Executive Order D-476-3 Injen Technology Co
Total Page：16
File Type：pdf, Size：1020Kb
State of California AIR RESOURCES BOARD EXECUTIVE ORDER D—476—3 Relating to Exemptions Under Section 27156 of the California Vehicle Code Injen Technology Cyborg Intake System Pursuant to the authority vested in the Air Resources Board by Section 27156 of the Vehicle Code; and Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of the Health and Safety Code and Executive Order G—02—003; IT IS ORDERED AND RESOLVED: That the installation of the Cyborg Intake System, produced and marketed by Injen Technology, 244 Pioneer Place, Pomona, California 91768, has been found not to reduce the effectiveness of the applicable vehicle pollution control systems and, therefore, is exempt from the prohibitions of Section 27156 of the Vehicle Code for the vehicles listed in Exhibit A. The Cyborg Intake System includes the following main components: open—element reusable air filter, heat shields (as applicable), intake system tubing, crankcase ventilation hose (as applicable, which may be silicone, and a color other than black), assorted brackets, and hardware. This Executive Order is valid provided that the installation instructions for the Injen Technology Cyborg Intake System will not recommend tuning the vehicle to specifications different from those of the vehicle manufacturer. Changes made to the design or operating conditions of the Injen Technology Cyborg Intake System, as exempt by the Air Resources Board, which adversely affect the performance of the vehicle‘s pollution control system shall invalidate this Executive Order. This Executive Order shall not apply to any Injen Technology Cyborg Intake System advertised, offered for sale, sold with, or installed on a new motor vehicle prior to or concurrent with transfer to an ultimate purchaser. Marketing of the Injen Technology Cyborg Intake System using any identification other than that shown in this Executive Order or marketing of the Injen Technology Cyborg Intake System for an application other than those listed in this Executive Order shall be prohibited unless prior approval is obtained from the Air Resources Board. This Executive Order does not constitute any opinion as to the effect the use of the Injen Technology Cyborg Intake Systems may have on any warranty either expressed or implied by the vehicle manufacturer. This Executive Order is granted based on an examination of the On—Board Diagnostic II (OBD—I1) system of a 2001 Ford Focus, 2002 Lexus 1S$300, and 2002 Mitsubishi Eclipse in the modified configuration, and an engineering evaluation of the emissions impact of the device if measured using the Cold—Start CVS—75 Federal Test Procedure. Furthermore, this Executive Order is granted based on emission test results in the modified configuration using the Supplemental Federal Test Procedure (SFTP USO6). Test data and engineering evaluation showed that the Cyborg Intake System will have no adverse impact on the vehicles‘ emissions or the OBD—Il system monitoring. Results from emissions testing conducted at Quantum Technologies are shown below (in grams per mile): Modeli— Model Standard Test Group NMHC+NOx CO Year 2001 Ford Focus (auto) ULEV 1FMXVO2.O0VJ2 0.136 0.884 2002 Lexus IS 300 LEV 2TYXVO3.0FFF 0.031 3.508 2002 Mitsubishi Eclipse LEV 2DSXVO3.0GNS 0.024 1.453 Standard 014 8.0 If evidence provides the ARB with reason to suspect that the Cyborg Intake System will affect the durability of emission control systems, Injen Technology shall be required to submit durability data to show that the durability of vehicle emission control systems are not, in fact, affected and/or that the add—on or modified part demonstrates adequate durability. The ARB reserves the right in the future to review this Executive Order and the exemption provided herein to assure that the exempted add—on or modified part continues to meet the standards and procedures of Title 13, California Code of Regulations, Section 2222, et seq. THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION, APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING ANTI—POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF INJEN TECHNOLOGY‘S CYBORG INTAKE SYSTEM. No claim of any kind, such as "Approved by the Air Resources Board", may be made with respect to the action taken herein in any advertising or other oral or written communication. INJEN TECHNOLOGY — CYBORG INTAKE SYSTEM — D—476—3 Violation of any of the above conditions shall be grounds for revocation of this order. The order may be revoked only after a ten—day written notice of intention to revoke the order, in which period the holder of the order may request in writing a hearing to contest the proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of the request and the order may not be revoked until a determination is made ‘after the hearing that grounds for revocation exist. Executed at El Monte, California, this _A/ ST _ day of October, 2002. Allengons. Chief Mobile Source Operations Division INJEN TECHNOLOGY — CYBORG INTAKE SYSTEM — D—476—3 Exhibit A E.0. D—476—3 Part No. Make/Model Model—Year 151300 |HONDA $2000 2000—02 1§1305 |HONDA $2000 1 Piece Cold Air Intake 2000—02 1§1420 |ACURA INTEGRA LS,RS,LS SPECIAL TYPE R 1994—01 1§1450 |ACURA INTEGRA GSR 1994—01 §1470 |ACURA RSX MANUAL TRASNMISSION 2002 I§1471 |ACURA RSX AUTOMATIC TRANSMISSION 2002 1§1475 |ACURA RSX TYPES 2002 RS1475 |ACURA RSX TYPES 2002 RS1470 |ACURA RSX 2002 1$1501 |HONDA CIVIC/CRX Ex, Si 1988—9 1 1§$1525 |HONDA CIVIC DEL SOL DOHC AND SOHC 1993—97 1§1545 |HONDA Civic Cx, Dx, Lx 1996—00 1$1565 |HONDA Civic Dx, Lx, Ex 2001—02 1§$1575 |HONDA CIVIC SI 2002 151660 |HONDA Accord V4é 1998—02 151660 |JACURA TL 3.2L 2002 HONDA Accord 4 Cylinder (excluding 2001 & 2002 Honda Accord, engine families 1HNXVO2.3BF9 & IS1670 |2HNXVO2.3FK6) 1998—02 I§1720 |HONDA Prelude All 1997—01 1§1830 |[MITSUBISHI LANCER 2.0 2002 151840 |MITSUBISHI GALANT 4 CYLINDER 1999—02 1$1845 |MITSUBISHI GALANT ALL V6é including 1999—01 1§$1845 |DODGE STRATUS R/T, CHRYSLER SEBRING CP LXi 2000—0 1 1$1850 |MITSUBISHI MONTERO SPORT 1997—02 1$1866 |MITSUBISHI ECLIPSE V6 2000—01 1$1867 |MITSUBISHI ECLIPSE V6 2000—02 1§1868 |MITSUBISHI ECLIPSE, GALANT ALL V—6 including 2002 S1868 |DODGE STRATUS R/T, CHRYSLER SEBRING CP LXI 2002 IS1870 |MITSUBISHI ECLIPSE 4 CYL. 2000—01 1S1871 |MITSUBISHI ECLIPSE 4 CYL. 2000—02 1§$1885 |MITSUBISHI ECLIPSE N/A 2.O0L 1989—94 IS1887 |MITSUBISHI ECLIPSE N/A 1.8L SOHC 1989—94 1$1888 |MITSUBISHI ECLIPSE TURBO 2.O0L 1989—94 151955 |NISSAN SENTRA SER 1995—96 151960 |NISSAN SENTRA 1.6L 1995—96 151970 |NISSAN ALTIMA 2.4L 1998—01 1$1980 |NISSAN 3007X 1990—96 1$2010 |TOYOTA TACOMA 4 CYL 1997—99 1$2015 |TOYOTA TACOMA 4 CYL 2WD 2000—02 182020 |TOYOTA CAMRY 4 CYL 1997—99 152022 |TOYOTA.CAMRY 4 CYL 2000—01 1§2022 |TOYOTA SOLARA 4 CYL. 1999—01 1§2025 |TOYOTA CAMRY/SOLARA 4 CYL 2002 1§2030 |TOYOTA CAMRY/SOLARA Vé 1997—02 1§2035 |TOYOTA CELICA GT 2000—02 Page 1 of 3 Exhibit A E.0. D—476—3 1$2040 [TOYOTA CELICA GT ONLY 1994—99 1§2045 |TOYOTA CELICA GITS 2000—02 1$2050 |TOYOTA 4RUNNER, TACOMA V6é 3.4L 1996—98 152055 |TOYOTA 4RUNNER/TACOMA V6é 1999—02 1$2055 |TOYOTA PRE—RUNNER V6é 1999—02 1§2055 |TOYOTA S—RUNNER V6é 2001—02 1§2080 |TOYOTA COROLLA S 1.8L 1998—02 1$2083 |LEXUS SC300 1992—97 1§$2083 |LEXUS GS300 1992—97 1§$2085 |LEXUS SC400 1992—97 1$2085 |LEXUS GS400 1992—97 1$2085 |LEXUS LS$400 1992—97 1$2090 |LEXUS 18300 2000—01 1$209 1 |LEXUS 18300 2000—02 1$2095 |LEXUS GS430 2001—02 153000 |VW 2.0 OBD1 ONLY JETTA/GOLF 1993—96 153010 |VW 2.0 JETTA VI, GOLF III, CABRIO OBD2 ONLY 1996—98 154000 |SATURN S SERIES SL1, SL2, SC2 199 1—99 154020 |SATURN S SERIES DOHC ONLY 2000—02 1§5000 |MERCURY COUGAR Vé 1999—02 1§5050 |CHRYSLER PT CRUISER 2000—02 156040 |MAZDA MIATA 1999—02 157000 |CHEVY CAVALIER 724 all 2.4L 1996—01 17010 |CHEVY CAVALIER 2.2L 1995—97 187015 |CHEVY CAVALIER2.21 1998—99 1§$7020 |CHEVY S—10, GMC Sonoma, Jimmy and Blazer V6é 1996—01 1§59001 |FORD FOCUS ZX3 2.0L 5 SPEED and AUTOMATIC 2000—02 RD1200 |SUBARU WRX 2002 RD1205 |SUBARU WRX Wagon, WRX Sedan 2002 RD1210 |SUBARU IMPREZA RS 2.5L, OUTBACK, FORESTER, 2000—02 RD1210 |LEGACY, WAGON GT RD 1220 |SUBARU IMPREZA RS 2.5L 1998—99 RD1350 |HYUNDAI TIBURON 1998—01 RD1400 |ACURA INTEGRA 1990—93 RD1420 |ACURA INTEGRA LS,RS,LS SPECIAL 1994—01 RD1425 |ACURA INTEGRA TYPER 1997—01 RD1450 |ACURA INTEGRA GSR 1994—01 RD 1480 |ACURA CL TYPES 2001—02 RD1480 |ACURA TL TYPE S 2002 RD1500 |HONDA Civic Ex, Si 1988—9 1 RD1520 |HONDA Civic Dx, Lx, Ex, Si 1992—95 RD1525 |HONDA CIVIC DEL SOL DOHC AND SOHC 1993—97 RD1540 |HONDA Civic Cx, Dx, Lx 1996—00 . RD 1550 |HONDA Civic Ex, Hx, Acura EL 1996—98 RD1555 |HONDA Civic Ex, Hx, Acura EL 1999—00 RD1560 |HONDA Civic Si 1999—00 RD1565 |HONDA Civic Dx, Lx, Ex [(Automatic) 2001—02 Page 2 of 3 Exhibit A E.O. D—476—3 RD1566 [HONDA Civic Dx, Lx, Ex (5 Speed) 2001—02 RD1575 |[HONDA CIVIC SI 2002 RD1600 [HONDA ACCORD 4 CYL.