Sodium periodate sc-203399 Material Safety Data Sheet Hazard Alert Code EXTREME HIGH MODERATE LOW Key: Section 1 - CHEMICAL PRODUCT AND COMPANY IDENTIFICATION PRODUCT NAME Sodium periodate STATEMENT OF HAZARDOUS NATURE CONSIDERED A HAZARDOUS SUBSTANCE ACCORDING TO OSHA 29 CFR 1910.1200. NFPA FLAMMABILITY0 HEALTH2 HAZARD INSTABILITY3 OX SUPPLIER Company: Santa Cruz Biotechnology, Inc. Address: 2145 Delaware Ave Santa Cruz, CA 95060 Telephone: 800.457.3801 or 831.457.3800 Emergency Tel: CHEMWATCH: From within the US and Canada: 877-715-9305 Emergency Tel: From outside the US and Canada: +800 2436 2255 (1-800-CHEMCALL) or call +613 9573 3112 PRODUCT USE Used as source of periodic acid, analytical reagent, oxidising agent. SYNONYMS Na-I-O4, "sodium metaperiodate", "periodic acid, sodium salt", "Merck 10259" Section 2 - HAZARDS IDENTIFICATION CANADIAN WHMIS SYMBOLS EMERGENCY OVERVIEW RISK Contact with combustible material may cause fire. Harmful by inhalation, in contact with skin and if swallowed. Irritating to eyes, respiratory system and skin. POTENTIAL HEALTH EFFECTS ACUTE HEALTH EFFECTS SWALLOWED ■ Accidental ingestion of the material may be harmful; animal experiments indicate that ingestion of less than 150 gram may be fatal or may produce serious damage to the health of the individual. ■ Animal studies suggest iodates cause kidney damage and may cause blood cell damage. Large doses produce vomiting. EYE ■ This material can cause eye irritation and damage in some persons. SKIN ■ Skin contact with the material may be harmful; systemic effects may resultfollowing absorption. ■ This material can cause inflammation of the skin oncontact in some persons. ■ The material may accentuate any pre-existing dermatitis condition. ■ Open cuts, abraded or irritated skin should not be exposed to this material. ■ Entry into the blood-stream, through, for example, cuts, abrasions or lesions, may produce systemic injury with harmful effects. Examine the skin prior to the use of the material and ensure that any external damage is suitably protected. INHALED ■ Inhalation of dusts, generated by the material, during the course of normalhandling, may be harmful. ■ The material can cause respiratory irritation in some persons. The body's response to such irritation can cause further lung damage. ■ Persons with impaired respiratory function, airway diseases and conditions such as emphysema or chronic bronchitis, may incur further disability if excessive concentrations of particulate are inhaled. CHRONIC HEALTH EFFECTS ■ Long-term exposure to respiratory irritants may result in disease of the airways involving difficult breathing and related systemic problems. Limited evidence suggests that repeated or long-term occupational exposure may produce cumulative health effects involving organs or biochemical systems. There is limited evidence that, skin contact with this product is more likely to cause a sensitization reaction in some persons compared to the general population. Based on experience with animal studies, there is a possibility that exposure to the material may result in toxic effects to the development of the fetus, at levels which do not cause significant toxic effects to the mother. Long term exposure to high dust concentrations may cause changes in lung function i.e. pneumoconiosis; caused by particles less than 0.5 micron penetrating and remaining in the lung. Prime symptom is breathlessness; lung shadows show on X-ray. Iodine and iodides, may give rise to local allergic reactions such as hives, rupture of skin blood vessels, pain in joints or diseases of the lymph nodes. Iodine and iodides cause goiter and diminished as well as increased activity of the thyroid gland. A toxic syndrome resulting from chronic iodide overdose and from repeated administration of small amounts of iodine is characterized by excessive saliva production, head cold, sneezing, conjunctivitis, headache, fever, laryngitis, inflammation of the bronchi and mouth cavity, inflamed parotid gland, and various skin rashes. Swelling and inflammation of the throat, irritated and swollen eyes and lung swelling may also occur. Swelling of the glottis, necessitating a tracheotomy has been reported. Use of iodides in frequency can cause fetal death, severe goiter, hypothyroidism and the cretinoid appearance of the newborn. Repeated ingestion may cause kidney dysfunction or failure and blood conditions such as haemolysis (destruction of red blood cells). The central nervous system may be affected. Persons with impaired liver or kidney function may be more susceptible to the effects of the substance. [Mallinckrodt] Section 3 - COMPOSITION / INFORMATION ON INGREDIENTS HAZARD RATINGS Min Max Flammability: 0 Toxicity: 2 Body Contact: 2 Min/Nil=0 Low=1 Reactivity: 3 Moderate=2 High=3 Chronic: 2 Extreme=4 NAME CAS RN % sodium periodate 7790-28-5 >98 Section 4 - FIRST AID MEASURES SWALLOWED ■ IF SWALLOWED, REFER FOR MEDICAL ATTENTION, WHERE POSSIBLE, WITHOUT DELAY. Where Medical attention is not immediately available or where the patient is more than 15 minutes from a hospital or unless instructed otherwise: For advice, contact a Poisons Information Center or a doctor. Urgent hospital treatment is likely to be needed. If conscious, give water to drink. INDUCE vomiting with fingers down the back of the throat, ONLY IF CONSCIOUS. Lean patient forward or place on left side (head-down position, if possible) to maintain open airway and prevent aspiration. NOTE: Wear a protective glove when inducing vomiting by mechanical means. In the mean time, qualified first-aid personnel should treat the patient following observation and employing supportive measures as indicated by the patient's condition. If the services of a medical officer or medical doctor are readily available, the patient should be placed in his/her care and a copy of the MSDS should be provided. Further action will be the responsibility of the medical specialist. If medical attention is not available on the worksite or surroundings send the patient to a hospital together with a copy of the MSDS. EYE ■ If this product comes in contact with the eyes: Wash out immediately with fresh running water. Ensure complete irrigation of the eye by keeping eyelids apart and away from eye and moving the eyelids by occasionally lifting the upper and lower lids. If pain persists or recurs seek medical attention. Removal of contact lenses after an eye injury should only be undertaken by skilled personnel. SKIN ■ If skin contact occurs: Immediately remove all contaminated clothing, including footwear Flush skin and hair with running water (and soap if available). Seek medical attention in event of irritation. INHALED ■ If fumes or combustion products are inhaled remove from contaminated area. Lay patient down. Keep warm and rested. Prostheses such as false teeth, which may block airway, should be removed, where possible, prior to initiating first aid procedures. Apply artificial respiration if not breathing, preferably with a demand valve resuscitator, bag-valve mask device, or pocket mask as trained. Perform CPR if necessary. Transport to hospital, or doctor, without delay. NOTES TO PHYSICIAN ■ for poisons (where specific treatment regime is absent): -------------------------------------------------------------- BASIC TREATMENT -------------------------------------------------------------- Establish a patent airway with suction where necessary. Watch for signs of respiratory insufficiency and assist ventilation as necessary. Administer oxygen by non-rebreather mask at 10 to 15 l/min. Monitor and treat, where necessary, for pulmonary edema . Monitor and treat, where necessary, for shock. Anticipate seizures . DO NOT use emetics. Where ingestion is suspected rinse mouth and give up to 200 ml water (5 ml/kg recommended) for dilution where patient is able to swallow, has a strong gag reflex and does not drool. -------------------------------------------------------------- ADVANCED TREATMENT -------------------------------------------------------------- Consider orotracheal or nasotracheal intubation for airway control in unconscious patient or where respiratory arrest has occurred. Positive-pressure ventilation using a bag-valve mask might be of use. Monitor and treat, where necessary, for arrhythmias. Start an IV D5W TKO. If signs of hypovolemia are present use lactated Ringers solution. Fluid overload might create complications. Drug therapy should be considered for pulmonary edema. Hypotension with signs of hypovolemia requires the cautious administration of fluids. Fluid overload might create complications. Treat seizures with diazepam. Proparacaine hydrochloride should be used to assist eye irrigation. BRONSTEIN, A.C. and CURRANCE, P.L. EMERGENCY CARE FOR HAZARDOUS MATERIALS EXPOSURE: 2nd Ed. 1994. Treatment regime for bromates may act as a guide for iodate poisonings. Syrup of ipecac or gastric lavage with tap water or perhaps a 1% solution of sodium thiosulfate Administer a demulcent and an analgesic like meperidine (Demerol). Avoid morphine. If readily available, the prompt use of hemodialysis or peritoneal lavage may serve to remove absorbed but unreacted iodate in significant amounts. Administer oxygen. If methaemoglobinaemia becomes severe a replacement transfusion with whole blood may become necessary. DO NOT attempt to correct methaemoglobinaemia with methylene blue as the dye may enhance the toxicity. Sodium thiosulfate solution (100 to 500 ml of 1%) by intravenous drip has been recommended by some authors. Correct dehydration by