KILLEEN INDEPENDENT SCHOOL DISTRICT Facility Design and Construction Standards VERSION 1.3OCTOBER 11, 2018, REVISED 06/07/2021 Killeen Independent School District Facilities Services 200 North W.S. Young Drive Killeen, Texas 76540-0967 Phone 254.336.0074 • Fax 254.519.5601 Killeen Independent School District Facility Design & Construction Standards 2 VERSION 1.3OCTOBER 11, 2018, REVISED 06/07/2021 Table of Contents Note: Divisions 34-50 of the CSI Master Format are omitted from this document, as they do not relate to the design or specifications for Educational Facility Design and Construction. CSI MasterFormat Section No. Title 00 10 00 Introduction 00 20 00 Purpose and Principals 00 21 00 KISD Front End Documents 00 30 00 Design Principals 00 40 00 Design Team Requirements 00 50 00 Life Cycle Schedule 01 05 00 General Requirements 01 91 00 Commissioning 02 41 00 Demolition 03 30 00 Cast-in-place Concrete 03 52 00 Lightweight Insulating Concrete Deck System 04 20 00 Unit Masonry 05 00 00 Metal Fabrications 06 10 00 Rough Carpentry 06 22 00 Finish Carpentry and Millwork 07 30 00 Steep-Sloped Metal Roofing System 07 40 00 Roofing and Siding Panels 07 52 00 Low Sloped Roofing Systems 07 62 00 Sheet Metal Flashing and Trim 07 81 10 Sprayed Fireproofing 08 05 00 Common Work Results for Doors 08 14 16 Flush Wood Doors 08 33 00 Overhead Coiling Doors 08 41 00 Entrances and Storefronts 08 45 00 Translucent Roof and Wall Assemblies 08 71 00 Finish Hardware 08 80 00 Glazing 09 00 00 General Finish Requirements 09 21 00 Gypsum Board Assemblies 09 25 00 Gypsum Board 09 30 00 Tiling 09 51 00 Acoustical Ceiling Panels 09 60 00 General Flooring Requirements 09 64 29 Stage Flooring 09 64 66 Wood Athletic Flooring 09 65 00 Resilient Flooring 09 65 19 Resilient Tile Flooring 09 68 00 Carpeting 09 90 00 Painting 10 00 00 Specialties - General Killeen Independent School District Facility Design & Construction Standards 3 VERSION 1.3OCTOBER 11, 2018, REVISED 06/07/2021 10 11 00 Visual Display Surfaces 10 14 00 Signage 10 21 13 Toilet Partitions 10 26 00 Wall Protection (Wall Guards) 10 28 13 Toilet Accessories 10 40 00 Electronic Marquee Signs 10 43 00 Emergency Eyewash and Safety Showers 10 44 13 Fire Extinguisher Cabinets 10 75 00 Flagpoles 11 23 36 Commercial Appliances 11 40 00 Food Service Equipment 11 61 43 Stage Curtains 11 68 00 Outdoor Athletic Equipment 11 68 43 Scoreboards 11 68 13 Playground Equipment 12 30 00 Educational Casework 12 35 00 Laboratory Casework 13 47 00 Cathodic Protection 13 91 00 Laboratory Safety Device System 14 42 00 Elevators 22 05 00 Common Work Results for Plumbing 22 10 00 Plumbing Piping and Pumps 22 15 00 General Service Compressed Air Systems 22 30 00 Plumbing Equipment 22 40 00 Plumbing Fixtures 22 66 00 Chemical-Waste Systems 23 05 00 Common Work Results for HVAC 23 05 13 Motors and Motor Controllers 23 05 48 Sound and Vibration Control 23 07 13 Duct Insulation 23 07 16 HVAC Equipment Insulation 23 07 19 HVAC Piping Insulation 23 09 00 Instrumentation and Control for HVAC 23 10 00 Facility Fuel Systems 23 21 00 Hydronic Piping and Pumps 23 23 00 Refrigerant Piping 23 23 16 Refrigerant Specialties 23 25 00 HVAC Water Treatment 23 31 00 HVAC Ducts and Casings 23 34 23 Power Ventilators 23 34 33 Air Curtains 23 36 00 Air Terminal Units 23 37 00 Air Outlets and Inlets (Air Distribution Devices) 23 40 00 HVAC Air Cleaning Devices 23 51 00 Breechings, Chimneys, and Stacks 23 52 00 Boilers 23 54 00 Furnaces 23 55 00 Fuel Fired Heaters Killeen Independent School District Facility Design & Construction Standards 4 VERSION 1.3OCTOBER 11, 2018, REVISED 06/07/2021 23 57 00 Heat Exchangers for HVAC 23 63 00 Refrigerant Condensers 23 64 00 Packaged Water Chillers 23 65 00 Cooling Towers 23 65 33 Liquid Coolers 23 70 00 Central HVAC Equipment 23 72 00 Energy Recovery Equipment 23 81 00 Decentralized Unitary HVAC Equipment 23 82 00 Heating and Cooling Units 23 82 16 Air Coils 26 05 00 Common Work Results for Electrical 26 05 26 Grounding Bonding for Electrical Systems 26 05 33 Raceway and Boxes for Electrical Systems 26 22 00 Low-Voltage Transformers 26 24 13 Switchboards 26 24 16 Panelboards 26 24 19 Motor Control Centers 26 25 00 Bus Duct Assemblies 26 27 13 Electricity Metering 26 27 16 Cabinets and Enclosures 26 27 26 Wiring Devices 26 28 16 Enclosed Switches and Circuit Breakers 26 29 16 Enclosed Controllers (Contactors) 26 32 33 Uninterruptible Power Supply Systems 26 35 33 Power Factor Correction Equipment 26 41 00 Facility Lightning Protection 26 43 00 Transient Voltage Surge Suppression 26 50 00 Lighting 26 60 00 Electrical Training and Final Electrical Equip Labeling 27 05 00 Technology Materials and Methods 27 11 00 Telecommunication Room Requirements 27 13 00 Communication Support Systems 27 30 00 Two-Way Radio System 27 50 00 Local Sound Reinforcing System 27 51 00 Intercom System 28 05 00 Security Materials and Methods 28 13 00 Access Control 28 16 00 Intrusion Detection Systems 28 21 00 Security Camera Systems 28 46 00 Fire Detection and Alarm 32 12 16 Asphalt Paving 32 13 13 Concrete Paving 32 16 13 Curbs, Gutters, Sidewalks, and Driveways 32 18 16 Playground Surfacing 32 31 13 Chain Link Fences and Gates 32 80 00 Irrigation 32 90 00 Planting 33 40 00 Storm Drainage Utilities Killeen Independent School District Facility Design & Construction Standards 5 VERSION 1.3OCTOBER 11, 2018, REVISED 06/07/2021 Preface This purpose of the Facilities Design and Construction Standards (FDCS) is to establish and sustain consistent representation of requirements and standards for all members of the KISD Administration, Faculty, Design Team, Architects, Engineers, and Contractors. It presents design guidelines and criteria for the planning, design and technical development for repurposing, renovating, or constructing new schools. The FDCS includes references to the Texas Education Code, Texas Administrative Code and Texas Education Agency. Killeen Independent School District Facility Design & Construction Standards 6 VERSION 1.3OCTOBER 11, 2018, REVISED 06/07/2021 00 10 00 - Introduction The purpose of this section is to communicate KISD’s Design and Construction Standards to the consultants who design facilities for the district. If any standard differs from the consultants’ professional opinion or experience as to the proper materials, components, or equipment for the project under contract by the consultant, the consultant is requested to communicate that concern through the KISD Project Manager in writing at the earliest possible phase of the project for review. Nevertheless, no provision herein shall alter the contractual or fiduciary responsibility of the consultant or of Killeen Independent School District, as executed in the Owner-Consultant Agreement. Neither shall the absence of a particular instruction or detail relieve the consultant of the responsibility to deliver a comprehensive professional service or final product in accordance with the most current Building Codes. KISD encourages innovative quality design of the architectural and engineering components of the work, but the following standards listed are not optional. The A/E may propose other materials and systems for KISD consideration and written approval. KISD encourages and supports sustainable architectural design. Minimal maintenance requirements, long life cycle, and flexible designs are paramount to the design of buildings that will last for the next 50 years. During the pre-design and design stages, discuss with the district possible options for meeting U.S. Green Building Council’s “LEED” criteria in every facet, and address recycling of waste materials and use of recycled and regionally manufactured products. Killeen Independent School District Facility Design & Construction Standards 7 VERSION 1.3OCTOBER 11, 2018, REVISED 06/07/2021 00 20 00 – Purpose and Principals A. PURPOSE 1. The Killeen Independent School District is committed to creating high-quality educational environments – places that provide well-planned, high-performing, healthy school environments that foster student achievement and well-being, as well as being centers of community. 2. The “Facilities Design and Construction Standards” establishes and ensures consistent representation of requirements and quality standards for those environments to all members of the Design Teams for KISD facilities. It is based on the current curricula, teaching methodologies, student groupings, structural functionality, intended use requirements, and site constraints of the District. 3. Architects and engineers shall follow the requirements and standards presented here for the planning and design of renovations, modernization, reconstruction, and new school construction. The intent of the FDCS is to serve as a foundation for all phases from concept to occupation. If a design professional feels that varying from specific requirements, while still meeting the intended design requirement, is desirable for a specific project, it may be possible to incorporate the variations into the design with written approval from KISD. 4. The FDCS incorporates and complements the policies, requirements, and standards of other KISD documents that direct the design of school facilities. Visit the Board Policy Standards webpage for the most current versions of existing standards, as well as the update bulletins. B. ORGANIZATION OF DESIGN REQUIREMENTS 1. The content of the “Facilities Design and Construction Standards Manual” is divided into four Parts: a. Part 1 – general items, purpose and principles b. Part 2 – functional and relational planning and design criteria; including general environmental and sustainability issues; and c. Part 3 – detailed information on material choices, system design criteria, requirements, by Specifications Divisions on each major technical discipline.