Nokia 105s Gateway Installation Guide Part No. N450000309 Rev 001 Published August 2006 COPYRIGHT ©2006 Nokia. All rights reserved. Rights reserved under the copyright laws of the United States. RESTRICTED RIGHTS LEGEND Use, duplication, or disclosure by the United States Government is subject to restrictions as set forth in subparagraph (c)(1)(ii) of the Rights in Technical Data and Computer Software clause at DFARS 252.227-7013. Notwithstanding any other license agreement that may pertain to, or accompany the delivery of, this computer software, the rights of the United States Government regarding its use, reproduction, and disclosure are as set forth in the Commercial Computer Software-Restricted Rights clause at FAR 52.227-19. IMPORTANT NOTE TO USERS This software and hardware is provided by Nokia Inc. as is and any express or implied warranties, including, but not limited to, implied warranties of merchantability and fitness for a particular purpose are disclaimed. In no event shall Nokia, or its affiliates, subsidiaries or suppliers be liable for any direct, indirect, incidental, special, exemplary, or consequential damages (including, but not limited to, procurement of substitute goods or services; loss of use, data, or profits; or business interruption) however caused and on any theory of liability, whether in contract, strict liability, or tort (including negligence or otherwise) arising in any way out of the use of this software, even if advised of the possibility of such damage. Nokia reserves the right to make changes without further notice to any products herein. TRADEMARKS Nokia is a registered trademark of Nokia Corporation. Other products mentioned in this document are trademarks or registered trademarks of their respective holders. 060101 2 Nokia 105s Gateway Installation Guide Nokia Contact Information Corporate Headquarters Web Site http://www.nokia.com Telephone 1-888-477-4566 or 1-650-625-2000 Fax 1-650-691-2170 Mail Nokia Inc. Address 313 Fairchild Drive Mountain View, California 94043-2215 USA Regional Contact Information Americas Nokia Inc. Tel: 1-877-997-9199 313 Fairchild Drive Outside USA and Canada: +1 512-437-7089 Mountain View, CA 94043-2215 email: [email protected] USA Europe, Nokia House, Summit Avenue Tel: UK: +44 161 601 8908 Middle East, Southwood, Farnborough Tel: France: +33 170 708 166 and Africa Hampshire GU14 ONG UK email: [email protected] Asia-Pacific 438B Alexandra Road Tel: +65 6588 3364 #07-00 Alexandra Technopark email: [email protected] Singapore 119968 Nokia Customer Support Web Site: https://support.nokia.com/ Email: [email protected] Americas Europe Voice: 1-888-361-5030 or Voice: +44 (0) 125-286-8900 1-613-271-6721 Fax: 1-613-271-8782 Fax: +44 (0) 125-286-5666 Asia-Pacific Voice: +65-67232999 Fax: +65-67232897 050602 Nokia 105s Gateway Installation Guide 3 4 Nokia 105s Gateway Installation Guide Contents About this Guide . .13 In this Guide . 13 Conventions this Guide Uses . 14 Notices . 14 Command-Line Conventions. 15 Text Conventions . 16 Related Documentation . 17 1 Overview . 19 About the Nokia 105s Gateway . 19 Built-In Gigabit Ethernet Ports. 21 PMC Expansion Slots . 22 System Status LEDs . 23 Managing the 105s Gateway . 24 Site Requirements, Warnings, and Cautions . 24 Software Requirements . 26 Product Disposal . 26 2 Installing the Nokia 105s Gateway . 29 Before You Begin . 29 Rack Mounting the Gateway . 30 Connecting Power . 31 Connecting to the Console or Auxiliary Port. 32 Console Port . 35 Auxiliary Port . 36 Connecting to Network Interfaces . 37 Nokia 105s Gateway Installation Guide 5 3 Performing the Initial Configuration . 39 Using a Console Connection . 40 Using Nokia Network Voyager . 43 Viewing Nokia IPSO Documentation by Using Nokia Network Voyager . 44 Using the Command-Line Interface . 45 4 Installing and Replacing Network Interface Cards . 49 Deactivating Configured Interfaces . 50 Removing, Installing, and Replacing NICs. 50 Before You Start . 51 Configuring and Activating Interfaces . 57 Monitoring Network Interface Cards. 57 5 Connecting PMC Network Interface Cards . 59 Four-Port 10/100 Mbps Ethernet NICs. 59 Ethernet NIC Features . 60 Ethernet NIC Connectors and Cables. 61 Two-Port Copper Gigabit Ethernet Network Interface Card. 63 Copper Gigabit Ethernet NIC Features . 63 Copper Gigabit Ethernet Connectors and Cables. 64 Two-Port Fiber-Optic Gigabit Ethernet Network Interface Card. 66 Fiber-Optic Gigabit Ethernet NIC Features . 66 Fiber-Optic Gigabit Ethernet Connectors and Cables. 67 6 Installing and Replacing Other Components . 69 Installing or Replacing a Hard-Disk Drive . 70 Before You Start . 71 Replacing or Upgrading Memory . 76 Before You Start . 77 Replacing the Battery. 82 6 Nokia 105s Gateway Installation Guide 7 Troubleshooting . 87 General Troubleshooting Information. 87 Troubleshooting Routing Problems . 97 A Technical Specifications . 103 Physical Dimensions . 103 Space Requirements . 103 Operating Temperature . 104 NIC Interfaces . 104 B Compliance Information . 105 Declaration of Conformity. 105 Compliance Statements . 107 FCC Notice (US) . 108 Index . 109 Nokia 105s Gateway Installation Guide 7 8 Nokia 105s Gateway Installation Guide Tables Table 1 Command-Line Conventions . 15 Table 2 Text Conventions . 16 Table 3 Specifications for the 105s Gateway . 20 Table 4 PMC Network Interface Card Slots . 22 Table 5 System Status LEDs . 23 Table 6 Pin Assignments Console Connector and Cable . 36 Table 7 Pin Assignments for AUX Connector and Modem Cable 37 Nokia 105s Gateway Installation Guide 9 10 Nokia 105s Gateway Installation Guide Figures Figure 1 Component Locations Front View . 20 Figure 2 Component Locations Rear View . 21 Figure 3 Built-In Gigabit Ethernet Ports Details . 21 Figure 4 Gateway Status LEDs . 23 Figure 5 Mounting Screws Location . 30 Figure 6 Adjustable Mounting Brackets . 31 Figure 7 Back Panel Power Switch and Socket . 32 Figure 8 Nokia Network Voyager Reference Access Points . 45 Figure 9 Four-Port Ethernet NIC Front Panel Details . 60 Figure 10 Output Connector for the Ethernet Cable . 62 Figure 11 Ethernet Crossover-Cable Pin Connections . 62 Figure 12 Gigabit Ethernet Crossover Cable Pin Connections . 63 Figure 13 Two-Port Copper Gigabit Ethernet NIC . 64 Figure 14 Copper Gigabit Ethernet Cable Connector Output Pin Assignments . 65 Figure 15 Gigabit Ethernet Crossover Cable Pin Connections . 65 Figure 16 Two-Port Fiber-Optic Gigabit Ethernet NIC . 67 Figure 17 Hard-Disk Drive Location . 70 Figure 18 DIMM Socket Locations . 77 Nokia 105s Gateway Installation Guide 11 12 Nokia 105s Gateway Installation Guide About this Guide This guide describes how to install and use Nokia 105s gateways. Installation and maintenance should be performed by experienced technicians or Nokia- approved service providers only. This preface provides the following information: In this Guide Conventions this Guide Uses Related Documentation In this Guide This guide is organized into the following chapters and appendixes: Chapter 1, “Overview” presents a general overview of the 105s gateway. Chapter 2, “Installing the Nokia 105s Gateway” describes how to rack-mount the gateway and how to physically connect it to a network and power. Chapter 3, “Performing the Initial Configuration” describes how to make the gateway available on the network. Chapter 4, “Installing and Replacing Network Interface Cards” describes how to install, monitor, and replace network interface cards (NICs). Chapter 5, “Connecting PMC Network Interface Cards” describes how to connect to and use each of the supported NICs. Nokia 105s Gateway Installation Guide 13 Chapter 6, “Installing and Replacing Other Components” describes how to install or replace RAM memory and hard-disk drives. Chapter 7, “Troubleshooting” describes problems you might encounter and proposes solutions to these problems. Appendix A, “Technical Specifications” provides technical specifications such as interface characteristics. Appendix B, “Compliance Information” provides compliance and regulatory information. Conventions this Guide Uses The following sections describe the conventions this guide uses, including notices, text conventions, and command-line conventions. Notices Warning Warnings advise the user that bodily injury might occur because of a physical hazard. Caution Cautions indicate potential equipment damage, equipment malfunction, loss of performance, loss of data, or interruption of service. Note Notes provide information of special interest or recommendations. 14 Nokia 105s Gateway Installation Guide Conventions this Guide Uses Command-Line Conventions You might encounter one or more of the following elements on a command- line path. Table 1 Command-Line Conventions Convention Description command This required element is usually the product name or other short word that invokes the product or calls the compiler or preprocessor script for a compiled Nokia product. It might appear alone or precede one or more options. You must spell a command exactly as shown and use lowercase letters. Italics Indicates a variable in a command that you must supply. For example: delete interface if_name Supply an interface name in place of the variable. For example: delete interface nic1 angle brackets < > Indicates arguments for which you must supply a value: retry-limit <1–100> Supply a value. For example: retry-limit 60 Square brackets [ ] Indicates optional arguments. delete [slot slot_num] For example: delete slot 3 Nokia 105s Gateway Installation Guide 15 Table 1 Command-Line Conventions Convention Description -flag A flag is usually an abbreviation for a function, menu, or option name, or for a compiler or preprocessor argument. You must enter a flag.