Flux-growth and characterization of LiFePO4 single a,* b c d b d G. Liang , J. Li , R. Benson , K. Park , D. Vaknin , and J. T. Markert aDepartment of Physics, Sam Houston State University, Huntsville, Texas 77341, USA bAmes Laboratory and Department of Physics and Astronomy, Iowa State University, Ames, Iowa 50011, USA cRigaku Americas Corporation, 9009 New Trails Drive, The Woodlands, Texas 77381, USA dDepartment of Physics, University of Texas at Austin, Austin, Texas 78712, USA

______Abstract

Large size high quality LiFePO4 single crystals have been grown by flux growth technique with LiCl as flux. The as-grown single crystals have volumes up to about 300 mm3(∼ 1.0 g). Single- x-ray diffraction (XRD) measurements at T = 293 K shows the crystals are orthorhombic with space group Pnma (Z = 4). The lattice parameters obtained from the refinement are: a = 10.3172 (11) Å, b = 6.0096(8) Å, c = 4.6775 (4) Å. The Fe-O and P-O bond

lengths were obtained. Powder XRD pattern of ground LiFePO4 single crystals shows that the crystals are pure phase. Magnetic susceptibility, measured with applied field along the a-axis,

shows that the Fe ions are antiferromagnetically ordered at Neel temperature TN = 51 ± 2 K.

Above TN, the Fe ions are in the paramagnetic state with an effective moment μeff = 5.42 μB/Fe, 2+ which is close to the μeff value of the Hund’s rule ground state of Fe ions with orbital moment quenched.

PACS: 61.10. Nz; 81.10.-h; 61.66.Fn; 75.50.Ee

Keywords: A2. Growth from high temperature solutions; A2. Flux method; A1. X-ray diffraction; A1. ; B1. Lithium iron phosphate.

______

*Corresponding author: Tel: +1-936-294-1608; fax: +1-936-294-1585. E-mail address: [email protected] (G. Liang)

1

1. Introduction

Lithium iron phosphate, LiFePO4, has been considered as one of the most promising candidates for next generation rechargeable Li-ion batteries cathode material due to its high theoretical specific capacity (∼170 mAh/g), high cycle life, low cost, high thermal stability, and non-toxicity [1-6]. However, the intrinsically poor electronic conductivity in the range from 10-10 -5 S/cm to ∼ 10 S/cm of LiFePO4 [3, 7, 8] limits the delivery of high specific capacity at high discharge rates. At present, there is a controversy regarding whether the enhancement in the + electronic conductivity for cation-doped LiFePO4 is truly due to the substitution of Li by the cations or due to the grain-boundary impurity network [3, 9-12]. The best way to resolve this 3 controversy is to synthesize pure phase and sizable (> 10 mm , for example ) cation-doped

LiFePO4 single crystals for electronic conductivity studies, because such single crystals are free of impurity grain-boundaries and thus that complicating factor can be ruled out. Also, the anisotropy of the magnetic and electronic structure can be studied only by using high quality and sizable single crystals. Thus, it appears very important to synthesize large-size high quality

LiFePO4 and cation-doped LiFePO4 single crystals for the study of the electronic conductivity and other physical/chemical properties.

Currently, due to the unavailability of large size LiFePO4 single crystals, almost all of the studies including electronic conductivity measurements were carried out on polycrystalline

LiFePO4-based materials synthesized by various methods [3, 13-19]. In the past, few results on

the growth of LiFePO4 single crystals were reported. For example, the hydrothermal growth [20,

21] has been reported, but the grown LiFePO4 single crystals were too small (with radius less than 0.15 mm) to be used for certain physical property studies such as the measurements of four probe electronic conductivity. Recently, growth of LiFePO4 crystals using an optical floating zone [22] technique was reported. In the 1960s, Mercier et al. [23-26] reported the growth of

single crystals of LiMPO4 (M = Mn, Co, Ni, Fe) by a flux method, however, the size and quality of the crystals were not reported. To our knowledge, there have been virtually no detailed reports

on the growth of sizable pure phase LiFePO4 single crystals using flux method. Very recently,

we have successfully grown LiFePO4 single crystals by a flux method for magnetic neutron scattering studies from spin-waves [27]. In this paper, we report the details of the growth of

2 sizable and high quality LiFePO4 single crystals by standard flux method and the results on the single-crystal (SC) x-ray diffraction (XRD), powder XRD, and magnetic susceptibility.

2. Experimental details

LiFePO4 single crystals were grown by a standard flux growing technique from

stoichiometric mixture of high purity FeCl2 (99.999% Aldrich) and Li3PO4 (99.999% Aldrich), carried out in an Ar atmosphere. LiCl was used as the flux during the following chemical

reaction: FeCl2 +Li3PO4 +LiCl = LiFePO4 + 3LiCl. To obtain large-size single crystals, the

molar ratio between the LiFePO4 and LiCl was kept at a value close to 1:3. The growth was performed in sealed platinum crucibles. Small holes of about 50 μm diameter were made on the crucibles to release the high vapor pressure of LiCl. The mixture was pre-melted at 800 °C and then heated at 890 °C for 5 hours (h), soaked at 890 °C for 5 h, slowly cooled down to 710 °C at a rate of 0.7 °C/h, and then further cooled to 650 °C at a rate of 1.5 °C/h. The furnace was turned off at 650 °C and naturally cooled to room temperature. The crystals were extracted from the mixture by dissolving the extra LiCl by water at room temperature. This protocol is similar to the one used for LiNiPO4 SC growth [28] The SC XRD data were measured at T = 293 K using a Rigaku SPIDER x-ray diffractometer -1 with Mo Kα radiation (λ = 0.7107 Å) to a resolution corresponding to sinθmax/λ = 0.6486 Å . The data refinement was done using program SHELXL [29]. Powder XRD of ground single crystals at room temperature was measured on a Rigaku Geigerflex diffractometer using Cu Kα radiation. The intensity data were accumulated at 0.02° step and a scanning rate of 5 seconds per step. The data was analyzed by software package Jade 6.1 provided by the Material Data Inc. The temperature dependent magnetic susceptibility measurements were carried out on a commercial superconducting quantum interference device (SQUID) magnetometer (model MPMS, Quantum Design) in the temperature range 5-300 K and at a field of 1 kOe.

3. Results and discussion The as-grown single crystals have volumes up to about 300 mm3 and mass up to 1.0 g, with average dimensions 4 mm × 4 mm × 6 mm ≈ 100 mm3. Fig. 1 shows some of the as-grown crystals with volume between 100 mm3 and 200 mm3. Most of the as-grown crystals are irregular in shape and dark-greenish in color. The sample used for SC XRD

3 measurement was a small piece (about 0.06 mm3) which was cut from a bigger rectangular crystal used for the magnetization measurement (see below). Shown in Fig. 2 is the SC XRD pattern measured with the x-ray along the a-axis of the crystal. The measurements of 1330

reflections gave 350 unique reflections with Rint = 0.032 and I > 2σ (I). The refinement method used is the full-matrix least-squares on F2, with the goodness-of-fit on F2 to be 1.100. The refinement result indicates that the crystal has orthorhombic crystal structure with space group Pnma (No. 62) and Z = 4, and yields lattice parameters: a = 10.3172 (11) Å, b = 6.0096(8) Å, c = 4.6775 (4) Å. The obtained atomic coordinates for Li, Fe, P, and O are listed in Table I. Our result is consistent with the earlier single crystal XRD results reported by Streltsov et al. [20], i.e., the cations occupy three different positions: an octahedral (Fe) site, a octahedral (Li) site, and a tetrahedral (P) site. Fig. 3 is a general view of the structure which contains the FeO6 -3 octahedra (in orange) and PO4 tetrahedra (in yellow). Each FeO6 octahedron is connected to

four other FeO6 octahedra by corner-sharing in the b-axis (or [010]) and c-axis ([001]) directions, -3 and connected to four PO4 tetrahedra in a-axis ( or [100]) direction via edge- and corner-

sharing. The Li ions are located at the centers of highly distorted LiO6 octahedra. Table II summarizes the values of the Fe-O and P-O bond lengths and Table III lists all of the bond angles formed between any two O-Fe bonds or two O-P bounds. The different values of the Fe-O

bond-lengths and the deviations of the bond-angles from 90° clearly indicate that the FeO6 octahedra are distorted. The maximum difference between the bond lengths is 0.181 Å within an average bond length of 2.154 Å. Figure 4 presents powder XRD pattern of a ground single crystal in the 2θ range of 15° ≤ 2θ

≤ 65°. The Kα2 lines have been removed from the pattern. All the reflections in the pattern can be indexed with the orthorhombic structure of space group Pnma. No impurity trace or inclusion is observed, indicating the single crystals synthesized by our flux method consist of a single phase. The least square refinement was performed over the 2θ range 15° ≤ 2θ ≤ 65° with intensity weight, yielding the following values of the lattice parameters: a = 10.3167 (12) Å, b = 5.9980(10) Å, c = 4.6905 (6) Å. For the least square fit, the estimated standard deviation (ESD) is 0.014°, the average of Δ(2θ) is 0.012°, and the Smith-Snyder figure-of-merit is F(24) = 34.6 (58). Compared with the values determined from the SC XRD data above, the value of the parameter a is the same within the ESD range, but the values of parameters b and c have a very

4 small difference. These values of lattice parameters are almost identical to those powder XRD results reported in the literature [4, 22, 30]. Figure 5 shows the temperature dependent magnetic susceptibility, χ(T) and inverse magnetic susceptibility, χ-1(T) curves. The χ(T) was measured on the crystal (dimensions 0.7 mm × 1.6 mm × 2.6 mm, mass 10.4 mg) from which the SC XRD sample was taken. A magnetic field of 1 kOe was applied along the a-axis ([100] direction) of the crystal. The χ(T) curve in

Fig. 5 indicates that LiFePO4 is antiferromagnetically (AFM) ordered at Neel temperature TN =

51 ± 2 K, where TN is defined as the temperature at the cusp of the χ(T) curve. This TN value is

very close to the values (≈ 50 ± 2 K) reported in the literature [31-33]. Below TN, the magnetic susceptibility decreases with the decrease of temperature and stays almost constant below 30 K, showing a typical behavior of the perpendicular susceptibility (with the field perpendicular to the

easy axis, here the b-axis) for AFM single crystals [34, 35]. Above TN, the Fe ions are paramagnetic, as can be seen clearly from the linear dependence of the χ-1 on the temperature T, shown in the inset of Fig. 5. Using the Curie-Weiss law χ(T) = C/(T -θ) with the Curie constant 2 2 -1 -1 C = NAg μB S(S+1)/3kB [35], the χ (T) data can be well fitted to χ = (T - θ )/C in the range of

60 K ≤ T ≤ 300 K (solid line in the inset of Fig. 5) with C = 3.667 ± 0.018 emu•K/mole and a

Curie temperature θ = -90.9 K ± 1.1 K. The negative value of θ is also an indication of the 1/2 antiferromagnetism. The effective magnetic moment obtained by μeff = (8C) is thus 5.42 ±

0.01 μB per Fe ion. This μeff value is slightly greater than the “spin-only” (i.e., with orbital

angular momentum L fully quenched by crystal field (CF)) moment 4.90 μB for the high spin 2+ 6 state (S = 2) of Fe (d ) ion [34] and substantially smaller than the free ion value of 6.71 μB calculated from the total angular momentum J = L + S. This result indicates that the Fe ions in the crystal are divalent and their orbital moments are substantially quenched by CF. The value of

μeff observed here is in excellent agreement with those observed in other compounds containing 2+ Fe ions, such as FeO (5.33 μB), FeF2 (5.59 μB), FeCl2 (5.38 μB), FeS (5.24 μB), KFeCl3 (5.50

μB), and BaLa2FeS5 (5.41 μB) [36-40]. The values of the -θ (≈ 91 K) and μeff (5.42 μB)

measured for the LiFePO4 samples in this study are considerably smaller than the values reported

by Creer et al. (-θ = 129 K and μeff = 5.65 μB) [41] and Arcon et al. (-θ = 115 K and μeff =

5.85 μB) [32] , but almost identical to the values (-θ = 88 K and μeff = 5.45 μB) reported by Santoro et al. [31].

5

4. Conclusions

LiFePO4 single crystals have been successfully grown by standard flux growth technique in Pt crucibles using LiCl as the flux. The crystals have volumes of up to 300 mm3 with an average volume of about 100 mm3, which are large enough for all the physical property measurements including four probe electronic conductivity measurements. Single-crystal XRD measurements showed that the crystals have orthorhombic crystal structure with space group Pnma (Z = 4). The -3 bond lengths between Fe and O in the FeO6 octahedra and between P and O in the PO4 tetrahedra were obtained. The high quality of the crystals is supported by the powder XRD measurement on ground LiFePO4 single crystals, which shows that the crystals are pure in phase. The magnetic susceptibility measurements indicate that the Fe ions in the crystal are

antiferromagnetically ordered at a Neel temperature TN ≈ 51 ± 2 K, above which the system is paramagnetic with effective moments of the Fe2+ ions close to the value for the orbital-moment- quenched Hund’s rule ground state.

Acknowledgements The work at Sam Houston State University (SHSU) is supported by a grant from the SHSU EGR program and by an award from the Research Corporation. The work at University of Texas at Austin is supported by the Welch Foundation under Grant No. F-1191 and by the National Science Foundation under Grant No. DMR-0605828. The work at Ames Laboratory is supported by the Department of Energy, Office of Basic Energy Sciences under contract number W-7405- Eng-82.

6 References: [1] A. K. Padhi, K. S. Nanjundaswamy, and J. B. Goodenough, J. Electrochem. Soc. 144 (1997) 1188. [2] H. Huang, Y. Lee, and J. B. Goodenough, J. Electrochem. Soc. 145 (1999) 3220. [3] S. –Y. Chung, J. Bloking, and Y. –M. Chiang, Nat. Mater. 1 (2002) 123. [4] G. X. Wang, S. Bewlay, S. A. Needham, H. K. Liu, R. S. Liu, V. A. Drozd, J. –F. Lee, and J. M. Chen, J. Electrochem. Soc. 153 (2006) A25. [5] K. Striebel, J. Shim, V. Srinivasan, and J. Newman, J. Electrochem. Soc. 152 (2005) A664. [6] X. Z. Liao, Z. F. Ma, L. Wang, X. M. Zhang, Y. Jiang, and Y. S. He, Electrochem. Solid- State Lett. 7 (2004) A522. [7] J. -M. Tarascon and M. Armand, Nature (London) 414 (2001) 359. [8] Yong-Nian Xu, Sung-Yoon Chung, Jason T. Blocking, Yet-Ming Chiang, and W. Y. Ching, Electrochem. Solid-State Lett. 7 (2004) A131. [9] P. Subramanya Herle, B. Ellis, N. Coombs, and L. F. Nazar, Nat. Mater. 3 (2004) 147. [10] S. Shi, L. Liu, C. Ouyang, D. S. Wang, Z. Wang, L. Chen, and X. Huang, Phys. Rev. B 68 (2003) 195108. [11] J. F. Ni, H. H. Zhou, J. T. Chen, X. X. Zhang, Materials Letters 59 (2005) 2361. [12] J. Molenda, Mat. Sci. Poland 24 (2006) 61. [13] H. Huang, S. –C. Yin, and L. F. Nazar, Electrochem. Solid-State Lett. 4 (2001) A170. [14] S. Franger, F. L. Cras, C. Bourbon, H. Rouault, J. Power Sources 119-121 (2003) 252. [15] J. Yang and J. J. Xu, Electrochem. Solid-State Lett. 7 (2004) A515. [16] C. H. Mi, X. B. Zhao, G. S. Cao, and J. P. Tu, J. Electrochem. Soc. 152 (2005) A483. [17] P. Prosini et al., J. Electrochem. Soc. 149 (2002) A886. [18] F. Croce et al., Electrochem. Solid-State Lett. 5 (2002) A47. [19] C. R. Sides, F. Croce, V. Y. Young, C. R. Martin, and B. Scrosati, Electrochem. Solid- State Lett. 8 (2005) A484. [20] V. A. Streltsov, E. L. Belokoneva, V. G. Tsirelson, and N. K. Hansen, Acta Cryst. B 49 (1993) 147. [21] Jonas Howing, Desertation, Acta Universitatis Upsaliensis, Uppsala, 2004. [22] D. P. Chen, A. Maljuk, C. T. Lin, J. 284 (2005) 86 [23] M. Mercier and J. Gareyte, Solid State Commun. 5 (1967) 139. [24] M. Mercier and P. Bauer, Comptes rendus 267 (serie B) (1968) 465. [25] M. Mercier, J. Gareyte, E. F. Bertaut, Comptes rendus 264 (serie B) (1967) 979. [26] M. Mercier, P. Bauer, B. Fouilieux, Comptes rendus 267 (serie B) (1968) 1345. [27] J. Li, V. O. Garlea, J. L. Zarestky, and D. Vaknin, Phys. Rev. B 73 (2006) 024410.

7 [28] V. I. Formin, V. P. Gnezdilov, V. S. Kurnosov, A. V. Peschanskii, A. V. Yeremenko, H. Schmid, J. –P. Rivera, and S. Gentil, Low Temp. Phys. 28 (2004) 203. [29] G. M. Sheldrick, SHELXL97, University of Göttingen, Germany, (1997). [30] P. Tang and N. A. W. Holzwarth, Phys. Rev. B 68 (2003) 165107. [31] R. P. Santoro and R. E. Newman, Acta Cryst. 22 (1967) 344. [32] D. Arcon, A. Zorko, R. Dominko, and Z. Jaglicic, J. Phys.: Condens. Matter 16 (2004) 5531. [33] S. Shi, C. Ouyang, Z. Xiong, L. Liu, Z. Wang, H. Li, D. Wang, L. Chen, and X. Wang, Phys. Rev. B 71 (2005) 144404. [34] C. Kittel, Intgroduction to Solid State Physics, 8th ed., John Wiley & Sons, Inc., 2005, p. 449. [35] Allan H. Morrish, The Physical Principles of Magnetism, John Wiley & Sons, Inc., New York, 1965, p. 449. [36] F. B. Koch and M. E. Fine, J. Appl. Phys. 38 (1967) 1470. [37] Edited by E. Du Tremolet de Lacheisserie, D. Gignoux, M. Schlenker, Magnetism Fundamentals, Springer, 2005, p. 266. [38] J. L. Horwood, M. G. Townsend, and A. H. Webster, J. Solid State Chem. 17 (1976 35. [39] E. Gurewitz, J. Makovsky, and H. Shaked, Phys. Rev. B 9 (1974) 1071. [40] M. Wakeshima, K. Ino, Y. Hinatsu, Solid State Commun. 120 (2001) 145. [41] J. G. Creer and G. J. Troup, Physics Letter 32A (1970) 439.

8 Figure Captions:

3 Figure 1. Samples of as-grown LiFePO4 single crystals with volume ranging from 100 mm to 200 mm3.

Figure 2. Single-crystal XRD pattern measured with the x-ray beam along the a-axis of the unit

cell of the LiFePO4 single crystal.

Figure 3. The structure of the orthorhombic LiFePO4 showing the positions of the atoms. The 3- orange-yellow octehedra represent FeO6 and the yellow tetrahedral represent PO4 . The arrows at the Fe-sites represent the spin moments.

Figure 4. Powder XRD pattern of the powder of ground LiFePO4 single crystal, taken at room temperature and in the 2θ range of 15° ≤ 2θ ≤ 65°

Figure 5. Temperature dependent dc magnetic susceptibility measured in a field of 1 kOe. The inset shows the inverse magnetic susceptibility. The solid line in the inset represent the linear fit χ-1= (T - θ )/C according to the Curie-Weiss law.

9 Tables:

Table I. Atomic coordinates of LiFePO4 single crystal. ======atom x y z Fe(1) 0.28198(4) 0.2500 0.47503(10) P(2) 0.40520(6) 0.7500 0.41808(17) O(3) 0.33456(12) 0.5464(2) 0.2847(3) O(4) 0.54280(18) 0.7500 0.2942(5) O(5) 0.40310(18) 0.7500 0.7428(4) Li(6) 0.5000 0.5000 0.0000 ======

Table II. Bond lengths (Å) ======atom---atom distance atom---atom distance

Fe Octahedron: Fe(1)---O(3) 2.0641(15) Fe(1)---O(3)1) 2.2451(15) Fe(1)---O(3)2) 2.0641(15) Fe(1)---O(3)3) 2.2451(15) Fe(1)---O(4)4) 2.106(2) Fe(1)---O(5)5) 2.1968(19)

P Tetrahedron: P(2)---O(3) 1.5545(15) P(2)---O(3)6) 1.5545(15) P(2)---O(4) 1.533(2) P(2)---O(5) 1.519(2) ======Symmetry Operators: (1) -X+1/2,Y+1/2-1,Z+1/2 (2) X,-Y+1/2,Z (3) -X+1/2,-Y+1,Z+1/2 (4) -X+1,-Y+1,-Z+1 (5) -X+1/2,Y+1/2-1,Z+1/2-1 (6) X,-Y+1/2+1,Z

Table III. Bond angles (°) ======Atom-atom-atom angle(°) atom-atom-atom angle (°)

O(3)-Fe(1)-O(3)1) 152.78(5) O(3)-Fe(1)-O(3)2) 119.34(6) O(3)-Fe(1)-O(3)3) 87.06(5) O(3)-Fe(1)-O(4)4) 89.74(4) O(3)-Fe(1)-O(5)5) 90.87(4) O(3)1)-Fe(1)-O(3)2) 87.06(5) O(3)1)-Fe(1)-O(3)3) 66.03(5) O(3)1)-Fe(1)-O(4)4) 97.41(6) O(3)1)-Fe(1)-O(5)5) 81.58(5) O(3)2)-Fe(1)-O(3)3) 152.78(5) O(3)2)-Fe(1)-O(4)4) 89.74(4) O(3)2)-Fe(1)-O(5)5) 90.87(4) O(3)3)-Fe(1)-O(4)4) 97.41(6) O(3)3)-Fe(1)-O(5)5) 81.58(5) O(4)4)-Fe(1)-O(5)5) 178.79(8) O(3)-P(2)-O(3)6) 103.79(8) O(3)-P(2)-O(4) 106.40(7) O(3)-P(2)-O(5) 113.23(7) O(3)6)-P(2)-O(4) 106.40(7) O(3)6)-P(2)-O(5) 113.23(7) O(4)-P(2)-O(5) 113.03(11) Fe(1)-O(3)-Fe(1)7) 127.43(6) Fe(1)-O(3)-P(2) 129.01(9) Fe(1)7)-O(3)-P(2) 94.66(7) Fe(1)4)-O(4)-P(2) 126.94(13) Fe(1)8)-O(5)-P(2) 120.45(11) ======Symmetry Operators: (1) -X+1/2,Y+1/2-1,Z+1/2 (2) X,-Y+1/2,Z (3) -X+1/2,-Y+1,Z+1/2 (4) -X+1,-Y+1,-Z+1 (5) -X+1/2,Y+1/2-1,Z+1/2-1 (6) X,-Y+1/2+1,Z (7) -X+1/2,Y+1/2,Z+1/2-1 (8) -X+1/2,Y+1/2,Z+1/2

10

Fig. 1

11

Fig. 2

12 Fig. 3

13 Fig. 4

14

Fig. 5

15