratory Janet Yanowitz Ecoengineering, Inc. NREL is a national laboratory of the U.S. Department of Energy Office of Energy Efficiency & Renewable Energy Operated by the Alliance for Sustainable Energy, LLC This report is available at no cost from the National Renewable Energy Laboratory (NREL) at www.nrel.gov/publications. Technical Report NREL/TP-5400-67243 November 2016 Contract No. DE-AC36-08GO28308 Property Analysis of Ethanol− Natural Gasoline−BOB Blends to Make Flex Fuel Teresa L. Alleman National Renewable Energy Laboratory Janet Yanowitz Ecoengineering, Inc. Prepared under Task No. WFGS.1000 NREL is a national laboratory of the U.S. Department of Energy Office of Energy Efficiency & Renewable Energy Operated by the Alliance for Sustainable Energy, LLC This report is available at no cost from the National Renewable Energy Laboratory (NREL) at www.nrel.gov/publications. National Renewable Energy Laboratory Technical Report 15013 Denver West Parkway NREL/TP-5400-67243 Golden, CO 80401 November 2016 303-275-3000 • www.nrel.gov Contract No. DE-AC36-08GO28308 NOTICE This report was prepared as an account of work sponsored by an agency of the United States government. Neither the United States government nor any agency thereof, nor any of their employees, makes any warranty, express or implied, or assumes any legal liability or responsibility for the accuracy, completeness, or usefulness of any information, apparatus, product, or process disclosed, or represents that its use would not infringe privately owned rights. Reference herein to any specific commercial product, process, or service by trade name, trademark, manufacturer, or otherwise does not necessarily constitute or imply its endorsement, recommendation, or favoring by the United States government or any agency thereof.
[Show full text]
Natural Gasoline
Safety Data Sheet 1. Identification Product Name: Natural Gasoline Synonyms: Debutanized Natural Gasoline - DNG Chemical Family: Aliphatic Hydrocarbon Mixture Manufacturers Name: Whiting Oil and Gas Corporation Address: 1700 Broadway, Suite 2300 Denver, Colorado 80290 Product Use: Hydrocarbon fuel Phone Number for Information: (303) 837-1661 Emergency Phone Number (Chemtrec): (800) 424-9300 Natural Gasoline is a mixture of saturated aliphatic hydrocarbons (predominantly C5 through C8) separated from natural gas by processes such as refrigeration or absorption. 2. Hazard Identification DANGER! FLAMMABLE LIQUID ASPIRATION OF LIQUID IN THE LUNGS CAN PRODUCE CHEMICAL PNEUMONIA OR EVEN DEATH. PRODUCES SKIN IRRITATION UPON PROLONGED OR REPEATED SKIN CONTACT. MAY CONTAIN BENZENE WHICH CAN CAUSE CANCER OR BE TOXIC TO BLOOD-FORMING ORGANS. NO SMOKING! KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. WEAR PROTECTIVE GLOVES, CLOTHING AND EYE WEAR WHEN HANDLING. AVOID RELEASE INTO THE ENVIRONMENT. Globally Harmonized System (GHS) Information Physical Hazards Classification Flammable Liquids, Category 1 Health Hazards Classification Skin Corrosion/irritation, Category 2 Serious eye damage/eye irritation, Category 2b Carcinogenicity, Category 1B Specific Target organ toxicity – single exposure, Category 3 (drowsiness and dizziness) Specific Target organ toxicity – repeated exposure, Category 2 (bone marrow, liver, thymus, nervous system) Aspiration hazard, Category 1 Product Name: Whiting Natural Gasoline Page 1 of 7 Environmental Hazards Classification
[Show full text]
5.1 OVERVIEW Gasoline Is a Mixture of Relatively Volatile Hydrocarbons
GASOLINE 117 5. POTENTIAL FOR HUMAN EXPOSURE 5.1 OVERVIEW Gasoline is a mixture of relatively volatile hydrocarbons, including alkanes, cycloalkanes, alkenes, and aromatics. Individual hydrocarbon components differentially partition to environmental media on the basis of their physical/chemical properties. Gasoline is released to the atmosphere as hydrocarbon vapors from processing and use as a fuel, and to surface water, groundwater, and soil through spills and leaks in aboveground and underground storage tanks and pipelines. Gasoline has been identified in 23 of the 1,397 NPL hazardous waste sites that have been proposed for inclusion on the NPL (HAZDAT 1992). The frequency of these sites within the Unites States can be seen in Figure 5-l. The volatile hydrocarbon fraction of gasoline, which consists primarily of short-chain (C4-C5) alkanes and alkenes and some aromatics, partitions to the atmosphere where photochemical oxidation is the main removal process. Much of what is released to surface waters and surface soils is lost by volatilization to the atmosphere. Releases to subsurface soils may leach through the unsaturated zone and contaminate groundwater. Aromatics constitute most of the water soluble fraction of gasoline. Biodegradation of gasoline hydrocarbons by a diverse group of microorganisms is an important removal process in surface waters, soil, and groundwater. Bioconcentration and sorption of gasoline hydrocarbons to soils and sediments may be important only for higher molecular weight hydrocarbons that are resistant to biodegradation. Exposure of the general population to gasoline occurs primarily through inhalation of very small quantities of the volatile fraction of the mixture during automobile refueling. Another important source of exposure is ingestion, dermal, and inhalation exposure for certain populations through the use of gasoline-contaminated surface water or groundwater in domestic potable water applications.
[Show full text]
Lonestar Shafter Deerfoot Consulting Inc. Natural Gasoline
Natural Gasoline - Lonestar Shafter SAFETY DATA SHEET Date of Preparation: April 11, 2016 Section 1: IDENTIFICATION Product Name: Natural Gasoline - Lonestar Shafter Synonyms: Not available. Product Use: Refinery feedstock. Restrictions on Use: Not available. Manufacturer/Supplier: Plains Midstream Canada ULC, and Affiliates Suite 1400, 607 – 8th Avenue SW Calgary, Alberta T2P 0A7 Phone Number: 1-866-875-2554 Emergency Phone: USA - CHEMTREC 1-800-424-9300 / CANADA - CANUTEC 1- 888-CAN-UTEC (226-8832), 613-996-6666 or *666 on a cellular phone Date of Preparation of SDS: April 11, 2016 Section 2: HAZARD(S) IDENTIFICATION GHS INFORMATION Classification: Flammable Liquids, Category 1 Skin Irritation, Category 2 Germ Cell Mutagenicity, Category 1B Carcinogenicity, Category 1A Toxic to Reproduction, Category 2 Specific Target Organ Toxicity (Single Exposure), Category 3 - Narcotic Effects Specific Target Organ Toxicity (Repeated Exposure), Category 2 Aspiration Hazard, Category 1 LABEL ELEMENTS Hazard Pictogram(s): Signal Word: Danger Hazard Extremely flammable liquid and vapor. Statements: Causes skin irritation. May cause genetic defects. May cause cancer. Suspected of damaging fertility or the unborn child. May cause drowsiness or dizziness. May cause damage to organs through prolonged or repeated exposure. May be fatal if swallowed and enters airways. Precautionary Statements Prevention: Obtain special instructions before use. Do not handle until all safety precautions have been read and understood. Keep away from heat, sparks, open flames, and hot surfaces. – No smoking. Page 1 of 13 Deerfoot Consulting Inc. Natural Gasoline - Lonestar Shafter SAFETY DATA SHEET Date of Preparation: April 11, 2016 Keep container tightly closed. Ground/bond container and receiving equipment.
[Show full text]
Production of NATURAL GASOLINE
Production of NATURAL GASOLINE By ROBERT B. BOWMAN fuel purposes. Either it has had the gasoline extracted from it, or it was originally produced without an appre- ciahle amount of gasoline in it. Dry gas is often ob- tained from gas wells which produce no oil, such as those in the Rio Vista. But~onwillow and other fields in California. The nredominant constituent of drv, ueras from wells is methane. Also present in dry gases discharged from natural gasoline plants are ethane, propane and some butane. Propane, isobutane and normal butane are in. termediate between dry gas and natural gasoline and are becoming increasingly important a'i raw materials for various products. Originally they were disposed of prin- cipally as liquefied petroleum gases, but isobutane has become so much more valuable as a raw material in aviation gasoline that it has been virtually eliminated FIG. I-Showing typical high-pressure absorber from this service. Bv direct combination with butvlenes installation. produced in refinery operations, isobutane yields a prod- uct high in isooctane content that is one of the principal base stocks for aviation fuels. Much normal butane is ATURAL gasoline is in the peculiar posilion of converted to isobnhme to increase this source material. being at the same time a raw material and a fin- Also normal butane is dehydrogenated to butadiene, an Nished product. It is seldom heard of in retail trans- important ingredient in synthetic rubber manufacture. actions involving petroleum products, because it is usu- Natural gasoline is composed principally of isopentane ally first blended with other fractions to produce motor and heavier hydrocarbons, with varying amounts of nor- and aviation fuels, in which it finds its principal outlet.
[Show full text]
Raw NGL and Natural Gasoline Products to Persons in a Manufacturing Facility Or Through Various Industrial Applications
Product Stewardship Summary Raw Natural Gas Liquids (NGL) and Natural Gasoline The product stewardship summary is intended to give general information about the chemical or categories of chemicals addressed. It is not intended to provide an in-depth discussion of all health and safety information. Additional information on these chemicals is available through the applicable Safety Data Sheets which must be consulted before using these chemicals. The product stewardship summary does not supplant or replace required regulatory and/or legal communication documents. Chemical Identity: Raw natural gas liquids (NGL) and natural gasoline are a category of products. They are a complex mixture of hydrocarbons separated as a liquid from natural gas. Raw NGL is the liquid condensate produced by natural gas processing plants. Raw NGL is typically a mixture primarily of ethane and propane, secondarily of normal butane and isobutane, with lesser amounts of pentane and heavier components. Natural gasoline is the bottoms cut of predominantly pentane (C5) and hexane (C6) range hydrocarbons produced in raw NGL fractionators. Natural gasoline is generally composed of straight-chain and branched hydrocarbons, with only trace amounts of aromatic or olefinic molecules. This category contains two members, with CAS numbers and names listed below. CAS Number Product Name 8006-61-9/68425-31-0 Natural gasoline 64741-48-6 Raw NGL Category Justification: Natural gasoline and raw NGL are both complex hydrocarbons from natural gas processing with significant overlap on carbon number range (C4 through C8 for natural gasoline and C2 through C8 for raw NGL). Product Uses: Natural gasoline is used as a motor gasoline blending component and as a petrochemical feedstock.
[Show full text]
Natural Gas Liquids
Natural Gas Natural Gas Liquids (NGLs) • Shale Gas Impacts Dan Brockett – Penn State Extension Natural Gas Liquids • Natural Gas Liquids (NGLs) are found in “wet gas” or “rich gas” areas of shale gas producing regions. These liquids are used in a variety of ways; as petrochemical feedstocks, as fuel, as a blending product for gasoline, and even for a backyard barbeque. • Natural gas (dry gas) is mostly methane. The Natural Gas Liquids can comprise 5% to 50% depending on where it is extracted. LNG is not NGL • LNG – Liquified Natural Gas is methane • NGL – Natural Gas Liquids are ethane, propane, butane, pentane NGL Volumes Grow; Cracker, Pipelines What’s Occurring Now? Cracker plants are proposed, but not committed • Oil prices are falling hard in the Appalachian Basin – Condensates follow similar path - Odebrecht said a final decision on building the proposed cracker plant will be made “by the end – Changes the Ethane – Naptha of 2015” (Parkersburg, WV) - estimated cost $4 Spread billion – Could affect LNG export? (spread - Shell has yet to make final decision to build oil-gas) ethane cracker (Monaca, PA) - estimated cost $3 billion • Exporting Ethane? - Appalachian Resins Inc. has leased 50 acres of • ME1 is a 12” line from Houston land in Salem Township to build a 600 million pound per year plant. Projected to start in early to Delmont. Then an 8” inch to 2019? (Monroe County, OH) – est. cost $1 billion Marcus Hook. It will move propane and ethane. Moving - PTT-Marubeni Joint Venture Looking at PA-WV- propane now and will have the OH for Chemical Complex Site.
[Show full text]
Natural Gas Liquids
June 14, 2013 EIA’s Proposed Definitions for Natural Gas Liquids Term Current Definition Proposed Definition Note Lease Condensate (lease condensate): A Lease condensate: Light liquid Includes lease condensate natural gas liquid recovered from hydrocarbons recovered from lease condensate as part of associated and non associated gas separators or field facilities at associated the crude oil stream, wells from lease separators or field and non-associated natural gas wells. not an NGL. facilities, reported in barrels of 42 Mostly pentanes and heavier U.S. gallons at atmospheric pressure hydrocarbons. Normally enters the crude and 60 degrees Fahrenheit. oil stream after production. Plant Plant condensate: One of the Plant condensate: Liquid hydrocarbons Adds temperature condensate natural gas liquids, mostly pentanes recovered at inlet separators or and pressure. and heavier hydrocarbons, recovered scrubbers in natural gas processing plants and separated as liquids at gas inlet at atmospheric pressure and ambient separators or scrubbers in processing temperatures. Mostly pentanes and plants. heavier hydrocarbons, equivalent to pentanes plus. Natural gas Natural gas plant liquids: Those Natural gas plant liquids (NGPL): Those Identifies ethane plant liquids hydrocarbons in natural gas that are hydrocarbons in natural gas that are separate from the (NGPL) separated as liquids at natural gas separated as liquids at natural gas LPG and includes it in processing plants, fractionating and processing plants, fractionating and NGPL. Removes cycling plants, and in some instances, cycling plants. Products obtained include isopentane, since it is field facilities. Lease condensate is ethane, liquefied petroleum gases part of pentanes excluded. Products obtained include (propane and butanes), and pentanes plus.
[Show full text]
PETROLEUM Refining PROCESSES CHEMICAL INDUSTRIES
91512.casewrap.indd 1 6/2/09 10:08 AM PETROLEUM REFininG PROCESSES CHEMICAL INDUSTRIES A Series of Reference Books and Textbooks Consulting Editor HEINZ HEINEMANN Berkeley, California 1. Fluid Catalytic Cracking with Zeolite Catalysts, Paul B. Venuto and E. Thomas Habib, Jr. 2. Ethylene: Keystone to the Petrochemical Industry, Ludwig Kniel, Olaf Winter, and Karl Stork 3. The Chemistry and Technology of Petroleum, James G. Speight 4. The Desulfurization of Heavy Oils and Residua, James G. Speight 5. Catalysis of Organic Reactions, edited by William R. Moser 6. Acetylene-Based Chemicals from Coal and Other Natural Resources, Robert J. Tedeschi 7. Chemically Resistant Masonry, Walter Lee Sheppard, Jr. 8. Compressors and Expanders: Selection and Application for the Process Industry, Heinz P. Bloch, Joseph A Cameron, Frank M. Danowski, Jr., Ralph James, Jr., Judson S. Swearingen, and Marilyn E. Weightman 9. Metering Pumps: Selection and Application, James P. Poynton 10. Hydrocarbons from Methanol, Clarence D. Chang 11. Form Flotation: Theory and Applications, Ann N. Clarke and David J. Wilson 12. The Chemistry and Technology of Coal, James G. Speight 13. Pneumatic and Hydraulic Conveying of Solids, 0. A. Williams 14. Catalyst Manufacture: Laboratory and Commercial Preparations, Alvin B. Stiles 15. Characterization of Heterogeneous Catalysts, edited by Francis Delannay 16. BASIC Programs for Chemical Engineering Design, James H. Weber 17. Catalyst Poisoning, L. Louis Hegedus and Robert W. McCabe 18. Catalysis of Organic Reactions, edited by John R. Kosak 19. Adsorption Technology: A Step-by-Step Approach to Process Evaluation and Application, edited by Frank L. Slejko 20. Deactivation and Poisoning of Catalysts, edited by Jacques Oudar and Henry Wise 21.
[Show full text]
Natural Gas Condensate (Sour)
Safety Data Sheet 1. Identification Product Name: Natural Gas Condensate (Sour) Synonyms: Condensate, Lease Condensate, Natural Gasoline Chemical Family: Petroleum Hydrocarbon Mixture; Mainly Alkanes, some aromatics and other families Manufacturers Name: Whiting Oil and Gas Corporation Address: 1700 Broadway, Suite 2300 Denver, Colorado 80290 Product Use: Bi-product of natural gas production Phone Number for Information: (303) 837-1661 Emergency Phone Number: (800) 424-9300 (Chemtrec) Natural gas condensate (sour) is composed of natural hydrocarbons just like crude oil except it has a greater proportion of the smaller, lighter, more volatile constituents. Therefore, it typically is less viscous, less dense, and gives off more flammable vapors. Natural gas condensate (sour) contains hydrogen sulfide (H2S). 2. Hazard Identification Natural gas condensate (sour) is extremely flammable and can cause eye, skin, gastrointestinal, and respiratory irritation as well as dizziness and loss of balance. More serious health effects can occur if condensate is inhaled or swallowed. Natural gas condensate (sour) may contain variable amounts of benzene, and n-hexane. Long-term exposure to these materials has been shown to lead to systemic toxicity such as leukemia and peripheral neurotoxicity. DANGER! FLAMMABLE LIQUID ASPIRATION OF LIQUID INTO THE LUNGS CAN PRODUCE CHEMICAL PNEUMONIA OR EVEN DEATH. MAY CONTAIN BENZENE WHICH CAN CAUSE CANCER OR BE TOXIC TO BLOOD-FORMING ORGANS. MAY VENT HARMFUL CONCENTRATIONS OF HYDROGEN SULFIDE (H S) GAS WHICH 2 CAN CAUSE RESPIRATORY IRRITATION AND ASPHYXIATION. NO SMOKING! KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. DO NOT BREATHE GAS. WEAR RESPIRATORY PROTECTION, PROTECTIVE GLOVES, CLOTHING AND EYE WEAR WHEN HANDLING.
[Show full text]