Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
Instruction No Version Part. No. 8637033 1.0
TV NTSC/PAL
© Volvo Car Corporation TV NTSC/PAL- 8637033 - V1.0
Page 1 / 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation TV NTSC/PAL- 8637033 - V1.0
Page 2 / 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available before starting installation.
Certain steps in the instructions are only presented in the form of images. Explanatory text is also given for more complicated steps.
In the event of any problems with the instructions or the accessory, contact your local Volvo dealer.
Note!
Applies only to Europe: A new rear windshield must be installed if the present windshield does not have an integrated antenna.
Note!
This accessory is connected to the car's electrical system. It requires software unique to the car.
Interior preparations
1 Interior preparations
Turn the ignition key to position O
Cars with manual gearboxes: Remove the ignition key
Disconnect the battery negative lead.
Note!
Wait at least five minutes before disassembling the connectors or removing other electrical equipment.
A8800136
© Volvo Car Corporation TV NTSC/PAL- 8637033 - V1.0
Page 3 / 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
2
Remove the seat cushion (1). First pull the front edge of the seat cushion up. Pull the cushion forwards. Then lift the seat cushion out.
D8503390
3
Fold both the rear backrests forward
Remove the seat belts from the guides (1).
M8503545
© Volvo Car Corporation TV NTSC/PAL- 8637033 - V1.0
Page 4 / 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
4
Remove the clip (1) at the side of the left-hand side cushion
Pull the top edge of the left front cargo compartment panel out to access the upper lock for the side cushion
Repeat the operation on the right-hand side.
M8503511
5
Remove the left-hand side cushion. First press in the catches (1) at the top edge of the reverse of the side cushion. Pull the cushion out slightly
Grasp the cushion using both hands. Twist counter-clockwise until the catches on the inside release
Remove the side cushion. First pull out the upper edge of the side cushion. Then pull upwards
Repeat the operation on the other side.
M8503546
© Volvo Car Corporation TV NTSC/PAL- 8637033 - V1.0
Page 5 / 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
6
Remove the cover and the screw for the left-hand C-post panel
Repeat the operation on the other side.
M8503596
7
Remove the rubber strip at the rear edge on the left-hand rear door frame
Grasp the top edge of the C post panel. Pull (A) the panel inwards until the three clips (1) release
Then pull (B) the panel straight up. Place the panel to one side
Repeat the operation on the other side.
M8503597
© Volvo Car Corporation TV NTSC/PAL- 8637033 - V1.0
Page 6 / 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
8
Carefully lift the front edge of the parcel shelf panel until the clips (1) release
Lift up the panel further until the locating pins (2) release from their holes
Pull out the parcel shelf. Lay the parcel shelf on the folded backrests.
M8503598
Cargo compartment preparations
9 Cargo compartment preparations
Remove the cargo compartment carpet at the rear edge. First turn the two handles (1) 90°.
M8503480
© Volvo Car Corporation TV NTSC/PAL- 8637033 - V1.0
Page 7 / 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
10
Pull up the front of the cargo compartment carpet. Fold the front half back over the rear half of the cargo compartment carpet.
M8503481
11
Slide the entire cargo compartment carpet forward slightly. Twist slightly to remove the cargo compartment carpet through the tailgate opening
Remove the cargo compartment carpet.
M8503482
© Volvo Car Corporation TV NTSC/PAL- 8637033 - V1.0
Page 8 / 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
12
Press the centres of the clips at the lower edge of the foldable side panel on the left-hand side until a click is heard
Remove the two clips
Remove the plastic nut at the front lower edge of the side panel.
M8902133
13 Remove:
the clips (1) in the left front side panel in the cargo compartment
the panel. Place the panel to one side.
M8503515
© Volvo Car Corporation TV NTSC/PAL- 8637033 - V1.0
Page 9 / 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
14
Remove the cable (1) between the GPS antenna on the parcel shelf and the foremost of the three upper sockets in the upper sockets in the RTI control module
Place the cable to one side. The amplifier will not be reused. A new cable harness is in the kit.
M3702459
15
Route the new cable harness (1) in the same way as the old harness
Position the connectors for the cable harness at the C-posts and at the rear edge of the wheel house. See the illustration
Press the cable harness into place in the parcel shelf with the existing clips
Connect the connector to the GPS antenna.
M3702460
© Volvo Car Corporation TV NTSC/PAL- 8637033 - V1.0
Page 10 / 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
16 Applies to Japan
Remove the ground lead for the rear windshield. First remove the screw (1). Remove the connector (2) from the rear windshield at the right-hand C-post
Place the ground lead and the screw to one side. They will not be reused.
Applies to Europe
Remove the screw (1). Remove the ground lead from the C- post. A new screw is included in the kit.
M3702461
17
Remove the cables (1, 2) for the existing antenna amplifier on the left C-post
Remove the screw (3) and remove the antenna amplifier
Place the antenna amplifier to one side. The amplifier will not be reused.
M3702462
© Volvo Car Corporation TV NTSC/PAL- 8637033 - V1.0
Page 11 / 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
18
Connect the new TV antenna amplifier (blue) to the new AM/FM antenna amplifier (blue) from the kit.
Applies to Japan
Carry out the same operation with the green antenna amplifiers.
Applies to Europe
For the EU only use the small green TV antenna amplifier.
M3903366
19A Applies to Japan
Install the new AM/MPX and TV antenna amplifiers (green) on the right C-post. Ensure that the antenna amplifier guide lugs engage in the two rectangular holes and in the small round holes
Tighten the amplifiers
Repeat the operation for the left-hand AM/FM and TV antenna amplifier (blue).
Applies to Europe
Install the small green TV antenna amplifier for the right hand C post in the rear position with the ground lead cable terminal on top. Tighten the antenna amplifier
Ensure that the amplifier guide lugs are in their relevant holes
Repeat the operation for the left-hand AM/FM and TV antenna M3903367 amplifier (blue). 19B
M3702548
© Volvo Car Corporation TV NTSC/PAL- 8637033 - V1.0
Page 12 / 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
20
Reinstall the cables (1) (that were removed earlier) in the front antenna amplifier on the left C-post
Connect the two single cables (2) (that were routed earlier) to the rear antenna amplifier on the left C-post
Connect the cables (3, 4, 5) to the connectors on the rear windshield as illustrated.
M3903368
21A Applies to Japan
Connect the two single cables (1) (that were routed earlier) to the rearmost of the two amplifiers on the right C-post
Connect the cables (2, 3, 4) to the connectors on the rear windshield as illustrated.
Applies to Europe
Connect the single cable (1) (previously routed) to the front terminal in the TV antenna amplifier on the right C-post as illustrated
Connect the cables (2) to the connectors on the rear windshield as illustrated.
M3702463
21B
M3702547
© Volvo Car Corporation TV NTSC/PAL- 8637033 - V1.0
Page 13 / 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
22
Clamp the cables on the parcel shelf, at the C-post and at the lead-in to the cargo compartment. See the arrows in the illustration.
M3903369
23
Remove the three screws (1) holding the CD ROM changer and bracket at the body
Lift up the unit and place it on the left rear side member.
M3903370
© Volvo Car Corporation TV NTSC/PAL- 8637033 - V1.0
Page 14 / 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
24
Take the TV tuner (1) and the three screws (2) from the kit. Tighten the TV tuner on the reverse of the bracket for the CD ROM changer
Connect the cable harness (3) with the green connector and the new DIN cable (4) to the TV tuner
Reinstall the CD ROM changer and the TV tuner.
M3903371
25
Connect the two cables (1) from the TV tuner to the RTI control module
Connect the two cables (2) routed from the parcel shelf to the TV tuner
Connect the cable (3) from the parcel shelf to the RTI control module
Clamp the cables with a tie strap (4) from the kit.
M3903372
26 Reinstall:
the parcel shelf panel
the C-post panels
the side cushions
the backrests
the seat cushion
the panels in the cargo compartment.
© Volvo Car Corporation TV NTSC/PAL- 8637033 - V1.0
Page 15 / 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
27
Turn the ignition key to position II
Reconnect the battery negative lead
Re-position the cargo compartment carpet
Program the software according to the service information in VIDA.
A8800137
© Volvo Car Corporation TV NTSC/PAL- 8637033 - V1.0
Page 16 / 16