A 16th century Iron Breech-Loading Swivel-Gun Michael Stroud Early in May 2000, the Mediterranean gave up the basic difference between the terms, Muzzle­ another of its jealously kept treasures. While loading and Breech-loading guns. To start with, pleasure diving off Malta's southern coast, the terms muzzle and breech refer to specific Michael Spiteri, a technical staff member of parts of the barrel of a gun, the muzzle being the Museums Department Archaeology Section its forward or front end, while the breech is the discovered a rare and unusual gun. Lying there rear or back end. on the seabed was a sixteenth century, breech­ During its long period of use, the particular loading swivel-gun. Seafarers of various nations type of swivel gun we are dealing with would used small swivel-guns of this type extensively normally be classed in a category on its own on ships, for many centuries. However, not that (Figure 1). The general term for this gun in many have survived and at the time it was found, Spanish speaking countries was 'Falcion this was the first officially recorded discovery Pedrero' or simply 'Pedrero'. In Italian it would in Maltese waters of an early, breech-loading be 'Peterara', or, as it was also known 'Pezza gun. Certainly not as sensational as the Riace di Braga'. 'Perrier' would be the French Bronzes, this fascinating relic is nonetheless of term, with 'Sling' or 'Murtherer' in English. considerable importance even by international In other words a 'Stone-firing Gun'. This was standards. (Plate 1) to identify it from another category of swivel Before examining this intriguing gun too guns, which were not breech-loaders. Recent closely to establish its approximate date of English publications refer to this type of gun manufacture or possible provenance, it would as a 'Breech-loading Petarara', or simply as a be easier to proceed by first placing it in its 'Breech-loading Swivel Gun'. Figure 1: Breech­ right perspective as a particular gun-type in the After consultation with the Conservation Loading Iron Swivel overall evolution and development of firearms. Department of the Royal Armouries, in Leeds, gun - European, first half of 16th In this regard, it would certainly be useful to the delicate task of carefully removing marine century those unfamiliar with firearms, to understand concretions that encased the gun was undertaken. (Plate 2) Pending a more complete conservation programme, a purpose-built holding tank at the Maritime Museum ensured the gun's stable condition. A preliminary examination revealed that this swivel gun is of wrought iron, i.e. hammered, built-up construction and its early style suggests mid-sixteenth century \---;;:_ .. r:·J ~~·._~ '-~~~ .:.....:-~ manufacture. However, old styles died hard and more precise scientific dating is required. The gun is around 1.840 mm. long overall. The UQ barrel section is approximately 1.110 mm. long, 22 Malta Archaeological Review • Issue 6 2002/2003 with a bore of 40 mm. (Plate 3) The gun is of submerged in the sea for some four hundred quite plain form with a slender, round barrel years. This resulted in extensive corrosion tapering slightly towards the muzzle end where in varying degrees over the entire surface. it flares out in a rather unusual, archaic style Unfortunately, certain areas are affected by muzzle-reinforce. Unlike the rounded muzzle more noticeable metal loss. However, it has mouldings normally encountered on swivel nonetheless survived remarkably well overall, guns, this muzzle-reinforce is octagonally and appears to be reasonably sound structurally. faceted in the style typical of early fifteenth The more serious, immediately visible damage century artillery or the muzzles of primitive is at the forward section of the barrel where the arquebuses and muskets. corrosion has caused a fairly large hole in the The barrel's breech end shows traces of barrel wall. Further investigation will determine what could have been simple, crude mouldings the full extent of the damage. where the barrel-breech widens to meet the The evolution of the breech-loader in the powder chamber trough. The trunnions, i.e. history of firearms is certainly intriguing. the cylindrical pivots projecting from the side, The earliest guns appear to have been mainly are constructed as one with the barrel, simply muzzle-loaders, i.e. loaded from the front. protruding from the barrel wall, 865 mm. from Putting a charge of powder down the bore from the muzzle. The sturdy iron swivel, supporting the muzzle, followed by a wad, then inserting the gun at the trunnions, and which gives this the shot and following this by another wad, particular type of gun its name, is still in place. and ramming each element home was certainly (Plate 4) time-consuming business. After firing, muzzle­ The powder chamber holder or trough, loading guns had to be withdrawn each time which extends rearwards from the barrel breech, from their position in the loophole or gun-port, is here constructed as an integral part of the then they were mopped out, re-loaded and gun. This trough is roughly rectangular in plan, re-positioned. Gunners in action usually had approximately 260 mm. long by 170 mm. wide, to reload while standing exposed to enemy widening slightly towards the rear. The inner fire. Meanwhile, the enemy had ample time to front part of the chamber trough is tapered at reform between shots. The difficulty of loading the breech opening to take the shaped mouth of a gun at the muzzle in the narrow space of a the powder chamber. There is a rectangular hole fortification, or even more so, on the crammed cut in the bottom of the trough, which served decks of early fighting ships, must have been to expel any accumulation of black powder the prime motive for the development of early residue. Further back at its rear the trough is breech-loaders. It soon became clear that it was pierced on either side with a rectangular slot easier and quicker to load a gun from the breech approximately 60 mm. long, by 25 mm. wide. than from the muzzle. Into these slots a substantial iron wedge was There seems little doubt that the first breech­ inserted and hammered in to force the powder loaders made their appearance during the first half chamber forward into the breech of the barrel of the fourteenth century. There are numerous and hold it firmly in position for firing. The references from this period to guns in use with separate Figure 2: powder chamber and its locking wedge are powder chambers that were removed for loading. Wrought iron Breech-Loading unfortunately missing. From the center of Many medieval and Renaissance cannon were Perrier c. 1400 the rear face of the chamber holder, which is roughly rectangular in shape, extends the long iron tiller or handle with which the gun was manoeuvred for aiming and was held firmly in position for firing. The tiller retains the usual knob at its end. There would normally be a mark on the top face of the rear of the chamber holder that matched identical marks on this particular breech-loader's set of chambers. Understandably, the gun has suffered considerably through the effects of being Malta Archaeological Review • Issue 6 2002/2003 23 gun when put to siege use, or fired from a ship in a broadside. On the other hand, when mounted on a swivel, with a long iron tiller to maneuver it, the lighter, all-metal breech-loader was indispensable as a very handy, quick-firing, anti­ personnel weapon, especially in close combat. In both cases, by providing tha gun with a number breech­ of spare chambers, pre-loaded before the start loaders, of battle, a fairly rapid fire could be kept up by and Pedrero, removing the fired chamber and replacing it with Perrier, or Peterara are a loaded one. Doubtless a slow but steady fire late Medieval terms used to could then be kept up by reloading the chambers indicate breech-loading pieces of as they were removed. Except for the inherent artillery designed to throw stone missiles, Two weakness of the gun, and that a gas-tight fit could Figure 3: Breech­ types of early breech-loaders were developed. The not be obtained for the chamber so that some of Loading Petarara first earlier version, was no more than a wrought the force of the exploding powder escaped, they c. 1470 iron tube, or barrel open at both ends, laid in a were ingenious, considering that muzzle loading heavy wooden bed and lashed down firmly. The cannon little different in concept from the earliest separate, pre-loaded powder chamber was placed guns, were to continue in use until the 1860's. against the rear barrel opening, and then held firmly The wrought iron breech-loading swivel in position by driving wooden wedges between gun was used extensively virtually the base of the chamber and the upstanding unchanged, from the rails of ships and the block of wood forming the rear end of the bed. crenellations of castles and forts for many A typical example complete with its wooden bed centuries. In fact, it would appear these swivel was recovered from the Mary Rose wreck, and an guns were still in use in ships as late as the later actual wrought iron chamber still retaining its iron part of the 16th century, as examples of these lifting-ring, is exhibited at the Palace Armoury in guns were raised from ships known to have been Valletta. Unfortunately, the provenance of this rare wrecked around that date. item is unknown. (Plate 5) The Spanish Pedrero, Italian Peterara, In the second, later type of breech-loader, the French Perrier and the English Sling are often earlier basic design was improved when metal encountered: in sixteenth century ordnance arms were extended rearwards from the barrel inventory lists and stone-throwing, breech­ as an integral part of the construction.