SPECIFICATION & DESCRIPTION Pag. | 1
TECNAM ASTORE Specification & Description
INTRODUCTION INDROD UCTION This document is published for the purpose of providing general information for the evaluation of design, performance and equipment of the Tecnam model Astore.
Should more information be required, please contact:
This document describes only the Tecnam model Astore, its powerplant and equipment.
www.tecnam.com
Pag. | 2 SPECIFICATION & DESCRIPTION
Table of Contents General description ...... 3 Construction ...... 3 Landing Gear ...... 3 Powerplant and propeller ...... 3 Cabin ...... 3 Three views ...... 6 Astore Standard equipment list ...... 7 OPTION 1 – Astore Six pack ...... 10 OPTION 2 - DYNON SV1000 TWO SCREENS + GPS796 ...... 11 OPTION 3 – G3X TWO SCREENS ...... 12 Engine Upgrade ...... 13 OPTIONALS ...... 14 TECNAM COLORS ...... 16 INTERIORS ...... 18
www.tecnam.com
SPECIFICATION & DESCRIPTION Pag. | 3
General description All information here applies to the Tecnam model Astore equipped with the Rotax 912 ULS2 / IS engine and the Astore equipped with the Rotax 914 Turbo engine.
Construction The Tecnam Astore is a low wing, two-place, single-engine airplane equipped with tricycle landing gear. The all metal airframe structure is complemented by the selective use of an epoxy reinforced matrix of carbon/glass fiber for the upper radome and fairings.
Landing Gear The main landing gear consists of two 7075T6 light alloy springs which are hinged inside the fuselage in order to maximize the wheel deflection and energy absorption efficiency. These springs are supported by robust machined components which spread the load directly onto the main bulkheads. Two rawhide liners are inserted between each spring-leaf and the external machined beam. Two bolts secure the individual spring-leaf to the edge of the beam via a light alloy clamp while a single bolt secures the inboard end of the leaf-spring to the hinge and inner machined beam. The nose gear is free castering and is supported by an oleo-pneumatic shock absorber connected directly to the firewall. Differential toe brakes for steering are standard for both pilot and co-pilot with redundant brake master cylinders (4 in total). The horizontal tail is made up of a stabilizer and elevator with tip balancing horns. All the control surfaces, except for the flaps and trim tab, are balanced, and all the surfaces, except for the rudder and fuselage aileron line, are controlled via push-pull rods.
Powerplant and propeller Standard engine is the well-known Rotax 912ULS2 but the injected (912iS2) and turbocharged (914UL2) version are also available. The standard propeller is a two blade fixed pitch wooden-composite wrapped Sensenich, with composite made propellers from the same brand also available in two and three bladed versions. The total usable fuel is 29 Gal (110lt) while the entire fuel system runs below the cabin structure, protecting the occupants from the fuel lines, which consist of rigid hoses and AN fittings. The canopy forms an integral part of the upper radome sliding forward and aft with final closing achieved by pulling the canopy vertically down onto an automotive-type seal. Three latches and 4 pins secure the canopy to the radome ensuring the best sound proofing possible.
Cabin The Cabin offers newly designed seats and seat rails which are easily operated and adjustable fore and aft via a single handle with a reinforced area between the rails to make cabin access even easier. A roomy baggage compartment accommodates voluminous items with both external and internal access. A strong automotive seal is used on the baggage door and a courtesy lamp illuminates when this big door is opened. A newly designed and wide cockpit panel provides the largest choice of avionics on offer with a comfortable armrest and USB charger rounding out the luxurious interior. The avionics package always includes an iPad Mini with a built in application called "Tecnam Astore Owner app" containing a lot of relevant and useful information.
www.tecnam.com
Pag. | 4 SPECIFICATION & DESCRIPTION
Everything about the Tecnam Astore is designed to allow you and your passenger to experience the most outstanding style, comfort, beauty and technology. Enjoy the Astore!
• Certification The Tecnam Astore is delivered in full compliance with the requirements of US LSA ASTM F2245 (Package 02)
• Engine & Propeller Allowed engine power: 98 to 115hp Manufacturer: ROTAX Models: 912ULS2 - 912is - 914 Propeller diameter: 1.73 to 1. 8mt (5.67 to 5.90ft) Number of blades: 2/3 Approved manufacturers: GT-Tonini-Sensenich- Approved prop. types: Fixed - Ground adj. • Dimensions Overall Height: 7.54ft 2.3mt Overall Length: 23.0ft 7.0mt • Wing Span (overall): 28.4ft 8.65mt Area: 131ft2 12.2mt2 Dihedral: 5° Aspect ratio: 6.2 • Cabin Height (max): 3.21ft 0.98mt Width (trim to trim): 3.8ft 1.15mt • Baggage door (optional) Height: 9.8in 0.25mt Width: 15.7in 0.40mt • Baggage Compartment Width: 2.95in 0.90mt Length: 2.39ft 0.73mt Height: 1.64ft 0.5mt Volume: 11,6cu.ft 329lt Max. permissible load: 77lb 35kg
www.tecnam.com
SPECIFICATION & DESCRIPTION Pag. | 5
• Performance (600kg\1320lbs-912 ULS-Sensenich propeller) Service Ceiling: 15.000ft 4572mt Takeoff Distance S.L. (Ground Roll): 715ft 218mt Takeoff Distance S.L. (To Clear 50ft. Obstacle): 1180ft 360mt Max Climb Rate S.L: 1100ft/min 5,6mt/sec Max Speed S.L: 127kt 235km/h
Max Range: 750nm Cruise Speed (75% pwr at 6.500ft): 118kt 219km/h
Vne (never exceed this speed) 150kt 278km/h Landing Distance (Ground Roll): 505ft 154mt Landing Distance (To Clear 50 ft Obstacle): 990ft 302mt Stall Speed, flap UP 44kt 81km/h Stall Speed, flap DW 38kt 70km/h • Design weight and capacities Standard empty weight 809lb 367kg Max Take-off Weight: 1320lb 600kg Landing Weight: 1320lb 600kg Maximum Useful Load: 511lb 233kg Fuel Capacity: 29US Gal 110lt
www.tecnam.com
Pag. | 6 SPECIFICATION & DESCRIPTION
Three views
www.tecnam.com
SPECIFICATION & DESCRIPTION Pag. | 7
Astore Standard equipment list The following list of equipment is included in the standard aircraft Analog Avionics Package and does not reflect optional equipment.
Flight instruments and indicators • MAGNETIC COMPASS • AIRSPEED IND., Kt • ALTIMETER • VERTICAL SPEED • SIDESLIP INDICATOR • PITOT SYSTEM • STATIC SYSTEM
Engine instruments Dynon D10 Includes: • TACHOMETER • HOUR RECORDER • OIL PRESS • OIL TEMP. • HEAD TEMP. • FUEL PRESS. • VOLTMETER • ELEVATOR TRIM POSITION INDICATOR • FLAP INDICATOR • LH + RH FUEL QTY
Flight controls • HYDRAULIC TOE BRAKES • PARKING BRAKE • ELECTRICAL FLAPS • DUAL FLIGHT CONTROLS • CASTORING NOSE WHEEL • STABILATOR TRIM (Electric actuated from Stick) • ENGINE CONTROLS: o CENTRAL QUADRANT WITH SINGLE THROTTLE LEVER o CHOKE • FLIGHT TRIM CONTROLS: o ELEVATOR TRIM with INDICATOR o FUEL CONTROL SELECTOR ANDAIR
Panel switches • SPLIT STARTER • AVIONICS MASTER • STARTER KEY ACS • FUEL PUMP
www.tecnam.com
Pag. | 8 SPECIFICATION & DESCRIPTION
Electrical system • 13,2V 7 AMP. ALLIANT BATTERY • 14V ALTERNATOR-20 AMP. • ROCKER SWITCHES INTERNALLY LIGHTED o Master switch o Landing light o Nav light o Strobe light • CIRCUIT BREAKER PANEL • LANDING/TAXI LIGHT LED • WING LIGHT GREEN/RED, WHITE and STROBE AVEO Full LED • 12 VOLT SOCKET
Fuel system • TWO INTEGRAL FUEL TANKS WITH 110lt\29USgal total capacity • ENGINE DRIVEN FUEL PUMP • AUXILIARY FUEL PUMP, ELECTRIC • FUEL TANK QUICK DRAIN , TWO • 1 X SHUT OFF AND FUEL SELECTOR VALVE (Andair)
Interiors • PILOT and CO-PILOT SEATS o Eco leatherette o Adjustable fore and aft • SEAT BELTS 3 POINTS ALL SEATS • WALL TO WALL CARPETING • MAP & STORAGE POCKETS • RADIO CALL PLATE • SOUNDPROOFING • LUGGAGE COMPARTMENTS • EMERGENCY HAMMER
Exterior • EPOXY CORROSION PROOFING, All structure • CANOPY, LOCK AND KEY • TIE DOWN RINGS • MAIN WHEELS, 5.00 X 5 - NOSE 5,00 X 5
Exteriors lights • WING TIP STROBE AND POSITION LIGHT LED • LANDING/TAXI LIGHT LED
Cabin comfort system • WINDSHIELD DEFROSTER • VENTILATOR ADJUSTABLE • HEATING SYSTEM
www.tecnam.com
SPECIFICATION & DESCRIPTION Pag. | 9
Powerplant and Propeller • ENGINE - 1 ROTAX 912ULS2 100 HP o 4 Cylinders o Liquid/air cooled o Integrated reduction gear • DUAL IGNITION SYSTEM • THROTTLE CONTROL (Central) • TUBULAR STEEL ENGINE MOUNT • PROPELLER 2 Blade Fix Pitch Sensenich • PROPELLER SPINNER • TWO AIR FILTERS • OIL FILTER • OIL AND WATER COOLERS • FIRE SLEEVE FUEL AND OIL TUBES
Standard Avionics Package • I-PAD Mini
Product support/documents • MANUFACTURER’S FULL TWO YEAR LIMITED WARRANTY • PILOT’S OPERATION HANDBOOK • MAINTENANCE MANUAL • PARTS CATALOG
STANDARD
www.tecnam.com
Pag. | 10 SPECIFICATION & DESCRIPTION
OPTION 1 – Astore Six pack Non additive, replaces standard equipment and avionics Flight instruments and indicators • ATTITUDE, electric • DIRECTIONAL, electric • TURN & BANK • ELEVATOR TRIM POSITION INDICATOR • FLAP INDICATOR
Engine analog instruments • TACHOMETER • HOUR RECORDER • OIL PRESS • OIL TEMP. • HEAD TEMP. • FUEL PRESS. • VOLTMETER • AMMETER • LH + RH FUEL QTY
AVIONICS PACKAGE • GARMIN GMA 240 Audio Panel • GARMIN GTR 200 COM (25 Mhz) non TSO(*) • GARMIN GTX 327 TRANSPONDER • GARMIN 796 GPS XM VERSION • STICK PUSH-TO-TALK SWITCH-PILOT/COPILOT • MIC & PHONE JACKS-PILOT/COPILOT • ANTENNAS: o TRANSPONDER o VHF o GPS
OPTION 1 export certificate requirements may require additional equipment or a different equipment list (*) If required 8,33 Mhz exchange with option 120B www.tecnam.com
SPECIFICATION & DESCRIPTION Pag. | 11
OPTION 2 - DYNON SV1000 TWO SCREENS + GPS796 Non additive, replaces standard equipment and avionic
DYNON SKY VIEW SV1000 TWO SCREENS AVIONICS PACK FOR ROTAX 912 ULS2 & IS • SKYVIEW SV 1000 10” 2 SCREEN DISPLAY (includes main wiring harness) • SV-ADAHRS-200 • SV-ADAHRS-201 • SV-EMS-221/A ENGINE MONITORING MODULE FOR ROTAX 912 • SV-GPS-250 • SV-BAT-320 • BACKUP ALTIMETER AND AIRSPEED INDICATOR
SV-EMS CONFIGURATION • AMMETER SHUNT OR HALL EFFECT • MONITOR CHT • AIRCRAFT BUS VOLTAGES • OIL TEMPERATURE • OAT • OIL PRESSURE • MANIFOLD PRESSURE • FUEL PRESSURE • RPM • TRIM INDICATOR • FLAP INDICATOR
AVIONICS PACKAGE • Dynon SV-INTERCOM-2S • Dynon SV-COM-C25 COM (25 Mhz)(*) • Dynon SV-XPNDR-261 TRANSPONDER • STICK PUSH-TO-TALK SWITCH-PILOT/COPILOT • MIC & PHONE JACKS-PILOT/COPILOT • ANTENNAS: o TRANSPONDER o VHF o GPS • AUXILIARY ALTERNATOR • GPS 796 GPS XM VERSION
OPTIONOPTION 2 export certificate requirements may require additional equipment or a different equipment list (*) If required 8,33 Mhz exchange with option 120B www.tecnam.com
Pag. | 12 SPECIFICATION & DESCRIPTION
OPTION 3 – G3X TWO SCREENS Non additive, replaces standard equipment and avionics Garmin G3X two screens Avionics Package for Rotax 912 ULS2 • GDU460 • GDU465 • ADAHRS GSU 25 • GEA 24 Engine Instrument Module • GMU 22 Magnetometer • GTP 59 Temperature Probe • GA 35 GPS/WAAS Antenna • BACK UP AIRSPEED. And ALTIMETER 3"
GSU CONFIGURATION • AMPS (AMMETER SHUNT OR HALL EFFECT) • MONITOR CHT • AIRCRAFT BUS VOLTAGES • OIL TEMPERATURE • OAT • OIL PRESSURE • MANIFOLD PRESSURE • FUEL PRESSURE • RPM • TRIM INDICATOR • FLAP INDICATOR
AVIONICS PACKAGE • GARMIN GMA 240 Audio Panel • GARMIN GTR 200 COM (25Mhz) NON TSO(*) • GTX 23 Transponder mode S remote mounted • STICK PUSH-TO-TALK SWITCH-PILOT/COPILOT • MIC & PHONE JACKS-PILOT/COPILOT • ANTENNAS: o TRANSPONDER o VHF
OPTION 3 export certificate requirements may require additional equipment or a different equipment list (*) If required 8,33 Mhz exchange with option 120B www.tecnam.com
SPECIFICATION & DESCRIPTION Pag. | 13
Engine Upgrade
EUP 01 US ROTAX 912 IS - Replacement of the engine Rotax 912ULS2
Non-Additive. Replaces all Standard Equipment.- Also Includes the following equipment:
x ENGINE ROTAX 912 IS
EUP 02 US ROTAX INTEGRA TL-6724 912iS (Add only for the Standard version)
EUP 03 US ROTAX 914 Turbo - Replacement of the engine Rotax 912ULS2
Non-Additive. Replaces all Standard Equipment.- Also Includes the following equipment:
x ENGINE ROTAX 914 TURBO
x SENSENICH ground adjustable 3 blade propeller (exchange for Std. FIX Prop.)
x MAP
Packages 01 ADVANTAGE includes: Non additive, replaces standard equipment and Avionics • FIREWALL INOX • GTR 225A COM INSTALLED • GTX 327 TRANSPONDER INSTALLED • ELT AK 450 INSTALLED • AERA 500 INSTALLED • PARACHUTE 600KG
02 LIGHT SPORT AIRCRAFT includes: Non additive, replaces standard equipment and Avionics • FIREWALL INOX • AIRSPEED IND. Kts • PANEL SWITCHES: o SPLIT STARTER o AVIONIC o STARTER KEY ACS • TIE DOWN RINGS • THERMOSTATIC VALVE OIL • BAGGAGE COMPARTMENT NET • EXTERNAL POWER SUPPLY • ELT 406 MHZ WITH ANTENNA AND REMOTE MOUNTED SWITCH
www.tecnam.com
Pag. | 14 SPECIFICATION & DESCRIPTION
OPTIONALS Code Description INSTRUMENTS Std. 1 2 3 106 Turn and Bank indicator O S N/A N/A 107 Chronometer O O N/A N/A 108 Ammeter O S N/A N/A 109 O.A.T. O O N/A N/A 110 M.A.P. O O N/A N/A 111 Attitude Indicator Electric O S N/A O 112 Attitude Indicator Electric small 2 1/4 O O O O 113 Directional Electric O S N/A N/A 115/B OBLO' EFIS Standard O O O O RADIO & NAV EQUIPMENT (GARMIN) Std. 1 2 3 116 GMA 240 Audio Panel with Antenna and inst. (non TSO) O S N/A S 117 GMA 340 Audio Panel with Antenna and inst. O O O O 117/A GMA 340 Audio Panel with Antenna and inst. (Exch for Std GMA240) O O O O 118/A GNC 255A COM/NAV 8.33 Mhz with Antennas and Inst. O O O O 118/B GNC 255A COM/NAV 8.33 Mhz with Ant. and Inst.(Exch for Std GTR200) O O O O 119 MD200 VOR Indicator Only for GNC255A (requires optional# 118/A) O O N/A N/A 120 GTR200 COM with Antenna and Inst. O S N/A S 120/A GTR225 COM with Antenna and Inst. O O O O 120/B GTR225A COM 8.33 Mhz with Antenna and Inst. O O O O 120/D GTR20 COM 25 Khz with Ant. and Inst. (Only with G3X) O O O O 123 GTX 327 Transponder mode C with Antenna and Inst. O S N/A N/A 124 GTX 328 Transponder mode S with Antenna and Inst. O O O O 125 GTX 330 Transponder mode S with Antenna and Inst. O O O O 129B 2nd ADAHRS for G3x N/A N/A N/A O 129C AUTOPILOT 2 Axis for G3X N/A N/A N/A O 129D Additional Autopilot Mode Controller (Requires Option 129C) N/A N/A N/A O 129E GAP 26 AOA Unheated N/A N/A N/A O 129F GAP 26 AOA Heated Unregulated N/A N/A N/A O 133 GPS 796 XM with Antenna, Panel Support and Inst. O S S O 134 GDL39R ADS-B Receiver O O O O RADIO & NAV EQUIPMENT (DYNON) Std. 1 2 3 140 DYNON D100/D120 (EXCHANGE FOR Analogue version see note # 2) O N/A O N/A 143/A DYNON SV D700 2 screen (EXCHANGE FOR Analogue version see note # 5b) O N/A O N/A 144 DYNON SV D1000 2 screen (EXCHANGE FOR Analogue version see note # 6) O N/A O N/A 144/E DYNON SV D1000T 2 screen (EXCHANGE FOR Analogue version see note # 6) O N/A O N/A 145 AUTOPILOT FOR SV D1000 and SV D700 N/A N/A O N/A 145/A DYNON SV-AP-PANEL N/A N/A O N/A 145/B DYNON SV-KNOB-PANEL N/A N/A O N/A 147/A SV-MAP-270 SkyView GPS Navigation Mapping Software N/A N/A O N/A
www.tecnam.com
SPECIFICATION & DESCRIPTION Pag. | 15
147/B AOA Unheated p/n 100141-000 N/A N/A O N/A 147/C AOA Heated p/n 100667-000 N/A N/A O N/A 147/D SV-ADSB-470 UAT Band Traffic and Weather Receiver + UAT Antenna N/A N/A O N/A AUTOPILOTS Std. 1 2 3 183 Trio Autopilot PRO PILOT O O N/A N/A OTHERS Std. 1 2 3 150 ELT ME406 ARTEX 406 Mhz O O O O 150/A ELT AK450 101.5 Mhz O O O O 151/A LEVIL AHRS G MINI for iPad® mini O O O O 157 HEAD SETS, two O O O O 157/A BOSE A 20 Head Sets, TWO O O O O 158 SPEAKERS O O O O 159 TELEX Microphone O O O O 168 STALL Warning O O O O 169/A Parachute MAGNUM 600 kg including installation O O O O 172 External Power Supply Receptable O O O O 180/A CLEVELAND Wheel and Brake (Exchange for Standard brake) O O O O 182 FUSELAGE Cover O O O O 184 NIGHT Package (See note # 4) N/A O O O INTERIORS / EXTERIORS Std. 1 2 3 170 Fire Extinguisher installed O O O O 171 First Aid Kit installed O O O O 174 Tinted windows O O O O 184/G Deluxe interiors (See note #12) O O O O 184/E Spinner Polished Alluminum Look O O O O 201 Special paint two colors O O O O ENGINE AND PROPELLER EQUIPMENTS Std. 1 2 3 186 Carburetors Heating System O O O O 187 Aux. alternator O O O O 191/A NEUFORM V.P. ELECTRIC with regulator (exchange for Std FIX Prop.) O O O O 191/B SENSENICH ground adjustable 3 blade propeller (ex. for Std FIX Prop.) O O O O 191/C SENSENICH ground adjustable 2 blade propeller (ex.for Std FIX Prop.) O O O O 193 MT PROPELLER V.P. non certified Hydraulic with Governor and inst. (ex.for Std fix Prop) O O O O 195 MT PROPELLER V.P. non cert. Hydr. with Gov. and Inst. (ex. Std fix Prop only for turbo) O O O O 196 Thermostartic Valve Oil O O O O 197 Thermostatic valve water O O O O LEGENDA: O = Optional S = Standard N/A = Not Applicable
#2 Dynon Package #5/B Dynon Pack. SV-D700 2 Screens #6 Dynon Package SV-D1000 or D1000T Two Screen D100 + D120 Super Bright SV-D700 two screens SV-D1000 or D1000T Rotax Pack ADAHRS PRIMARY ADAHRS PRIMARY OAT prob ADAHRS BACK UP SV-D1000 Fuel Press ENGINE MODULE ADAHRS BACK UP Wiring Harness GPS RECEIVER ENGINE MODULE Airspeed Ind. And Altimeter 3 Inch backup BACK UP BATTERY GPS RECEIVER NON TSO Airspeed Ind. And Altimeter 2-1/4 Inch BACK UP BATTERY Internal Back up Battery back up NON TSO Airspeed Ind. And Alt. 2-1/4 Inch back up NON TSO Rotax Sensor Rotax Sensor #4 Night Package includes: #12 De Luxe interiors ASTORE: instruments light (only for std. equipment) Seats new style with reclining Head Rest cabin light Throttle Knob Chrome TSO wiring Insert Side www.tecnam.comwww.tecnam.com Dimmer Centre Arm Rest Astore Logo Polished Aluminum Look
Pag. | 16 SPECIFICATION & DESCRIPTION
TECNAM COLORS Standard color, for more information please visit www.tecnam.com
Livery standard version
Special Paint #1
www.tecnam.com
SPECIFICATION & DESCRIPTION Pag. | 17
Special paint #2
Special paint #3
Special paint #4
www.tecnam.com
Pag. | 18 SPECIFICATION & DESCRIPTION
INTERIORS For more interiors combination please refer to www.tecnam.com
www.tecnam.com