DOCSLIB.ORG

Better Cost-Control Measures Are Needed on the Army's Cost

Total Page：16

File Type：pdf, Size：1020Kb

Download full-text PDF Read full-text
Better Cost-Control Measures Are Needed on the Army's Cost Report No. DODIG-2012-102 June 18, 2012 Better Cost-Control Measures Are Needed on the Army's Cost-Reimbursable Services Contract for Logistics Support of Stryker Vehicles Additional Copies To obtain additional copies of this report, visit the Web site of the Department of Defense Inspector General at http://www.dodig.mil/audit/reports or contact the Secondary Reports Distribution Unit at (703) 604-8937 (DSN 664-8937) or fax (571) 372-7469 Suggestions for Audits To suggest or request audits, contact the Office of the Deputy Inspector General for Auditing by phone (703) 604-9142 (DSN 664-9142), by fax (571) 372-7469, or by mail: Department of Defense Office of Inspector General Office of the Deputy Inspector General for Auditing Attn: Audit Suggestions/13F25-04 4800 Mark Center Drive Alexandria, VA 22350-1500 Acronyms AAA Army Audit Agency ACC Army Contracting Command ASA(ALT) Assistant Secretary of the Army for Acquisition, Logistics, and Technology AWCF Army Working Capital Fund BCA Business Case Analysis CAP Contractor Acquired Property CLS Contractor Logistics Support DFARS/PGI Defense Federal Acquisition Regulation Supplement, Procedure, Guidance, Instruction DVH Double V-Hull FAR Federal Acquisition Regulation OPTEMPO Operational Tempo ORR Operational Readiness Rate PBL Performance-Based Logistics PEO Program Executive Officer PMO Project Management Office TLCSM Total Life-Cycle Systems Management USD(AT&L) Under Secretary of Defense for Acquisition, Technology, and Logistics U.S.C. United States Code INSPECTOR GENERAL DEPARTMENT OF DEFENSE 4800 MARK CENTER DRIVE ALEXANDRIA, VIRGINIA 22350-1500 June 18,2012 MEMORANDUM FOR UNDER SECRETARY OF DEFENSE FOR ACQUISITION, TECHNOLOGY, AND LOGISTICS AUDITOR GENERAL DEPARTMENT OF THE ARMY SUBJECT: Better Cost-Control Measures Are Needed on the Army's Cost-Reimbursable Services Contract for Logistics Support of Stryker Vehicles (Report No. DODIG-20 12-1 02) We are providing this report for information and use. The Army's cost-reimbursable services contract for logistics support of Stryker vehicles lacked adequate cost-control metrics and a tangible deliverable. The contractor was authorized to spend about $1.453 billion, but we calculated the operational support costs for Stryker vehicles at about $1.117 billion for 5 years, resulting in about $335.9 million that the contractor used to accumulate inventory that could have been put to better use. As a result of the audit, the Project Manager for Stryker Brigade Combat Team identified $152.4 million in excess inventory that will be used to reduce Program Year 2011 and Program Year 2012 contract requirements. This report is the first of three reports on the effectiveness of the contractor logistics support strategy for the Stryker family of vehicles. We considered management comments on a draft of this report when preparing the final report. The Director, Defense Procurement and Acquisition Policy; Assistant Secretary of Defense for Logistics and Materiel Readiness; Assistant Secretary of the Army for Acquisition, Logistics, and Teclll1010gy; Program Executive Officer Ground Combat Systems; and Executive Director, Army Contracting Command comments conformed to the requirements of DoD Directive 7650.3; therefore, additional comments are not required. We appreciate the cOUltesies extended to the staff. Please direct questions to Mr. Helll'Y F. Kleinknecht at (703) 604-9324 (DSN 664-9324). ~D.!t£I:~'!'~ Assistant Inspector General Acquisition and Contract Management Report No. DODIG-2012-102 (Project No. D2011-D000CH-0032.000) June 18, 2012 Better Cost-Control Measures Are Needed on the Army’s Cost-Reimbursable Services Contract for Logistics Support of Stryker Vehicles • establish the cost-reimbursable contract What We Did as one of the basic contract forms: either We evaluated the effectiveness of the contractor the completion-form contract in which logistics support strategy for the Stryker family the contractor is required to deliver a of vehicles. The Project Management Office for specified, definitive end product or the Stryker Brigade Combat Team (PMO Stryker) term-form contract in which the entered into the contract with General Dynamics contractor is required to provide a Land Systems with a singular focus to achieve specified level of effort for a stated an operational readiness rate (ORR) goal of period of time; and 90 percent and actually achieved an ORR in excess of 96 percent. This report is the first of • establish an effective means to measure three reports and addresses performance metrics operational costs and ensure that the and contract type; subsequent reports will level of operational funding was tied to address the contract funding procedures, the actual workload required to sustain contractor billings, and controls over the Stryker vehicle, but instead, used Government property being managed by the estimates made years earlier. contractor. What We Found Consequently, the Stryker contractor logistics support contract had no tangible deliverable; PMO Stryker and the Army Contracting neither complied with nor met the intent of DoD Command (ACC)-Warren contracting officer performance-based logistics guidance; and did did not implement adequate cost-control not meet Federal Acquisition Regulation procedures on the cost-reimbursable services requirements for a cost-reimbursable contract. contract valued at about $1.5 billion from In addition, the Army had no means to measure March 2007 to February 2012 because they did the efficiency of the contractor’s cost not: performance or actual cost overruns or • adequately define performance-based underruns in relation to the fixed fee. Also, the contract requirements in clear, specific, sole focus on operational readiness created an and objective terms with measurable incentive for the contractor to spend all outcomes. The contract included a available funds on Army inventory, valued by metric for availability (90-percent ORR), General Dynamics at about $676.2 million, but did not include essential metrics resulting in little, if any, cost risk for the relating to cost-per-unit usage (for contractor or incentive to control cost. example, miles driven) and logistics footprint (that is, dollars in inventory); The contractor was authorized to spend about $1.453 billion on the contract, but we calculated the operational support costs for Stryker vehicles at about $1.117 billion for the first i Report No. DODIG-2012-102 (Project No. D2011-D000CH-0032.000) June 18, 2012 5 years, resulting in about $335.9 million used Additionally, the Director, Defense Procurement to accumulate inventory that could have been and Acquisition Policy; Assistant Secretary of put to better use. As a result of the audit, PMO Defense for Logistics and Materiel Readiness; Stryker identified $152.4 million in excess and the Assistant Secretary of the Army for inventory that will be used to reduce Program Acquisition, Logistics, and Technology need to Year 2011 (October 2011 to February 2012) and establish a multifunctional team to support PMO Program Year 2012 (March 2012 to Stryker and ACC officials in negotiating the February 2013) contract requirements. next Stryker logistics support contract scheduled for award in June 2013. What We Recommend Among other recommendations, the Program Management Comments and Executive Officer Ground Combat Systems with the support of the Executive Director, ACC, Our Response should require PMO Stryker to establish and Management comments were responsive to the monitor appropriate cost and inventory control recommendations, and management is taking metrics, define contract remedies that include action to address cost-control measures, both positive and negative fee measures related contract-type, and operational support funding to inventory turns and inventory accuracy issues. PMO Stryker is performing a business metrics, use one of the basic contract forms case analysis to determine whether PBL is the (either term or completion), and define a appropriate strategy and cost-reimbursable is the tangible deliverable. Further, the Program appropriate contract type to execute logistics Executive Officer Ground Combat Systems support of Stryker vehicles. Additionally, PMO needs to continue to review operational support Stryker will continue to monitor operational costs for Stryker vehicles and determine support costs and consider currently available whether current funding levels are appropriate. inventory to satisfy future requirements. Please We also recommend converting the high-risk, see the recommendations table on page iii. cost-reimbursable contract or portions of the contract to a lower risk, firm-fixed-price contract. Figure 1. Stryker Vehicle, Mobile Gun System Source: www.sbct.army.mil ii Report No. DODIG-2012-102 (Project No. D2011-D000CH-0032.000) June 18, 2012 Recommendations Table Management Recommendations No Additional Comments Requiring Comment Required Director, Defense Procurement 5 and Acquisition Policy Assistant Secretary of Defense for Logistics and Materiel 5 Readiness Assistant Secretary of the Army for Acquisition, Logistics, and 2, 5 Technology Program Executive Officer 1, 3 Ground Combat Systems Executive Director, Army 4 Contracting Command-Warren iii Table of Contents Introduction 1 Objectives 1 Background 1 Review of Internal Controls 7 Finding. Inadequate Cost Controls on the Cost-Reimbursable Services Contract for Logistics Support of Stryker Vehicles 8 Performance-Based Contract Did Not Adequately Define Requirements With Measurable Outcomes
Load more

Recommended publications
  • 2020 Corporate Sustainability Report
    TRANSPARENCY. TRUST. ALIGNMENT. HONESTY. 2020 Corporate Sustainability Report OUR ETHOS TRANSPARENCY. TRUST. ALIGNMENT. HONESTY. These four values undergird everything we do at General Dynamics — they are our defining moral character. All of us at General Dynamics have a duty to behave according to these values. Through our shared Ethos, we ensure that we continue to be good stewards of the investments our shareholders, customers, employees and communities make in us, now and in the future. TABLE OF CONTENTS OUR ETHOS 2 A Letter From Our CEO 4 OUR BUSINESS 5 Our Values at Work 6 Business Overview 7 Corporate Responsibility 10 Global Supply Chain 12 GOVERNANCE 14 Corporate Governance 15 Ethics 18 Information Security 21 HUMAN CAPITAL MANAGEMENT 25 Employee Safety 26 Employee Well-Being 27 Developing and Engaging Our Talent 28 DIVERSITY AND INCLUSION 29 Diversity Is Critical to Innovation 30 Talent Recruiting and Retaining Diverse Talent 32 Awards & Recognition 36 ENVIRONMENT 37 Environmental Responsibility 38 Examples From Our Businesses 41 COMMUNITY RELATIONS 45 Investing in Our Communities 46 COVID-19 Response 50 REPORTING APPROACH 52 A Letter from Our CEO Dear Fellow Shareholder, Corporate sustainability at General Dynamics is rooted in our Ethos — our defining moral character as a company and the standard to which we hold ourselves and our more than 100,000 employees worldwide. It informs all that we do and guides us as we deliver value to our shareholders, our customers and our communities. Ongoing conversations with all of our stakeholders have been an integral part of building and evolving our sustainability program. We remain committed to reducing our global environmental impact, including our carbon footprint; protecting and promoting human rights; increasing the diversity of our workforce; supporting the health, welfare and safety of our employees; and fostering mutually beneficial relationships with our communities.
    [Show full text]
  • BOMBS AWAY' from 60,0
    The unconventional, far-ahead, supersonic B-58 Hustler is poised combat-ready at Cars- well AFB in Texas — a new addition to the free world's deterrent strength. USAF air- men and their B-58s have been engaged in intensive training. They have also taken time out to rewrite a page or two of the record book . 'BOMBS AWAY' from 60,0 Col. J. K. Johnson, USAF FORMER COMMANDER, 43d BOMB WING (M), SAC HE TARGET is Deerfield, Mass. You're twelve sive. It may not quite rival those reported by miles up, moving at twice the speed of sound. high-altitude record setters and balloonists, or T But there's no sense of speed, of motion. You nation's first Astronaut, but it still covers a giant fi seem to be hanging high above the earth on an in- of vision. To the right, far below, are the lights visible thread strung from somewhere in the universe. Buffalo, N. Y., 150 miles away. You see a lot of te It's calm, smooth, peaceful, quiet—in sharp con- tory from a dozen miles up—although you don't rea trast to the dread lethality of your bomb load. Actu- need to for purposes of this mission. All the infa ally, the bomb load is simulated. This is a practice mation required to plunk your "electronic payloac strike. It could be for real. Deerfield, some 3,500 on target is carried in black boxes in the plane. It miles from home base by a circuitous exercise route, automatically fed to computers to keep you on ems! provides a particular pattern on a radar screen.
    [Show full text]
  • General Dynamics Electric Boat Invoices
    General Dynamics Electric Boat Invoices tastedBruce panningswhole while prehistorically small-town Constantineif inessive Stanly monkey sleeved that sumpters.or vitalised. Festinate and sprightliest Rodrick sectarianizing some limos so lingually! Morton still The invoicing party of command and the developer shall be construed as this retirement benefits are currently under this Ifeither part breache an ofthe terms provisions orconditions ofthis Agreementb. Gtin information with written notice and this allegation is used as we also be. At General Dynamics Electric Boat We hook the sentence that. The versatile Greyhound can void support special operations and distinguished visitor transport requirements. Landlord of any or all other rights or remedies provided for in this Lease, if any, or now or hereafter existing at law or in equity or by statute or otherwise. Conflict mineral that year of invoices received from raw materials per share data, legal meaning to minimiz terroristhreat throug th. We are using cookies to give you the best experience follow our website. To the extent backlog has not been funded, there is no assurance that congressional appropriations or agency allotments will be forthcoming. Assigned to the Military Sealift Command they are manned by civilian mariners. AGREEMENT GENERAL DYNAMICS ELECTRIC BOAT. Electric boat corporation company estimates made in advanced gun and all gtins may be. City any attempt to supplying any manner cannot pay to take a general dynamics electric boat invoices have the delivery of being used. Terminal range of invoices received from indeed, service providers and deduction of? Haanyon eve aske me a captcha proves you agree on gold for general dynamics electric boat pursuant to.
    [Show full text]
  • Appendix C – Key Studies on Aircraft Deviation ACRP 4-09 - Risk Assessment Method to Support Modification of Airfield Separation Standards
    Appendix C – Key Studies on Aircraft Deviation ACRP 4-09 - Risk Assessment Method to Support Modification of Airfield Separation Standards The following table summarizes some of the most relevant studies addressing lateral aircraft deviations during runway, taxiway and taxilane operations. The models developed by Scholz (2003a and 2003b) were used in the approach to analyze taxiway and taxilane separations. Table C-1. Relevant studies on aircraft lateral deviation in airfields Title Year/Author Description Evaluation of Brown & This study was conducted with test sections for B-47 Existing Thompson, 1973 (Stratojet), B-52, KC-87, and KC-135 aircraft. The Airfields for C- report also makes reference to studies conducted in 1949 5A Operations and field observations carried out in 1956. The concept of wander was introduced. Wander was defined as “the maximum lateral movement of a point on the centerline of an aircraft about the centerline (or guideline) on taxiways or runways during operation of the aircraft.” The lateral deviations for those aircraft from the taxiway and runway centerlines can be considered as approximately 3.2 ft and 33.7 ft, respectively, during 75 percent of the time. Field Survey and HoSang, 1975 Deviation data were collected from 9 airports and 12 Analysis of types of commercial aircraft with maximum gross Aircraft weights above 50,000 pounds, including: Boeing 747, Distribution on 707, 727 and 737; McDonnell-Douglas DC-10, DC-8 and Airport DC-9; Lockheed L-1101; General Dynamics Convair 880 Pavements and 580; British Aircraft Corporation BAC-111; and Nihon YS-11. The standard deviations for individual aircraft types, compared at the various airports, varied from 3 to 8 ft for takeoffs and from 4 to 9 ft for landings.
    [Show full text]
  • Marine Corps Advanced Reconnaissance Vehicle (ARV)
    Updated June 10, 2021 Marine Corps Advanced Reconnaissance Vehicle (ARV) What Is the Advanced Reconnaissance anti-armor capability to defeat close-in heavy armor Vehicle (ARV)? threats; According to the Marine Corps, the Advanced Reconnaissance Vehicle (ARV) aims to be a new armored precision-guided munitions (PGMs) to defeat threats vehicle family to replace the Light Armored Vehicle (LAV) beyond the engagement range of threat systems; (Figure 1): Since the 1980s, the Light Armored Vehicle (LAV) unmanned systems swarm capability to provide persistent, multifunction munitions; has supported Marine Air-Ground Task Force missions on the battlefield. While the LAV remains advanced, networked, multifunctional electronic warfare operationally effective, the life cycle of this system (EW ) capabilities; is set to expire in the mid-2030s…. The Advanced Reconnaissance Vehicle (ARV) [the LAV’s a modern command-and-control suite and a full range of replacement] will be highly mobile, networked, sensors to enhance and extend reconnaissance and transportable, protected, and lethal. The capability surveillance ranges; will provide, sensors, communication systems and lethality options to overmatch threats that have organic unmanned aerial and ground systems historically been addressed with more heavily (UAS/UGS) that can be deployed from the ARV; armored systems. The ARV will be an advanced combat vehicle system, capable of fighting for active and passive vehicle protection capabilities to information that balances competing capability sense, orient, classify, track, and defeat incoming demands to sense, shoot, move, communicate and rocket-propelled grenades (RPGs), anti-tank guided remain transportable as part of the naval missiles (ATGMs), and PGM threats with hard-and soft- expeditionary force.
    [Show full text]
  • San Diego History Center Is a Museum, Education Center, and Research Library Founded As the San Diego Historical Society in 1928
    The Journal of San Diego Volume 58 Fall 2012 Number 4 • The Journal of San Diego Number History 2012 58 Fall Volume History Publication of The Journal of San Diego History is underwritten by a major grant from the Quest for Truth Foundation, established by the late James G. Scripps. Additional support is provided by “The Journal of San Diego History Fund” of the San Diego Foundation and private donors. The color section for the Charles Reiffel Exhibit Review has been underwritten by Thompson Fetter. The San Diego History Center is a museum, education center, and research library founded as the San Diego Historical Society in 1928. Its activities are supported by: the City of San Diego’s Commission for Arts and Culture; the County of San Diego; individuals; foundations; corporations; fundraising events; membership dues; admissions; shop sales; and rights and reproduction fees. Articles appearing in The Journal of San Diego History are abstracted and indexed in Historical Abstracts and America: History and Life. The paper in the publication meets the minimum requirements of American National Standard for Information Science-Permanence of Paper for Printed Library Materials, ANSI Z39.48-1984. Front Cover: Charles Reiffel, San Diego Harbor. Oil on Canvas, 1936. The San Diego History Center on loan from the Fine Arts Program, Public Building Services, US General Administration, commissioned through the New Deal art projects. Charles Reiffel: An American Post-Impressionist, Catalogue No. 63. Back Cover: Charles Reiffel, detail from History of San Diego—Colonial, 1939. The San Diego History Center, gift of Donna Sefton. Cover Design: Allen Wynar The Journal of San Diego History IRIS H.
    [Show full text]
  • Type Rating of an Aircraft, Compare the Aircraft Model from Block 2 of the Airworthiness Certificate to the Civil Model Designation Column Below
    FAA Order 8900.1, Volume 5, Chapter 2, Section 19 06/28/2021 FIGURE 5-88, PILOT CERTIFICATE AIRCRAFT TYPE DESIGNATIONS – AIRPLANE NOTE: 1. As of November 2015 the FAA has begun removing marketing names from the Civil Model Designation column. When determining the appropriate type rating of an aircraft, compare the aircraft model from Block 2 of the Airworthiness Certificate to the Civil Model Designation column below. The column titled Current Type Rating Designation will show the appropriate type rating for this aircraft. EQUIVALENT CURRENT TYPE TYPE CERTIFICATE CIVIL MODEL PRIOR MODEL MILITARY RATING HOLDER DESIGNATION DESIGNATION DESIGNATION DESIGNATION 328 Support Services GmbH Dornier 328-100 C-146A DO-328 Dornier 328-300 None D328JET Aero Commander Division (See Israel Aircraft Industries None Ltd.) Aérospatiale, France SN 601 Corvette None SN-601 Aérospatiale/Aeritalia, France (See ATR – GIE Avions de None Transport Régional) Airbus A340-200 Series: None A-340 Models: A340-211, -212, -213 A340-300 Series: Models: A340-311, -312, -313 A340-500 Series: Models: A340-541 A340-600 Series: Models: A340-642 Airbus Canada Limited BD-500-1A10 None BD500 Partnership BD-500-1A11 Airbus Defense and Space S.A. Model: C-212-CB, C-212-CC, None CA-212 C-212-CD, C-212-CE, C-212-CF, C-212-DF, C-212-DE Model CN-235, CN-235 CN-235 Series C-295 CN-235-100, CN-235-200, CN-235-300, C-295 Airbus SAS A300, Model B2-1A None A-300 A300, Model B2-1C A300, Model B4-2C A300, Model B2K-3C A300, Model B4-103 A300, Model B2-203 A300, Model B4-203 A300, Model B4-601
    [Show full text]
  • Idfflt Annual Report 1957-1958 ;
    * iDfflT annual report 1957-1958 ; f Annual Report for the Fiscal Year October 1— September 30 SAS OPERATIONS - GENERAL SAS one of the very first international carriers to op­ erate a fully modern medium-range jet fleet, which will SAS operations have shown a certain increase during successively go into service in 1959 and 1960. the fiscal year 1957-58. The production increase has, Extensive efforts have been made to counteract the con ­ however, been less pronounced than during the pre­ tinuous increase of production costs. In this connection, ceding fiscal year. the advantages of closer co-operation with other airlines The modernization of the fleet has continued. Three have been carefully studied. Negotiations with the additional Douglas DC-7Cs and four Convair Metro ­ Swiss carrier Swissair during the spring and summer politans have gone into operation, while older equipment 1958 have resulted in an agreement between SAS and has been sold. The modification program for the DC-6 Swissair concerning a co-ordinated equipment policy, a fleet has been completed. The costs for this program, distribution between the carriers of maintenance work which has been carried out during the last two fiscal for their future jet fleets, and a close co-operation in years, have been charged to the operations of the re­ every respect in the technical and operational fields. spective years. Under this agreement, SAS will, in 1960, obtain a new The operational results for 1957-58 have, to a certain type of jet aircraft by leasing a number of four-engine extent, been influenced by the economic recession dur­ Convair 880s from Swissair.
    [Show full text]
  • Total Quality Management
    • • • • • • • • • • • • • Total Quality Management Aerospace Industries Association 0 Introduction 3 Total Quality Management 4-10 Advanced Technologies/ Techniques 11-17 Statistical Process Control (SPC) 18-22 Control of Purchased Materials 23-27 Motivation/ Training 28-32 • • • front Cover Photo-Raytheon Co mpany 2 • • • • n the early 1980s, the aerospace industry recognized that foreign competitors were aggressively pursuing targets in its arena, as they had done in many basic industries. Highly publicized • "honor stories" related to the quality and reliability of defense indust7y products made the problem more acute. After an objective and sometimes painful self-evaluation, the members of the Aerospace Indust7ies Assocation of America (AIA) are responding with firm commit7nents to improvements in quality and productivity. Und erstanding that the pursuit of excellence through continuous quality improvement requires revolu­ tionary cultural changes, member companies are rapidly implementing those changes through what might be ca ll ed ''Total Quality Management. " Cultural changes do not occur overnight. They result from long-term commitments and require persistent reo·aining and modification of practices, covering every individual in a company-from the high est to th e lowest level. Th e members of AlA present this brochure to illustrate how they are successfully implementing these process es . Th ey are addressing every phase of their business - from product conceptualization, through prototyping, testing,final design , and fabrication, to delivery and beyond. There are individual differ­ ences, depending on each company's products, size, and overall business environment. There are even differences within companies, as various divisions cope with their particular situations. In fact, each company must have the freedom and flexibility to structure a process that fits its own unique needs.
    [Show full text]
  • Winning the Institute for Atf Airpower Studies by Sherman N
    L INS EL TIT CH U T T I E M fo s r A die irpower Stu Mitchell wiNNiNg the iNStitute for atf airpower StudieS www.afa.org/Mitchell By Sherman N. Mullin Mitchell paper 9 Promoting Air Force Air Power Brig. Gen. Billy Mitchell On September 12, 1918, at St. Mihiel in France, Col. William Mitchell became the first person ever to command a major force of allied aircraft in a com- bined-arms operation. This battle was the debut of the US Army fighting under a single American com- mander on European soil. Under Mitchell’s control, more than 1,100 allied aircraft worked in unison with ground forces in a broad offensive—one en- compassing not only the advance of ground troops but also direct air attacks on enemy strategic tar- gets, aircraft, communications, logistics, and forces beyond the front lines. Mitchell was promoted to Brigadier General by order of Gen. John J. Persh- ing, commander of the American Expeditionary Force, in recognition of his command accomplishments during the St. Mihiel offensive and the subse- quent Meuse-Argonne offensive. After World War I, General Mitchell served in Washington and then became Commander, First Provisional Air Brigade, in 1921. That summer, he led joint Army and Navy demonstration attacks as bombs delivered from air- craft sank several captured German vessels, including the SS Ostfriesland. His determination to speak the truth about airpower and its importance to America led to a court-martial trial in 1925. Mitchell was convicted and resigned from the service in February 1926. Mitchell, through personal example and through his writing, inspired and encouraged a cadre of younger airmen.
    [Show full text]
  • The One That Got Away
    50 GENERAL DYNAMICS F-111B | STORY: STEWART WILSON The one that got away The General Dynamics F-111 overcame masses of ‘bad press’ in its early days and many technical difficulties to be recognised as arguably the best strike bomber of its era. But there was one version which failed due to the flawed philosophy behind its development: the F-111B carrier-based fleet defence fighter for the US Navy. GENERAL DYNAMICS F-111B 51 Above: The first F-111B (Bu151970) fleet defence fighter first flew on 18 May 1965 but three years later the programme was cancelled after just seven had been built. The main external difference to the land- based F-111 models is the shortened nose. US Navy THE F-111 QUALIFIES as a remarkable aircraft on all counts. It incorporated a high level of new and advanced technology, overcame its problems and went on to perform superbly as a strike and later electronics warfare platform. In retrospect it can be seen that the US Navy’s F-111B was never going to work. It was a victim of its political architect’s vision for an aircraft that could be both a large land-based strike bomber and a naval fighter. That architect was US Secretary of Defense Robert Strange McNamara, whose ‘procedural commonality’ philosophy was intended to create industrial, technical and financial efficiencies. It had the opposite effect. Grumman was given prime responsibility for the F-111B programme due to General Dynamics’ lack of experience with naval aircraft. Grumman, on the other Rollout of the first F-111B from Grumman’s hand, had a long and illustrious history in that field.
    [Show full text]
  • Aircraft Accident Report Japan Airlines Company, Ltd
    SA-None File No. A-0004 AIRCRAFT ACCIDENT REPORT JAPAN AIRLINES COMPANY, LTD. CONVAIR 880, MODEL 22M, JA8028 GRANT COUNTY AIRPORT MOSES LAKE, WASHINGTON JUNE 24,1969 Adopted: June 17, 1970 / Report Number: NTSB-AAR-70-11 lL4TIOEXL TRANSPORTATION SAFEIT BOARD DEPARlMENT OF TRANS€QRTATION WASHINGTON. D. C . JAPAN AIR LINES COMF'ANY. IIPD . COMTAIR 880. MODEL 22M. JA-8028 GRANT COUNTY AIReORT MOSEWASHINGTON JUNE 24. 1969 TABIX OF CONTENTS EE synopsis .................. 1 Probable Cause .............. 1 1. Investigation ............... 2 1.1 History of Flight ............. 2 1.2 Injuries to Persons ............ 4 1.3 Damage to Aircraft .............. 5 1.4 Other Dama@;e ................ 5 1.5 Crew Information .............. 5 1.6 Aircraft Information ............ 6 1.7 Meteorological Information ......... 6 1.8 Aids to Navigation .............. 6 1.9 Couuuunications ................ 6 1.10 Aerodrome and Ground Facilities ....... 7 1.ll Flight Recorders ............... 7 1.12 Wreckage ................... 8 1.13 Fire .................... 9 1.14 Survival Aspects .............. 10 1.15 Tests and Research ............. 10 2 . Analysis and Conclusions .......... 15 2.1 Analysis ................... 15 2.2 Conclusions ................. 18 (a) Findings ............... 18 (b) Probable Cause ........... 19 3 . Recommendations ............... 20 Attachment Appendices A . Crew Information B . Investigation and Hearing File No. A-0004 NATIONAL TRANSPORTATION SAFEIT BOARD DEPARTMENT OF TRANSPOFSATION AIRCRAFT ACCIDENT KEWRl Adopted: June 17, 1970 JAPAN AIR LINES COMPANY, LTD. CONVAIR 880, MODEL 22M, JA-8028 GRANT COUNTY AIRPORT MOSES LAEX, WASHINGTON 24, 1969 SYNOPSIS Ja an~.Air.,Li&es _-trainin& __ flight 90 of June 24, 1969, crashed at 1603 &hile executing a takeoff on Runway 32R. Of the five crew- members and trainees on board, three received fatal injuries and two sustained serious burn injuries.
    [Show full text]