Job Hazard Analysis Worksheet

JOB HAZARD ANALYSIS

Organization: Division: Section/Shop: I&E WASTE WATER TREATMENT FAC. WWTF

Task: RAKING A BAR SCREEN

Conducted By: Reviewed By: Approved By: G.G. MURPHY/TACTICAL SAFETY SPEC./BASE SAFETY

Date:20130611 Date:20130611 Date:20130611

Sequence of Steps Potential Accidents or Preventative Measures Hazards

1. TURN VENTILATION ON TO 1. ELECTRICAL HAZARDS WHEN 1. TRAINING (ARC FLASH AND RID CONFINED SPACE OF TURNING VENTILATION SYSTEM ON, ELECTRICAL SAFETY, FALL GASES AND ENSURE THAT HEARING LOSS DUE TO NOISE PROTECTION, CONFINED SPACE, PERMIT TO ENTER PRODUCED FROM VENTILATION SYSTEM. ETC…) AND ON THE JOB TRAINING CONFINED SPACE IS 2. RODENTS, VERMENTS, AND PESTS CONDUCTED BY EXPERINCED OBTAINED. (BLACK WIDOWS, SNAKES, ETC…; EMPLOYEES (SHIFT OPS. TRAIN 2. OBSERVATION OF AREA (TO SLIPS, TRIPS, AND FALLS; NEW EMPLOYEES). INCLUDE VENTILATION ELECTRICAL HAZARDS. 2. INSPECT WORKPLACE PRIOR TO SYSTEM AND AROUND WORK 3. INCORRECT P.P.E., WORK STARTING, ENSURE TO AREA) UNSERVICEABLE P.P.E., OR LACK OF INSPECT SMALL CREVICES. 3. DON PERSONAL PROTECTIVE UNDERSTANDING ON HOW TO DON/DOFF 3. INSPECT P.P.E. PRIOR TO START EQUIPMENT (P.P.E.) AND P.P.E. OF WORK EACH DAY FOR ENSURE THERE IS AN 4. ATMOSPHERE MONITOR SERVICEABILITY (STEEL TOE ATTENDANT AND ENTRY MALFUNCTIONS OR IS NOT BOOTS, TYVEX SUITS, SAFETY PERSON PRESENT. CALIBRATED. GOGGLES, OIL AND SLIP 4. TEST THE ATMOSPHERE 5. ENGULFMENT HAZARDS, RESISTANT SOLES ON BOOTS). WITHIN THE CONFINED RESPIRATORY HAZARDS, 4. VERIFY CALIBRATION AND TEST SPACE. CHEMICAL/BIO-HAZARDOUS MATERIAL MACHINE BEFORE LEAVING WORK 5. RADIO CONTACT BASE OPS. (SPLASHING). CENTER. TEST AT ALL LEVELS IN TO INFORM ENTRY INTO 6. HOIST FAILS, FALL ARREST SPACE TO ENSURE ALL LEVELS CONFINED SPACE. SYSTEM FAILS TO FUNCTION, FALL ARE FREE OF GASES. 6. SET UP HOIST AFTER INTO PIT OR THROUGH HATCH AT 5. ENSURE S.O.P. WRITTEN INSPECTION SYSTEM (FALL SURFACE LEVEL. OUTLINING REQUIRED STEPS FOR ARREST, FALL PROTECTION 7. SLIPS, TRIPS, AND FALLS ENTERING CONFINED SPACES, EQUIPMENT, ETC…) (LADDER SLIPPERY OR DAMP, FALL CONFINED SPACE TRAINING. 7. ENTER AFTER ATMOSPHERE INTO PIT). 6. INSPECT FOR WEAR AND DAMAGE, HAS BEEN CONFIRMED 8. BIO-HAZARDOUS WASTE CAN SPLASH UTILIZE A FALL ARRESTER AT CLEARED AND RAKE THE ON EMPLOYEES, AND ERGONOMIC ALL TIMES, ENSURE ATTENDANT BAR SCREEN. ISSUES FROM LIFTING IMPROPERLY, IS WEARING FALL PROTECTION 8. FILL BUCKETS WITH WASTE RESPIRATORY HAZARDS. GEAR WHILE OVER OPEN HATCH OF AND ATTACH TO RAISING 9. SLIPS, TRIPS, AND FALLS WHEN PIT. DEVICE FOR THE EXITING PIT, ERGONOMIC ISSUES 7. TRAINING, P.P.E., ATTENDANT TO LIFT TO FROM LIFTING EUIPMENT AND GEAR COMMUNICATION SYSTEM SURFACE. FROM CONFINED SPACE, AND ESTABLISHED FOR EMPLOYYE IN 9. EXIT CONFINED SPACE RESPIRATORY HAZARDS. ATTENDANT PIT AND ATTENDANT OUTSIDE OF WITH ALL EQUIPMENT. COULD FALL INTO OPEN PIT. PIT. 10. RADIO BASE OPS. TO 10. PINCH HAZARDS CLOSING 8. ERGONOMICS TRAINING, UTILIZE INFORM THAT PROCESS IS CONFINED SPACE HATCH; SLIPS, LIFTING DEVICE VICE MANUAL COMPLETE AND CONFINED SPACE TRIPS, AND FALLS; RESPIRATORY LIFT TO SURFACE. HAS BEEN SECURED. HAZARDS, ELECTRICAL HAZARDS, 99. PROPER DONNING/DOFFING P.P.E. ENGULFMENT IN SPACE WHEN EXITING. CLASSES, FALL PROTECTION TRAINING. 10. WEAR GLOVES THAT WILL MINIMIZE PINCH HAZARDS WHEN CLOSING HATCH TO PITS, ENSURE S.O.P. IS IN PLACE FOR EXITING PITS.

Copy To: Work Center, Unit Safety Officer, Base Safety Office Copy To: Work Center, Unit Safety Officer, Base Safety Office