Service Bulletin PRELIMINARY INFORMATION

Total Page：16

File Type：pdf, Size：1020Kb

Service Bulletin PRELIMINARY INFORMATION

File in Section: - Bulletin No.: PI1217 Service Bulletin Date: April, 2014 PRELIMINARY INFORMATION Subject: Diagnostic Tips for Transmission Fluid Leaking from Vent After Installing a Remanufactured Transmission or Valve Body Models: 1997-1999 Buick Riviera 1997-2004 Buick Regal 1997-2005 Buick Century, LeSabre, Park Avenue 2002-2007 Buick Rendezvous 2005-2007 Buick Terraza 2005-2009 Buick LaCrosse (Allure in Canada) 2006-2011 Buick Lucerne 1997-2001 Chevrolet Lumina 1997-2007 Chevrolet Monte Carlo 1999-2005 Chevrolet Venture 2001-2011 Chevrolet Impala 2005-2008 Chevrolet Uplander 2006-2007 Chevrolet Malibu 1997 Oldsmobile Cutlass Supreme 1997-1999 Oldsmobile Aurora, 88 1998-2002 Oldsmobile Intrigue 1999-2002 Oldsmobile Silhouette 2001-2002 Oldsmobile Aurora 1997-2005 Pontiac Bonneville 1997-2008 Pontiac Grand Prix 1998 Pontiac Transport 1999-2008 Pontiac Montana 2001-2005 Pontiac Aztek 2006-2009 Pontiac G6 2005-2007 Saturn Relay Equipped with 4T65 Automatic Transmission (RPO M15, MN7, MN3, M76 or MD7) Condition/Concern Some customers or technicians may comment on transmission fluid leaking from the vent after installing a remanufactured transmission or valve body. This condition may be caused by a worn, oversized pressure regulator valve bore in the valve body causing line pressure to leak into the exhausted port just under the transmission vent. Recommendation/Instructions If transmission fluid is encountered, please inspect the transmission for the following conditions: 1. Transmission fluid level overfilled. Refer to Transmission Fluid Level and Condition Check in SI. 2. Incorrect fluid level indicator. 3. Water or coolant in the fluid (fluid may appear milky in color). 4. Plugged or damaged vent. 5. Transmission case porous in the area of the vent. 6. Case cover assembly (Channel Plate) not torqued properly. 7. Case cover assembly gasket installed incorrectly. Note: If the cause of the fluid leak was not found after performing the inspection listed above, replace the valve body..

Copy Link

Recommended publications

IVIC Notifications
Department of Transportation Safety Division Towing Section 5/2/2016 NOTICE TO LAST KNOWN REGISTERED OWNERS AND SECURED PARTIES OF ABANDONED VEHICLES TAKEN INTO CUSTODY BY THE POLICE PURSUANT TO SECTION 25-205 OF THE TRANSPORTATION ARTICLE OF THE MARYLAND ANNOTATED CODE, THIS IS TO GIVE NOTICE THAT VARIOUS VEHICLES HAVE BEEN TAKEN INTO CUSTODY AND ARE NOW STORED AT THE TOWING SECTION LOCATED AT 6700 PULASKI HIGHWAY, BALTIMORE, MARYLAND 21237. ALL REGISTERED OWNERS AND SECURED PARTIES OF THESE VEHICLES HAVE THE RIGHT TO RECLAIM THEIR VEHICLES WITHIN ELEVEN (11) WORKING DAYS AFTER THE DATE OF THIS NOTICE SO LONG AS ALL TOWING, PRESERVATION AND STORAGE CHARGES ARE PAID. FAILURE OF AN OWNER OR SECURED PARTY TO EXERCISE THIS RIGHT WITHIN THE TIME PRESCRIBED ABOVE CONSTITUTES A WAIVER BY THEM OF ALL RIGHTS, TITLE AND INTEREST IN THEIR VEHICLE AND WILL BE CONSIDERED THEIR CONSENT TO THE SALE OF THE VEHICLE AT PUBLIC AUCTION OR RETENTION OF THE VEHICLE FOR PUBLIC PURPOSES. VISIT OUR WEBSITES: WWW.BALTIMORECITY.GOV/GOVERNMENT/TRANSPORTATION AND WWW.BALTIMORECITYTOWING.NET TO VIEW THE FULL LISTING OF THESE “UNCLAIMED” VEHICLES. Babatunde Yussuf ACTING TOWING MANAGER Page: 1 Year Make Type Serial Number Prop.No. 97 ACURA 2.5TL CAR JH4UA265XVC002145 P316163 01 ACURA 3.2CL CAR 19UYA427X1A012719 P315881 01 ACURA 3.2CL CAR 19UYA42771A014749 P315994 97 ACURA 3.2TL CAR JH4UA3655VC000132 P313879 99 ACURA 3.2TL CAR 19UUA5641XA055343 P314190 99 ACURA 3.2TL CAR 19UUA5647XA035825 P315931 99 ACURA 3.2TL CAR 19UUA5647XA018491 P316615 00 ACURA 3.2TL CAR 19UUA5666YA007100
[Show full text]
North America Sales History and Forecast
North America sales history and forecast 1998 1999 2000 2001 2002 2003 2004 2005 2006 U.S. car 131,559 153,658 162,703 172,505 166,848 170,794 172,594 195,026 211,172 Canada car 7,701 8,922 9,182 9,900 10,903 10,895 10,872 13,956 13,423 Mexico car 1,944 2,442 3,995 5,219 4,573 4,990 6,468 7,680 8,189 North America car 141,204 165,022 175,880 187,624 182,324 186,679 189,934 216,662 232,784 U.S. truck – 1,312 26,720 40,622 34,021 37,789 68,611 66,613 67,151 Canada. truck – 89 1,840 2,802 3,072 2,857 5,102 5,142 4,909 Mexico truck 115 233 213 897 982 989 928 890 983 North America truck 115 1,634 28,773 44,321 38,075 41,635 74,641 72,645 73,043 BMW 141,319 166,656 204,653 231,945 220,399 228,314 264,575 289,307 305,827 U.S. car 739,217 – – – – – – – – Canada car 86,148 – – – – – – – – Mexico car 47,176 – – – – – – – – North America car 872,541 – – – – – – – – U.S. truck 1,770,794 – – – – – – – – Canada truck 183,048 – – – – – – – – Mexico truck 45,123 – – – – – – – – North America truck 1,998,965 – – – – – – – – CHRYSLER CORP. 2,871,506 – – – – – – – – U.S. car – 889,506 894,219 863,043 739,430 744,526 751,850 775,084 796,545 Canada car – 92,064 89,163 76,691 83,291 80,243 79,625 84,883 88,430 Mexico car 52,058 65,957 86,948 78,504 86,942 87,746 91,957 97,751 North America car – 1,033,628 1,049,339 1,026,682 901,225 911,711 919,221 951,924 982,726 U.S.
[Show full text]
Doug Williams and His Final 500 Aurora
DOUG WILLIAMS AND HIS FINAL 500 AURORA Also in this issue: More Chapter members tell about their Final 500 Olds Who Am I – See if you can guess Special guest speakers for our monthly meetings Editor’s message……. 2014 R. E. Olds Chapter Board of Directors As you read this issue, I hope you appreciate the efforts of the several members that provided stories. I contacted all of our members who have a Final 500 car President listed with the Chapter, and requested a story about their special car. This April Bruce Powelson will be 10 years since Oldsmobile closed their assembly line. The response was H 517-548-2793 overwhelming and I even have one story for the next issue. C 517-331-3560 [email protected] This year is also the 50th anniversary of the 442 and all other 1964 models. If you have a 1964 Oldsmobile please consider sending me a picture and article for the Vice-President newsletter. This is a special milestone and I would love to fill the pages with Chris Heminger stories of your 50-year old Oldsmobile. I look forward to hearing from you. 517-655-3514 [email protected] Until we meet again……….keep those rockets rolling and stories coming, Secretary Judy Badgley Ed Shand 517-655-4739 Send newsletter articles, classifieds, etc. to Judy Badgley at [email protected] [email protected] or 4631 Doane Hwy., Potterville, MI 48876 Treasurer Jerry Garfield 248-881-3619 President’s message….. [email protected] This was our first meeting of the New Year, January's meeting having been Membership Coordinator cancelled due to extreme weather conditions.
[Show full text]
Autoreturn - Indianapolis Auction List for February 13, 2020
AutoReturn - Indianapolis Auction List for February 13, 2020 Lien TR# Exp. State License Make Model Year Body Color VIN Sold For S AUC # Type ABN 20200110A0116 2020 IN AUJ842 PONTIAC GRAND AM 1995 4 DOOR BLACK 1G2NW55MXSC80646 300 1 D 3 ABN 20200107A0059 2020 IN BEO540 DODGE NEON 2005 4 DOOR BLUE 1B3ES56C55D239110 600 2 D ABN 20200108A0057 2020 IN BEB273 CHEVROLET TRAIL 2004 SPORT BLACK 1GNDT13S942212991 425 3 D BLAZER S UTILITY ABN 20200109A0014 2017 IN UYY869 FORD EXPLORER 2000 SPORT BLUE 1FMZU85P3YZB51207 300 4 D S UTILITY ABN 20200104A0050 2020 IN BTK489 FORD FREESTAR 2004 VAN BLACK 2FMDA58224BA31137 325 5 D ABN 20200104A0077 IN YNE663 GMC SIERRA 2005 PICK GRAY 1GTEC19T85Z134810 575 6 D UP ABN 20200106A0009 2019 IN BCT276 PONTIAC GRAND PRIX 2005 4 DOOR GRAY 2G2WR524351149970 725 7 D ABN 20191224A0010 2020 IN BTH950 LINCOLN LS 2004 4 DOOR GOLD 1LNHM86S24Y668383 375 8 D ABN 20200105A0070 2018 IN 765FDH PONTIAC BONNEVILLE 2004 4 DOOR BLACK 1G2HY54K24U190262 675 9 D ABN 20200110A0097 2020 IN 623RLW PONTIAC G6 2009 4 DOOR RED 1G2ZH57N094100866 800 10 D ABN 20200104A0037 2020 IN 937RCS FORD TAURUS 2003 4 DOOR GREE 1FAFP55273G216300 575 11 D N ABN 20200105A0013 IN 9185655 HONDA CRV 1998 SPORT GREE JHLRD1868WC065876 375 12 D S N UTILITY ABN 20200105A0030 2020 IN URS591 CHEVROLET TRAIL 2002 SPORT GREE 1GNDT13S022323927 525 13 D BLAZER S N UTILITY ABN 20200104A0025 2020 IN TK804NQ CHRYSLER TOWN- 2006 VAN BLACK 2A4GP54L96R696037 325 14 D Q COUNT ABN 20191215A0027 -- NO CHEVROLET MALIBU 2015 4 DOOR GRAY 1G11C5SL5FF103381 1400 31 D PLATE ABN 20200103A0041
[Show full text]
The Bridge That Made Zilwaukee Famous
SEE PAGE 5B SEE PAGE 1B SEE PAGE 3A Dental check up Boating season every 6 months... running full Fun day at Really? speed ahead the mud bogs $1.00 Featured Section SUNDAY EDITION INSIDE LIFESTYLES: HEALTHY TEETH, HEALTHY BODY Weekend VOL. 21 NO. XXVIII SUNDAY, JULY 13, 2014 2012 & 2013 NEWSPAPER OF THE YEAR tctimes.com ONLINE COMMENTS The bridge that made Zilwaukee famous Pride is a matter of hon- ‘‘esty, integrity and honor. It has nothing to do with per- sonal sexual choices.” Mark my words, the downtown ‘‘ crosswalks are a lawyer’s dream. Some- one, hopefully not a child, is going to get injured or killed soon.” Was stuck for over 10 minutes at Ellen and ‘‘ LeRoy. Do something. The restaurant is making tons of money and the citizens are paying the price. Where is the logic here?” Landmark bridge gets first major makeover this year By Tim Jagielo TRI-COUNTY TIMES | TIM JAGIELO If you don’t like a cer- [email protected]; 810-433-6795 With its safety called into ques- tain float, close your eyes Zilwaukee — Towering over North Westervelt tion, the Zilwaukee Bridge was ‘‘when it goes by. It was a finished in 1987, after a three- wonderful parade.” Road is the bridge that made Zilwaukee famous. From underneath it looks like a typical Michigan overpass, year delay. Since then, millions I am so excited by the albeit enormous, transporting thousands of vehicles of travelers have trusted the bridge as they crossed over construction of the Cor- daily over the Saginaw River. ‘‘nerstone building.
[Show full text]
Road & Track Magazine Records
http://oac.cdlib.org/findaid/ark:/13030/c8j38wwz No online items Guide to the Road & Track Magazine Records M1919 David Krah, Beaudry Allen, Kendra Tsai, Gurudarshan Khalsa Department of Special Collections and University Archives 2015 ; revised 2017 Green Library 557 Escondido Mall Stanford 94305-6064 [email protected] URL: http://library.stanford.edu/spc Guide to the Road & Track M1919 1 Magazine Records M1919 Language of Material: English Contributing Institution: Department of Special Collections and University Archives Title: Road & Track Magazine records creator: Road & Track magazine Identifier/Call Number: M1919 Physical Description: 485 Linear Feet(1162 containers) Date (inclusive): circa 1920-2012 Language of Material: The materials are primarily in English with small amounts of material in German, French and Italian and other languages. Special Collections and University Archives materials are stored offsite and must be paged 36 hours in advance. Abstract: The records of Road & Track magazine consist primarily of subject files, arranged by make and model of vehicle, as well as material on performance and comparison testing and racing. Conditions Governing Use While Special Collections is the owner of the physical and digital items, permission to examine collection materials is not an authorization to publish. These materials are made available for use in research, teaching, and private study. Any transmission or reproduction beyond that allowed by fair use requires permission from the owners of rights, heir(s) or assigns. Preferred Citation [identification of item], Road & Track Magazine records (M1919). Dept. of Special Collections and University Archives, Stanford University Libraries, Stanford, Calif. Conditions Governing Access Open for research. Note that material must be requested at least 36 hours in advance of intended use.
[Show full text]
Approved Vehicles List
The School Board of Superintendent of Schools Hillsborough County, FL Jeff Eakins Deputy Superintendent, Instruction Van Ayres Tamara P. Shamburger, Chair Deputy Superintendent, Operations Melissa Snively, Vice Chair Christopher Farkas Steve P. Cona III Chief of Schools, Administration Lynn L. Gray Harrison Peters Stacy A. Hahn General Manager of Employee Relations Karen Perez OPERATIONS DIVISION Mark West Cindy Stuart SAFETY AND RISK MANAGEMENT Director of Safety & Risk Management Corries Culpepper APPROVED VEHICLES LIST 2019-2020 INTER-OFFICE COMMUNICATION Date: August 15, 2019 TO: All Principals/Program Administrators FROM: Corries Culpepper, Director of Safety and Risk Management SUBJECT: Transportation for School Related Functions (Updated List) Florida Statutes regulate the type of vehicles that may be used to transport students for school related functions, such as field trips and athletic events. • No Pick-up trucks of any type • No Conversion Vans of any type • No Compact Recreation Vehicles (CRV) Parents, teachers, coaches and other volunteers may use the following vehicles to transport students: • ALL PASSENGER CARS (except convertibles) ARE APPROVED. Approved Multipurpose Passenger Vehicles (MPV’s), listed below Must meet the National Highway Traffic Safety Administration Passenger Car Standards and be on the Florida Department of Education’s TSA #T-00-4. If you have a question regarding your vehicle, please call the Safety and Risk Management Office at 840 - 7324. The Approved MPV’s are: MANUFACTURER MODEL YEAR NOTES Acura
[Show full text]
Recall Bulletin Date: July 2010
File In Section: Product Recalls Bulletin No.: 10153A Recall Bulletin Date: July 2010 PRODUCT SAFETY RECALL SUBJECT: Heated Windshield Washer Module Short Circuit – Permanently Disable and Remove Module MODELS: 2006-2009 Buick Lucerne 2008-2009 Buick Enclave 2006-2009 Cadillac DTS 2007-2009 Cadillac Escalade, Escalade ESV, Escalade EXT 2008-2009 Cadillac CTS 2007-2009 Chevrolet Avalanche, Silverado, Suburban, Tahoe 2009 Chevrolet Traverse 2007-2009 GMC Acadia, Sierra, Yukon, Yukon XL 2006-2009 HUMMER H2 2007-2009 Saturn OUTLOOK Equipped with Heated Washer Fluid System (RPO XA7/CHW) The population in this safety recall has been expanded. The breakpoints for the GMC Acadia and Saturn OUTLOOK have been revised to reflect these additional vehicles. A Question and Answer (Q&A) section has also been added to this bulletin to clarify the customer compensation process. When issuing a check, dealers are to record the vehicle identification number (VIN) on the customer check. Please discard all copies of bulletin 10153, issued June 2010. CONDITION General Motors has decided that a defect, which relates to motor vehicle safety, exists in certain 2006-2009 model year Buick Lucerne; Cadillac DTS; HUMMER H2; 2008-2009 model year Buick Enclave; Cadillac CTS; 2007-2009 model year Cadillac Escalade, Escalade ESV, Escalade EXT; Chevrolet Avalanche, Silverado, Suburban, Tahoe; GMC Acadia, Sierra, Yukon, Yukon XL; Saturn OUTLOOK; and 2009 model year Chevrolet Traverse vehicles equipped with a heated washer fluid system (RPO XA7/CHW). A recall was implemented on some vehicles in 2008 to add a fuse to the HWFS control circuit harness to address the potential consequences of a printed circuit board electrical short.
[Show full text]
Trends in the Static Stability Factor of Passenger Cars, Light Trucks, and Vans
DOT HS 809 868 June 2005 NHTSA Technical Report Trends in the Static Stability Factor of Passenger Cars, Light Trucks, and Vans This document is available to the public from the National Technical Information Service, Springfield, Virginia 22161 The United States Government does not endorse products or manufacturers. Trade or manufacturers’ names appear only because they are considered essential to the object of this report. Technical Report Documentation Page 1. Report No. 2. Government Accession No. 3. Recipient’s Catalog No. DOT HS 809 868 4. Title and Subtitle 5. Report Date June 2005 Trends in the Static Stability Factor of Passenger Cars, Light Trucks, and Vans 6. Performing Organization Code 7. Author(s) 8. Performing Organization Report No. Marie C. Walz 9. Performing Organization Name and Address 10. Work Unit No. (TRAIS) Office of Regulatory Analysis and Evaluation Planning, Evaluation and Budget 11. Contract or Grant No. National Highway Traffic Safety Administration Washington, DC 20590 12. Sponsoring Agency Name and Address 13. Type of Report and Period Covered Department of Transportation NHTSA Technical Report National Highway Traffic Safety Administration 14. Sponsoring Agency Code Washington, DC 20590 15. Supplementary Notes 16. Abstract Rollover crashes kill more than 10,000 occupants of passenger vehicles each year. As part of its mission to reduce fatalities and injuries, since model year 2001 NHTSA has included rollover information as part of its NCAP ratings. One of the primary means of assessing rollover risk is the static stability factor (SSF), a measurement of a vehicle’s resistance to rollover. The higher the SSF, the lower the rollover risk.
[Show full text]
2003 Chevrolet Venture
2003 CHEVY VENTURE 2003 CHEVY VENTURE FEATURES: CHEVY VENTURE ■ 185-hp, 3400 V6 engine ■ Air conditioning and Solar-Ray glass FAMILY-FRIENDLY ■ Available seating plans for up to eight passengers (LS and Warner Bros. models) FUN TRAVELER. ■ Up to 140.7 cu. ft. of cargo space (extended wheelbase models) ■ Four-wheel ABS (optional on Value Van and Plus Van) Wherever you’re going, Chevy Venture makes travel fun for everybody. And you can be sure there’s a Venture exactly right for your family, thanks to a wide range of models and seating plans. Depending on the model, you can opt for dual power sliding side doors, a third-row stowable seat, and Versatrak — a versatile, all-wheel-drive traction system. You’ll love the response of the standard V6 engine (with the highest highway MPG in its class*) and you’ll feel secure knowing that Venture surrounds you and your passengers with a comprehensive safety package. Chevy Venture. It’s the perfect ﬁt for your family’s travel adventures. *Estimated MPG 19 city, 26 highway (front-wheel-drive models), 18 city, 24 highway (all-wheel-drive models). Based on front-wheel-drive and all- Venture Warner Bros. Edition all-wheel-drive model in Galaxy Silver Metallic. wheel-drive minivans using 2002 competitive information. 2003 Venture mileage estimates based on GM testing. Official EPA estimates not yet available. 0 2 WARNER BROS. EDITION THE MAIN ATTRACTION. Take the show on the road with the Venture Warner Bros. Edition with entertainment features that will have you inventing reasons for going places.
[Show full text]
Assembly Guide for Plastic Mounting Kits for 1982-2004 Ford, GM and Mopar Vehicles
Assembly Guide for Plastic Mounting Kits for 1982-2004 Ford, GM and Mopar Vehicles The information enclosed in this installation manual is to be used as a guide to assist you during the process of installation. This guide does not cover every installation possibility, vehicle, or every aspect of the installation process. Retro Manufacturing, LLC, RetroSound®, or its subsidiaries, assume no responsibility for any installation. This manual may be updated from time to time. Please check our website for the latest updates: retrosound.com. 1 2 3 4 ZONE REV. DESCRIPTION DATE ISSUE BY C B A ITEM PART NO. PART NAME QTY. MATERIAL SPEC. MODEL NAME MATERIAL/COLOR MODEL NO. CAVITY QTY. UNLESS OTHERWISE SPECIFIED DRAWN DATE 1, REMOVE ALL BURRS & SHARP CORNERS. 2, ALL DIMENSION ARE IN MILLIMETER ( ) mm APPD. DATE 3, TOLERANCE ARE LINEAR : .X ± 0.1 TOOL NO. .XX ± 0.05 DWG. FILE SHT. ANGULAR : ± 0.25° SCALE REV. GM, Ford and Mopar Plastic Mounting Kit Assembly Guide Table of Contents (GM Applications) BUICK CHEVROLET (cont.) Century 1982-96*........................7 Suburban 1989-91*.....................9 Electra 1984-94*.........................7 Suburban 1995-02......................10 Estate wagon 1984-94*.............. 7 Tahoe 1995-02............................10 LeSabre 1984-94*.......................7 Van (full) 1988-95........................13 Park Ave. 1984-94*.....................7 Venture 1997-99.........................15 Reatta 1990-91*..........................7 GMC Regal 1984-87*...........................7 Jimmy (full) 1989-91*..................9 Riviera 1983-85*.........................7 Jimmy 1998-02...........................10 Riviera 1990-95*.........................7 S15 Jimmy 1982-85....................17 Roadmaster 1991-94..................8 S15 Jimmy 1986-94....................18 Skyhawk 1982-89*......................9 S15 Pickup 1982-85....................17 Skylark 1983-85*.........................9 S15 Pickup 1986-93....................18 Skylark 1987-89*.........................9 Safari 1985-89...........................
[Show full text]
2006 Terraza 2006 Terraza
61606_FCa_2.qxd 6/17/05 2:18 AM Page 1 2006 TERRAZA 61606_2b_1.qxd 6/9/05 10:05 AM Page 1 61606_3b_5.qxd 7/20/05 1:16 PM Page 1 2006 BUICK TERRAZA ķ TREAT YOUR FAMILY TO THE PLEASURES OF TRAVELLING FIRST CLASS. For many years family transportation translated into a purely pragmatic form of driving, without any accompanying rewards. All that changed with the introduction of the Buick Terraza. Finally, a family vehicle that is as refined as it is versatile. A vehicle with real style, that is built to an exacting standard of quality. A vehicle employing sophisticated technology, such as the new 240 horsepower 3.9L V6 with variable valve timing on CXL FWD models*, as well as the added safety and security through the standard OnStar System. And incorporating a high level of luxury p.3 represented by the sumptuous interior appointments and the exemplary acoustic insulation provided by QuietTuning. Together, these components help define Terraza more as a Buick than as a conventional family vehicle. With this level of quality, refinement and craftsmanship, it could only be from Buick: the 2006 Terraza. Every Buick is built with exquisite care to exceptionally high standards, achieving a level of quality that ranks Buick among the elite. Every Buick is also equipped with the enhanced safety and security of OnStar, and employs QuietTuning for a supremely quiet ride. And now, for 2006, every Buick is backed by a new comprehensive four-year/80,000 km warranty** that solidifies Buick’s position as one of the world’s premium automakers.
[Show full text]