PNNL-18290 Rev 4 Contractor Environment, Safety & Health Manual For Work Conducted At Battelle Pacific Northwest Division Richland, Washington 99352 November 2012 Contractor Environment, Safety & Health Manual For Work Conducted At Battelle Pacific Northwest Division Richland, Washington 99352 June 2011 Acronyms and Abbreviations ACGIH American Conference of Governmental Industrial Hygienists ALARA As Low as Reasonably Achievable ANSI American National Standards Institute CFR Code of Federal Regulations BCR Battelle Contract Representative CM Construction Manager CPR Cardiopulmonary Resuscitation CSHP Construction Safety and Health Plan dBA Decibels DOE U.S. Department of Energy ECT Equivalent Chill Temperature EU Electrical Utilities EWP Electrical Work Permit GFCI Ground Fault Circuit Interrupters HAZCOM Hazard Communication HGET Hanford General Employee Training IARC International Agency for Research on Cancer IDLH Immediately Dangerous to Life and Health IH Industrial Hygiene ISM Integrated Safety Management JSA Job Safety Analysis MSDS Material Safety Data Sheet NEC National Electric Code NFPA National Fire Protection Association NRR Noise Reduction Rating NTP National Toxicology Program OSHA Occupational Safety and Health Administration PEL Permissible Exposure Limit PNWD Pacific Northwest Division PPE Personal Protective Equipment TLV Threshold Limit Value TWA Time-weighted-average UNP Unbound Engineered Nanoparticle WAC Washington Administrative Code WBGT Wet Bulb Globe Temperatures WISHA Washington Industrial Safety and Health Act iii Contents Acronyms and Abbreviations ...................................................................................................................... iii 1.0 Introduction ...................................................................................................................................... 1.1 1.1 Integrated Safety Management System .................................................................................. 1.1 2.0 Program Policy ................................................................................................................................. 2.1 2.1 Purpose ................................................................................................................................... 2.1 2.2 Definitions .............................................................................................................................. 2.1 2.3 Requirements .......................................................................................................................... 2.1 2.3.1 Responsibility ............................................................................................................ 2.1 2.3.2 Contractor/Subcontractor Responsibilities ................................................................ 2.2 2.3.3 General Requirements ............................................................................................... 2.3 2.3.4 Safety Requirements.................................................................................................. 2.4 2.3.5 Safety Rights ............................................................................................................. 2.4 2.3.6 Safety Responsibilities .............................................................................................. 2.5 2.3.7 Safety Bulletin Boards............................................................................................... 2.6 2.3.8 Adverse Weather Conditions..................................................................................... 2.6 2.4 References .............................................................................................................................. 2.7 2.5 Records ................................................................................................................................... 2.7 2.6 Forms ...................................................................................................................................... 2.7 2.7 Exhibits ................................................................................................................................... 2.7 3.0 Environmental Protection Plan......................................................................................................... 3.1 3.1 Purpose ................................................................................................................................... 3.1 3.2 Definitions .............................................................................................................................. 3.1 3.3 Requirements .......................................................................................................................... 3.1 3.3.1 Cultural and Biological Resource Protection ............................................................ 3.2 3.3.2 Excavation ................................................................................................................. 3.2 3.3.3 Erosion Control ......................................................................................................... 3.2 3.3.4 Dust Control .............................................................................................................. 3.3 3.3.5 Hazardous Material Storage ...................................................................................... 3.3 3.3.6 Waste Accumulation and Inspection ......................................................................... 3.3 3.3.7 Waste Disposal .......................................................................................................... 3.5 3.3.8 Spill Control .............................................................................................................. 3.5 3.3.9 Liquid Effluent Management .................................................................................... 3.5 3.3.10 Waste Minimization and Pollution Prevention (P2) Program ................................... 3.6 3.3.11 Equipment and Waste Transportation ....................................................................... 3.7 v 3.3.12 Miscellaneous Wastes ............................................................................................... 3.7 3.4 References .............................................................................................................................. 3.9 3.5 Records ................................................................................................................................. 3.10 3.6 Forms .................................................................................................................................... 3.10 4.0 Occupational Medicine .................................................................................................................... 4.1 4.1 Purpose ................................................................................................................................... 4.1 4.2 Definitions .............................................................................................................................. 4.1 4.3 Requirements .......................................................................................................................... 4.1 4.3.1 General Requirements ............................................................................................... 4.1 4.3.2 Contractor Requirements ........................................................................................... 4.2 4.4 References .............................................................................................................................. 4.2 4.5 Records ................................................................................................................................... 4.2 4.6 Forms ...................................................................................................................................... 4.2 4.7 Exhibits ................................................................................................................................... 4.2 5.0 Industrial Hygiene ............................................................................................................................ 5.1 5.1 Purpose ................................................................................................................................... 5.1 5.2 Responsibility ......................................................................................................................... 5.1 5.3 General Requirements ............................................................................................................ 5.2 5.4 Procedures .............................................................................................................................. 5.3 5.4.1 Hearing Conservation/Hearing Protection ................................................................ 5.3 5.4.2 Lead Program ............................................................................................................ 5.4 5.4.3 Asbestos Program ...................................................................................................... 5.5 5.4.4 Carcinogen Control ................................................................................................... 5.5 5.5 Sanitation ................................................................................................................................ 5.6 5.6 Temperature Extremes ..........................................................................................................