DIAMOND DA62 Product Presentation / Twin Engine / up to 7 seats www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 1 Last Update: December 2017, DAI-A OVERVIEW Aircraft Characteristics & Systems Avionics & Features Composite Material & Maintenance Saftey Concept Fleet Concept & DA42 Worldwide www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 2 DA62 CHARACTERISTICS www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 3 AIRCRAFT CHARACTERISTICS • Low wing, whole composite design • 5 to 7 seats, dual controls • Garmin G1000 NXi Glass Cockpit incl. GFC700 Autopilot • Twin Piston Engine burning Jet Fuel (2x 180 hp Austro Engine AE330-E4P) • Day/Night-VFR, IFR (Single Pilot IR certified), Flights into known or forecast icing conditions • Certification basis JAR-23 with additions acc. CRI A-01 www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 4 TARGET GROUPS • Leisure Flying (private flying, travelling, etc.) • Air-Taxi Flights (island hopping, corporate aircraft, etc.) • Flight Training www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 5 DIMENSIONS www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 6 KEY PERFORMANCE DATA • Max. Take-off Weight (MTOW) 2,300 kg / 5,071 lbs • Typical Empty Weight (subject to optional equipment) 1,590 kg / 3,505 lbs • Max. Cruise Speed (ISA, FL140, 95% Power) 352 km/h / 190 KTAS • Rate of Climb, ISA, SL, Flaps up 5.2 m/s / 1,029 ft/min • Max. Range 2,376 km / 1,283 nm • Max. Operating Altitude 6,096 m / 20,000 ft • Fuel Type Jet-A1 (or equiv.) • Fuel Consumption at 60% for both engines 44.7 l / 11.8 USG/h • Fuel capacity 327 l / 86.4 US gal • Stall speed, 2,300 kg, Landing config. 69 / 64 KIAS • Take-off roll (distance to 50 ft); ISA, SL, MTOW, Flaps T/O 480 (833) m / 1,575 (2,733) ft • One engine inoperative climb ceiling ISA 3,962 m / 13,000 ft • Max. demonstrated cross wind 46 km/h / 25 knots www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 7 MAXIMUM RANGE FL140 *Theoretical range, no fuel reserve, at no wind conditions. Sample Empty Weight 1,650kg, MTOW 2,300 kg, FL140, ISA conditions. Higher Flight Level will provide longer range. Not to be used for flight planning, refer to AFM. www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 8 MAXIMUM ENDURANCE *Theoretical endurance, no fuel reserve. Sample Empty Weight 1,650 kg, MTOW 2,300 kg. Airspeed will depend on flight altitude. Not to be used for flight planning, refer to AFM. www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 9 ENDURANCE AND RANGE DA62 with 2,300 kg at FL160 • Optimal Cruise 75% / 180 kts, 14.8 USG/h / Economy Cruise 60% 160 kts, 11.8 USG/h • Full Fuel 87 US gal • Max Endurance 5:52 h / 7:22 h • Max Range 1,056 nm / 1,179 nm • Main Tanks only 50 US gal • Max Endurance 3:22 h / 4:13 h • Max Range 608 nm / 678 nm *Max Endurance and Range theoretical examples up to zero fuel. For realistic IFR Operation consider alternate fuel, 45 min reserve, contingency fuel (3-5%) or any other required by national authority www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 10 EXPERIENCE TRUE TWIN BENEFIT One Engine Inoperative Climb Rate, ft/min Press. Alt. 1,999 kg 2,300 kg SL 294 163 2,000 277 146 4,000 259 128 6,000 241 110 8,000 222 88 10,000 199 65 12,000 175 41 14,000 127 -5 16,000 69 -61 18,000 2 -124 *Not to be used for flight planning, refer to AFM. One Engine Inoperative Climb, ISA conditions, Power: feathered/95%, gear retracted, flaps up, Vyse KIAS. www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 11 RANGE MAP (acc. to power settings) FL140, ISA, without fuel reserve In order to calculate the range from your city/country please visit: http://www.diamond-air.at/twin-engine- aircraft/da62.html www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 12 DA62 AVIONICS & FEATURES www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 13 AVIONICS & OPTIONAL FEATURES Diamond’s DA62 Standard equipped Optional features for the DA62 are: version includes: (PENDING) • Glass Cockpit Garmin G1000Nxi (integrated COM, NAV, ILS) • Automatic Flight Control System Garmin GFC700 • Adjustable Backrests for Pilot & Co-Pilot Seat • Electrically Adjustable Rudder Pedals • Long Range Fuel Tank (326 l / 86 US gal) • Garmin ESP (electronic stability & protection) • Sun glare shields and canopy lining • Landing and taxi lights (Xenon) & Position and strobe lights with LED technology www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 14 AUTOPILOT GFC700 Digital AFCS fully integrated within G1000 architecture Main Operating Functions: • Flight Director (FD) • Autopilot (AP) • Manual Electric Trim (MET) • Yaw Damper Highlights: • Flight Level Change Mode (Indicated Airspeed) • Vertical Navigation Mode • Full IFR Capabilities – automatic conduction of SIDs/STARs, SBAS, P-RNAV Operation and coupled procedures • Over speed protection in VS mode www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 15 GARMIN ESP • Provides automatic control inputs to discourage operation outside of safe envelope. • Engages when any of Pitch, Roll, Airspeed is beyond the normal flight parameters. • Can be interrupted by the pilot (pressing and holding AP Disconnect button / pressing and holding CWS Button) • Can be disabled or enabled in AUX-SYSTEM SETUP 2 page in G1000 NXi • Autopilot Underspeed Protection* (USP): • in non-altitude critical mode (LVL, PIT, FLC, VS, VNV) – pitch down to maintain 90 KIAS, aural AIRSPEED alert sounds once • in altitude critical mode (ALT, GS, GP, GA) and Stall Warning active > 1 sec – maintains wings level and pitch down to eliminate Stall Warning +2 KIAS. Aural AIRSPEED alert sounds every 5 sec. • Coupled GO-AROUND (pressing GA button will not disengage AP, but AP will attempt to capture and track FD Bars. In case of insufficient performance AP will enter USP mode, when stall warning sounds. www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 16 GARMIN CHARTVIEW • Shows Jeppesen Airport Terminal charts in MFD www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 17 GARMIN SYNTHTETIC VISION • Software add-on shows 3D Terrain in PFD • Also shows obstacles, traffic, airports, runways, flightpath, etc. www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 18 L-3WX500 STORMSCOPE • Adds Lightning Strike Indication to Garmin G1000 NXi www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 19 GARMIN GWX70 WEATHER RADAR • GWX70 helps to detect and avoid adverse weather • Bringing full-colour storm cell tracking to the MFD • Accurate, easy-to-interpret, weather analysis in the cockpit • Weather Attenuated Color Highlight (WATCH™) can identify areas beyond the radar's capability that may contain even more hazardous areas of precipitation www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 20 TRAFFIC ADVISORY SYSTEM • The TAS605 system is designed to help in detection and collision avoidance of other aircraft. • Shows other air traffic (with transponder) on • Automatic traffic warnings www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 21 GSR 56 SATELLITE TRANSCEIVER The GSR 56 Iridium Transceiver provides an airborne low speed data link, on-demand satellite weather, Iridium Satellite Telephone service, and Short Message Service (SMS). The telephone is available to the flight crew through the audio panel and headsets. A subscriber account must be established prior to using the Iridium Satellite System. www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 22 DA62 SYSTEMS www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 23 AUSTRO ENGINE AE330 • 180 HP • Four cylinders, liquid-cooled, 1,991 ccm • Common-rail direct injection • Reduction gear 1:1,69 • Dual channel digital engine control (EECU) • Turbocharger • Torsional vibration damper • Max. power: (5 min time limit) 132 kW (180HP) at 2,300 RPM • Max continuous power: 126 kW (171HP) at 2,200 RPM • Current TBO 1,800 hrs (time between overhaul) www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 24 AUSTRO ENGINE AE330 High Pressure Pump Turbo Charger Coolant Cooler Heat Exchanger www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 25 AUSTRO ENGINE AE330 Gearbox Alternator Oil Tank Fuel Cooler www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 26 DUAL DIGITAL ENGINE CONTROL • FADEC (Full Authority Digital Engine Control) Wizard Software Program state of art engine control unit • Single Lever Power Control (easy handling) • Fully automated Run-Up check • Dual ECU for redundancy • Sophisticated engine health monitoring (Wizard Software) ECU Test Single Lever Power Control Easy handling because • NO Manual Leaning • NO Manual Priming XB • NO Manual Propeller XP XA Control EECU www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 27 ADVANTAGES OF LIQUID-COOLED SYSTEMS • No shock cooling on cylinders • Cabin Heating system uses heat exchanger like in a car – no CO danger • Easy maintenance and operation: • No need to check Coolant Level in daily operation • Coolant Temperature is indicated on MFD in G1000 NXi • Coolant LVL Low annunciation is available in G1000 NXi www.diamond-air.at AVIATION AS UNIQUE AS YOU ARE #WeFlyDiamondAircraft 28 AE330 TEMPERATURE LIMITATIONS • Fuel • Operation with Kerosene min. -30°C / -22 °F max. 60°C / 140°F • Oil • Oil tempature (start) min. -30°C / -22 °F • Oil temperature max. 139°C / 282 °F • Coolant • Coolant temp (start) min. -30°C / -22 °F • Coolant temp (full load) min. 60°C / 140°F • Coolant temp max. 100 °C / 212°F • Gearbox • Gearbox Oil temp (start) min.