Product Data Sheet

PRODUCT DATA SHEET

No. 10490 JANUARY 2011

RONSEAL KITCHEN & BATHROOM REPAIR KIT Ronseal Kitchen & Bathroom Repair Kit contains everything you need for the easy and professional repair of cracks, scratches, and defects on kitchen and bathroom fixtures and appliances.

INTRODUCTION

Ronseal Kitchen & Bathroom Repair Kit contains a repair compound and hardener, touch up enamel with brush applicator, sandpaper DRYING TIME and mixing spatula. Filler will be dry in thirty minutes. Ronseal Kitchen & Bathroom Repair Kit provides the instantaneous repair of kitchens and bathroom fixtures and appliances. In order to achieve 100% hardness do not use water on the repaired surface for 4 days.

PROPERTIES IMPORTANT NOTES

Filler Important - In order to achieve 100% hardness do not use water on the repaired surface for 4 days. Appearance- Coloured paste. Odour-Characteristic styrene type. Do not apply in temperatures below 00C or in conditions of high Flammable. humidity. Immiscible with water. Flash Point – 35 CC (Closed Cup) Heat resistant to 60C

Touch Up Enamel Avoid the inhalation of dust when sanding, wear a suitable face mask or employ wet sanding techniques. Appearance – White liquid. Odour – Characteristic solvent type. STORAGE Flammable. Immiscible with water. Store in a cool, dry, well ventilated place away from heat and Flash Point – Less than 23 CC (Closed Cup) sources of ignition.

FIELDS OF APPLICATION HEALTH AND SAFETY

For use on enamelled cast iron and steel, porcelain, fibreglass, Observe and follow all warnings and instructions for use shown on acrylic and other similar material. the pack.

Avoid contact with skin and eyes. PREPARATION In case of contact with eyes, rinse immediately with plenty of water Ensure all surfaces are clean, dry and free from dust, dirt and and seek medical advice. grease. Remove any rust spots or loose material. After contact with skin, wash immediately with plenty of soap and Do not use this product in damp conditions or if temperature is below water or a proprietary skin cleanser. 0C. If swallowed seek medical advice immediately and show the APPLICATION container label.

Mix the required amount of repair compound and a little hardener at Use only in well ventilated areas. a 30 to 1 ratio. Only 1g of the hardener is required to mix with the 30g of repair compound. Apply the filler to the damaged area and Keep out of reach of children. allow it to dry for half an hour. Specific health and safety data sheets are available on request. Use the brown sandpaper for enamel and porcelain items, until the surface is smooth and there are no more projections or holes. For Touch-up Enamel: acrylic and fibreglass surfaces it is important to use the grey wet/dry sandpaper with water. Thoroughly clean off all sanding dust. Contains Xylene.

Shake the touch-up enamel vigorously for two minutes. Hold upright Highly flammable. when opening. Harnful by inhalation and contact with skin. Apply the enamel coating in multiple thin coats. Repeated exposure may cause skin dryness or cracking.

Repair compound: Contains styrene.

Flammable.

Harmful by inhalation.

Irritating to eyes and skin.

Hardener:

Contains Benzoyl Peroxide.

Irritating to eyes.

Toxic to aquatic organisms, may cause long term adverse effects in the aquatic environment.

May cause fire.

May cause sensitisation by skin contact.

Wear suitable gloves.

FLAMMABILITY

Flammable.

SUPPLY

Obtainable from paint suppliers, DIY retailers and builder’s merchants.

Available in re-sealable kit.

DISPOSAL

Some local authorities have special facilities for disposal of waste paints/varnishes.

Do not empty any product into drains or watercourses.

LIABILITY

Whilst these specifications are based on expert technical knowledge Ronseal Ltd. has been registered to BS EN ISO 9000 1994 and practical experience, we cannot assume responsibility for any (Registered Firm No. FM 1669/1). work as the ultimate result depends on factors beyond our direct control. Standard codes of painting practice should be followed. Ronseal Ltd. operate an Environmental Management System that complies with the requirements of BS 7750:1994, Certificate No. INFORMATION AND SERVICE EMS 35924

Our Technical Services Department will be pleased to offer specific Ronseal Ltd. has achieved Investors in People certification, guidance or provide any further information you may require. (certificate number 59586). DATA SHEETS ©RONSEAL LTD., Data sheets on other Ronseal Products are available on request Thorncliffe Park from our Technical Services Department. Chapeltown Sheffield S35 2YP

Tel: +44 (0114) 240 9469 (Technical Services) +44 (0114) 246 7171 ( Main Switchboard) Fax: +44 (0114) 245 5629 E. Mail: [email protected] Website: www.ronseal.co.uk

Ronseal is a registered trademark of the Sherwin Williams Company. JANUARY, 2011. ISSUE 1