Key to Lubrication Chart - 10/42 & 10/60

Every 10 hours

(1) FRONT AXLE - Apply the grease gun filled with grease. Give two shots to each nipple. (2) AIR CLEANER - Check the condition of the oil bath, replenish or change as necessary. (3) HAND BRAKE (when fitted) - Apply the grease gun filled with grease to the nipple on the brake pedal cross-shaft lever. (4) ENGINE - Inspect the level of the engine oil by the dipstick. Replenish if necessary. (5) TRANSMISSION - Check the level of the transmission oil by the dipstick. Replenish if necessary. (6) RADIUS RODS - Apply the grease gun filled with grease. Give two shots to the nipple on the rear bracket pivot.

Every 50 hours

(7) PULLEY UNIT - Replenish as necessary with new oil. (8) HYDRAULIC POWER UNIT - Remove the suction and magnetic filter. Clean thoroughly and replace. (9) HYDRAULIC POWER UNIT CROSS-SHAFT - Apply the grease gun filled with grease. Give two shots to each nipple. (10) RESERVOIR - Check the level of the fluid, and replenish as necessary. (11) FRONT HUBS - Apply the grease gun filled with grease. Give two shots to each nipple. (12) FUEL - Top up oil level with new oil. LINKAGE AND CONTROLS - Apply oil to the following points: foot brake, hand brake (if fitted), clutch mechanism, radiator shutters, control.

Every 200 hours

(13) STEERING - Check the level of the steering-box oil, and replenish if necessary. (14) ENGINE - Drain the old oil from the engine , and refill with new oil. (15) POWER STEERING UNIT - Give one shot of grease to each of the three nipples. (16) PUMP - Drain and refill with new oil. (19) - Add two drops of engine oil into the lubricating hole in the end of the dynamo.

Every 400 hours

(17) OIL FILTER - Discard the engine oil filter element, and replace it with a new one. (18) WATER PUMP - Apply the grease gun filled with grease. Give two shots.

Every 1200 hours

(20) TRANSMISSION - Drain and refill with new oil. (21) BELT PULLEY UNIT - Drain and refill with new oil.

Use only recommended Recommended Lubricants

Power Engine , Transmission and Hydraulics Steering Box Grease Points Assisted Steering

Climatic Above 32°C to -7°C Below All conditions All conditions All conditions conditions 32°C (90°F) (90°F to 20°F) -7°C (20°F) Shell SAE EP90 Farm Grease ATF TRACTOR OIL UNIVERSAL BP or Universal (Automatic Castrol Hypoid 90 or Transmission Duckhams SAE HD 30 SAE HD 20W SAE 10W Multi-Purpose Fluid) ESSO or or or Grease Filtrate SAE 20W/30 SAE HD SAE HD 10W or Mobil 20/20W Or Lithium Sternol or SAE 10W/30 Grease SAE 20W/50