August 17, 2009 Rodney Reynolds, Manager Madison County Water Facilities Board P.O. Box 606 Huntsville, Arkansas 72740 RE: Madison County Water Line Installation Project AFIN: N/A NPDES Permit No.: ARR150000 Dear Mr. Reynolds: On August 13, 2009, I performed a stormwater discharge permit compliance inspection of the above-referenced project in response to a complaint. The complainant was concerned that various permits required for the construction project may not have been obtained. The inspection was conducted in accordance with the provisions of the Federal Clean Water Act, the Arkansas Water and Air Pollution Control Act, and the regulations promulgated thereunder. This inspection revealed the following violations: 1. The Notice of Coverage (NOC) was not posted in a publicly accessible location near where construction is actively underway as required for linear projects. This is in violation of Part 1.B.8.C of the permit. Copies of the NOC should be posted at each active construction location. During our phone conversation today, you stated that this phase of the project will ultimately disturb less than 5 acres. As such, your construction project is automatically covered by the permit. A copy of the NOC can be obtained from the Water Division’s Construction Stormwater webpage. 2. A Stormwater Pollution Prevention Plan (SWPPP) was not prepared prior to commencement of construction activity. This is in violation Part II.A of the permit. A SWPPP must be prepared and implemented in accordance with Part II.A of the permit, and the plan must follow the order outlined in Part II.A.4-7 of the permit. The SWPPP must be retained at the construction site during normal business hours (8:00 A.M. – 5:00 P.M.). 3. Lack of adequate stormwater controls at the construction site. This is in violation of Part II.A.4.H of the permit. The permittee must select, install, implement, and maintain best management practices (BMPs) at the site that minimize pollutants in the discharge as necessary to meet applicable water quality standards. BMPs were not utilized in the area where a water line vault was constructed. This vault is located west of War Eagle Creek on a hillside immediately south of CR 8500. Appropriate BMPs must be employed to prevent sediment from being discharged from your easement. Rodney Reynolds, Madison County Water Line Installation August 14, 2009 Page 2 The above items require your immediate attention. Please submit a written response to these findings to Cindy Garner, Water Division Enforcement Branch Manager. This response should be mailed to the address listed at the bottom of Page 1 of this letter. This response should contain documentation describing the course of action planned to correct the items noted. This corrective action should be completed as soon as possible, and the written response is due by August 27, 2009. You stated that the water line will be buried across War Eagle Creek. In accordance with the requirements of Arkansas Pollution Control and Ecology Commission Regulation No. 2, you must contact the Department to request a Short Term Activity Authorization to allow for temporary exceedance of the Arkansas Water Quality Standards during the installation of the water line across War Eagle Creek and other stream crossings associated with the construction of the water line. Be aware that authorization must be granted prior to any in-stream construction activity. You may contact Bob Singleton in the Water Quality Planning Branch at 501-682-0645 for assistance with these requirements. For additional information you may contact the Enforcement Branch by telephone at 501-682-0639 or by fax at 501-682-0910. If I can be of any assistance, please contact me at 479-267-0811, ext. 16. Sincerely, John Fazio District 1 Field Inspector Water Division cc: Water Division Enforcement Branch Water Division Permits Branch NPDES Report Page 2 ADEQ Water NPDES Inspection AFIN: N/A Permit #: ARR150000 Form Approved OMB No. 2040-0003 UNITED STATES ENVIRONMENTAL PROTECTION AGENCY Washington, D.C. 20460 NPDES Compliance Inspection Report Section A: National Data System Coding Transaction Code NPDES Yr/Mo/Day Inspec. Type Inspector Fac. Type 1 N 2 5 3 A R R 1 5 0 0 0 0 11 12 0 9 0 8 1 3 17 18 W 19 S 20 2 Remarks Inspection Work Days Facility Evaluation Rating BI QA -------------------------------Reserved------------------------------ 67 69 70 N 71 N 72 N 73 74 75 80 Section B: Facility Data Name and Location of Facility Inspected (For industrial users discharging to POTW, also Entry Time/Date Permit Effective Date include POTW name and NPDES permit number) 1315 / 08-13-09 N/A Madison County Water Line Installation From CR 8500 west of War Eagle Creek eastward to Withrow Springs State Park Madison County, Arkansas Exit Time/Date Permit Expiration Date 1425 / 08-13-09 10/31/11 Name(s) of On-Site Representative(s)/Title(s)/Phone and Fax Number(s) Other Facility Data No-one present Name, Address of Responsible Official/Title/Phone and Fax Number Rodney Reynolds, Manager Contacted Madison County Water Facilities Board P.O. Box 606 Huntsville, Arkansas 72740 Yes; No 479-738-2214 Section C: Areas Evaluated During Inspection (S = Satisfactory, M = Marginal, U = Unsatisfactory, N = Not Evaluated) S Permit N Flow Measurement N Operations & Maintenance N Sampling U Records/Reports N Self-Monitoring Program N Sludge Handling/Disposal N Pollution Prevention M Facility Site Review N Compliance Schedules N Pretreatment N Multimedia N Effluent/Receiving Waters N Laboratory M Storm Water Other: Section D: Summary of Findings/Comments (Attach additional sheets if necessary) The following violations were noted: 1. Notice of Coverage is not posted. 2. SWPPP not prepared prior to commencement of construction activity. 3. Lack of adequate stormwater controls in an area of soil disturbance. At the time of the inspection, construction activity appeared to be limited to the area of vault construction west of War Eagle Creek along CR 8500. Mr. Reynolds stated that his engineer was preparing a SWPPP and would request the STAA. Name(s) and Signature(s) of Inspector(s) Agency/Office/Telephone/Fax Date AR Dept. of Environmental Quality-Fayetteville 08/14/09 479-267-0811, ext. 16 / 479-267-0819 John Fazio Signature of Reviewer Agency/Office/Phone and Fax Numbers Date NPDES Report Page 3 ADEQ Water NPDES Inspection AFIN: N/A Permit #: ARR150000 SECTION I: SITE POSTING AND SITE INFORMATION SITE NAME: Madison County Water Line Installation TOTAL ACREAGE: ~6 ACREAGE DISTURBED: <5 LATITUDE: LONGITUDE: STARTING DATE: July 2009 A. Is site posted with Notice of Coverage? (Part II, A.2.D) Y ;N NA NE B. Is posting at construction entrance and visible to the public? (Part II, A.2.D) Y N ;NA NE C. If project is linear, is posting at area actively under construction? (Part I,B.8.C) (Linear Project) Y ;N NA NE D. If project is part of larger common plan of development, what is development name and permit number? Development Name: N/A Development Permit No: SECTION II: STORMWATER POLLUTION PREVENTION PLAN EVALUATION AND IMPLEMENTATION A. Is the SWPPP being maintained on site from 08:00 am to 5:00 pm? (Part II,A.2.A) Y ;N NA NE B. Is the SWPPP properly signed as required by Part II, B.1.B of the permit? Y N ;NA NE C. Is the SWPPP being updated as required by Part II, A.3 of the permit? Y N ;NA NE D. Site map in SWPPP (Part II,A.4.G) Y N ;NA NE 1) Direction of stormwater flow (i.e., use arrows to show which direction stormwater will flow) and Y N ;NA NE approximate slopes anticipated after major grading activities (Part II,A.4.G.1); 2) Delineate on the site map areas of soil disturbance and areas that will not be disturbed under the coverage of this Y N ;NA NE permit (Part II,A.4.G.2) 3) Location of major structural and nonstructural controls identified in the plan (Part II,A.4.G.3) Y N ;NA NE 4) Location of main construction entrance and exit (Part II,A.4.G.4) Y N ;NA NE 5) Location where stabilization practices are expected to occur (Part II,A.4.G.5) Y N ;NA NE 6) Locations of off-site materials, waste, borrow area, or equipment storage area (Part II,A.4.G.6) Y N ;NA NE 7) Location of areas used for concrete wash-out (Part II,A.4.G.7) Y N ;NA NE 8) Location of all surface water bodies (including wetlands) (Part II,A.4.G.8) Y N ;NA NE 9) Locations where stormwater is discharged to a surface water and/or municipal separate storm Y N ;NA NE sewer system if applicable (Part II,A.4.G.9) 10) Locations where stormwater is discharged off-site (should be continuously updated) (Part Y N ;NA NE II,A.4.G.10) 11) Areas where final stabilization has been accomplished and no further construction phase Y N ;NA NE permit requirements apply(Part II,A.4.G.11) E. Stormwater Controls (no controls implemented at time of the inspection) 1) Are all controls installed as described in the SWPPP? (Part II,A.4.H) Y N ;NA NE 2) Silt fences properly installed and maintained? (Part II,B.17.A) Y N ;NA NE 3) Check dams and velocity dissipation devices properly installed and maintained? (Part II,B.17.A) Y N ;NA NE 4) Sedimentation basins and sediment traps properly installed and maintained (sediment removed Y N ;NA NE when 50% capacity)? (Part II,B.17.A) and (Part II,A.4.N) 5) Has sediment that has been transported offsite been removed? (Part II,A.4.H.1.d) Y N ;NA NE 6) Is construction site entrance sufficiently stabilized to prevent off site tracking? (Part II,A.4.I.2) Y N ;NA NE 7) Are stabilization methods described in SWPPP being implemented in a timely manner? (Part Y N ;NA NE II,A.4.H.2) NPDES Report Page 4 ADEQ Water NPDES Inspection AFIN: N/A Permit #: ARR150000 F.